NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
55 reportsClear category filterMileage unknown · Feb 14, 2025
Electrical SystemEngineFuel/propulsion System
Powertrain control module software is faulty, causing improper diagnosis of catalytic converters efficiency. Prompting a check engine light and P0430/P0420 code. I could not pass emissions testing with this code. The Ford dealer made me pay out of pocket to replace catalytic converters ~6 months ago, total cost of $2975.12. The …
Read full complaint
Powertrain control module software is faulty, causing improper diagnosis of catalytic converters efficiency. Prompting a check engine light and P0430/P0420 code. I could not pass emissions testing with this code. The Ford dealer made me pay out of pocket to replace catalytic converters ~6 months ago, total cost of $2975.12. The have now addressed that it is unlikely the catalytic converters were faulty, and are offering no reimbursement.
NHTSA ODI #11642766
Mileage unknown · Jan 16, 2025
EngineFuel/propulsion System
The Cam phasers on this vehicle are defective. This will be my third cam phasers in less than 3 years. The Cam Phasers cause the emissions to fail and can also cause unsafe driving such as the first time they failed while driving on the highway. I have brought this to the attention of the dealership numerous times and they sa…
Read full complaint
The Cam phasers on this vehicle are defective. This will be my third cam phasers in less than 3 years. The Cam Phasers cause the emissions to fail and can also cause unsafe driving such as the first time they failed while driving on the highway. I have brought this to the attention of the dealership numerous times and they say they can't duplicate it, even though it makes the noise when turning on the car or idling every time. They finally admitted this past visit to the Mall of Georgia Ford that it is an issue and a known recurring issue with this vehicle. I see the issue reported online, Ford Facebook pages, blogs, etc with thousands of people experiencing the same unsafe issue with both emissions and driving safety. Please advise.
NHTSA ODI #11636250
Mileage unknown · Nov 15, 2024
Fuel/propulsion System
My truck stopped in the middle of an intersection and would not crank again. The fuel pump had exploded on the inside and metal shavings were found all throughout my fuel system. The cost to repair my truck was $ 11,867.60 plus tax. From what I have been told, this is an ongoing problem that occurs with this specific fuel pump. …
Read full complaint
My truck stopped in the middle of an intersection and would not crank again. The fuel pump had exploded on the inside and metal shavings were found all throughout my fuel system. The cost to repair my truck was $ 11,867.60 plus tax. From what I have been told, this is an ongoing problem that occurs with this specific fuel pump. I was told from the service manager at the dealership that he sees this problem all the time. I was told from the claim adjuster that this is a problem with all Ford and Chevrolet trucks with diesel engines that use this specific fuel pump. I believe this should be a recall since it is a problem with any diesel that not only Ford but Chevrolet makes. I did file this with my insurance company but it was not covered. My claim # with Farm Bureau is 10000600403. My case # with Ford is CXH-02697972-W5T6Y4. Ford did end up covering half of the cost to repair but I still believe that it should be a recall. If you need any further information, please do not hesitate to contact me.
NHTSA ODI #11625636
Mileage unknown · Sep 30, 2024
Fuel/propulsion SystemPower Train
My truck started having issue(s) accelerating properly on-time over the past few months. The issue was only intermittent and occurred sometimes when needing to accelerate quickly in certain scenarios such as turning onto a busy road or merging in high traffic. It would also sometimes downshift very hard when driving at moderate …
Read full complaint
My truck started having issue(s) accelerating properly on-time over the past few months. The issue was only intermittent and occurred sometimes when needing to accelerate quickly in certain scenarios such as turning onto a busy road or merging in high traffic. It would also sometimes downshift very hard when driving at moderate speeds ~40 - 50 mph, and jarred the vehicle so hard it felt like the engine was going to drop out of the truck. The acceleration issue resulted in several incidents in which I was in danger of being struck by other drivers for being momentarily "dead in the water", but the worst incident occurred when I was attempting to merge into a left lane (9/11/2024) during rush hour in front of an on-coming dump truck; my truck did not accelerate AT ALL and the dump truck had to slam on his breaks and swerve out of the lane, coming extremely close to destroying me at about 45 MPH; had my vehicle accelerated correctly it would have never an issue. I am certain I would have suffered severe injury or death from this incident. I had no warning lights or other indications something was wrong and have no notices from Ford about the issue (see below). I took the truck to Coughlin Ford of Heath (Ohio) and they quoted me over $4000 for the parts and labor stating that cam sprockets need replaced along with re-timing labor. They said there were no active recalls but Coughlin and two other repair shops (one private and one Ford dealership) told me that this is a very common problem with these trucks and that there previously was a Ford customer satisfaction program to have this problem fixed in the past few years. I was NEVER notified of the program despite being the sole owner and only ever taking my truck to dealerships for repair over the past 6 years. I contacted Ford and filed a complaint (ref CXH02678193) but they indicated they would not be helping me despite nearly getting me killed. My out of pocket total was $4619.11 for parts, labor, and a rental car.
NHTSA ODI #11617305
115,000 miles · Sep 24, 2024
Electrical SystemEngineFuel/propulsion System
I was driving, I looked down because my truck was unresponsive, my truck had died, a warning light had come on stating the following: "Auto Start/Stop Shift to P, then Restart Engine". I was on the interstate, in a two lane construction zone, I had to pull over into the construction area, stop my truck, and try and restart. Afte…
Read full complaint
I was driving, I looked down because my truck was unresponsive, my truck had died, a warning light had come on stating the following: "Auto Start/Stop Shift to P, then Restart Engine". I was on the interstate, in a two lane construction zone, I had to pull over into the construction area, stop my truck, and try and restart. After a minute or two, I was able to restart my truck and re-enter the road way. A very dangerous situation, luckily I did not have my children in the vehicle at the time. I scheduled a service appointment after this and was told it was the fuel pump control module. Unfortunately, it has happened twice since my service appointment... something needs to me done!
NHTSA ODI #11616100
132,000 miles · Sep 13, 2024
EngineFuel/propulsion SystemPower Train
Unknown my truck was running rough so took it to shoo they ran the codes told me CPS camshaft position sensor bank 2 was coding so replaced all 4 sensors but was still having issues and then truck started having a rattle but not all the time it would come and go then the shop said replace spark plugs so I did then rattle got wor…
Read full complaint
Unknown my truck was running rough so took it to shoo they ran the codes told me CPS camshaft position sensor bank 2 was coding so replaced all 4 sensors but was still having issues and then truck started having a rattle but not all the time it would come and go then the shop said replace spark plugs so I did then rattle got worse but would go away when came to stop sign. During all of this I was using alot of oil 1 qt about every 3000 to 5000 miles then the truck started having noisy start up that went away after couple seconds loss of power poor fuel economy and the rattle was more constant oil levels checked daily and were good but yesterday the day after an oil.change and my truck lost power when depressed the gas pedal I continued to lose speed and then it stalled going down the highway and the Orange wrench showed up on the dash and my truck won't start
NHTSA ODI #11614404
Mileage unknown · Aug 18, 2024
Fuel/propulsion SystemPower TrainVehicle Speed Control
I on a trip [XXX] round trip is about 332 miles. I had approximately 42 miles to go and the truck speed was reduced and it started to jerk. This is the second trip over two hundred miles and the same thing happened. have extended warranty insurance but I can’t get any one to accept it here in Cleveland, Mississippi. I really thi…
Read full complaint
I on a trip [XXX] round trip is about 332 miles. I had approximately 42 miles to go and the truck speed was reduced and it started to jerk. This is the second trip over two hundred miles and the same thing happened. have extended warranty insurance but I can’t get any one to accept it here in Cleveland, Mississippi. I really think this truck is a lemon. I purchased it last year in November and it’s been giving me problems ever since then. I don’t have money to just give away on something that is not worth it. I even went to the dealer where I bought the truck and asked him if I could swap out for another truck and he told me he couldn’t do it. When I checked on car fax it just shows that this truck had 126 ,000miles on it. But at the dealership it showed 149,000miles.So it only showed history for 126,000 and less. I don’t know the history of the 23,000 miles that’s not accounted for. I want my money back or a reliable truck that has no problems with it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11609253
Mileage unknown · Jun 26, 2024
EngineFuel/propulsion SystemVehicle Speed Control
Been having this issue for months. Go to hit the gas to go from a stop truck shutters and hastates to move. No check engine light has come on. Thought it was the fuel we put in it but no matter what fuel it still does it. Almost have been hit a dozen times with my children in the truck with me due to truck will not Accelerate an…
Read full complaint
Been having this issue for months. Go to hit the gas to go from a stop truck shutters and hastates to move. No check engine light has come on. Thought it was the fuel we put in it but no matter what fuel it still does it. Almost have been hit a dozen times with my children in the truck with me due to truck will not Accelerate and shutters when you go to take off from a stop. Even when putting the vehicle into sports mode and hit the gas, the truck hesitates and shutters as well. Been to repair shops and they stated they can't find anything wrong with it due to no check engine light being on.
NHTSA ODI #11596871
Mileage unknown · Jun 17, 2024
Fuel/propulsion System
The 2018 Ford F150 truck came with a cap less fuel fill. What seals the fuel refill area is the gas cap door. The door is equipped with a seal on the gas cap door for when the door is closed, it keeps the weather elements from entering into the gas fill area that is equipped with a cap less mechanism for the gas tank filling. Th…
Read full complaint
The 2018 Ford F150 truck came with a cap less fuel fill. What seals the fuel refill area is the gas cap door. The door is equipped with a seal on the gas cap door for when the door is closed, it keeps the weather elements from entering into the gas fill area that is equipped with a cap less mechanism for the gas tank filling. The hinge spring on the door is of poor quality and design and the swivel pin that holds the gas cap door in place fails by the pin working out of place. This now causes the gas cap door to not fully close allowing weather elements to make their way into the cap less gas fill tube. From internet research, this is a common problem with the 2018 F150, as well as other years with this type of cap less gas door. I had to pay out of pocket expense for the gas cap door replacement. The replacement gas cap door was of the same design as the one that failed and I expect the replacement to fail with time.
NHTSA ODI #11594769
Mileage unknown · May 15, 2024
EngineFuel/propulsion System
see NTSHA report of technical service bulletin. This describes exactly the issue. As a result, the timing chain has been diagnosed as stretched due to the cam phaser issue. From what I understand, the safety concern is that the timing chain, if left undiagnosed/unrepaired can cause engine failure, loss of control etc. Ford …
Read full complaint
see NTSHA report of technical service bulletin. This describes exactly the issue. As a result, the timing chain has been diagnosed as stretched due to the cam phaser issue. From what I understand, the safety concern is that the timing chain, if left undiagnosed/unrepaired can cause engine failure, loss of control etc. Ford has attempted to fix the VCT (Variable camshaft timing. [XXX] . the below is Ford's TSB issued 04May2023 TECHNICAL SERVICE BULLETIN 3.5L EcoBoost - Cold Start Ticking/Tapping/Rattle With Possible No Restart During Auto-Start-Stop Operation 23-2143 04 May 2023 This bulletin supersedes 22-2200. Model: Ford 2018-2020 Expedition Built on or before 30-Nov-2019 2017-2020 F-150 Engine: 3.5L EcoBoost Built on or before 30-Nov-2019 Lincoln 2018-2020 Navigator Built on or before 30-Nov-2019 Summary This article supersedes TSB 22-2200 to update the production fix date, Action statement and customer symptom. NOTE: Certain parts may now be reused for this repair. Refer to the Service Procedure for details. Issue: Some 2017-2020 F-150 and 2018-2020 Expedition/Navigator vehicles built on or before 30-Nov-2019 and equipped with a 3.5L EcoBoost engine may exhibit a ticking/tapping or rattle type noise from the top front cover area of the engine on initial start-up after a cold soak of 6 hours or more that may last for 2-5 seconds. Some vehicles may also exhibit an intermittent condition with no auto restart during auto-start-stop operation with or without diagnostic trouble code (DTC) P164C present in the powertrain control module (PCM). This may be due to a worn variable camshaft timing (VCT) unit. To correct the condition, follow the Service Procedure to replace the VCT units. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11588966
Official recalls
18Jun 9, 2026
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 vehicles previously repaired incorrectly under recall number 20V097. When the headlight switch is turned from "Autolamps" to "Headlamps On," the Daytime Running Lamps (DRLs) may remain fully bright instead of dimming to parking lamps as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: Daytime Running Lamps that do not dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: ,Dealers will reprogram the body control module software, free of charge. Owner notification letters were mailed July 17, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26C28. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.
Jun 9, 2026
Ford Motor Company (Ford) is recalling certain 2018 F-150 vehicles previously repaired incorrectly under recall number 17V669. Quickly moving the shift lever from Park to Drive may cause a loss of gear indication on the instrument cluster display and a momentary selection of an unintended gear, such as Reverse or Neutral.
Consequence & remedy
Consequence: Unintended gear selection may cause the vehicle to move in an unexpected direction, increasing the risk of crash or injury.
Remedy: Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed July 9, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26S42. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.
Apr 11, 2025
Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence & remedy
Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:master Cylinder
Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.
Service Brakes, Hydraulic:power Assist
Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Mar 11, 2022
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Expedition, Lincoln Navigator, and 2016-2018 F-150 vehicles equipped with 3.5L Ecoboost engines. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence & remedy
Consequence: A loss of brake fluid may result in a change in brake pedal travel, increased pedal effort and reduced front brake function, requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. An interim owner notification letter notifying customers of the safety defect were mailed on April 29, 2022. Owner notification letters were mailed April 29, 2022. This recall is an expansion of NHTSA recall number 20V-332. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S11.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:master Cylinder
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Expedition, Lincoln Navigator, and 2016-2018 F-150 vehicles equipped with 3.5L Ecoboost engines. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel, increased pedal effort and reduced front brake function, requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. An interim owner notification letter notifying customers of the safety defect were mailed on April 29, 2022. Owner notification letters were mailed April 29, 2022. This recall is an expansion of NHTSA recall number 20V-332. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S11.
Service Brakes, Hydraulic:power Assist
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Expedition, Lincoln Navigator, and 2016-2018 F-150 vehicles equipped with 3.5L Ecoboost engines. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel, increased pedal effort and reduced front brake function, requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. An interim owner notification letter notifying customers of the safety defect were mailed on April 29, 2022. Owner notification letters were mailed April 29, 2022. This recall is an expansion of NHTSA recall number 20V-332. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S11.
Dec 16, 2021
Ford Motor Company (Ford) is recalling certain 2018 F-150 vehicles with manual and power release tailgates. The tailgate latches may unlatch unexpectedly while driving.
Consequence & remedy
Consequence: Unexpected tailgate opening may allow unrestrained cargo to fall out of the truck bed and become a road hazard, increasing the risk of a crash.
Remedy: Dealers will replace the left-hand and right-hand tailgate latches, free of charge. An interim notification letter was mailed January 31, 2022. Owner notification letters were mailed on May 31, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S53.
Mar 10, 2021
Ford Motor Company (Ford) is recalling certain 2018 F-150, 2018-2020 F-250, F-350, and 2019 Escape vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the tires, and replace them as necessary, free of charge. The recall began on March 27, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S10.
Feb 21, 2020
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 trucks equipped with high series LED headlamps with Autolamp (On/Off) functionality. The Daytime Running Lamps (DRL) may remain activated instead of dimming to parking lamps when the Master Lighting Switch (MLS) is manually rotated from the "Autolamps" switch position to "Headlamps On." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the body control module, free of charge. The recall began March 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C03.
Aug 28, 2019
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Apr 8, 2019
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence & remedy
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Additional source detail variants (2)
Engine
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Equipment:electrical
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Dec 18, 2018
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.
Consequence & remedy
Consequence: When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.
Aug 31, 2018
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence & remedy
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.
Additional source detail variants (2)
Seat Belts:pretensioner
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.
Structure:body:roof And Pillars
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.
Jun 12, 2018
Ford Motor Company (Ford) is recalling certain 2018 Ford Expedition, F-150, and Lincoln Navigator vehicles equipped with 3.5L GTDI V6 engines. These vehicles have high pressure fuel pump assemblies with welds that can fracture, which may cause an oil or fuel leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will replace the high pressure fuel pump and associated components, free of charge. The recall began July 17, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S17.
Apr 4, 2018
Ford Motor Company (Ford) is recalling certain 2017-2018 Ford F-150 and 2018 Ford Expedition and Mustang and Lincoln Navigator vehicles equipped with 10-speed automatic transmissions. A roll pin may not have been installed in the transmission, potentially causing a loss of the "Park" function.
Consequence & remedy
Consequence: Despite the transmission shift lever being placed in 'Park' and the instrument panel display indicating 'Park,' the vehicle may roll away after it has been exited if the parking brake has not been applied, increasing the risk of injury or a crash.
Remedy: Ford will notify owners, and dealers will inspect the transmission to make sure it has the roll pin, installing one if it is missing, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S09.
Apr 4, 2018
Ford Motor Company (Ford) is recalling certain 2018 F-650 and F-750 vehicles equipped with 6-speed automatic transmissions and 2018 Ford F-150 and Expedition vehicles equipped with 10-speed automatic transmissions (excluding Expedition vehicles with a Rotary Gear Shift Dial on the console). The gear shift cable clip may not be properly seated, allowing the transmission to be in a different gear than indicated by the gear shift lever position.
Consequence & remedy
Consequence: If the gear shift cable clip becomes unseated or dislodged, the gear shift lever position may indicate that the transmission is in 'Park' when it may be in a different gear. Additionally, despite selecting 'Park', if the parking brake is not applied before the vehicle is exited, the vehicle may roll. Either scenario increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the shift cable locking clip and properly seat it, if necessary, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for the recall is 18S10.
Additional source detail variants (2)
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain 2018 F-650 and F-750 vehicles equipped with 6-speed automatic transmissions and 2018 Ford F-150 and Expedition vehicles equipped with 10-speed automatic transmissions (excluding Expedition vehicles with a Rotary Gear Shift Dial on the console). The gear shift cable clip may not be properly seated, allowing the transmission to be in a different gear than indicated by the gear shift lever position.
Consequence: If the gear shift cable clip becomes unseated or dislodged, the gear shift lever position may indicate that the transmission is in 'Park' when it may be in a different gear. Additionally, despite selecting 'Park', if the parking brake is not applied before the vehicle is exited, the vehicle may roll. Either scenario increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the shift cable locking clip and properly seat it, if necessary, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for the recall is 18S10.
Power Train:automatic Transmission
Ford Motor Company (Ford) is recalling certain 2018 F-650 and F-750 vehicles equipped with 6-speed automatic transmissions and 2018 Ford F-150 and Expedition vehicles equipped with 10-speed automatic transmissions (excluding Expedition vehicles with a Rotary Gear Shift Dial on the console). The gear shift cable clip may not be properly seated, allowing the transmission to be in a different gear than indicated by the gear shift lever position.
Consequence: If the gear shift cable clip becomes unseated or dislodged, the gear shift lever position may indicate that the transmission is in 'Park' when it may be in a different gear. Additionally, despite selecting 'Park', if the parking brake is not applied before the vehicle is exited, the vehicle may roll. Either scenario increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the shift cable locking clip and properly seat it, if necessary, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for the recall is 18S10.
Oct 23, 2017
Ford Motor Company (Ford) is recalling certain 2018 F-150 vehicles equipped with a 3.3L engine, a 6-speed transmission and a column mounted shift lever. Quickly moving the shift lever from Park to Drive may cause a loss of gear indication on the instrument cluster display and a momentary selection of an unintended gear, such as Reverse or Neutral before the vehicle achieves Drive function.
Consequence & remedy
Consequence: Unidentified or unintended gear selection may cause the vehicle to move in a way that was not intended by the driver, increasing the risk of crash or injury.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 17S35.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:column Shift
Ford Motor Company (Ford) is recalling certain 2018 F-150 vehicles equipped with a 3.3L engine, a 6-speed transmission and a column mounted shift lever. Quickly moving the shift lever from Park to Drive may cause a loss of gear indication on the instrument cluster display and a momentary selection of an unintended gear, such as Reverse or Neutral before the vehicle achieves Drive function.
Consequence: Unidentified or unintended gear selection may cause the vehicle to move in a way that was not intended by the driver, increasing the risk of crash or injury.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 17S35.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Ford Motor Company (Ford) is recalling certain 2018 F-150 vehicles equipped with a 3.3L engine, a 6-speed transmission and a column mounted shift lever. Quickly moving the shift lever from Park to Drive may cause a loss of gear indication on the instrument cluster display and a momentary selection of an unintended gear, such as Reverse or Neutral before the vehicle achieves Drive function.
Consequence: Unidentified or unintended gear selection may cause the vehicle to move in a way that was not intended by the driver, increasing the risk of crash or injury.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 17S35.
Oct 23, 2017
Ford Motor Company (Ford) is recalling certain 2018 F-150 vehicles equipped with 3.5L engines. The cylinder heads may have been machined without lubrication supply holes for the camshaft bearing journals.
Consequence & remedy
Consequence: Without a proper supply of lubrication, the engine will fail, causing a stall and increasing the risk of a crash.
Remedy: Ford is not aware of any affected vehicles outside of dealer control. Should owner contact subsequently be required, arrangements will be made to transport their vehicle to a Ford or Lincoln dealer to have the engine replaced.The recall began October 24, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S37.
Sep 25, 2017
Ford Motor Company (Ford) is recalling certain 2018 Ford F-150 Raptor Super Cab pick-up trucks not equipped with a moonroof. The structural roof braces may be missing rivets at the attachment of the roof rail, thereby reducing the structural integrity.
Consequence & remedy
Consequence: If the structural integrity is reduced, in the event of a rollover crash, there may be an increased risk of injury .
Remedy: Ford will notify owners, and dealers will install the rivets for the roof brace attachments, free of charge. The recall began October 17, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S29.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE24019 · Low-pressure Fuel Pump Failure
Opened Jul 29, 2024 · Closed Sep 19, 2025
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
On July 29, 2024, the Office of Defects Investigation (ODI) opened PE24019 to investigate complaints of low-pressure fuel pump failures in MY 2021 Ford Bronco vehicles. Some consumers reported that the failure occurred without warning while driving, resulting in a complete loss of motive power with no ability to restart the engine. Ford determined that several other vehicle models contain low-pressure fuel pumps substantially similar to the 2021 Ford Bronco, including the 2022-2023 Ford Bronco, 2018-2023 Ford F-150, 2022-2023 Ford Expedition, 2019-2023 Lincoln Navigator, 2020-2023 Ford F-250-F-550, 2024 Ford Super Duty Chassis Cab, 2024-2025 Ford Ranger, 2020-2023 Ford Explorer, 2020-2023 Lincoln Aviator, and 2021-2025 Ford Mustang. ODI's investigation found that the affected vehicles may lose fuel pressure and flow from the fuel delivery module (consisting of a low-pressure fuel pump, jet pump, reservoir, and other parts) due to a low-pressure pump failure. This can cause the engine to stall while driving. The root cause is reduced internal clearance in the fuel pump, increasing friction and sensitivity to vapor lock. Fuel blockage from contamination inside the jet pump also contributed to the failure. Ford stated that the contamination source was unknown. On July 7, 2025, Ford filed recall 25V-455 for certain 2021-2023 Ford F-550 SD/F-450 SD/F-350 SD/F-250 SD, 2021-2022 Lincoln Navigator, 2021-2022 Ford Mustang, 2021-2022 Ford F-150, 2021-2023 Ford Explorer, 2022 Ford Expedition, and 2021-2023 Ford Bronco vehicles produced between July 1, 2021, and July 30, 2022. The recall also included certain 2021-2023 Lincoln Aviator produced between July 1, 2021, and December 21, 2022. Ford explained in its recall filingthat the production dates used for the recall were based on changes in the manufacturing process. Specifically, Ford determined that in June 2021, the supplier modified the jet pump manufacturing process, producing fuel pump chambers with a lower-than-specified internal clearance. In July 2022, the supplier implemented corrective actions to the manufacturing process by adding two additional vacuum pumps to reduce contamination during the production of the jet pump. ODI has identified approximately 1,000 reports involving vehicles covered in this investigation but excluded from recall 25V-455. However, even with such reports, these vehicles experienced comparatively lower failure rates than the vehicles that are subject to Recall 25V-455. Ford has explained that these vehicles were excluded from the recall population because they did not experience the manufacturing changes that prompted the recall. Specifically, according to Ford, vehicles built before July 1, 2021 (the recall production start date), were not affected by the supplier’s change to the jet pump manufacturing process. Even after closing this investigation, ODI will continue to monitor complaints for vehicles excluded from recall 25V-455 to consider whether they exhibit the same risks as the vehicles encompassed by the recall. The recall remedy is currently under development. In view of Ford’s recall action, ODI is closing this Preliminary Evaluation, but will continue to monitor the issue as a remedy is developed and implemented. ODI will take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18008 · Seatbelt Pretensioner Fire
Opened Aug 3, 2018 · Closed Dec 17, 2018
Status: closed (inferred from source dates) · Seat Belts:pretensioner
On June 18, 2018, the Office of Defects Investigations (ODI) opened a Preliminary Evaluation (PE18-008) to investigate complaints alleging post-crash fires at the B pillar in the area of the seat belt pretensioners on MY 2014-2018 Ford F-150 Regular Cab, and Super Crew Cab Vehicles. On August 24, 2018, Ford Motor Company recalled (FSA 18S27 - NHTSA #18V568) the affected population. Ford's investigation found that some front seat belt pretensioners may generate sparks during deployment in excess of Ford's specification. Sparks in the pretensioner exhaust gases inside the lower portion of the B-pillar may subsequently ignite combustible components contained in the B-pillar, such as insulation or carpet, and may cause a subsequent vehicle fire. ODI also requested relevant information from other manufacturers to assess the potential scope of post-crash pretensioner fires. Ford will notify owners and require dealers to remove B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall notification began September 28, 2018.Owners may contact Ford customer service at 1-866-436-7332.The VOQs associated with the closing of this investigation are: 11143035, 11130056, 11129828, 11128761, 11127993, 11127880, 11124717, 11123419, 11119651, 11119626, 11114065, 11113160, 11111822, 11097937, 11078447, 11014688
Illustration