NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
503 reportsClear category filter3,000 miles · Dec 13, 2018
Engine
MY 2018 FORD F150 XLT V8 WITH 10-SPEED TRANSMISSION HAS FAILED TO ACCELERATE FROM A STOP AFTER IDLING. THE START/STOP FUNCTION IS ALWAYS DISABLED WHEN I DRIVE. THE TRUCK HESITATES AND STUMBLES UPON LIGHT ACCELERATION. ONE TIME IT CONTINUED FOR A FEW SECONDS BEFORE QUITTING COMPLETELY. IT MAKES ME REALLY NERVOUS WHEN I AM PULLING…
Read full complaint
MY 2018 FORD F150 XLT V8 WITH 10-SPEED TRANSMISSION HAS FAILED TO ACCELERATE FROM A STOP AFTER IDLING. THE START/STOP FUNCTION IS ALWAYS DISABLED WHEN I DRIVE. THE TRUCK HESITATES AND STUMBLES UPON LIGHT ACCELERATION. ONE TIME IT CONTINUED FOR A FEW SECONDS BEFORE QUITTING COMPLETELY. IT MAKES ME REALLY NERVOUS WHEN I AM PULLING OUT INTO TRAFFIC AS I FEEL IT MAY HESITATE. I GIVE PLENTY ROOM TO TRAFFIC AND EXPECT IT TO STUMBLE SO THAT I DO NOT GET INTO THE MIDDLE OF THE ROAD AND HAVE IT QUIT. I'VE NEVER HAD A VEHICLE THAT I HAD TO SUBSTANTIALLY CHANGE MY DRIVING BEHAVIOR TO ADAPT TO ITS MANY FAULTS. DANGEROUS TRUCK.
NHTSA ODI #11161195
30 miles · Dec 13, 2018
Engine
MY TRUCK HAS A CONSTANT RATTLE/DETONATION/PREIGNITION NOISE DURING ALL DRIVING. IT IS ESPECIALLY BAD DURING HOT SUMMER MONTHS. IT HAS ONLY GOTTEN WORSE AS MONTHS HAVE GONE BY. IT IS ESPECIALLY NOTICEABLE WHILE CLIMBING VERY SLIGHT UPHILL GRADES AND AT SPEEDS BETWEEN 35-55MPH. IT CAN BE HEARD FROM INSIDE AND OUTSIDE VEHICLE. THE …
Read full complaint
MY TRUCK HAS A CONSTANT RATTLE/DETONATION/PREIGNITION NOISE DURING ALL DRIVING. IT IS ESPECIALLY BAD DURING HOT SUMMER MONTHS. IT HAS ONLY GOTTEN WORSE AS MONTHS HAVE GONE BY. IT IS ESPECIALLY NOTICEABLE WHILE CLIMBING VERY SLIGHT UPHILL GRADES AND AT SPEEDS BETWEEN 35-55MPH. IT CAN BE HEARD FROM INSIDE AND OUTSIDE VEHICLE. THE NOISE IS COMING FROM ENGINE. A VIBRATION AND SHUDDER CAN BE FELT IN VEHICLE WHEN NOISE IS PRESENT. WHEN IT IS REALLY BAD, THE SOUND IS VERY LOUD AND SOUNDS LIKE A METAL HAMMER BANGING ON INSIDE OF ENGINE. I WAS TOLD THIS WOULD GET BETTER WITH MILEAGE, BUT HAS ONLY GOTTEN WORSE. I HAVE AUDIO AND VIDEO RECORDINGS OF NOISE OVER THEN PAST 10MONTHS. I AM VERY WORRIED THAT THIS ENGINE IS GOING TO FAIL.
NHTSA ODI #11161174
20 miles · Dec 13, 2018
Engine
MY TRUCK HAS HAD AN ENGINE STUMBLING, HESITATION, AND MISFIRING PROBLEM SINCE DAY 1 OF OWNERSHIP. THE DEALERSHIP SAID IT WOULD RESOLVE ITSELF AFTER 2000MILES OF NORMAL DRIVING BUT IT HAS NOT. IT HAS PROGRESSIVELY GOTTEN WORSE OVER 10 MONTHS OF OWNERSHIP. IT IS MUCH WORSE DURING HOT SUMMER WEATHER (IE TEMPS ABOVE 90F). OCCASIONAL…
Read full complaint
MY TRUCK HAS HAD AN ENGINE STUMBLING, HESITATION, AND MISFIRING PROBLEM SINCE DAY 1 OF OWNERSHIP. THE DEALERSHIP SAID IT WOULD RESOLVE ITSELF AFTER 2000MILES OF NORMAL DRIVING BUT IT HAS NOT. IT HAS PROGRESSIVELY GOTTEN WORSE OVER 10 MONTHS OF OWNERSHIP. IT IS MUCH WORSE DURING HOT SUMMER WEATHER (IE TEMPS ABOVE 90F). OCCASIONALLY WHEN DEPRESSING THE ACCELERATOR, THE TRUCK HESITATES AND FAILS TO ACCELERATE. I AM VERY WORRIED THAT IT WILL DO THIS WHEN PULLING OUT IN TRAFFIC. THE DEALERSHIPS HAVE BEEN ABLE TO DUPLICATE THE PROBLEM BUT HAVE NOT BEEN ABLE TO FIX IT. I AM USING MY 2ND VEHICLE TO DRIVE TO/FROM WORK AS THIS NEW 2018 F-150 V8 IS UNRELIABLE.
NHTSA ODI #11161171
700 miles · Dec 10, 2018
EnginePower Train
THE TRUCK HAS ACCELERATION PROBLEMS.. ITS KNOWN AS THE DEAD PEDAL.. I HAVE TAKEN IT BACK TO FORD TWICE. THEY TELL ME ALL THE TRUCKS HAVE THIS PROBLEM. IM AFRAID THAT IT GOING TO CAUSE A ACCIDENT. MY WIFE WILL NOT DRIVE THE TRUCK BECAUSE OF THIS..
NHTSA ODI #11157285
Mileage unknown · Dec 3, 2018
EngineUnknown Or OtherFire
DAUGHTER DROVE THE VEHICLE HOME, PARKED IT, AND TURNED OFF VEHICLE. WHILE INSIDE THE RESIDENCE, DAUGHTER HEARD DOGS OUTSIDE BARKING. DAUGHTER WENT TO CHECK ON DOGS AND SAW THAT THE VEHICLE WAS ON FIRE. THE VEHICLE WAS PARKED AND ENGINE WAS NOT ON. THE VEHICLE FULLY ENGULFED IN FLAMES. THE VEHICLE FIRE ALSO BURNED A PART OF …
Read full complaint
DAUGHTER DROVE THE VEHICLE HOME, PARKED IT, AND TURNED OFF VEHICLE. WHILE INSIDE THE RESIDENCE, DAUGHTER HEARD DOGS OUTSIDE BARKING. DAUGHTER WENT TO CHECK ON DOGS AND SAW THAT THE VEHICLE WAS ON FIRE. THE VEHICLE WAS PARKED AND ENGINE WAS NOT ON. THE VEHICLE FULLY ENGULFED IN FLAMES. THE VEHICLE FIRE ALSO BURNED A PART OF THE EXTERIOR OF THE RESIDENCE. THE VEHICLE IS CURRENTLY STILL AT THE RESIDENCE WHERE IT BURNED. I REQUEST THAT THIS VEHICLE BE INVESTIGATED BECAUSE THERE WAS NOT REASON FOR IT TO HAVE CAUGHT FIRE. IT WAS NOT INVOLVED IN ANY TYPE OF ACCIDENT.
NHTSA ODI #11155760
4,300 miles · Nov 30, 2018
Engine
WITH AUTO STOP/START DISABLED USING THE DASH CONTROL, THE ENGINE SHUT DOWN WHILE MOVING ON A CITY STREET IN TRAFFIC DURING A SLOW-SPEED 90 RIGHT-HAND TURN. THE ON-DASH MESSAGE REFERENCED EITHER THE AUTO SHUTDOWN OR AUTO START/STOP FUNCTION STOPPING THE ENGINE AND INSTRUCTED THAT THE VEHICLE BE PLACED IN PARK TO RESTART. THE VE…
Read full complaint
WITH AUTO STOP/START DISABLED USING THE DASH CONTROL, THE ENGINE SHUT DOWN WHILE MOVING ON A CITY STREET IN TRAFFIC DURING A SLOW-SPEED 90 RIGHT-HAND TURN. THE ON-DASH MESSAGE REFERENCED EITHER THE AUTO SHUTDOWN OR AUTO START/STOP FUNCTION STOPPING THE ENGINE AND INSTRUCTED THAT THE VEHICLE BE PLACED IN PARK TO RESTART. THE VEHICLE DID RESTART AFTER COMING TO A COMPLETE STOP AND PLACING THE TRANSMISSION IN PARK. VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. THEY REPORTED THAT NO DIAGNOSTIC TROUBLE CODES WERE PRESENT IN THE SYSTEM AND THAT THE PROBLEM COULD NOT BE REPLICATED AFTER "SEVERAL" TEST DRIVES.
NHTSA ODI #11155158
4,144 miles · Nov 13, 2018
EngineFuel/propulsion SystemVehicle Speed Control
I HAVE HAD TWO RUN AWAY FULL ACCELERATIONS IN THIS NEW TRUCK. I ACCELERATED FIRMLY AND THE ACCELERATOR REFUSED TO DISENGAGE. AT OVER 90 MPHM I PUT THE CAR IN NEUTRAL, THE RPM INCREASED AND I SHUT OFF THE KEY. NEXT TIME IN THE SAME DRIVE IT HAPPENED AGAIN AND I IMMEDIATELY SHUT OFF THE KEY. I WILL NOTIFY MY DEALER TOMORRO…
Read full complaint
I HAVE HAD TWO RUN AWAY FULL ACCELERATIONS IN THIS NEW TRUCK. I ACCELERATED FIRMLY AND THE ACCELERATOR REFUSED TO DISENGAGE. AT OVER 90 MPHM I PUT THE CAR IN NEUTRAL, THE RPM INCREASED AND I SHUT OFF THE KEY. NEXT TIME IN THE SAME DRIVE IT HAPPENED AGAIN AND I IMMEDIATELY SHUT OFF THE KEY. I WILL NOTIFY MY DEALER TOMORROW. I WILL NOT DRIVE IN THIS VEHICLE AGAIN. AS AN EXPERIENCED COMMERCIAL PILOT I HAVE BEEN TRAINED HOW TO DEAL WITH THIS ISSUE BUT THE PUBLIC HAS NO CLUE WHAT TO DO.
NHTSA ODI #11151116
820 miles · Sep 15, 2018
EngineUnknown Or OtherVehicle Speed ControlCrash
I WAS HEADED HOME FROM WORK AND MY TRUCK WAS STATIONARY STOPPED AT A STOP LIGHT, AND THE AUTOMATIC ENGINE STOP WAS ACTIVE, WITH SYNC NETWORKED. A VEHICLE FROM BEHIND RAN INTO MY 3 WEEK OLD VEHICLE. THE ENGINE AUTOMATIC START-STOP SYNC STARTED, AND THE ENGINE RACED TO VERY HIGH RPMS. THROWING MY HEAD BACK INTO THE HEADREST AGA…
Read full complaint
I WAS HEADED HOME FROM WORK AND MY TRUCK WAS STATIONARY STOPPED AT A STOP LIGHT, AND THE AUTOMATIC ENGINE STOP WAS ACTIVE, WITH SYNC NETWORKED. A VEHICLE FROM BEHIND RAN INTO MY 3 WEEK OLD VEHICLE. THE ENGINE AUTOMATIC START-STOP SYNC STARTED, AND THE ENGINE RACED TO VERY HIGH RPMS. THROWING MY HEAD BACK INTO THE HEADREST AGAIN. I HAD TO PRESS REALLY HARD UPON THE BRAKES TO PREVENT MY VEHICLE FROM SLAMMING INTO THE CAR AHEAD OF ME. AT THAT MOMENT MY MIND THOUGHT OF THE TOYOTA CAMRY ACCELERATION PROBLEM YEARS AGO, AND UPON THE VEHICLE RETURNING TO NORMAL IDLE RPMS, I DOUBLE CHECKED THAT MY FOOT WAS ACTUALLY ON THE BRAKE. MY FOOT WAS ACTUALLY ON THE BRAKE.
NHTSA ODI #11129702
4,500 miles · Sep 6, 2018
EngineFuel/propulsion SystemPower Train
SAME ISSUES I'M READING HERE. VEHICLE FREQUENTLY MAKES A LOUD BANG WHEN STARTED. SHIFTS GEARS EXTREMELY ROUGH TO THE POINT WHERE YOU'RE JERKED AROUND. NO POWER WHEN TRYING TO ACCELERATE FROM A STOP WHICH IS EXTREMELY DANGEROUS WHEN CARS ARE BEHIND YOU OR TRYING TO ACCELERATE MERGING ONTO THE FREEWAY. MY TRUCK HAS BEEN TO DEALER …
Read full complaint
SAME ISSUES I'M READING HERE. VEHICLE FREQUENTLY MAKES A LOUD BANG WHEN STARTED. SHIFTS GEARS EXTREMELY ROUGH TO THE POINT WHERE YOU'RE JERKED AROUND. NO POWER WHEN TRYING TO ACCELERATE FROM A STOP WHICH IS EXTREMELY DANGEROUS WHEN CARS ARE BEHIND YOU OR TRYING TO ACCELERATE MERGING ONTO THE FREEWAY. MY TRUCK HAS BEEN TO DEALER TWICE NOW. THE FIRST TIME IT WAS BECAUSE MY FUEL INJECTOR WENT OUT AT 4,500 MILES! IT DOESN'T RUN MUCH BETTER NOW. WHEN I TOOK IT IN THEY JUST BLEW ME OFF AND SAID IT WAS 'NORMAL BEHAVIOR FOR THE VEHICLE'. READING ALL THESE ISSUES HERE, FORD REALLY NEEDS TO TAKE ACTION! EXTREMELY DANGEROUS!!
NHTSA ODI #11124723
8,000 miles · Aug 2, 2018
EnginePower TrainSeats
I HAVE 2018 FORD F150 RAPTOR EDITION AND HAVE HAD NOTHING BUT ISSUES WITH IT SINCE PURCHASING THE VEHICLE IN NOVEMBER OF 2017 BRAND NEW. CURRENTLY THE ENGINE IS BLOWN AND IT HAS BEEN IN AND OUT OF SERVICE FOR OVER 118 DAYS SINCE PURCHASE.I WAS DRIVING ON THE EXPRESSWAY, FIRST DAY AFTER GETTING TRUCK BACK FROM 28 DAY SERVICE AND …
Read full complaint
I HAVE 2018 FORD F150 RAPTOR EDITION AND HAVE HAD NOTHING BUT ISSUES WITH IT SINCE PURCHASING THE VEHICLE IN NOVEMBER OF 2017 BRAND NEW. CURRENTLY THE ENGINE IS BLOWN AND IT HAS BEEN IN AND OUT OF SERVICE FOR OVER 118 DAYS SINCE PURCHASE.I WAS DRIVING ON THE EXPRESSWAY, FIRST DAY AFTER GETTING TRUCK BACK FROM 28 DAY SERVICE AND THE ENGINE OIL PRESSURE LIGHT CAME ON AGAIN WHICH IS WHY IT WAS IN SERVICE. I CALLED THE DEALER AND FORD AND THEY ADVISED TO KEEP DRIVING UNTIL THEY HEARD BACK FROM THE FORD HOTLINE. A WEEK OR SO LATER IT WAS BROKE DOWN SMOKING ON THE SIDE OF THE HIGHWAY. IN ADDITION THERE HAVE BEEN NUMEROUS OTHER PROBLEMS.
NHTSA ODI #11115281
Official recalls
18Jun 9, 2026
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 vehicles previously repaired incorrectly under recall number 20V097. When the headlight switch is turned from "Autolamps" to "Headlamps On," the Daytime Running Lamps (DRLs) may remain fully bright instead of dimming to parking lamps as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: Daytime Running Lamps that do not dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: ,Dealers will reprogram the body control module software, free of charge. Owner notification letters were mailed July 17, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26C28. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.
Jun 9, 2026
Ford Motor Company (Ford) is recalling certain 2018 F-150 vehicles previously repaired incorrectly under recall number 17V669. Quickly moving the shift lever from Park to Drive may cause a loss of gear indication on the instrument cluster display and a momentary selection of an unintended gear, such as Reverse or Neutral.
Consequence & remedy
Consequence: Unintended gear selection may cause the vehicle to move in an unexpected direction, increasing the risk of crash or injury.
Remedy: Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed July 9, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26S42. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.
Apr 11, 2025
Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence & remedy
Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:master Cylinder
Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.
Service Brakes, Hydraulic:power Assist
Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Mar 11, 2022
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Expedition, Lincoln Navigator, and 2016-2018 F-150 vehicles equipped with 3.5L Ecoboost engines. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence & remedy
Consequence: A loss of brake fluid may result in a change in brake pedal travel, increased pedal effort and reduced front brake function, requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. An interim owner notification letter notifying customers of the safety defect were mailed on April 29, 2022. Owner notification letters were mailed April 29, 2022. This recall is an expansion of NHTSA recall number 20V-332. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S11.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:master Cylinder
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Expedition, Lincoln Navigator, and 2016-2018 F-150 vehicles equipped with 3.5L Ecoboost engines. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel, increased pedal effort and reduced front brake function, requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. An interim owner notification letter notifying customers of the safety defect were mailed on April 29, 2022. Owner notification letters were mailed April 29, 2022. This recall is an expansion of NHTSA recall number 20V-332. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S11.
Service Brakes, Hydraulic:power Assist
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Expedition, Lincoln Navigator, and 2016-2018 F-150 vehicles equipped with 3.5L Ecoboost engines. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel, increased pedal effort and reduced front brake function, requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. An interim owner notification letter notifying customers of the safety defect were mailed on April 29, 2022. Owner notification letters were mailed April 29, 2022. This recall is an expansion of NHTSA recall number 20V-332. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S11.
Dec 16, 2021
Ford Motor Company (Ford) is recalling certain 2018 F-150 vehicles with manual and power release tailgates. The tailgate latches may unlatch unexpectedly while driving.
Consequence & remedy
Consequence: Unexpected tailgate opening may allow unrestrained cargo to fall out of the truck bed and become a road hazard, increasing the risk of a crash.
Remedy: Dealers will replace the left-hand and right-hand tailgate latches, free of charge. An interim notification letter was mailed January 31, 2022. Owner notification letters were mailed on May 31, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S53.
Mar 10, 2021
Ford Motor Company (Ford) is recalling certain 2018 F-150, 2018-2020 F-250, F-350, and 2019 Escape vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the tires, and replace them as necessary, free of charge. The recall began on March 27, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S10.
Feb 21, 2020
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 trucks equipped with high series LED headlamps with Autolamp (On/Off) functionality. The Daytime Running Lamps (DRL) may remain activated instead of dimming to parking lamps when the Master Lighting Switch (MLS) is manually rotated from the "Autolamps" switch position to "Headlamps On." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the body control module, free of charge. The recall began March 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C03.
Aug 28, 2019
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Apr 8, 2019
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence & remedy
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Additional source detail variants (2)
Engine
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Equipment:electrical
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Dec 18, 2018
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.
Consequence & remedy
Consequence: When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.
Aug 31, 2018
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence & remedy
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.
Additional source detail variants (2)
Seat Belts:pretensioner
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.
Structure:body:roof And Pillars
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.
Jun 12, 2018
Ford Motor Company (Ford) is recalling certain 2018 Ford Expedition, F-150, and Lincoln Navigator vehicles equipped with 3.5L GTDI V6 engines. These vehicles have high pressure fuel pump assemblies with welds that can fracture, which may cause an oil or fuel leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will replace the high pressure fuel pump and associated components, free of charge. The recall began July 17, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S17.
Apr 4, 2018
Ford Motor Company (Ford) is recalling certain 2017-2018 Ford F-150 and 2018 Ford Expedition and Mustang and Lincoln Navigator vehicles equipped with 10-speed automatic transmissions. A roll pin may not have been installed in the transmission, potentially causing a loss of the "Park" function.
Consequence & remedy
Consequence: Despite the transmission shift lever being placed in 'Park' and the instrument panel display indicating 'Park,' the vehicle may roll away after it has been exited if the parking brake has not been applied, increasing the risk of injury or a crash.
Remedy: Ford will notify owners, and dealers will inspect the transmission to make sure it has the roll pin, installing one if it is missing, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S09.
Apr 4, 2018
Ford Motor Company (Ford) is recalling certain 2018 F-650 and F-750 vehicles equipped with 6-speed automatic transmissions and 2018 Ford F-150 and Expedition vehicles equipped with 10-speed automatic transmissions (excluding Expedition vehicles with a Rotary Gear Shift Dial on the console). The gear shift cable clip may not be properly seated, allowing the transmission to be in a different gear than indicated by the gear shift lever position.
Consequence & remedy
Consequence: If the gear shift cable clip becomes unseated or dislodged, the gear shift lever position may indicate that the transmission is in 'Park' when it may be in a different gear. Additionally, despite selecting 'Park', if the parking brake is not applied before the vehicle is exited, the vehicle may roll. Either scenario increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the shift cable locking clip and properly seat it, if necessary, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for the recall is 18S10.
Additional source detail variants (2)
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain 2018 F-650 and F-750 vehicles equipped with 6-speed automatic transmissions and 2018 Ford F-150 and Expedition vehicles equipped with 10-speed automatic transmissions (excluding Expedition vehicles with a Rotary Gear Shift Dial on the console). The gear shift cable clip may not be properly seated, allowing the transmission to be in a different gear than indicated by the gear shift lever position.
Consequence: If the gear shift cable clip becomes unseated or dislodged, the gear shift lever position may indicate that the transmission is in 'Park' when it may be in a different gear. Additionally, despite selecting 'Park', if the parking brake is not applied before the vehicle is exited, the vehicle may roll. Either scenario increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the shift cable locking clip and properly seat it, if necessary, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for the recall is 18S10.
Power Train:automatic Transmission
Ford Motor Company (Ford) is recalling certain 2018 F-650 and F-750 vehicles equipped with 6-speed automatic transmissions and 2018 Ford F-150 and Expedition vehicles equipped with 10-speed automatic transmissions (excluding Expedition vehicles with a Rotary Gear Shift Dial on the console). The gear shift cable clip may not be properly seated, allowing the transmission to be in a different gear than indicated by the gear shift lever position.
Consequence: If the gear shift cable clip becomes unseated or dislodged, the gear shift lever position may indicate that the transmission is in 'Park' when it may be in a different gear. Additionally, despite selecting 'Park', if the parking brake is not applied before the vehicle is exited, the vehicle may roll. Either scenario increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the shift cable locking clip and properly seat it, if necessary, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for the recall is 18S10.
Oct 23, 2017
Ford Motor Company (Ford) is recalling certain 2018 F-150 vehicles equipped with a 3.3L engine, a 6-speed transmission and a column mounted shift lever. Quickly moving the shift lever from Park to Drive may cause a loss of gear indication on the instrument cluster display and a momentary selection of an unintended gear, such as Reverse or Neutral before the vehicle achieves Drive function.
Consequence & remedy
Consequence: Unidentified or unintended gear selection may cause the vehicle to move in a way that was not intended by the driver, increasing the risk of crash or injury.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 17S35.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:column Shift
Ford Motor Company (Ford) is recalling certain 2018 F-150 vehicles equipped with a 3.3L engine, a 6-speed transmission and a column mounted shift lever. Quickly moving the shift lever from Park to Drive may cause a loss of gear indication on the instrument cluster display and a momentary selection of an unintended gear, such as Reverse or Neutral before the vehicle achieves Drive function.
Consequence: Unidentified or unintended gear selection may cause the vehicle to move in a way that was not intended by the driver, increasing the risk of crash or injury.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 17S35.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Ford Motor Company (Ford) is recalling certain 2018 F-150 vehicles equipped with a 3.3L engine, a 6-speed transmission and a column mounted shift lever. Quickly moving the shift lever from Park to Drive may cause a loss of gear indication on the instrument cluster display and a momentary selection of an unintended gear, such as Reverse or Neutral before the vehicle achieves Drive function.
Consequence: Unidentified or unintended gear selection may cause the vehicle to move in a way that was not intended by the driver, increasing the risk of crash or injury.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 17S35.
Oct 23, 2017
Ford Motor Company (Ford) is recalling certain 2018 F-150 vehicles equipped with 3.5L engines. The cylinder heads may have been machined without lubrication supply holes for the camshaft bearing journals.
Consequence & remedy
Consequence: Without a proper supply of lubrication, the engine will fail, causing a stall and increasing the risk of a crash.
Remedy: Ford is not aware of any affected vehicles outside of dealer control. Should owner contact subsequently be required, arrangements will be made to transport their vehicle to a Ford or Lincoln dealer to have the engine replaced.The recall began October 24, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S37.
Sep 25, 2017
Ford Motor Company (Ford) is recalling certain 2018 Ford F-150 Raptor Super Cab pick-up trucks not equipped with a moonroof. The structural roof braces may be missing rivets at the attachment of the roof rail, thereby reducing the structural integrity.
Consequence & remedy
Consequence: If the structural integrity is reduced, in the event of a rollover crash, there may be an increased risk of injury .
Remedy: Ford will notify owners, and dealers will install the rivets for the roof brace attachments, free of charge. The recall began October 17, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S29.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE24019 · Low-pressure Fuel Pump Failure
Opened Jul 29, 2024 · Closed Sep 19, 2025
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
On July 29, 2024, the Office of Defects Investigation (ODI) opened PE24019 to investigate complaints of low-pressure fuel pump failures in MY 2021 Ford Bronco vehicles. Some consumers reported that the failure occurred without warning while driving, resulting in a complete loss of motive power with no ability to restart the engine. Ford determined that several other vehicle models contain low-pressure fuel pumps substantially similar to the 2021 Ford Bronco, including the 2022-2023 Ford Bronco, 2018-2023 Ford F-150, 2022-2023 Ford Expedition, 2019-2023 Lincoln Navigator, 2020-2023 Ford F-250-F-550, 2024 Ford Super Duty Chassis Cab, 2024-2025 Ford Ranger, 2020-2023 Ford Explorer, 2020-2023 Lincoln Aviator, and 2021-2025 Ford Mustang. ODI's investigation found that the affected vehicles may lose fuel pressure and flow from the fuel delivery module (consisting of a low-pressure fuel pump, jet pump, reservoir, and other parts) due to a low-pressure pump failure. This can cause the engine to stall while driving. The root cause is reduced internal clearance in the fuel pump, increasing friction and sensitivity to vapor lock. Fuel blockage from contamination inside the jet pump also contributed to the failure. Ford stated that the contamination source was unknown. On July 7, 2025, Ford filed recall 25V-455 for certain 2021-2023 Ford F-550 SD/F-450 SD/F-350 SD/F-250 SD, 2021-2022 Lincoln Navigator, 2021-2022 Ford Mustang, 2021-2022 Ford F-150, 2021-2023 Ford Explorer, 2022 Ford Expedition, and 2021-2023 Ford Bronco vehicles produced between July 1, 2021, and July 30, 2022. The recall also included certain 2021-2023 Lincoln Aviator produced between July 1, 2021, and December 21, 2022. Ford explained in its recall filingthat the production dates used for the recall were based on changes in the manufacturing process. Specifically, Ford determined that in June 2021, the supplier modified the jet pump manufacturing process, producing fuel pump chambers with a lower-than-specified internal clearance. In July 2022, the supplier implemented corrective actions to the manufacturing process by adding two additional vacuum pumps to reduce contamination during the production of the jet pump. ODI has identified approximately 1,000 reports involving vehicles covered in this investigation but excluded from recall 25V-455. However, even with such reports, these vehicles experienced comparatively lower failure rates than the vehicles that are subject to Recall 25V-455. Ford has explained that these vehicles were excluded from the recall population because they did not experience the manufacturing changes that prompted the recall. Specifically, according to Ford, vehicles built before July 1, 2021 (the recall production start date), were not affected by the supplier’s change to the jet pump manufacturing process. Even after closing this investigation, ODI will continue to monitor complaints for vehicles excluded from recall 25V-455 to consider whether they exhibit the same risks as the vehicles encompassed by the recall. The recall remedy is currently under development. In view of Ford’s recall action, ODI is closing this Preliminary Evaluation, but will continue to monitor the issue as a remedy is developed and implemented. ODI will take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18008 · Seatbelt Pretensioner Fire
Opened Aug 3, 2018 · Closed Dec 17, 2018
Status: closed (inferred from source dates) · Seat Belts:pretensioner
On June 18, 2018, the Office of Defects Investigations (ODI) opened a Preliminary Evaluation (PE18-008) to investigate complaints alleging post-crash fires at the B pillar in the area of the seat belt pretensioners on MY 2014-2018 Ford F-150 Regular Cab, and Super Crew Cab Vehicles. On August 24, 2018, Ford Motor Company recalled (FSA 18S27 - NHTSA #18V568) the affected population. Ford's investigation found that some front seat belt pretensioners may generate sparks during deployment in excess of Ford's specification. Sparks in the pretensioner exhaust gases inside the lower portion of the B-pillar may subsequently ignite combustible components contained in the B-pillar, such as insulation or carpet, and may cause a subsequent vehicle fire. ODI also requested relevant information from other manufacturers to assess the potential scope of post-crash pretensioner fires. Ford will notify owners and require dealers to remove B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall notification began September 28, 2018.Owners may contact Ford customer service at 1-866-436-7332.The VOQs associated with the closing of this investigation are: 11143035, 11130056, 11129828, 11128761, 11127993, 11127880, 11124717, 11123419, 11119651, 11119626, 11114065, 11113160, 11111822, 11097937, 11078447, 11014688
Illustration