NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
26 reportsClear category filterMileage unknown · Aug 5, 2024
Fuel/propulsion SystemVehicle Speed Control
The 5.0L Ford F-150 Engine experienced a P2005 :Manifold Runner Control Stuck Open Bank 2. This code triggers when the powertrain control module (PCM) can't control the intake manifold runner as requested . It also experienced a P2007 This code may be set due to a bad intake manifold runner solenoid or actuator with a mechanical…
Read full complaint
The 5.0L Ford F-150 Engine experienced a P2005 :Manifold Runner Control Stuck Open Bank 2. This code triggers when the powertrain control module (PCM) can't control the intake manifold runner as requested . It also experienced a P2007 This code may be set due to a bad intake manifold runner solenoid or actuator with a mechanical failure within the intake manifold runner system. symptoms included poor engine performance, reduced fuel efficiency, and engine surge. It also has a P2019 DTC CODE related to the intake manifold flow control valve/position sensor, also called known as a IMRC valve/sensor (typically located at one end of the intake manifold) which helps the vehicle’s PCM control the amount of air being allowed into the engine at various RPMs. This code is set for Bank 2 errors. This is a safety issue as my vehicle slowed down and experienced significant power loss on the highway. FORD is aware of this problem with defective parts and has not issued a recall. FORD'S answer is have the entire intake manifold replaced at the owners cost.
NHTSA ODI #11606496
Mileage unknown · Oct 6, 2023
EngineFuel/propulsion SystemPower Train
I was driving at highway speeds (60mph) in congested traffic on a road with a steep incline with no shoulder when the truck suddenly went into limp mode when it downshifted. The engine went to idle and I had to coast to the far edge of the right line before coming to a stop. Multiple cars around me had to take evasive action. Th…
Read full complaint
I was driving at highway speeds (60mph) in congested traffic on a road with a steep incline with no shoulder when the truck suddenly went into limp mode when it downshifted. The engine went to idle and I had to coast to the far edge of the right line before coming to a stop. Multiple cars around me had to take evasive action. This could have been catastrophic if I had been crossing an intersection. Similar reports online indicates issue with the Electronic Throttle Body which creates an error that causes the truck to go into limp mode. Turning the truck off and back on again reset the condition so I could safely pull off to a side road to further evaluate. The limp mode feature is entirely unsafe and places the safety of the vehicle's mechanical components over the safety of the occupants. I would rather damage or destroy my engine in the process of safely exiting the roadway than come to an unexpected stop in an unsafe location.
NHTSA ODI #11548582
Mileage unknown · Jun 13, 2023
Fuel/propulsion System
My 2017 Ford F150 truck developed a fuel leak in the line between the gas tank and the engine. The leak is located at a disconnect fitting where the steel tubing from the tank transitions to nylon tubing. This presents a fire risk. The vehicle did not provide any warning messages. I discovered the leak after smelling fuel wh…
Read full complaint
My 2017 Ford F150 truck developed a fuel leak in the line between the gas tank and the engine. The leak is located at a disconnect fitting where the steel tubing from the tank transitions to nylon tubing. This presents a fire risk. The vehicle did not provide any warning messages. I discovered the leak after smelling fuel when parked after driving.
NHTSA ODI #11526740
Mileage unknown · Feb 20, 2023
Fuel/propulsion SystemPower TrainVehicle Speed Control
While traveling down the interstate at the posted speed limit of 70 MPH in the fast lane, I experienced the vehicle immediately hesitating without pressing the brake and a loud grinding noise in the front drivers side and caused me to put on my brakes, change lanes and drive off to the side of the road. The grinding stopped and…
Read full complaint
While traveling down the interstate at the posted speed limit of 70 MPH in the fast lane, I experienced the vehicle immediately hesitating without pressing the brake and a loud grinding noise in the front drivers side and caused me to put on my brakes, change lanes and drive off to the side of the road. The grinding stopped and then it happened again about 20 more miles down the road. I was able to get it to the Ford dealership and was told it was a defective IWE Check Valve which attempted to put my vehicle into 4 Wheel Drive. As a result, I had to replace the Front IWE and the new & improved IWE Check Valve which was designed to prevent this from happening in the future. For obvious reasons, I became upset that a known issue with defective IWE check valves causes this event to occur. After exploring the internet for this same exact problem, I found this has been going on for more than 5 years. I now have the "corrected" part, but my major concern is that while I did not get into an accident this time, what is to prevent it from happening to someone who may not exhibit the same composure and causes their vehicle to crash into someone else and death or injury is caused and could have been prevented with a relatively cheap replacement part.
NHTSA ODI #11508215
Mileage unknown · Aug 14, 2022
Fuel/propulsion SystemInjury
Yesterday evening, 8/13/2022, I had my family in the F150 TRUCK. We were traveling at 77 mph (in a 70 mph zone) on toll route 576 enroute to Pittsburgh Airport. The F150 TRUCK was on cruise control (this time) when it downshifted from 10th gear to 1st gear. My neck is very sore, now. It continued to mis-shift although no ser…
Read full complaint
Yesterday evening, 8/13/2022, I had my family in the F150 TRUCK. We were traveling at 77 mph (in a 70 mph zone) on toll route 576 enroute to Pittsburgh Airport. The F150 TRUCK was on cruise control (this time) when it downshifted from 10th gear to 1st gear. My neck is very sore, now. It continued to mis-shift although no service light illuminated this time. The milage during this incident was 53,809.3 (give or take a mile or two, I don't take pictures when at the wheel of F150 TRUCK) All my family was traumatized again. The truck made it to the airport. Where we picked up our foreign exchange student from Japan named Jua. The ride home, I white knuckled the steering wheel, not knowing when we would go out of control. The truck made it home without causing death to our family or innocent civilians. This is the second time this has occurred. Ford attempted to fix with valve body replacement.
NHTSA ODI #11479227
Mileage unknown · Jul 5, 2022
EngineFuel/propulsion System
Incident x2: When coming to a stop after towing, once on the off ramp and the other at the gas station, the truck died/stopped running and would not stay started when trying to restart. Both times, the gas tank was at 50 miles to empty, and while in tow mode, towing a camper trailer. First time we had it towed to dealer, they fo…
Read full complaint
Incident x2: When coming to a stop after towing, once on the off ramp and the other at the gas station, the truck died/stopped running and would not stay started when trying to restart. Both times, the gas tank was at 50 miles to empty, and while in tow mode, towing a camper trailer. First time we had it towed to dealer, they found nothing wrong, no faulty codes. Second time, after fueling, started the truck and pressed the gas pedal for about 10-15 seconds to RPM at 4000 then let off gas and truck stayed running. Seems something in the gas line, tank or computer system. Does not happen when not towing.
NHTSA ODI #11472314
Mileage unknown · Oct 31, 2021
Electrical SystemEngineFuel/propulsion System
Check engine light on error code P2007 Runner control was replaced via Ford OEM PART #FR3Z 9J559 C Ran well for 2 days then stopped working.
NHTSA ODI #11438805
50,000 miles · Apr 19, 2021
Electrical SystemEngineFuel/propulsion System
AFTER TOWING MY 2017 FORD F150 ECOBOOST EXHIBITS AN INTERMITTENT ENGINE STALL WHEN COMING TO A STOP WHILE TOWING. EXACT SAME ISSUE AS BELOW TSB, JUST MINE IS A 2017 MODEL TECHNICAL SERVICE BULLETIN 2.7L - WHILE TOWING - INTERMITTENT ENGINE STALL WHEN COMING TO A STOP - BUILT ON OR BEFORE 27-NOV-2017 18- 2249 16 AUGUST …
Read full complaint
AFTER TOWING MY 2017 FORD F150 ECOBOOST EXHIBITS AN INTERMITTENT ENGINE STALL WHEN COMING TO A STOP WHILE TOWING. EXACT SAME ISSUE AS BELOW TSB, JUST MINE IS A 2017 MODEL TECHNICAL SERVICE BULLETIN 2.7L - WHILE TOWING - INTERMITTENT ENGINE STALL WHEN COMING TO A STOP - BUILT ON OR BEFORE 27-NOV-2017 18- 2249 16 AUGUST 2018 MODEL: FORD 2018 F-150 ISSUE: SOME 2018 F-150 VEHICLES EQUIPPED WITH A 2.7L ECOBOOST ENGINE AND BUILT ON OR BEFORE 27-NOV2017 MAY EXHIBIT AN INTERMITTENT ENGINE STALL WHEN COMING TO A STOP WHILE TOWING. ACTION: FOLLOW THE SERVICE PROCEDURE STEPS TO CORRECT THE CONDITION. WARRANTY STATUS: ELIGIBLE UNDER PROVISIONS OF NEW VEHICLE LIMITED WARRANTY COVERAGE WARRANTY/ESP COVERAGE LIMITS/POLICIES/PRIOR APPROVALS ARE NOT ALTERED BY A TSB. WARRANTY/ESP COVERAGE LIMITS ARE DETERMINED BY THE IDENTIFIED CAUSAL PART AND VERIFIED USING THE OASIS PART COVERAGE TOOL. LABOR TIMES DESCRIPTION OPERATION NO. TIME 2018 F-150 2.7L: REPROGRAM THE PCM (DO NOT USE WITH ANY OTHER LABOR OPERATIONS) 182249A 0.3 HRS. REPAIR/CLAIM CODING CAUSAL PART: RECAL CONDITION CODE: 04
NHTSA ODI #11412811
53,000 miles · Dec 20, 2020
Electrical SystemFuel/propulsion System
THE VEHICLE BEGINS TO SHUT DOWN AFTER GAS FILL UP. IT SEEMS LIKE THE VEHICLE HAS A VALVE SELENOID PROBLEM BECAUSE EVERYBODY IS TALKING ABOUT IT ONLINE. IT IS A HAZARD BECAUSE THE VEHICLE WILL TURN OFF WHILE DRIVING. I HAVE ALSO HAVE HAD TO REPLACE THE ELECTRIC USB AND POWER PLUG TWICE. THIS VEHICLE HAS ALOT OF ELECTRIC/GAS RE…
Read full complaint
THE VEHICLE BEGINS TO SHUT DOWN AFTER GAS FILL UP. IT SEEMS LIKE THE VEHICLE HAS A VALVE SELENOID PROBLEM BECAUSE EVERYBODY IS TALKING ABOUT IT ONLINE. IT IS A HAZARD BECAUSE THE VEHICLE WILL TURN OFF WHILE DRIVING. I HAVE ALSO HAVE HAD TO REPLACE THE ELECTRIC USB AND POWER PLUG TWICE. THIS VEHICLE HAS ALOT OF ELECTRIC/GAS RELATED ISSUES WHICH CAUSE IT TO TURN OFF.
NHTSA ODI #11384222
31,713 miles · Dec 22, 2019
Fuel/propulsion System
WHILE DRIVING IN LOCAL SHOPPING CENTER BETWEEN STORE #1 AND STORE #2 APPROXIMATELY DISTANCE OF 300 FEET, THE FRONT OF MY GAS TANK FELL TO THE PAVEMENT WHILE THE REAR OF THE TANK REMAINED. I CONTACTED THE FORD ROADSIDE SERVICE WHICH DISPATCHED A TOW VEHICLE THE TOW DRIVER WAS ABLE TO RAISE THE FRONT ENOUGH TO GET MY TRUCK ONTO TH…
Read full complaint
WHILE DRIVING IN LOCAL SHOPPING CENTER BETWEEN STORE #1 AND STORE #2 APPROXIMATELY DISTANCE OF 300 FEET, THE FRONT OF MY GAS TANK FELL TO THE PAVEMENT WHILE THE REAR OF THE TANK REMAINED. I CONTACTED THE FORD ROADSIDE SERVICE WHICH DISPATCHED A TOW VEHICLE THE TOW DRIVER WAS ABLE TO RAISE THE FRONT ENOUGH TO GET MY TRUCK ONTO THE TOW TRUCK. THIS INCIDENT HAPPENED AT 5:15 PM ON 12/21/2019 TEMPERATURE AT 70 DEGREES.
NHTSA ODI #11290668
Official recalls
17Jun 9, 2026
Ford Motor Company (Ford) is recalling certain 2017 F-150 vehicles previously repaired incorrectly under recall number 17V053. The instrument cluster may lose power after initial vehicle start-up in cold ambient temperatures. Several gauges, including the transmission gear position indicator, may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect."
Consequence & remedy
Consequence: An instrument cluster that fails to display critical safety information, such as gear position or warning lights, increases the risk of a crash or injury.
Remedy: Dealers will update the Instrument Panel Cluster Assembly (IPC) software, free of charge. Owner notification letters were mailed July 17, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C26. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.
Apr 14, 2026
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150 vehicles. A loss of signal between the transmission range sensor and the powertrain control module can cause the transmission to unexpectedly downshift into second gear.
Consequence & remedy
Consequence: Unexpectedly downshifting into second gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed July 24, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S28. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 15, 2026.
Apr 11, 2025
Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence & remedy
Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:master Cylinder
Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.
Service Brakes, Hydraulic:power Assist
Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.
Mar 11, 2022
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Expedition, Lincoln Navigator, and 2016-2018 F-150 vehicles equipped with 3.5L Ecoboost engines. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence & remedy
Consequence: A loss of brake fluid may result in a change in brake pedal travel, increased pedal effort and reduced front brake function, requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. An interim owner notification letter notifying customers of the safety defect were mailed on April 29, 2022. Owner notification letters were mailed April 29, 2022. This recall is an expansion of NHTSA recall number 20V-332. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S11.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:master Cylinder
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Expedition, Lincoln Navigator, and 2016-2018 F-150 vehicles equipped with 3.5L Ecoboost engines. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel, increased pedal effort and reduced front brake function, requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. An interim owner notification letter notifying customers of the safety defect were mailed on April 29, 2022. Owner notification letters were mailed April 29, 2022. This recall is an expansion of NHTSA recall number 20V-332. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S11.
Service Brakes, Hydraulic:power Assist
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Expedition, Lincoln Navigator, and 2016-2018 F-150 vehicles equipped with 3.5L Ecoboost engines. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel, increased pedal effort and reduced front brake function, requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. An interim owner notification letter notifying customers of the safety defect were mailed on April 29, 2022. Owner notification letters were mailed April 29, 2022. This recall is an expansion of NHTSA recall number 20V-332. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S11.
Jun 8, 2020
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence & remedy
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:master Cylinder
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
Service Brakes, Hydraulic:power Assist
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
Apr 8, 2019
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence & remedy
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Additional source detail variants (2)
Engine
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Equipment:electrical
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Dec 18, 2018
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.
Consequence & remedy
Consequence: When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.
Aug 31, 2018
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence & remedy
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.
Additional source detail variants (2)
Seat Belts:pretensioner
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.
Structure:body:roof And Pillars
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.
Apr 4, 2018
Ford Motor Company (Ford) is recalling certain 2017-2018 Ford F-150 and 2018 Ford Expedition and Mustang and Lincoln Navigator vehicles equipped with 10-speed automatic transmissions. A roll pin may not have been installed in the transmission, potentially causing a loss of the "Park" function.
Consequence & remedy
Consequence: Despite the transmission shift lever being placed in 'Park' and the instrument panel display indicating 'Park,' the vehicle may roll away after it has been exited if the parking brake has not been applied, increasing the risk of injury or a crash.
Remedy: Ford will notify owners, and dealers will inspect the transmission to make sure it has the roll pin, installing one if it is missing, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S09.
Oct 24, 2017
Ford Motor Company (Ford) is recalling certain 2017 F-150 vehicles equipped with ten-speed transmissions. The pin that attaches the transmission shift linkage to the transmission may come out, preventing the transmission from responding to movement of the shift lever.
Consequence & remedy
Consequence: The disconnected linkage may cause the vehicle to not move forward or backward as selected by the driver with the shift lever. Additionally, despite selecting 'Park', if the parking brake is not applied, the vehicle may roll. Either scenario increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the roll pin with an updated part, free of charge. The recall is expected to begin December 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S36.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain 2017 F-150 vehicles equipped with ten-speed transmissions. The pin that attaches the transmission shift linkage to the transmission may come out, preventing the transmission from responding to movement of the shift lever.
Consequence: The disconnected linkage may cause the vehicle to not move forward or backward as selected by the driver with the shift lever. Additionally, despite selecting 'Park', if the parking brake is not applied, the vehicle may roll. Either scenario increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the roll pin with an updated part, free of charge. The recall is expected to begin December 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S36.
Power Train:automatic Transmission:lever And Linkage:column Shift
Ford Motor Company (Ford) is recalling certain 2017 F-150 vehicles equipped with ten-speed transmissions. The pin that attaches the transmission shift linkage to the transmission may come out, preventing the transmission from responding to movement of the shift lever.
Consequence: The disconnected linkage may cause the vehicle to not move forward or backward as selected by the driver with the shift lever. Additionally, despite selecting 'Park', if the parking brake is not applied, the vehicle may roll. Either scenario increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the roll pin with an updated part, free of charge. The recall is expected to begin December 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S36.
Oct 16, 2017
Ford Motor Company (Ford) is recalling certain 2015-2017 Ford F-150, and 2017 F-250, F-350, F-450, and F-550 Super Duty trucks. The doors on these vehicles may have a bent or kinked actuation cable or the door latches may freeze after water gets into the latch. Either condition can result in the doors opening while driving although they appear to be closed.
Consequence & remedy
Consequence: A door that opens while driving can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will inspect the door latch actuation cables and repair if necessary, and install water shields over the door latches, free of charge. The recall began October 12, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S33.
Sep 25, 2017
Ford Motor Company (Ford) is recalling certain 2017 Ford F-150, F-250, F-350, F-450, and F-550 trucks with manually-adjusted front passenger seats. The seat belt anchor may not be adequately welded to the seat cushion frame. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages," and 207, "Seating Systems."
Consequence & remedy
Consequence: The seat belt buckle weld may fail, preventing the occupants from being properly restrained in the event of a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will replace the front passenger manual seat track, free of charge. The recall is expected to begin November 6, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C17.
Additional source detail variants (2)
Seats
Ford Motor Company (Ford) is recalling certain 2017 Ford F-150, F-250, F-350, F-450, and F-550 trucks with manually-adjusted front passenger seats. The seat belt anchor may not be adequately welded to the seat cushion frame. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages," and 207, "Seating Systems."
Consequence: The seat belt buckle weld may fail, preventing the occupants from being properly restrained in the event of a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will replace the front passenger manual seat track, free of charge. The recall is expected to begin November 6, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C17.
Seat Belts:front:anchorage
Ford Motor Company (Ford) is recalling certain 2017 Ford F-150, F-250, F-350, F-450, and F-550 trucks with manually-adjusted front passenger seats. The seat belt anchor may not be adequately welded to the seat cushion frame. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages," and 207, "Seating Systems."
Consequence: The seat belt buckle weld may fail, preventing the occupants from being properly restrained in the event of a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will replace the front passenger manual seat track, free of charge. The recall is expected to begin November 6, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C17.
Aug 28, 2017
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250 and F-350 trucks equipped with a crew cab. The left rear inflatable seat belt buckle assembly may be inadequately attached to its mounting bracket. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages."
Consequence & remedy
Consequence: If the left rear inflatable seat belt buckle separates from it's mounting bracket, the seat occupant may not be adequately restrained, increasing their risk of injury.
Remedy: Ford will notify owners, and dealers will inspect the seat belt assembly, replacing the attaching rivet as necessary, free of charge. Interim notices informing owners of the safety risk were mailed October 18, 2017. Owners will receive a second notice when the remedy becomes available. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 17C12.
Aug 28, 2017
Ford Motor Company (Ford) is recalling certain 2017 F-150 and Mustang vehicles. The air bag inflator within the passenger frontal air bag module may rupture in the event of a crash.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began October 11, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S26.
May 22, 2017
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250, F-350, F-450, and F-550 vehicles originally produced with black or body colored exterior door handles that may have been subsequently equipped with a chrome exterior door handle cover accessory kit purchased from a Ford dealer. These accessory door handle covers may cause the doors to unlatch in a side impact collision. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."
Consequence & remedy
Consequence: If the doors unlatch and open in a side impact collision, the occupants have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will remove the accessory covers and refund the purchase price. The recall began July 13, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for the recall is 17C09.
Additional source detail variants (2)
Latches/locks/linkages:doors:latch
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250, F-350, F-450, and F-550 vehicles originally produced with black or body colored exterior door handles that may have been subsequently equipped with a chrome exterior door handle cover accessory kit purchased from a Ford dealer. These accessory door handle covers may cause the doors to unlatch in a side impact collision. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."
Consequence: If the doors unlatch and open in a side impact collision, the occupants have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will remove the accessory covers and refund the purchase price. The recall began July 13, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for the recall is 17C09.
Structure:body:door
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250, F-350, F-450, and F-550 vehicles originally produced with black or body colored exterior door handles that may have been subsequently equipped with a chrome exterior door handle cover accessory kit purchased from a Ford dealer. These accessory door handle covers may cause the doors to unlatch in a side impact collision. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."
Consequence: If the doors unlatch and open in a side impact collision, the occupants have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will remove the accessory covers and refund the purchase price. The recall began July 13, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for the recall is 17C09.
May 22, 2017
Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: If the occupant is not adequately restrained in the event of a crash, they have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.
Additional source detail variants (2)
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."
Consequence: If the occupant is not adequately restrained in the event of a crash, they have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.
Seats
Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."
Consequence: If the occupant is not adequately restrained in the event of a crash, they have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.
Jan 24, 2017
Ford Motor Company (Ford) is recalling certain 2017 F-150 trucks equipped with an eight-inch productivity screen. In these vehicles, the instrument cluster may lose power after the initial vehicle start-up in cold ambient temperatures. Several gauges, including the transmission gear position indicator, may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicles Safety Standard (FMVSS) number 102, "Transmission shift position sequence, starter interlock, and transmission braking effect."
Consequence & remedy
Consequence: If the transmission gear position indicator fails to illuminate, the driver may be unable to tell the transmission shift position, increasing the risk of a crash or injury from unintended vehicle movement.
Remedy: Ford will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began February 20, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C01.
Additional source detail variants (2)
Electrical System: Instrument Cluster/panel
Ford Motor Company (Ford) is recalling certain 2017 F-150 trucks equipped with an eight-inch productivity screen. In these vehicles, the instrument cluster may lose power after the initial vehicle start-up in cold ambient temperatures. Several gauges, including the transmission gear position indicator, may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicles Safety Standard (FMVSS) number 102, "Transmission shift position sequence, starter interlock, and transmission braking effect."
Consequence: If the transmission gear position indicator fails to illuminate, the driver may be unable to tell the transmission shift position, increasing the risk of a crash or injury from unintended vehicle movement.
Remedy: Ford will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began February 20, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C01.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain 2017 F-150 trucks equipped with an eight-inch productivity screen. In these vehicles, the instrument cluster may lose power after the initial vehicle start-up in cold ambient temperatures. Several gauges, including the transmission gear position indicator, may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicles Safety Standard (FMVSS) number 102, "Transmission shift position sequence, starter interlock, and transmission braking effect."
Consequence: If the transmission gear position indicator fails to illuminate, the driver may be unable to tell the transmission shift position, increasing the risk of a crash or injury from unintended vehicle movement.
Remedy: Ford will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began February 20, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C01.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA26001 · Unintended Transmission Downshift And Rear Wheel Lock-up
Opened Jan 30, 2026 · No close date supplied
Status: open (inferred from source dates) · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
On March 21, 2025, NHTSA’s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE25002) to investigate instances of unexpected transmission downshifting without driver input in model year (MY) 2015-2017 Ford F-150 vehicles (subject vehicles) manufactured by Ford Motor Company (Ford). The complaints allege that, without warning or driver input, the subject vehicles experienced a sudden and rapid deceleration often accompanied by temporary rear wheel lockup, seizure, or skidding, resulting in a loss of vehicle control that increases the risk of crash and injury to all motorists, including those not within the subject vehicles. The MY 2015 and MY 2016 F-150 vehicles were equipped with the “6R80” transmission, while the MY 2017 vehicles were equipped with either the “6R80” transmission or the “10R80” transmission. This investigation was limited to MY 2015-2017 Ford F-150 with the “6R80” transmission. ODI identified 329 Vehicle Owners Questionnaires (VOQs) related to this investigation and sixty percent of these consumers were interviewed to confirm the details of their allegations. Consumers reported that their vehicles’ transmission suddenly downshifted to a lower gear, often to 1st or 2nd gear, without driver input or advance warning. Consumers described the downshift events to be regular and repeated occurrences, with some consumers stating that they no longer drive the vehicle due to safety concerns. Forty-three percent of consumers reported experiencing at least one wheel lockup event, during which the rear tires locked, screeched, or skidded during the transmission downshift. ODI also found that 114 of the 329 consumers reported having their vehicle’s molded lead frame or valve body assembly (which comes with a molded lead frame) replaced, 80 of which were confirmed through consumer submitted repair invoices. In its response to ODI’s Information Request, Ford provided an assessment of potential root cause of failure for the subject vehicles and how this failure is different from the failure associated with MY 2011-2014 Ford F-150 vehicles that was addressed by four safety recalls (16V-248, 19V-075, 19V-433, and 24V-444). Ford has identified that the defect in the recalled vehicle population involved lead frame supplier production issues resulting in signal loss from the Output Shaft Speed (OSS) sensor. Ford has identified that the alleged defect in the subject vehicle population involved degradation of electrical connections within the lead frame due to thermal cycling and vibration over extended time in service resulting in signal loss from the Transmission Range Sensor (TRS). Signal loss from the TRS can result in an unintended shift to neutral, unintended upshift, or unintended downshift which are regulated by a gear “shift map” based on the vehicle’s speed at the time of signal loss. According to Ford’s “shift map”, at speeds between 35-64 mph, the maximum allowable downshift would be to 2nd gear (i.e. a 6th to 2nd gear downshift event) which Ford has designated to represent the worst-case scenario for subject vehicles. Ford has also acknowledged that the worst-case scenario may also involve temporary wheel lockup. However, Ford has stated that the failure mechanism in the MY 2011-2014 F-150 vehicles—previously addressed through recalls—primarily involved OSS sensor signal loss that could result in 6th to 1st gear downshift events. This OSS-related failure mode is distinct from the TRS-related signal loss identified in the subject vehicle population. ODI has identified an additional potential safety defect associated with the alleged defect in the subject vehicles. Preliminary testing performed by NHTSA’s Vehicle Research Test Center (VRTC) showed that when the TRS experiences an intermittent signal loss, one possible outcome is a change in vehicle direction. Specifically, if a vehicle is operating in reverse up an incline when the TRS signal loss occurs, then the vehicle may shift into neutral causing the vehicle to change directions and roll forward. ODI is opening this Engineering Analysis (EA) to, among other things, perform component-level testing and vehicle testing, as well as review additional technical information to better understand the alleged defect that has been identified. To review the reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25002 · Unintended Transmission Downshift And Rear Wheel Lock-up
Opened Mar 21, 2025 · Closed Jan 30, 2026
Status: closed (inferred from source dates) · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
On March 21, 2025, NHTSA’s Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE25002) to investigate instances of unexpected transmission downshifting without driver input in model year (MY) 2015-2017 Ford F-150 vehicles (subject vehicles) manufactured by Ford Motor Company (Ford). The complaints allege that, without warning or driver input, the subject vehicles experienced a sudden and rapid deceleration often accompanied by temporary rear wheel lockup, seizure, or skidding, resulting in a loss of vehicle control that increases the risk of crash and injury to all motorists, including those not within the subject vehicles. The MY 2015 and MY 2016 F-150 vehicles were equipped with the “6R80” transmission, while the MY 2017 vehicles were equipped with either the “6R80” transmission or the “10R80” transmission. This investigation was limited to MY 2015-2017 Ford F-150 with the “6R80” transmission. ODI identified 329 Vehicle Owners Questionnaires (VOQs) related to this investigation and sixty percent of these consumers were interviewed to confirm the details of their allegations. Consumers reported that their vehicles’ transmission suddenly downshifted to a lower gear, often to 1st or 2nd gear, without driver input or advance warning. Consumers described the downshift events to be regular and repeated occurrences, with some consumers stating that they no longer drive the vehicle due to safety concerns. Forty-three percent of consumers reported experiencing at least one wheel lockup event, during which the rear tires locked, screeched, or skidded during the transmission downshift. ODI also found that 114 of the 329 consumers reported having their vehicle’s molded lead frame or valve body assembly (which comes with a molded lead frame) replaced, 80 of which were confirmed through consumer submitted repair invoices. In its response to ODI’s Information Request, Ford provided an assessment of potential root cause of failure for the subject vehicles and how this failure is different from the failure associated with MY 2011-2014 Ford F-150 vehicles that was addressed by four safety recalls (16V-248, 19V-075, 19V-433, and 24V-444). Ford has identified that the defect in the recalled vehicle population involved lead frame supplier production issues resulting in signal loss from the Output Shaft Speed (OSS) sensor. Ford has identified that the alleged defect in the subject vehicle population involved degradation of electrical connections within the lead frame due to thermal cycling and vibration over extended time in service resulting in signal loss from the Transmission Range Sensor (TRS). Signal loss from the TRS can result in an unintended shift to neutral, unintended upshift, or unintended downshift which are regulated by a gear “shift map” based on the vehicle’s speed at the time of signal loss. According to Ford’s “shift map”, at speeds between 35-64 mph, the maximum allowable downshift would be to 2nd gear (i.e. a 6th to 2nd gear downshift event) which Ford has designated to represent the worst-case scenario for subject vehicles. Ford has also acknowledged that the worst-case scenario may also involve temporary wheel lockup. However, Ford has stated that the failure mechanism in the MY 2011-2014 F-150 vehicles—previously addressed through recalls—primarily involved OSS sensor signal loss that could result in 6th to 1st gear downshift events. This OSS-related failure mode is distinct from the TRS-related signal loss identified in the subject vehicle population. ODI has identified an additional potential safety defect associated with the alleged defect in the subject vehicles. Preliminary testing performed by NHTSA’s Vehicle Research Test Center (VRTC) showed that when the TRS experiences an intermittent signal loss, one possible outcome is a change in vehicle direction. Specifically, if a vehicle is operating in reverse up an incline when the TRS signal loss occurs, then the vehicle may shift into neutral causing the vehicle to change directions and roll forward. Based on NHTSA’s analysis of consumer data, information provided by Ford, and preliminary testing conducted by NHTSA’s VRTC, this Preliminary Evaluation is being upgraded to an Engineering Analysis (EA26001). During this Engineering Analysis, the agency plans to, among other things, perform component-level testing and vehicle testing, as well as review additional technical information to better understand the alleged defect that has been identified from this Preliminary Evaluation. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18008 · Seatbelt Pretensioner Fire
Opened Aug 3, 2018 · Closed Dec 17, 2018
Status: closed (inferred from source dates) · Seat Belts:pretensioner
On June 18, 2018, the Office of Defects Investigations (ODI) opened a Preliminary Evaluation (PE18-008) to investigate complaints alleging post-crash fires at the B pillar in the area of the seat belt pretensioners on MY 2014-2018 Ford F-150 Regular Cab, and Super Crew Cab Vehicles. On August 24, 2018, Ford Motor Company recalled (FSA 18S27 - NHTSA #18V568) the affected population. Ford's investigation found that some front seat belt pretensioners may generate sparks during deployment in excess of Ford's specification. Sparks in the pretensioner exhaust gases inside the lower portion of the B-pillar may subsequently ignite combustible components contained in the B-pillar, such as insulation or carpet, and may cause a subsequent vehicle fire. ODI also requested relevant information from other manufacturers to assess the potential scope of post-crash pretensioner fires. Ford will notify owners and require dealers to remove B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall notification began September 28, 2018.Owners may contact Ford customer service at 1-866-436-7332.The VOQs associated with the closing of this investigation are: 11143035, 11130056, 11129828, 11128761, 11127993, 11127880, 11124717, 11123419, 11119651, 11119626, 11114065, 11113160, 11111822, 11097937, 11078447, 11014688
Illustration