NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
299 reportsClear category filter54,439 miles · Aug 20, 2020
Electrical SystemService BrakesVehicle Speed Control
WHILE DRIVING MY 2015 FORD F150 ON A CITY STREET AT 45 MILES PER HOUR THE VEHICLE LOST ACCELERATION, RMP DROPPED TO BARELY 2 AND HILL ASSIST DISABLED LIGHT CAME ON. GLIDED TO A RED LIGHT, PUT THE VEHICLE IN NEUTRAL, CAME TO A STOP AND KEPT THE GAS LIGHTLY PRESSED HOPING TO KEEP POWER TO THE ENGINE. WHEN LIGHTED TURNED GREEN PUT…
Read full complaint
WHILE DRIVING MY 2015 FORD F150 ON A CITY STREET AT 45 MILES PER HOUR THE VEHICLE LOST ACCELERATION, RMP DROPPED TO BARELY 2 AND HILL ASSIST DISABLED LIGHT CAME ON. GLIDED TO A RED LIGHT, PUT THE VEHICLE IN NEUTRAL, CAME TO A STOP AND KEPT THE GAS LIGHTLY PRESSED HOPING TO KEEP POWER TO THE ENGINE. WHEN LIGHTED TURNED GREEN PUT TRUCK BACK INTO DRIVE AND ACCELERATION RETURNED. PARKED AT MY PLACE OF BUSINESS. SHUT THE TRUCK OFF BUT THE BRAKE LIGHTS STAYED ON. HAD THE VEHICLE TOWED TO THE DEALERSHIP BECAUSE OF CONCERN TO DRIVE IT AFTER LOSING ACCELERATION (TOW TRUCK DRIVER CALL THE VEHICLE IN LIMP MODE). THE DEALERSHIP FOUND NOT FAULT CODES BUT DID FIND PLASTIC PIECES ON THE FLOOR BOARD. DEALERSHIP SAID IT WAS A "BROKEN BRAKE PEDAL" - A SMALL PLASTIC DISC (GROMMET) INSIDE THE BRAKE ASSEMBLY BROKE INTO PIECES CAUSING LOSS F ACCELERATION, THE ELECTRONIC MESSAGING SYSTEM TO DISABLE HILL ASSIST AND THE BRAKE LIGHTS TO REMAIN ON. DEALERSHIP SAID THEY HAVE SEEN THIS IN FORD FUSIONS BUT NOT IN AN F150. THE NEW BRAKE ASSEMBLY IS A TOTAL REDESIGN FROM THE THE ONE THAT THE VEHICLE WAS BUILT WITH. THE IMAGE ON THE LEFT IS THE BROKEN BRAKE ASSEMBLE (THE FINGER IS POINTING TO THE DAMAGED ITEM), THE PART ON THE RIGHT WHERE YOU WILL SEE THE SMALL WHITE DISC (GROMMET) IS THE REPLACEMENT BRAKE ASSEMBLY. I PURCHASED THE VEHICLE NEW IN 2015 AND HAVE BEEN THE ONLY OWNER. MY VEHICLE HAS 54K MILES, IS DRIVEN LOCALLY, NOT USED TO TOW OR OFF ROAD AND IS GARAGED WHEN NOT IN USE. A VEHICLE LOOSING ACCELERATION WHILE DRIVING IS A MAJOR SAFELY CONCERN AND I HOPE THIS WILL BE INVESTIGATED AS IT IS A KNOWN ISSUE IN OTHER FORD VEHICLES.
NHTSA ODI #11350529
40,000 miles · Aug 18, 2020
Electronic Stability Control (esc)Service Brakes
TL* THE CONTACT OWNS A 2015 FORD F-150. THE CONTACT STATED WHILE DRIVING 85 MPH, THE LOW BRAKE FLUID WARNING LIGHT WAS ILLUMINATED. THE CONTACT STATED WHILE DEPRESSING THE BRAKE PEDAL, THE VEHICLE FAILED TO STOP. THE CONTACT WAS ABLE TO IDLE THE VEHICLE SPEED TO SLOW DOWN UNTIL HE WAS ABLE TO USE THE PARKING BRAKE TO STOP THE VE…
Read full complaint
TL* THE CONTACT OWNS A 2015 FORD F-150. THE CONTACT STATED WHILE DRIVING 85 MPH, THE LOW BRAKE FLUID WARNING LIGHT WAS ILLUMINATED. THE CONTACT STATED WHILE DEPRESSING THE BRAKE PEDAL, THE VEHICLE FAILED TO STOP. THE CONTACT WAS ABLE TO IDLE THE VEHICLE SPEED TO SLOW DOWN UNTIL HE WAS ABLE TO USE THE PARKING BRAKE TO STOP THE VEHICLE ON THE SIDE OF THE ROADWAY. THE VEHICLE WAS NOT DRIVABLE. THE VEHICLE WAS TOWED TO LOCAL DEALER CENTRAL FORD LOCATED AT 5645 FIRESTONE BLVD, SOUTH GATE, CA 90280, (562) 927-7888, AND THE DEALER WAS MADE AWARE OF THE FAILURE. THE VEHICLE HAD NOT BEEN DIAGNOSED NOR REPAIRED AS OF YET. THE VIN WAS ASSOCIATED NHTSA CAMPAIGN NUMBER: 20V332000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER HAD NOT BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 40,000.
NHTSA ODI #11350075
2,800 miles · Aug 10, 2020
Service Brakes
WHEN I APPLIED BRAKE PEDAL IT WENT TO THE FLOOR . I DROVE TO FORD DEALER IMMEDIATELY AND THEY COULD NOT DUPLICATE PROBLEM. IT HAPPENED AGAIN BEFORE I GOT HOME. FORD SERVICE TECHNITION SAID THERE WAS A RECALL FOR THIS PROBLEM. I HAVE NOT RECEIVED A NOTIFICATION FOR THIS PROBLEM.
NHTSA ODI #11344314
41,650 miles · Aug 8, 2020
Service Brakes
MOVING MY TRUCK INTO LANE OF TRAFFIC OUT OF MY DRIVEWAY; WHEN I STARTED THE VEHICLE THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR BOARD AND THE ON BOARD NOTIFICATION SYSTEM ON THE DASH STATED "LOW BRAKE FLUID" AND I HAD ALMOST NO BRAKING CAPABILITY. I HAD NO INDICATION OF THIS PRIOR TO THAT AND IF I HAD NOT APPLIED MY EMERGENCY …
Read full complaint
MOVING MY TRUCK INTO LANE OF TRAFFIC OUT OF MY DRIVEWAY; WHEN I STARTED THE VEHICLE THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR BOARD AND THE ON BOARD NOTIFICATION SYSTEM ON THE DASH STATED "LOW BRAKE FLUID" AND I HAD ALMOST NO BRAKING CAPABILITY. I HAD NO INDICATION OF THIS PRIOR TO THAT AND IF I HAD NOT APPLIED MY EMERGENCY BRAKE ON I WOULD HAVE ENTERED THE LANE OF TRAFFIC AND VEHICLES WERE COMING FROM BOTH DIRECTIONS AND IT VERY EASILY COULD HAVE TURNED INTO AN MVA WITH INJURIES SUSTAINED BOTH IN MY TRUCK AND PERSONS DRIVING ON MY STREET. I STILL HAVE NO BRAKES AND I HAVE FILLED MY RESERVOIR WITH DOT 4 BRAND NEW BOTTLE OF BRAKE FLUID.
NHTSA ODI #11344122
134,200 miles · Aug 4, 2020
Service Brakes
THE BRAKING SYSTEM COMPLETELY FAILED WITH VIRTUALLY NO WARNING. I WAS TRAVELING ON THE FREEWAY AND THE "LOW BRAKE FLUID" LIGHT APPEARED. THERE HAD BEEN NO MECHANICAL SIGNS OF ANY ISSUES. WHEN I EXITED THE INTERSTATE THE BRAKE PEDAL WENT TO THE FLOOR AND THE BRAKES DID NOT WORK. I WAS BARELY ABLE TO GET THE VEHICLE TO A STOP …
Read full complaint
THE BRAKING SYSTEM COMPLETELY FAILED WITH VIRTUALLY NO WARNING. I WAS TRAVELING ON THE FREEWAY AND THE "LOW BRAKE FLUID" LIGHT APPEARED. THERE HAD BEEN NO MECHANICAL SIGNS OF ANY ISSUES. WHEN I EXITED THE INTERSTATE THE BRAKE PEDAL WENT TO THE FLOOR AND THE BRAKES DID NOT WORK. I WAS BARELY ABLE TO GET THE VEHICLE TO A STOP WITHOUT HITTING THE VEHICLE IN FRONT OF ME ON THE OFF RAMP. FORD HAS NOW RELEASED A RECALL ON THIS BUT PARTS ARE NOT AVAILABLE TO FIX IT YET. I'M NOT SURE IF OR WHAT THEY ARE GOING TO DO FOR MY VEHICLE BUT I WANTED TO FILE THE REPORT GIVEN THE EXTREME RISK THIS FAILURE POSES. I WAS VERY FORTUNATE TO NOT END UP IN A COLLISION.
NHTSA ODI #11343180
82,000 miles · Aug 3, 2020
Service Brakes
MY TRUCK WAS SERVICED WITH COMPLETE FLUIDS AND SYSTEMS CHECK ON JULY 2ND, 2020 REPORTING EVERYTHING IN THE GREEN CHECK ZONE. SATURDAY AUGUST 1ST, 2020 WHILE RETURNING FROM A FAMILY TRIP, THE BRAKE WARNING LIGHT CAME ON INDICATING A BRAKE PROBLEM. THE BRAKES WERE APPLIED TO ENSURE THAT THEY WERE WORKING AND WHEN APPLIED, THERE WA…
Read full complaint
MY TRUCK WAS SERVICED WITH COMPLETE FLUIDS AND SYSTEMS CHECK ON JULY 2ND, 2020 REPORTING EVERYTHING IN THE GREEN CHECK ZONE. SATURDAY AUGUST 1ST, 2020 WHILE RETURNING FROM A FAMILY TRIP, THE BRAKE WARNING LIGHT CAME ON INDICATING A BRAKE PROBLEM. THE BRAKES WERE APPLIED TO ENSURE THAT THEY WERE WORKING AND WHEN APPLIED, THERE WAS NO BRAKING POWER AND THE PEDAL WENT STRAIGHT TO THE FLOOR. WHEN WE WERE FINALLY ABLE TO STOP WE ROLLED INTO A GAS STATION AND OPENED THE HOOD TO CHECK THE BRAKE FLUID LEVEL AND IT WAS EMPTY. SO WE PURCHASED TWO BOTTLES OF BRAKE FLUID TO REFILL THE RESERVOIR THINKING THAT MAYBE THE SERVICE PERSON FORGOT TO REFILL THE BRAKE FLUID. ONCE WE FILLED THE RESERVOIR AND PUMPED THE BRAKES A BIT THEY GOT TIGHT SO WE GOT BACK ON THE ROAD. AS SOON AS WE PULLED ONTO THE ROAD AND BEGAN TO DRIVE THE BRAKE WARNING SIGNAL CAME ON AGAIN. AGAIN, WE PULLED OVER TO CHECK FOR LEAKS, WHICH THERE WERE NONE. AND AGAIN, THE BRAKE RESERVOIR WAS EMPTY. AGAIN WE PURCHASE MORE BRAKE FLUID AND ADDITIONAL BOTTLES AND REFILL THE RESERVOIR TO THE FILL LINE. WE DROVE AROUND THE PARKING LOT QUITE A BIT BEFORE WE DECIDED TO GET BACK ON THE ROAD DUE TO THE VEHICLE SEEMING TO FUNCTION NORMALLY. AT THIS POINT WE ENTER THE HIGHWAY AND DROVE TO OUR AREA NEAR THE DEALER. WHEN EXITING THE HIGHWAY A GREAT DEAL OF SMOKE CAME FROM THE BACK OF OUR CAR THAT SMELLED LIKE BRAKE FLUID. WE PULLED OVER AND AGAIN THERE WAS NOTHING LEAKING. WE STILL SEEMED TO HAVE SOME BREAKING ABILITY SO DROVE THE TRUCK TO THE CAR DEALERSHIP TO PARK IT FOR THEM TO TAKE A LOOK AT TO DO REPAIRS. UPON DOING SOME RESEARCH I SAW THAT FORD MOTOR COMPANY JUST ANNOUNCED THE BEGINNINGS OF A RECALL ON JUNE 6 FOR THIS SAME PROBLEM ON THIS YEAR VEHICLE.
NHTSA ODI #11342928
Mileage unknown · Jul 21, 2020
Service Brakes
DRIVING DOWN THE HIGHWAY AT 60MPH AND OUT OF NO WHERE THE LOW BRAKE FLUID LIGHT CAME ON THE DASH SCREEN. PUSHED ON THE BRAKE AND IT WENT TO THE FLOOR, PUMPING THE BRAKE DID NOT HELP. WAS ABLE TO MANUALLY DOWN SHIFT AND STOP WITH THE E BRAKE. LUCKY I WAS NOT IN ANY TRAFFIC.
NHTSA ODI #11340776
82,000 miles · Jul 21, 2020
Service Brakes
TL* THE CONTACT OWNS A 2015 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED OPERATE AS DESIGNED EXTENDING THE BRAKING DISTANCE WITHOUT WARNING. THE VEHICLE WAS TOWED TO COUNTY FORD (18411 LYNDON B JOHNSON FREE WAY, MESQUITE TX 75150), BUT WAS NOT DIAGNOSED NOR REPAIRED. THE M…
Read full complaint
TL* THE CONTACT OWNS A 2015 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED OPERATE AS DESIGNED EXTENDING THE BRAKING DISTANCE WITHOUT WARNING. THE VEHICLE WAS TOWED TO COUNTY FORD (18411 LYNDON B JOHNSON FREE WAY, MESQUITE TX 75150), BUT WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 82,000.
NHTSA ODI #11340611
32,000 miles · Jul 18, 2020
Service Brakes
DRIVING DOWN THE ROAD EARLY IN THE MORNING AND LOST BOTH FRONT AND BACK BRAKES. WHEN THE BRAKE WAS PRESSED DOWN COMPLETELY THE TRUCK DID NOT STOP; PUMPING THE BRAKE CAUSED THE TRUCK TO SLOW BUT NOT QUICKLY. WE SAW AN EMPTY MALL AREA AND HEADED TOWARDS THE PARKING LOT AND COASTED TO A STOP. HAD WE BEEN ON THE FREEWAY OR LATER…
Read full complaint
DRIVING DOWN THE ROAD EARLY IN THE MORNING AND LOST BOTH FRONT AND BACK BRAKES. WHEN THE BRAKE WAS PRESSED DOWN COMPLETELY THE TRUCK DID NOT STOP; PUMPING THE BRAKE CAUSED THE TRUCK TO SLOW BUT NOT QUICKLY. WE SAW AN EMPTY MALL AREA AND HEADED TOWARDS THE PARKING LOT AND COASTED TO A STOP. HAD WE BEEN ON THE FREEWAY OR LATER IN THE DAY DURING TRAFFIC THIS COULD HAVE BEEN A SERIOUS ACCIDENT. WE WERE DRIVING ON A 2 LANE ROAD IN A CITY AREA GOING ABOUT 40 MPH. WE WERE VERY VERY LUCKY - THIS COULD EASILY CAUSE A SERIOUS ACCIDENT. LOCAL BRAKE COMPANY WERE ABLE TO GET THE BRAKES WORKING AND WE DROVE THE TRUCK BACK TO THE HOUSE - A FEW HOUR DRIVE. RECEIVED NOTICE OF THE RECALL ABOUT 3-4 DAYS AFTER THE BRAKES FAILED AND WE DID NOT DRIVE THE TRUCK. WE CALLED THE DEALER AND THEY TOLD US NOTHING COULD BE DONE BECAUSE THE FIX HAD NOT BEEN SOLVED BY FORD, WE ASKED IF THE TRUCK WAS DRIVABLE AND THEY COULD NOT ANSWER AS THE RECALL IS UNCLEAR. WE ASKED THE DEALER IF WE COULD DROP TRUCK OFF AND THEY COULD FIX AND THEY TOLD US NO BECAUSE THEY DID NOT HAVE PARTS AND DID NOT KNOW WHAT THE FIX WAS GOING TO BE. CALLED FORD AND TALKED TO A CUSTOMER SERVICE PERSON AND THEY CALLED THE DEALERSHIP AND HAD THEM TAKE THE TRUCK SINCE NEITHER FORD OR THE DEALER COULD TELL US IF THE TRUCK WAS DRIVABLE. THE DEALER TOLD US THEY WOULD LOOK AT THE TRUCK TO DETERMINE IF THE TRUCK WAS DRIVABLE - THAT WAS JUNE 27, 2020 AND WE HAVE NOT HEARD BACK FROM DEALER. CALLED DEALER AGAIN ON 07.16.20 AND TALKED AND THEY STILL DID NOT KNOW AND WOULD CALL BACK, NO CALL BACK AS OF 11PM 06/18/2020
NHTSA ODI #11340181
58,000 miles · Jul 16, 2020
Service Brakes
WE RECEIVED SAFETY RECALL NOTICE 20S31/NHTSA RECALL 20V-332 ON OUR 2015 FORD F-150. NEITHER THE DEALER NOR FORD CUSTOMER SERVICE IS WILLING TO REPLACE OUR MASTER BRAKE CYLINDER UNDER THE RECALL UNTIL IT ACTUALLY FAILS, OR WE SEE THE RED BRAKE WARNING SIGNAL ETC. CONSIDERING WE USE THE TRUCK TO PULL OUR 6,000 LB. 25FT. AIRSTREA…
Read full complaint
WE RECEIVED SAFETY RECALL NOTICE 20S31/NHTSA RECALL 20V-332 ON OUR 2015 FORD F-150. NEITHER THE DEALER NOR FORD CUSTOMER SERVICE IS WILLING TO REPLACE OUR MASTER BRAKE CYLINDER UNDER THE RECALL UNTIL IT ACTUALLY FAILS, OR WE SEE THE RED BRAKE WARNING SIGNAL ETC. CONSIDERING WE USE THE TRUCK TO PULL OUR 6,000 LB. 25FT. AIRSTREAM WE DON'T FEEL IT IS A SAFE SITUATION TO TAKE THE CHANCE OF PULLING THE AIRSTREAM AND JUST WAITING TO SEE IF THE BRAKE FAILS. WE MAY BE HOURS FROM A FORD DEALERSHIP WHEN IT HAPPENS. I AM VERY DISAPPOINTED WITH FORD FOR THEIR SEEMING INDIFFERENCE & WILLINGNESS TO JUST WAIT UNTIL PEOPLE CRASH INTO OTHER CARS AND DO BODILY HARM BEFORE THEY WILL TAKE RESPONSIBILITY OF FIXING AN OBVIOUS SAFETY RECALL ISSUE. NEVER BEFORE HAVE WE EVER HAD A RECALL NOTICE WHERE WE HAD FIRST TO PROVE OUR VEHICLE HAD FAILED BEFORE THEY FIXED THE RECALL ISSUE. EVERYONE KEPT TELLING ME THAT ONLY A SMALL PERCENTAGE OF THE VEHICLES THAT RECEIVED THE SAFETY RECALL NOTICE WOULD ACTUALLY HAVE THE BRAKES FAIL, SO WHY WORRY? JUST KEEP DRIVING & HOPE FOR THE BEST? THE LETTER SAYS IT'S DUE TO A PART SHORTAGE & WE'D BE NOTIFIED WHEN PARTS ARE AVAILABLE, BUT THE DEALER & AN FORD OPERATIONS SUPERVISOR SAID THE MASTER BRAKE CYLINDER WOULD NOT BE FIXED ON OUR VEHICLE UNLESS THE VEHICLE WAS EXHIBITING SYMPTOMS, REGARDLESS OF THE SAFETY RECALL. I'VE WASTED A WEEK OF MY LIFE TALKING TO FORD, AND WAITING FOR CALL BACKS & BASICALLY AM JUST BEING BLOWN OFF..AND WE'RE TALKING ABOUT BRAKE FAILURES!! THIS WAS OUR 3RD FORD VEHICLE OVER THE YEARS, BUT LIKELY OUR LAST. NOT IMPRESSED AT ALL WITH THEIR CUSTOMER SERVICE OR THEIR CONCERN ABOUT THEIR CUSTOMERS SAFETY ONCE THEY'VE PURCHASED THE VEHICLE.
NHTSA ODI #11339826
Official recalls
13Apr 14, 2026
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150 vehicles. A loss of signal between the transmission range sensor and the powertrain control module can cause the transmission to unexpectedly downshift into second gear.
Consequence & remedy
Consequence: Unexpectedly downshifting into second gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed July 24, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S28. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 15, 2026.
Jun 8, 2020
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence & remedy
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:master Cylinder
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
Service Brakes, Hydraulic:power Assist
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
Feb 21, 2020
Ford Motor Company (Ford) is recalling certain 2015-2016 F-150 pick-up trucks equipped with 3.5L GTDI engines and block immersion heaters that were potentially relocated from their originally installed location. The incorrect location could put the heater too close to hot engine components, possibly resulting in a damaged cable.
Consequence & remedy
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the block heater's location and its cable, replacing components as necessary, free of charge. If the replacement parts are not available, dealers will disable the existing block heater cable from being used until parts become available. The recall began April 9, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S08.
Additional source detail variants (2)
Engine
Ford Motor Company (Ford) is recalling certain 2015-2016 F-150 pick-up trucks equipped with 3.5L GTDI engines and block immersion heaters that were potentially relocated from their originally installed location. The incorrect location could put the heater too close to hot engine components, possibly resulting in a damaged cable.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the block heater's location and its cable, replacing components as necessary, free of charge. If the replacement parts are not available, dealers will disable the existing block heater cable from being used until parts become available. The recall began April 9, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S08.
Equipment:electrical
Ford Motor Company (Ford) is recalling certain 2015-2016 F-150 pick-up trucks equipped with 3.5L GTDI engines and block immersion heaters that were potentially relocated from their originally installed location. The incorrect location could put the heater too close to hot engine components, possibly resulting in a damaged cable.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the block heater's location and its cable, replacing components as necessary, free of charge. If the replacement parts are not available, dealers will disable the existing block heater cable from being used until parts become available. The recall began April 9, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S08.
Apr 8, 2019
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence & remedy
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Additional source detail variants (2)
Engine
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Equipment:electrical
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Dec 18, 2018
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.
Consequence & remedy
Consequence: When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.
Aug 31, 2018
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence & remedy
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.
Additional source detail variants (2)
Seat Belts:pretensioner
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.
Structure:body:roof And Pillars
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.
Oct 16, 2017
Ford Motor Company (Ford) is recalling certain 2015-2017 Ford F-150, and 2017 F-250, F-350, F-450, and F-550 Super Duty trucks. The doors on these vehicles may have a bent or kinked actuation cable or the door latches may freeze after water gets into the latch. Either condition can result in the doors opening while driving although they appear to be closed.
Consequence & remedy
Consequence: A door that opens while driving can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will inspect the door latch actuation cables and repair if necessary, and install water shields over the door latches, free of charge. The recall began October 12, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S33.
Aug 28, 2017
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250 and F-350 trucks equipped with a crew cab. The left rear inflatable seat belt buckle assembly may be inadequately attached to its mounting bracket. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages."
Consequence & remedy
Consequence: If the left rear inflatable seat belt buckle separates from it's mounting bracket, the seat occupant may not be adequately restrained, increasing their risk of injury.
Remedy: Ford will notify owners, and dealers will inspect the seat belt assembly, replacing the attaching rivet as necessary, free of charge. Interim notices informing owners of the safety risk were mailed October 18, 2017. Owners will receive a second notice when the remedy becomes available. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 17C12.
May 22, 2017
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250, F-350, F-450, and F-550 vehicles originally produced with black or body colored exterior door handles that may have been subsequently equipped with a chrome exterior door handle cover accessory kit purchased from a Ford dealer. These accessory door handle covers may cause the doors to unlatch in a side impact collision. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."
Consequence & remedy
Consequence: If the doors unlatch and open in a side impact collision, the occupants have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will remove the accessory covers and refund the purchase price. The recall began July 13, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for the recall is 17C09.
Additional source detail variants (2)
Latches/locks/linkages:doors:latch
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250, F-350, F-450, and F-550 vehicles originally produced with black or body colored exterior door handles that may have been subsequently equipped with a chrome exterior door handle cover accessory kit purchased from a Ford dealer. These accessory door handle covers may cause the doors to unlatch in a side impact collision. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."
Consequence: If the doors unlatch and open in a side impact collision, the occupants have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will remove the accessory covers and refund the purchase price. The recall began July 13, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for the recall is 17C09.
Structure:body:door
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250, F-350, F-450, and F-550 vehicles originally produced with black or body colored exterior door handles that may have been subsequently equipped with a chrome exterior door handle cover accessory kit purchased from a Ford dealer. These accessory door handle covers may cause the doors to unlatch in a side impact collision. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."
Consequence: If the doors unlatch and open in a side impact collision, the occupants have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will remove the accessory covers and refund the purchase price. The recall began July 13, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for the recall is 17C09.
Dec 22, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Ford F-150 SuperCrew trucks manufactured January 22, 2015, to March 17, 2015. The affected vehicles may be equipped with driver or front passenger seat belt anchorage assemblies whose pretensioner cable was not properly crimped. As a result, the seat belts may not properly restrain the seat occupant in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 209, "Seat Belt Assemblies" and 210, " Seat Belt Assembly Anchorages."
Consequence & remedy
Consequence: An occupant that is not be properly restrained is at an increased risk of injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the driver and/or front passenger side seat belt retractor(s) and pretensioner(s), free of charge. The recall began on February 12, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15C17.
Sep 30, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Ford F-150 trucks manufactured March 18, 2014, to August 6, 2015 and equipped with Adaptive Cruise Control (ACC). While using the Adaptive Cruise Control, the vehicle may falsely detect an obstacle in its path and may unexpectedly apply the brakes.
Consequence & remedy
Consequence: A vehicle that unexpectedly brakes increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the cruise control module with updated ACC radar software, free of charge. The recall began on October 25, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S29.
May 12, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Ford F-150 trucks manufactured March 19, 2015, to March 30, 2015. The affected vehicles may have been built with a steering upper intermediate shaft that was improperly riveted.
Consequence & remedy
Consequence: If the intermediate shaft was improperly riveted, it could separate from the intermediate shaft flex coupling, resulting in a loss of steering control and increasing the risk of a vehicle crash.
Remedy: Ford will notify owners, and dealers will inspect the intermediate shaft and replace it, as necessary, free of charge. The recall began on May 22, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S17.
Apr 28, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Ford F-150 vehicles manufactured January 30, 2015, to January 31, 2015. The affected vehicles may have loose or missing underbody heat shields.
Consequence & remedy
Consequence: A missing underbody heat shield can lead to degradation or melting of the fuel or vapor lines, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the vehicle for missing underbody heat shields and fasteners, and will install the missing components as required, free of charge. The recall began on May 13, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S12.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA26001 · Unintended Transmission Downshift And Rear Wheel Lock-up
Opened Jan 30, 2026 · No close date supplied
Status: open (inferred from source dates) · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
On March 21, 2025, NHTSA’s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE25002) to investigate instances of unexpected transmission downshifting without driver input in model year (MY) 2015-2017 Ford F-150 vehicles (subject vehicles) manufactured by Ford Motor Company (Ford). The complaints allege that, without warning or driver input, the subject vehicles experienced a sudden and rapid deceleration often accompanied by temporary rear wheel lockup, seizure, or skidding, resulting in a loss of vehicle control that increases the risk of crash and injury to all motorists, including those not within the subject vehicles. The MY 2015 and MY 2016 F-150 vehicles were equipped with the “6R80” transmission, while the MY 2017 vehicles were equipped with either the “6R80” transmission or the “10R80” transmission. This investigation was limited to MY 2015-2017 Ford F-150 with the “6R80” transmission. ODI identified 329 Vehicle Owners Questionnaires (VOQs) related to this investigation and sixty percent of these consumers were interviewed to confirm the details of their allegations. Consumers reported that their vehicles’ transmission suddenly downshifted to a lower gear, often to 1st or 2nd gear, without driver input or advance warning. Consumers described the downshift events to be regular and repeated occurrences, with some consumers stating that they no longer drive the vehicle due to safety concerns. Forty-three percent of consumers reported experiencing at least one wheel lockup event, during which the rear tires locked, screeched, or skidded during the transmission downshift. ODI also found that 114 of the 329 consumers reported having their vehicle’s molded lead frame or valve body assembly (which comes with a molded lead frame) replaced, 80 of which were confirmed through consumer submitted repair invoices. In its response to ODI’s Information Request, Ford provided an assessment of potential root cause of failure for the subject vehicles and how this failure is different from the failure associated with MY 2011-2014 Ford F-150 vehicles that was addressed by four safety recalls (16V-248, 19V-075, 19V-433, and 24V-444). Ford has identified that the defect in the recalled vehicle population involved lead frame supplier production issues resulting in signal loss from the Output Shaft Speed (OSS) sensor. Ford has identified that the alleged defect in the subject vehicle population involved degradation of electrical connections within the lead frame due to thermal cycling and vibration over extended time in service resulting in signal loss from the Transmission Range Sensor (TRS). Signal loss from the TRS can result in an unintended shift to neutral, unintended upshift, or unintended downshift which are regulated by a gear “shift map” based on the vehicle’s speed at the time of signal loss. According to Ford’s “shift map”, at speeds between 35-64 mph, the maximum allowable downshift would be to 2nd gear (i.e. a 6th to 2nd gear downshift event) which Ford has designated to represent the worst-case scenario for subject vehicles. Ford has also acknowledged that the worst-case scenario may also involve temporary wheel lockup. However, Ford has stated that the failure mechanism in the MY 2011-2014 F-150 vehicles—previously addressed through recalls—primarily involved OSS sensor signal loss that could result in 6th to 1st gear downshift events. This OSS-related failure mode is distinct from the TRS-related signal loss identified in the subject vehicle population. ODI has identified an additional potential safety defect associated with the alleged defect in the subject vehicles. Preliminary testing performed by NHTSA’s Vehicle Research Test Center (VRTC) showed that when the TRS experiences an intermittent signal loss, one possible outcome is a change in vehicle direction. Specifically, if a vehicle is operating in reverse up an incline when the TRS signal loss occurs, then the vehicle may shift into neutral causing the vehicle to change directions and roll forward. ODI is opening this Engineering Analysis (EA) to, among other things, perform component-level testing and vehicle testing, as well as review additional technical information to better understand the alleged defect that has been identified. To review the reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25002 · Unintended Transmission Downshift And Rear Wheel Lock-up
Opened Mar 21, 2025 · Closed Jan 30, 2026
Status: closed (inferred from source dates) · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
On March 21, 2025, NHTSA’s Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE25002) to investigate instances of unexpected transmission downshifting without driver input in model year (MY) 2015-2017 Ford F-150 vehicles (subject vehicles) manufactured by Ford Motor Company (Ford). The complaints allege that, without warning or driver input, the subject vehicles experienced a sudden and rapid deceleration often accompanied by temporary rear wheel lockup, seizure, or skidding, resulting in a loss of vehicle control that increases the risk of crash and injury to all motorists, including those not within the subject vehicles. The MY 2015 and MY 2016 F-150 vehicles were equipped with the “6R80” transmission, while the MY 2017 vehicles were equipped with either the “6R80” transmission or the “10R80” transmission. This investigation was limited to MY 2015-2017 Ford F-150 with the “6R80” transmission. ODI identified 329 Vehicle Owners Questionnaires (VOQs) related to this investigation and sixty percent of these consumers were interviewed to confirm the details of their allegations. Consumers reported that their vehicles’ transmission suddenly downshifted to a lower gear, often to 1st or 2nd gear, without driver input or advance warning. Consumers described the downshift events to be regular and repeated occurrences, with some consumers stating that they no longer drive the vehicle due to safety concerns. Forty-three percent of consumers reported experiencing at least one wheel lockup event, during which the rear tires locked, screeched, or skidded during the transmission downshift. ODI also found that 114 of the 329 consumers reported having their vehicle’s molded lead frame or valve body assembly (which comes with a molded lead frame) replaced, 80 of which were confirmed through consumer submitted repair invoices. In its response to ODI’s Information Request, Ford provided an assessment of potential root cause of failure for the subject vehicles and how this failure is different from the failure associated with MY 2011-2014 Ford F-150 vehicles that was addressed by four safety recalls (16V-248, 19V-075, 19V-433, and 24V-444). Ford has identified that the defect in the recalled vehicle population involved lead frame supplier production issues resulting in signal loss from the Output Shaft Speed (OSS) sensor. Ford has identified that the alleged defect in the subject vehicle population involved degradation of electrical connections within the lead frame due to thermal cycling and vibration over extended time in service resulting in signal loss from the Transmission Range Sensor (TRS). Signal loss from the TRS can result in an unintended shift to neutral, unintended upshift, or unintended downshift which are regulated by a gear “shift map” based on the vehicle’s speed at the time of signal loss. According to Ford’s “shift map”, at speeds between 35-64 mph, the maximum allowable downshift would be to 2nd gear (i.e. a 6th to 2nd gear downshift event) which Ford has designated to represent the worst-case scenario for subject vehicles. Ford has also acknowledged that the worst-case scenario may also involve temporary wheel lockup. However, Ford has stated that the failure mechanism in the MY 2011-2014 F-150 vehicles—previously addressed through recalls—primarily involved OSS sensor signal loss that could result in 6th to 1st gear downshift events. This OSS-related failure mode is distinct from the TRS-related signal loss identified in the subject vehicle population. ODI has identified an additional potential safety defect associated with the alleged defect in the subject vehicles. Preliminary testing performed by NHTSA’s Vehicle Research Test Center (VRTC) showed that when the TRS experiences an intermittent signal loss, one possible outcome is a change in vehicle direction. Specifically, if a vehicle is operating in reverse up an incline when the TRS signal loss occurs, then the vehicle may shift into neutral causing the vehicle to change directions and roll forward. Based on NHTSA’s analysis of consumer data, information provided by Ford, and preliminary testing conducted by NHTSA’s VRTC, this Preliminary Evaluation is being upgraded to an Engineering Analysis (EA26001). During this Engineering Analysis, the agency plans to, among other things, perform component-level testing and vehicle testing, as well as review additional technical information to better understand the alleged defect that has been identified from this Preliminary Evaluation. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18008 · Seatbelt Pretensioner Fire
Opened Aug 3, 2018 · Closed Dec 17, 2018
Status: closed (inferred from source dates) · Seat Belts:pretensioner
On June 18, 2018, the Office of Defects Investigations (ODI) opened a Preliminary Evaluation (PE18-008) to investigate complaints alleging post-crash fires at the B pillar in the area of the seat belt pretensioners on MY 2014-2018 Ford F-150 Regular Cab, and Super Crew Cab Vehicles. On August 24, 2018, Ford Motor Company recalled (FSA 18S27 - NHTSA #18V568) the affected population. Ford's investigation found that some front seat belt pretensioners may generate sparks during deployment in excess of Ford's specification. Sparks in the pretensioner exhaust gases inside the lower portion of the B-pillar may subsequently ignite combustible components contained in the B-pillar, such as insulation or carpet, and may cause a subsequent vehicle fire. ODI also requested relevant information from other manufacturers to assess the potential scope of post-crash pretensioner fires. Ford will notify owners and require dealers to remove B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall notification began September 28, 2018.Owners may contact Ford customer service at 1-866-436-7332.The VOQs associated with the closing of this investigation are: 11143035, 11130056, 11129828, 11128761, 11127993, 11127880, 11124717, 11123419, 11119651, 11119626, 11114065, 11113160, 11111822, 11097937, 11078447, 11014688
AQ17001 · Champion Ford Edinboro / Steering Shaft
Opened Jan 4, 2017 · Closed Jun 15, 2018
Status: closed (inferred from source dates) · Steering
NHTSA opened AQ17-001 to determine whether Champion Ford Edinboro, Inc. (Champion Ford), of Edinboro, Pennsylvania, complied with the requirements of the National Traffic and Motor Vehicle Safety Act, 49 U.S.C. Chapter 301 (Safety Act) and its implementing regulations. The Safety Act requires, among other things, that a manufacturer notify its dealers of defects related to motor vehicle safety and non-compliances with Federal Motor Vehicle Safety Standards and, in turn, that a dealer not sell a new vehicle subject to a recall unless the recall remedy has been performed (49 U.S.C. ?30120(i)).NHTSA issued an information request (IR) letter to Champion Ford on January 4, 2017.Champion Ford responded to this request on January 19, 2017.Also on January 4, 2017, an IR letter was issued to Ford Motor Company (Ford) and a response was received from Ford on January 25, 2017.Finally, another IR was issued to Champion Ford on May 31, 2017, and Champion Ford's response letter was submitted to NHTSA on June 14, 2017.NHTSA's investigation indicated that Champion Ford did sell and deliver recalled vehicles that did not have the recall remedy completed at the time the vehicles were delivered to the customers.NHTSA therefore concluded that Champion Ford was liable for civil penalties for violations of the Safety Act, pursuant to 49 U.S.C. ?30165.Under a Settlement Agreement dated April 16, 2018, Champion Ford agreed to pay compromised civil penalties in the amount of $20,000.Champion Ford also represented in writing that it repaired all twenty-three (23) recalled vehicles identified in AQ17-001 and will strictly adhere to Ford's procedures requiring dealers to check for outstanding safety recalls prior to customer delivery.NHTSA's Recall Management Division has verified that all twenty-three (23) vehicles have been remedied of the safety recalls identified in AQ17-001.This Audit Query is closed.
RQ16001 · Brake Master Cylinder Failure
Opened Sep 28, 2016 · Closed Jul 5, 2020
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder
On June 8, 2020, Ford Motor Company issued a safety recall (NHTSA Recall No. 20V-332) of 292,311 model year (MY) 2014-2017 Ford F-150 vehicles equipped with 3.5L Ecoboost engines and built from 9/1/2014 to 8/1/2016. Ford stated that the causes of brake fluid loss in the master cylinder are brake fluid contamination that can interfere with rear cup seal function, and rolling of the rearmost cup seal.Prior to total loss of the front brakes, depending on the amount of brake fluid loss in the master cylinder, the driver may receive an audible chime, message center alert and red brake warning indicator in the instrument cluster, and may experience a change in brake pedal travel and increased pedal effort. It should be noted that a small number of late-built MY 2014 and early-built MY 2017 F-150 vehicles are included in the recall along with the subject vehicles (MY 2015-2016).This Recall Query is closed based on the safety recall issued by Ford. The ODI reports cited above can be viewed at NHTSA.gov under the following ID numbers:10734951 10839988 10862418 10872737 10873438 10876359 10881590 10883442 10885352 10888026 10888524 10891826 10891829 10891886 10893632 10894688 10894844 10896122 10896446 10898079 10899093 10899198 10902944 10903776 10904695 10908281 10910101 10913678 10913867 10914016 10914164 10914288 10914361 10914382 10914483 10914507 10915027 10915894 10916302 10916346 10916578 10920258 10925699 10926076 10926148 10926179 10927388 10927402 10927459 10927578 10928457 10928906 10930128 10936207 10940199 10943902 10948941 10950413 10954419 10956798 10969452 10969971 10984389 10985533 10991033 10993430 10993826 10994249 11000331 11000746 11001283 11001291 11001403 11001550 11002014 11002827 11003801 11004795 11005551 11010248 11010341 11011291 11011502 11012944 11013023 11013826 11014954 11015390 11018677 11018771 11020059 11021249 11021632 11022034 11022116 11022243 11023791 11025448 11030416 11030852 11039991 11082190 11082307 11083373 11083998 11089076 11091017 11092142 11093509 11096406 11096501 11097550 11097885 11099405 11099859 11100723 11101189 11101357 11101515 11101631 11102242 11102281 11102299 11102326 11102360 11102481 11104187 11104212 11104877 11109739 11110958 11111028 11111445 11111776 11112143 11112145 11112331 11112445 11112504 11112969 11112970 11114501 11115336 11115612 11118050 11118324 11119688 11119741 11120003 11120625 11120839 11121496 11122946 11123817 11124180 11124313 11124735 11129689 11129763 11129799 11130736 11131008 11132384 11139389 11139955 11154079 11163050 11183075 11189767 11192325 11193564 11195772 11196715 11205224 11205725 11208030 11208558 11209657 11210390 11217868 11218183 11218476 11218533 11218548 11218703 11218773 11219228 11219556 11220778 11221408 11221528 11221888 11222322 11222604 11222909 11228582 11228780 11229191 11229412 11229541 11229673 11230311 11230525 11230553 11230595 11230606 11230664 11231440 11231744 11231985 11232226 11232462 11233423 11233425 11233557 11233595 11233614 11233857 11233864 11234025 11234577 11234715 11234752 11240161 11240184 11240219 11240344 11241143 11241328 11241565 11241737 11241755 11241979 11242032 11242096 11242101 11242222 11242430 11242723 11243775 11244070 11244092 11244223 11244613 11244872 11245199 11245233 11245259 11245846 11246001 11251825 11252130 11252506 11252570 11252595 11252809 11254026 11254116 11254385 11254816 11255210 11255273 11255487 11256470 11257328 11257549 11258458 11258978 11265268 11267540 11269887 11279423 11281670 11287382 11291824 11297512 11298972 11301103 11306644 11310503 11315450 11316153 11318273 11319339 11319344 11319751
Additional source detail variants (4)
Service Brakes
On June 8, 2020, Ford Motor Company issued a safety recall (NHTSA Recall No. 20V-332) of 292,311 model year (MY) 2014-2017 Ford F-150 vehicles equipped with 3.5L Ecoboost engines and built from 9/1/2014 to 8/1/2016. Ford stated that the causes of brake fluid loss in the master cylinder are brake fluid contamination that can interfere with rear cup seal function, and rolling of the rearmost cup seal.Prior to total loss of the front brakes, depending on the amount of brake fluid loss in the master cylinder, the driver may receive an audible chime, message center alert and red brake warning indicator in the instrument cluster, and may experience a change in brake pedal travel and increased pedal effort. It should be noted that a small number of late-built MY 2014 and early-built MY 2017 F-150 vehicles are included in the recall along with the subject vehicles (MY 2015-2016).This Recall Query is closed based on the safety recall issued by Ford. The ODI reports cited above can be viewed at NHTSA.gov under the following ID numbers:10734951 10839988 10862418 10872737 10873438 10876359 10881590 10883442 10885352 10888026 10888524 10891826 10891829 10891886 10893632 10894688 10894844 10896122 10896446 10898079 10899093 10899198 10902944 10903776 10904695 10908281 10910101 10913678 10913867 10914016 10914164 10914288 10914361 10914382 10914483 10914507 10915027 10915894 10916302 10916346 10916578 10920258 10925699 10926076 10926148 10926179 10927388 10927402 10927459 10927578 10928457 10928906 10930128 10936207 10940199 10943902 10948941 10950413 10954419 10956798 10969452 10969971 10984389 10985533 10991033 10993430 10993826 10994249 11000331 11000746 11001283 11001291 11001403 11001550 11002014 11002827 11003801 11004795 11005551 11010248 11010341 11011291 11011502 11012944 11013023 11013826 11014954 11015390 11018677 11018771 11020059 11021249 11021632 11022034 11022116 11022243 11023791 11025448 11030416 11030852 11039991 11082190 11082307 11083373 11083998 11089076 11091017 11092142 11093509 11096406 11096501 11097550 11097885 11099405 11099859 11100723 11101189 11101357 11101515 11101631 11102242 11102281 11102299 11102326 11102360 11102481 11104187 11104212 11104877 11109739 11110958 11111028 11111445 11111776 11112143 11112145 11112331 11112445 11112504 11112969 11112970 11114501 11115336 11115612 11118050 11118324 11119688 11119741 11120003 11120625 11120839 11121496 11122946 11123817 11124180 11124313 11124735 11129689 11129763 11129799 11130736 11131008 11132384 11139389 11139955 11154079 11163050 11183075 11189767 11192325 11193564 11195772 11196715 11205224 11205725 11208030 11208558 11209657 11210390 11217868 11218183 11218476 11218533 11218548 11218703 11218773 11219228 11219556 11220778 11221408 11221528 11221888 11222322 11222604 11222909 11228582 11228780 11229191 11229412 11229541 11229673 11230311 11230525 11230553 11230595 11230606 11230664 11231440 11231744 11231985 11232226 11232462 11233423 11233425 11233557 11233595 11233614 11233857 11233864 11234025 11234577 11234715 11234752 11240161 11240184 11240219 11240344 11241143 11241328 11241565 11241737 11241755 11241979 11242032 11242096 11242101 11242222 11242430 11242723 11243775 11244070 11244092 11244223 11244613 11244872 11245199 11245233 11245259 11245846 11246001 11251825 11252130 11252506 11252570 11252595 11252809 11254026 11254116 11254385 11254816 11255210 11255273 11255487 11256470 11257328 11257549 11258458 11258978 11265268 11267540 11269887 11279423 11281670 11287382 11291824 11297512 11298972 11301103 11306644 11310503 11315450 11316153 11318273 11319339 11319344 11319751
Service Brakes, Hydraulic:fluid
On June 8, 2020, Ford Motor Company issued a safety recall (NHTSA Recall No. 20V-332) of 292,311 model year (MY) 2014-2017 Ford F-150 vehicles equipped with 3.5L Ecoboost engines and built from 9/1/2014 to 8/1/2016. Ford stated that the causes of brake fluid loss in the master cylinder are brake fluid contamination that can interfere with rear cup seal function, and rolling of the rearmost cup seal.Prior to total loss of the front brakes, depending on the amount of brake fluid loss in the master cylinder, the driver may receive an audible chime, message center alert and red brake warning indicator in the instrument cluster, and may experience a change in brake pedal travel and increased pedal effort. It should be noted that a small number of late-built MY 2014 and early-built MY 2017 F-150 vehicles are included in the recall along with the subject vehicles (MY 2015-2016).This Recall Query is closed based on the safety recall issued by Ford. The ODI reports cited above can be viewed at NHTSA.gov under the following ID numbers:10734951 10839988 10862418 10872737 10873438 10876359 10881590 10883442 10885352 10888026 10888524 10891826 10891829 10891886 10893632 10894688 10894844 10896122 10896446 10898079 10899093 10899198 10902944 10903776 10904695 10908281 10910101 10913678 10913867 10914016 10914164 10914288 10914361 10914382 10914483 10914507 10915027 10915894 10916302 10916346 10916578 10920258 10925699 10926076 10926148 10926179 10927388 10927402 10927459 10927578 10928457 10928906 10930128 10936207 10940199 10943902 10948941 10950413 10954419 10956798 10969452 10969971 10984389 10985533 10991033 10993430 10993826 10994249 11000331 11000746 11001283 11001291 11001403 11001550 11002014 11002827 11003801 11004795 11005551 11010248 11010341 11011291 11011502 11012944 11013023 11013826 11014954 11015390 11018677 11018771 11020059 11021249 11021632 11022034 11022116 11022243 11023791 11025448 11030416 11030852 11039991 11082190 11082307 11083373 11083998 11089076 11091017 11092142 11093509 11096406 11096501 11097550 11097885 11099405 11099859 11100723 11101189 11101357 11101515 11101631 11102242 11102281 11102299 11102326 11102360 11102481 11104187 11104212 11104877 11109739 11110958 11111028 11111445 11111776 11112143 11112145 11112331 11112445 11112504 11112969 11112970 11114501 11115336 11115612 11118050 11118324 11119688 11119741 11120003 11120625 11120839 11121496 11122946 11123817 11124180 11124313 11124735 11129689 11129763 11129799 11130736 11131008 11132384 11139389 11139955 11154079 11163050 11183075 11189767 11192325 11193564 11195772 11196715 11205224 11205725 11208030 11208558 11209657 11210390 11217868 11218183 11218476 11218533 11218548 11218703 11218773 11219228 11219556 11220778 11221408 11221528 11221888 11222322 11222604 11222909 11228582 11228780 11229191 11229412 11229541 11229673 11230311 11230525 11230553 11230595 11230606 11230664 11231440 11231744 11231985 11232226 11232462 11233423 11233425 11233557 11233595 11233614 11233857 11233864 11234025 11234577 11234715 11234752 11240161 11240184 11240219 11240344 11241143 11241328 11241565 11241737 11241755 11241979 11242032 11242096 11242101 11242222 11242430 11242723 11243775 11244070 11244092 11244223 11244613 11244872 11245199 11245233 11245259 11245846 11246001 11251825 11252130 11252506 11252570 11252595 11252809 11254026 11254116 11254385 11254816 11255210 11255273 11255487 11256470 11257328 11257549 11258458 11258978 11265268 11267540 11269887 11279423 11281670 11287382 11291824 11297512 11298972 11301103 11306644 11310503 11315450 11316153 11318273 11319339 11319344 11319751
Service Brakes, Hydraulic
On June 8, 2020, Ford Motor Company issued a safety recall (NHTSA Recall No. 20V-332) of 292,311 model year (MY) 2014-2017 Ford F-150 vehicles equipped with 3.5L Ecoboost engines and built from 9/1/2014 to 8/1/2016. Ford stated that the causes of brake fluid loss in the master cylinder are brake fluid contamination that can interfere with rear cup seal function, and rolling of the rearmost cup seal.Prior to total loss of the front brakes, depending on the amount of brake fluid loss in the master cylinder, the driver may receive an audible chime, message center alert and red brake warning indicator in the instrument cluster, and may experience a change in brake pedal travel and increased pedal effort. It should be noted that a small number of late-built MY 2014 and early-built MY 2017 F-150 vehicles are included in the recall along with the subject vehicles (MY 2015-2016).This Recall Query is closed based on the safety recall issued by Ford. The ODI reports cited above can be viewed at NHTSA.gov under the following ID numbers:10734951 10839988 10862418 10872737 10873438 10876359 10881590 10883442 10885352 10888026 10888524 10891826 10891829 10891886 10893632 10894688 10894844 10896122 10896446 10898079 10899093 10899198 10902944 10903776 10904695 10908281 10910101 10913678 10913867 10914016 10914164 10914288 10914361 10914382 10914483 10914507 10915027 10915894 10916302 10916346 10916578 10920258 10925699 10926076 10926148 10926179 10927388 10927402 10927459 10927578 10928457 10928906 10930128 10936207 10940199 10943902 10948941 10950413 10954419 10956798 10969452 10969971 10984389 10985533 10991033 10993430 10993826 10994249 11000331 11000746 11001283 11001291 11001403 11001550 11002014 11002827 11003801 11004795 11005551 11010248 11010341 11011291 11011502 11012944 11013023 11013826 11014954 11015390 11018677 11018771 11020059 11021249 11021632 11022034 11022116 11022243 11023791 11025448 11030416 11030852 11039991 11082190 11082307 11083373 11083998 11089076 11091017 11092142 11093509 11096406 11096501 11097550 11097885 11099405 11099859 11100723 11101189 11101357 11101515 11101631 11102242 11102281 11102299 11102326 11102360 11102481 11104187 11104212 11104877 11109739 11110958 11111028 11111445 11111776 11112143 11112145 11112331 11112445 11112504 11112969 11112970 11114501 11115336 11115612 11118050 11118324 11119688 11119741 11120003 11120625 11120839 11121496 11122946 11123817 11124180 11124313 11124735 11129689 11129763 11129799 11130736 11131008 11132384 11139389 11139955 11154079 11163050 11183075 11189767 11192325 11193564 11195772 11196715 11205224 11205725 11208030 11208558 11209657 11210390 11217868 11218183 11218476 11218533 11218548 11218703 11218773 11219228 11219556 11220778 11221408 11221528 11221888 11222322 11222604 11222909 11228582 11228780 11229191 11229412 11229541 11229673 11230311 11230525 11230553 11230595 11230606 11230664 11231440 11231744 11231985 11232226 11232462 11233423 11233425 11233557 11233595 11233614 11233857 11233864 11234025 11234577 11234715 11234752 11240161 11240184 11240219 11240344 11241143 11241328 11241565 11241737 11241755 11241979 11242032 11242096 11242101 11242222 11242430 11242723 11243775 11244070 11244092 11244223 11244613 11244872 11245199 11245233 11245259 11245846 11246001 11251825 11252130 11252506 11252570 11252595 11252809 11254026 11254116 11254385 11254816 11255210 11255273 11255487 11256470 11257328 11257549 11258458 11258978 11265268 11267540 11269887 11279423 11281670 11287382 11291824 11297512 11298972 11301103 11306644 11310503 11315450 11316153 11318273 11319339 11319344 11319751
Service Brakes, Hydraulic:foundation Components:master Cylinder
On June 8, 2020, Ford Motor Company issued a safety recall (NHTSA Recall No. 20V-332) of 292,311 model year (MY) 2014-2017 Ford F-150 vehicles equipped with 3.5L Ecoboost engines and built from 9/1/2014 to 8/1/2016. Ford stated that the causes of brake fluid loss in the master cylinder are brake fluid contamination that can interfere with rear cup seal function, and rolling of the rearmost cup seal.Prior to total loss of the front brakes, depending on the amount of brake fluid loss in the master cylinder, the driver may receive an audible chime, message center alert and red brake warning indicator in the instrument cluster, and may experience a change in brake pedal travel and increased pedal effort. It should be noted that a small number of late-built MY 2014 and early-built MY 2017 F-150 vehicles are included in the recall along with the subject vehicles (MY 2015-2016).This Recall Query is closed based on the safety recall issued by Ford. The ODI reports cited above can be viewed at NHTSA.gov under the following ID numbers:10734951 10839988 10862418 10872737 10873438 10876359 10881590 10883442 10885352 10888026 10888524 10891826 10891829 10891886 10893632 10894688 10894844 10896122 10896446 10898079 10899093 10899198 10902944 10903776 10904695 10908281 10910101 10913678 10913867 10914016 10914164 10914288 10914361 10914382 10914483 10914507 10915027 10915894 10916302 10916346 10916578 10920258 10925699 10926076 10926148 10926179 10927388 10927402 10927459 10927578 10928457 10928906 10930128 10936207 10940199 10943902 10948941 10950413 10954419 10956798 10969452 10969971 10984389 10985533 10991033 10993430 10993826 10994249 11000331 11000746 11001283 11001291 11001403 11001550 11002014 11002827 11003801 11004795 11005551 11010248 11010341 11011291 11011502 11012944 11013023 11013826 11014954 11015390 11018677 11018771 11020059 11021249 11021632 11022034 11022116 11022243 11023791 11025448 11030416 11030852 11039991 11082190 11082307 11083373 11083998 11089076 11091017 11092142 11093509 11096406 11096501 11097550 11097885 11099405 11099859 11100723 11101189 11101357 11101515 11101631 11102242 11102281 11102299 11102326 11102360 11102481 11104187 11104212 11104877 11109739 11110958 11111028 11111445 11111776 11112143 11112145 11112331 11112445 11112504 11112969 11112970 11114501 11115336 11115612 11118050 11118324 11119688 11119741 11120003 11120625 11120839 11121496 11122946 11123817 11124180 11124313 11124735 11129689 11129763 11129799 11130736 11131008 11132384 11139389 11139955 11154079 11163050 11183075 11189767 11192325 11193564 11195772 11196715 11205224 11205725 11208030 11208558 11209657 11210390 11217868 11218183 11218476 11218533 11218548 11218703 11218773 11219228 11219556 11220778 11221408 11221528 11221888 11222322 11222604 11222909 11228582 11228780 11229191 11229412 11229541 11229673 11230311 11230525 11230553 11230595 11230606 11230664 11231440 11231744 11231985 11232226 11232462 11233423 11233425 11233557 11233595 11233614 11233857 11233864 11234025 11234577 11234715 11234752 11240161 11240184 11240219 11240344 11241143 11241328 11241565 11241737 11241755 11241979 11242032 11242096 11242101 11242222 11242430 11242723 11243775 11244070 11244092 11244223 11244613 11244872 11245199 11245233 11245259 11245846 11246001 11251825 11252130 11252506 11252570 11252595 11252809 11254026 11254116 11254385 11254816 11255210 11255273 11255487 11256470 11257328 11257549 11258458 11258978 11265268 11267540 11269887 11279423 11281670 11287382 11291824 11297512 11298972 11301103 11306644 11310503 11315450 11316153 11318273 11319339 11319344 11319751
Illustration