IllustrationPROBLEM START SINCE I BOUGHT THE TRUCK,DRIVERSHAFT MAKE AN UNCOMFORTABLE BUMP OR HIT EVERYTIME TRUCK STOP OR ACCELERATE.I BEEN TREE TIMES IN FORD SERVICE AND THEY SAID IS A NORMAL THING.I HAVE TESTED OTHER FRIENDS TRUCK AND THEY DONT HAVE ANY PROBLEMS.THIS IS MY THIRD FORD TRUCK AND IS THE FIRST TIME I FEEL THIS PROBLEM.
2014 Ford F-150
Owner reports · Recalls · Investigations
More warning signs than most F-150 years
Owner complaints for the 2014 Ford F-150 are substantially higher than the model-year median of 676.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-150 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1700–25K
20525–50K
21150–75K
14675–100K
167100–150K
109150K+
1,008 reports with mileage · 523 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 422 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 288 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 178 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
38 crash reports16 fire reports27 injury reports
Power Train complaints
422 reports3.5 ECO BOOST ENGINE RUNS ROUGH AT TIMES AND WHEN PASSING AT HIGHWAY SPEEDS SOMETIMES GOES INTO "SAFE MODE" AND SHUTS DOWN TO IDLE WHEN UNDER FULL ACCELERATION. MILEAGE IS CONSTANTLY GOING DOWN, FROM 22MPG TO 13MPG. DEALER SAYS THIS IS NEW TO THEM.THE DEALER SAID THEY FOUND TRACKS ON THE SPARK PLUGS AND CHANGED THEM, NEW PLUG WI…
Read full complaint
3.5 ECO BOOST ENGINE RUNS ROUGH AT TIMES AND WHEN PASSING AT HIGHWAY SPEEDS SOMETIMES GOES INTO "SAFE MODE" AND SHUTS DOWN TO IDLE WHEN UNDER FULL ACCELERATION. MILEAGE IS CONSTANTLY GOING DOWN, FROM 22MPG TO 13MPG. DEALER SAYS THIS IS NEW TO THEM.THE DEALER SAID THEY FOUND TRACKS ON THE SPARK PLUGS AND CHANGED THEM, NEW PLUG WIRES WERE SUPPOSEDLY BAD, REPLACED BOTH TURBOS. STILL NO DIFFERENCE.I HAVE A VIDEO OF THIS HAPPENING WITH THE ENG CHECK LIGHT COMING ON AND AFTER THE DEALER SAID THERE WAS NO INDICATION OF THIS IN OBD2 MEMORY.
UPON DRIVING AFTER START UP, THE TRUCK WILL EXPERIENCE A HARSH UP SHIFT WHEN SHIFTING FROM 2ND TO 3RD GEAR. THE TRUCK WILL LURCH FORWARD VIOLENTLY. AFTER OPERATING, THE HARSH UP-SHIFT WILL GO AWAY. I HAVE BROUGHT THE TRUCK TO THE DEALER, AND THEY CANNOT DETERMINE WHAT IS CAUSING THE HARSH SHIFT.
TL* THE CONTACT OWNS A 2014 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT A HIGH SPEED, VARIOUS WARNING INDICATORS FLICKERED AND THE VEHICLE COASTED IN REVERSE. THE CONTACT WAS ABLE TO COAST THE VEHICLE OVER TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO A DEALER WHO STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. …
Read full complaint
TL* THE CONTACT OWNS A 2014 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT A HIGH SPEED, VARIOUS WARNING INDICATORS FLICKERED AND THE VEHICLE COASTED IN REVERSE. THE CONTACT WAS ABLE TO COAST THE VEHICLE OVER TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO A DEALER WHO STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 16,000.
ACCELERATION LAG IN A ROLLING OR STANDING START. MOST NOTICEABLE WHEN STOPPED WITH TRUCK FACING UPHILL OR SLOWING TO A NEAR STOP AND THEN SLOWLY ACCELERATING (SLOWING FOR A STOP LIGHT THAT TURNS GREEN AS YOU APPROACH THE INTERSECTION). ONCE ACCELERATION KICKS IN, THE VEHICLE JUMPS AS IF THE TRANSMISSION HAS DROPPED FROM NEUTRAL …
Read full complaint
ACCELERATION LAG IN A ROLLING OR STANDING START. MOST NOTICEABLE WHEN STOPPED WITH TRUCK FACING UPHILL OR SLOWING TO A NEAR STOP AND THEN SLOWLY ACCELERATING (SLOWING FOR A STOP LIGHT THAT TURNS GREEN AS YOU APPROACH THE INTERSECTION). ONCE ACCELERATION KICKS IN, THE VEHICLE JUMPS AS IF THE TRANSMISSION HAS DROPPED FROM NEUTRAL TO BEING INTO GEAR AT INCREASED RPM'S OR THE CLUTCH HAS SLIPPED. GEAR INDICATOR DOESN'T SHOW VEHICLE HAD EVER DROPPED INTO NEUTRAL. IF ACCELERATION RATE IS INCREASED FROM STOP OR ROLLING START, PROBLEM DOES NOT SEAM TO OCCUR. PROBLEM WAS NOTICED FROM BEGINNING OF OWNERSHIP AND HAS BEEN INTERMITTENT EVER SINCE (TRUCK WAS PURCHASED NEW IN MARCH 2015). HAVE NOT TAKEN TO DEALER FOR DIAGNOSIS AS IT IS INTERMITTENT, BUT TALKED TO A NON-FORD MECHANIC THAT HAD HEARD OF OTHER PEOPLE NOTICING ACCELERATION LAG.
TL* THE CONTACT OWNS A 2014 FORD F-150. WHILE ATTEMPTING TO ACCELERATE FROM A STOP LIGHT, THE VEHICLE JERKED AND SOUNDED AS IF IT WOULD STALL. THE VEHICLE SUDDENLY ACCELERATED AND WAS TAKEN TO A LOCAL DEALER, BUT NO FAILURES COULD BE FOUND. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA TO FILE …
Read full complaint
TL* THE CONTACT OWNS A 2014 FORD F-150. WHILE ATTEMPTING TO ACCELERATE FROM A STOP LIGHT, THE VEHICLE JERKED AND SOUNDED AS IF IT WOULD STALL. THE VEHICLE SUDDENLY ACCELERATED AND WAS TAKEN TO A LOCAL DEALER, BUT NO FAILURES COULD BE FOUND. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA TO FILE A COMPLAINT. THE FAILURE MILEAGE WAS 14,000.
TL* THE CONTACT OWNS A 2014 FORD F-150. WHILE THE VEHICLE WAS PARKED, IT MOVED IN REVERSE INDEPENDENTLY AND DAMAGED THE DRIVER SIDE DOOR AND FRONT FENDER. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS…
Read full complaint
TL* THE CONTACT OWNS A 2014 FORD F-150. WHILE THE VEHICLE WAS PARKED, IT MOVED IN REVERSE INDEPENDENTLY AND DAMAGED THE DRIVER SIDE DOOR AND FRONT FENDER. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 10,000.
AT APPROXIMATELY 12,600 MILES ON MY NEWLY PURCHASED VEHICLE, I EXPERIENCED BRAKE VIBRATION, A HESITATION AND JERK IN TRANSMISSION AT LOW ACCELERATING SPEED OR SLOWING DOWN AND THEN ACCELERATING, AND A LOUD WHINING NOISE FROM REAR END BETWEEN 60-65 MILES PER HOUR. I TOOK IT TO RIVER CITY FORD AND THEY TURNED THE ROTORS FOR THE B…
Read full complaint
AT APPROXIMATELY 12,600 MILES ON MY NEWLY PURCHASED VEHICLE, I EXPERIENCED BRAKE VIBRATION, A HESITATION AND JERK IN TRANSMISSION AT LOW ACCELERATING SPEED OR SLOWING DOWN AND THEN ACCELERATING, AND A LOUD WHINING NOISE FROM REAR END BETWEEN 60-65 MILES PER HOUR. I TOOK IT TO RIVER CITY FORD AND THEY TURNED THE ROTORS FOR THE BRAKES. I TOLD RIVER CITY FORD THAT WAS UNACCEPTABLE FOR A NEW VEHICLE AND BY TURNING THE ROTORS THEY JUST REDUCED THE LIFE OF THE ROTORS FOR A NEW VEHICLE. I ALSO TOLD THEM THAT THE BRAKE PADS SHOULD BE REPLACED ALSO. I CONTACTED FORD CORP AND THEY WOULD NOT TAKE ANY ACTION AND WOULD NOT LET ME TALK TO ANYONE HIGHER THAN A CUSTOMER SERVICE SUPERVISOR. RIVER CITY FORD HAS HAD MY VEHICLE IN THE SHOP SINCE 7/20/2015. THEY HAVE TRIED SHIMMING RING AND PINION IN REAR END AND IT DID NOT FIX THE PROBLEM. THEY HAVE TRIED VARIOUS THINGS AND HAS NOT FIXED THE PROBLEM. THEY CLAIM THAT ADDING GREASE TO THE TRANSMISSION SUPPOSEDLY FIXED THE JERKING WHEN ACCELERATING. FORD CORP HAS WASTED A LOT OF TIME TRYING TO FIX A KNOWN PROBLEM BY FORD. MY RESEARCH SHOWS THE REAR END ISSUE HAS EXISTED FOR YEARS AND MANY CUSTOMERS HAVE EXPERIENCED THE PROBLEM. BRAKE VIBRATION, TRANSMISSION JERKING, AND LOUD HUMMING FROM THE REAR END ARE ALL SAFETY ISSUES, THAT IF A FAILURE OCCURS, COULD RESULT IN AN ACCIDENT AT HIGH SPEED.
I HAVE BEEN HAVING PROBLEMS WITH THE ENGINE AND BRAKES SINCE I BOUGHT THIS TRUCK. I HAVE HAD IT TO THE DEALER NUMEROUS TIMES AND THEY THROW PARTS AT IT AND IT DOES NOT FIX IT. AT BEGINNING OF ACCELERATION THERE IS A DEAD SPOT IN THE THROTTLE AND WHEN YOU PUSH PAST IT SLIGHTLY YOU FIND THE VEHICLE ACCELERATES RAPIDLY AND SOMETIME…
Read full complaint
I HAVE BEEN HAVING PROBLEMS WITH THE ENGINE AND BRAKES SINCE I BOUGHT THIS TRUCK. I HAVE HAD IT TO THE DEALER NUMEROUS TIMES AND THEY THROW PARTS AT IT AND IT DOES NOT FIX IT. AT BEGINNING OF ACCELERATION THERE IS A DEAD SPOT IN THE THROTTLE AND WHEN YOU PUSH PAST IT SLIGHTLY YOU FIND THE VEHICLE ACCELERATES RAPIDLY AND SOMETIMES SPINS THE DRIVE TIRES. A FEW DAYS AGO I WAS PULLING OUT INTO A BREAK IN TRAFFIC THAT WAS MORE THAN ADEQUATE AND THE ENGINE STARTED O.K. THEN HESITATED PUTTING ME IN DANGER OF BEING HIT BY NOW CLOSELY APPROACHING TRAFFIC. WHEN I BRING THE TRUCK TO THE DEALER THEY TRY THEIR BEST TO FIND THE PROBLEM BUT CAN'T.THEY SAID IT WAS BAD TURBOS AND REPLACED THEM THAT DID NOTHING TO HELP, THEY ALSO SAID THE PLUG WIRE BOOTS HAD TRACKS ON THEM AND THE SPARK PLUGS WERE MISFIRING, ALL WAS REPLACED TO NO AVAIL. ALSO WHEN YOU ARE DRIVING AT CITY SPEEDS AND PUSH THE THROTTLE TO PASS OR ACCELERATE IN TRAFFIC THERE IS A NOTICEABLE LAG IN DEPRESSING THE THROTTLE AND THE ENGINE RESPONDING. THIS IS ALSO A DANGEROUS PROBLEM.I BROUGHT THE TRUCK IN FOR OVERLY SENSITIVE BRAKES AND I WAS TOLD BY ONE SERVICE WRITER THAT THE TECH FOUND FLUID IN THE BOOSTER AND ANOTHER WRITER SAID IT WAS ASSEMBLY LUBE. THEY CHANGED THE BOOSTER BUT NOT THE MASTER CYLINDER.
THIS HAS TRUCK HAS A SHUDDER OR VIBRATION FROM STARTING OUT FROM 1 TO 10 MILES AN HOUR AND ADDITIONALLY WHEN PASSING AND DRIVING ON THE HIGHWAY. THERE IS ALSO AN ACCELERATION DELAY AT ALL SPEEDS. THIS TRUCK IS EQUIPPED WITH THE 3.5L ECO BOOST ENGINE. THESE ISSUES ARE ESPECIALLY MORE NOTICEABLE WHEN THERE IS A LOAD ON THE TRUCK S…
Read full complaint
THIS HAS TRUCK HAS A SHUDDER OR VIBRATION FROM STARTING OUT FROM 1 TO 10 MILES AN HOUR AND ADDITIONALLY WHEN PASSING AND DRIVING ON THE HIGHWAY. THERE IS ALSO AN ACCELERATION DELAY AT ALL SPEEDS. THIS TRUCK IS EQUIPPED WITH THE 3.5L ECO BOOST ENGINE. THESE ISSUES ARE ESPECIALLY MORE NOTICEABLE WHEN THERE IS A LOAD ON THE TRUCK SUCH AS A TOPPER AND LUGGAGE, ETC.
Official recalls
826V378000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Jun 9, 2026
Ford Motor Company (Ford) is recalling certain model year 2014 F-150 vehicles previously repaired incorrectly under recall number 24V444. A loss of signal between the transmission output shaft speed sensor and the powertrain control module (PCM) can cause the transmission to unexpectedly downshift into first gear.
Consequence & remedy
Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed July 8, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26S45. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.
24V444000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Jun 17, 2024
Ford Motor Company (Ford) is recalling certain 2014 F-150 vehicles. A loss of signal between the transmission output shaft speed sensor and the powertrain control module can cause the transmission to unexpectedly downshift into first gear, regardless of vehicle speed.
Consequence & remedy
Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed July 1, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S37.
20V332000 · Service Brakes, Hydraulic:foundation Components:master Cylinder; Service Brakes, Hydraulic:power Assist
Jun 8, 2020
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence & remedy
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:master Cylinder
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
Service Brakes, Hydraulic:power Assist
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
17V472000 · Seat Belts; Seats
Jul 25, 2017
Ford Motor Company (Ford) is recalling certain 2014 Ford F-150 and E-350, 2014-2015 Ford Escape, and 2015 Lincoln MKC vehicles. Improperly manufactured bolts may have been used to install certain seats, seatbacks, seatbelt buckles, or seatbelt anchors on these vehicles.
Consequence & remedy
Consequence: The improperly manufactured bolts may fracture. If a seat, seatback, or seatbelt anchor attaching bolt fractures, the affected component may not be properly secured, increasing the risk of injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the affected bolts, free of charge. Interim notices informing owners of the safety risk were mailed September 8, 2017. Owners will receive a second notice when remedy parts become available in the fourth quarter of 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S17.
Additional source detail variants (2)
Seats
Ford Motor Company (Ford) is recalling certain 2014 Ford F-150 and E-350, 2014-2015 Ford Escape, and 2015 Lincoln MKC vehicles. Improperly manufactured bolts may have been used to install certain seats, seatbacks, seatbelt buckles, or seatbelt anchors on these vehicles.
Consequence: The improperly manufactured bolts may fracture. If a seat, seatback, or seatbelt anchor attaching bolt fractures, the affected component may not be properly secured, increasing the risk of injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the affected bolts, free of charge. Interim notices informing owners of the safety risk were mailed September 8, 2017. Owners will receive a second notice when remedy parts become available in the fourth quarter of 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S17.
Seat Belts
Ford Motor Company (Ford) is recalling certain 2014 Ford F-150 and E-350, 2014-2015 Ford Escape, and 2015 Lincoln MKC vehicles. Improperly manufactured bolts may have been used to install certain seats, seatbacks, seatbelt buckles, or seatbelt anchors on these vehicles.
Consequence: The improperly manufactured bolts may fracture. If a seat, seatback, or seatbelt anchor attaching bolt fractures, the affected component may not be properly secured, increasing the risk of injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the affected bolts, free of charge. Interim notices informing owners of the safety risk were mailed September 8, 2017. Owners will receive a second notice when remedy parts become available in the fourth quarter of 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S17.
16V345000 · Service Brakes, Hydraulic:fluid
May 24, 2016
Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.
Consequence & remedy
Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.
14V710000 · Seats
Nov 7, 2014
Ford Motor Company (Ford) is recalling certain model year 2014 Ford F-150 and Flex vehicles manufactured March 1, 2014, to May 31, 2014. The affected vehicles were manufactured with a reduced clearance between the seat frame and the seat track assembly. This can cause the Occupant Classification System (OCS) to inaccurately register passenger weight and improperly suppress the passenger front airbag when the passenger seat is occupied by an adult passenger. Thus, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) No. 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Improper suppression of the passenger airbag increases the risk of an injury to the seat occupant in the event of a crash necessitating deployment of the front passenger airbag.
Remedy: Ford will notify owners, and dealers will widen the gap between the seat frame and seat track assembly and recalibrate the seat OCS, free of charge. The recall began November 25, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14C10.
14V709000 · Exterior Lighting:brake Lights:switch; Service Brakes, Hydraulic:pedals And Linkages
Nov 5, 2014
Ford Motor Company (Ford) is recalling certain model year 2014 F-150 vehicles manufactured March 1, 2014, to March 13, 2014. The affected vehicles may have a brake pedal position switch that is improperly adjusted. As a result, the brake lights may illuminate with a delay or not at all. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the brake lights fail to illuminate, or illuminate after a delay, there is an increased risk of a crash.
Remedy: Ford has notified owners, and dealers will adjust the brake pedal position switch, free of charge. The recall began on November 24, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14C09. Note: Until the vehicle has been remedied, owners are advised not to use their cruise control system.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
Ford Motor Company (Ford) is recalling certain model year 2014 F-150 vehicles manufactured March 1, 2014, to March 13, 2014. The affected vehicles may have a brake pedal position switch that is improperly adjusted. As a result, the brake lights may illuminate with a delay or not at all. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the brake lights fail to illuminate, or illuminate after a delay, there is an increased risk of a crash.
Remedy: Ford has notified owners, and dealers will adjust the brake pedal position switch, free of charge. The recall began on November 24, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14C09. Note: Until the vehicle has been remedied, owners are advised not to use their cruise control system.
Service Brakes, Hydraulic:pedals And Linkages
Ford Motor Company (Ford) is recalling certain model year 2014 F-150 vehicles manufactured March 1, 2014, to March 13, 2014. The affected vehicles may have a brake pedal position switch that is improperly adjusted. As a result, the brake lights may illuminate with a delay or not at all. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the brake lights fail to illuminate, or illuminate after a delay, there is an increased risk of a crash.
Remedy: Ford has notified owners, and dealers will adjust the brake pedal position switch, free of charge. The recall began on November 24, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14C09. Note: Until the vehicle has been remedied, owners are advised not to use their cruise control system.
14V316000 · Steering:electric Power Assist System
Jun 12, 2014
Ford Motor Company (Ford) is recalling certain model year 2014 Ford F-150 trucks manufactured May 26, 2014 to June 19, 2014, and equipped with Electronic Power Assist Steering (EPAS). The affected vehicles may have an incorrectly installed EPAS gear motor position sensor magnet that can lead to a total loss of steering control while driving.
Consequence & remedy
Consequence: A loss of steering control while driving increases the risk of a vehicle crash.
Remedy: Ford will notify owners, and dealers will replace the EPAS steering gear, free of charge. The recall began in July 2014. Note: Owners are advised not to drive their vehicles until they have been remedied. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S09.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ24005 · Unintended Transmission Downshift
Opened Mar 27, 2024 · Closed Jul 29, 2024
Status: closed (inferred from source dates) · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
In September 2016, Ford Motor Company (Ford) issued safety recall 16V-248 which included certain model year (MY) 2011-2012 Ford F-150 vehicles equipped with 6-speed (6R80) automatic transmissions. This recall was in response to allegations of unintended, unexpected vehicle transmission downshifting to a lower gear without warning, often accompanied by temporary rear wheel lock-up, increasing the risk of a crash and/or injury, and included approximately 153,581 vehicles. Ford identified the root cause of the unintended, unexpected vehicle transmission downshifting to a lower gear to be intermittent signal loss from the transmission’s Output Shaft Speed (OSS) sensor due to solder joint cracks on the OSS circuit board as a result of manufacturing process issues. The OSS sensor is mounted onto the molded lead frame and transmits changes in transmission shaft speed to the Powertrain Control Module (PCM). The remedy program described in safety recall 16V-248 involved reprogramming of the PCM to prevent unintended vehicle transmission downshifting from occurring. In December 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-010) to assess the scope and remedy effectiveness of safety recall 16V-248. As a result of this ODI investigation, Ford issued safety recall 19V-075 to expand the scope of 16V-248 to include MY 2011-2013 Ford F-150 vehicles equipped with 6-speed (6R80) automatic transmissions and included approximately 1,263,051 vehicles. The remedy program described in safety recall 19V-075 involved reprogramming of the PCM to prevent unintended vehicle transmission downshifting from occurring. In June 2019, Ford issued safety recall 19V-433 as the remedy program used to service MY 2013 Ford F-150 5.0L and 6.2L vehicles in accordance with safety recall 19V-075 did not contain the necessary updates to prevent unintended vehicle transmission downshifting from occurring and included approximately 107,857 vehicles. On March 27, 2024, ODI opened this Recall Query (RQ24-005) to investigate the scope of the above-described safety recalls. At the time that this investigation was opened, ODI had received 86 Vehicle Owner Questionnaires (VOQs) reporting allegations of unintended, unexpected vehicle transmission downshifting to a lower gear without warning, often accompanied by temporary rear wheel lock-up, in MY 2014 Ford F-150 vehicles. As a result of this Recall Query, Ford filled safety recall 24V-444 on June 14, 2024, to include MY 2014 Ford F-150 vehicles and expand the scope of safety recalls 16V-248, 19V-075 and 19V-433. The remedy program described in safety recall 24V-444 involved reprogramming of the PCM to prevent unintended vehicle transmission downshifting from occurring and included approximately 552,188 vehicles. In its May 2024 response to ODI’s information request, Ford concluded that a predominant root cause for the intermittent OSS signal loss has not been identified outside of the original safety recall (16V-248). Ford’s investigation also concluded that the primary causes of the defect in MY 2014 F-150 vehicles were related to the molded lead frame and the control assembly transmission main. In the May 2024 response, Ford identified 2,184 total reports that described unintended vehicle transmission downshifting and rear wheel lock-up events; 1,441 warranty claims and 743 reports from consumer complaints, field reports, consumer surveys, and lawsuits/legal claims. Note that the values presented here and in the table above represent the total number of reports which can include a single consumer with multiple reports of the same event as well as a consumer with reports of multiple distinct events. Of the 1,441 warranty claims, 551 warranty claims involved repair of the molded lead frame (38%) and 509 warranty claims involved repair of the control assembly transmission main (35%). Ford has also stated that the PCM programming used to prevent unintended vehicle transmission downshifting was implemented starting with MY 2015 vehicle #1 production and onward. In view of the safety recall action being taken by Ford, ODI is closing this Recall Query (RQ24-005). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE16003 · Master Cylinder External Leak
Opened Feb 29, 2016 · Closed Jul 26, 2016
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Additional source detail variants (4)
Service Brakes
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Service Brakes, Hydraulic:fluid
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Service Brakes, Hydraulic
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Service Brakes, Hydraulic:foundation Components:master Cylinder
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107