IllustrationIN MOTION AT 70MPH ENGINE LOST POWER VEHICLE BEGAN TO SHUTTER, WHILE ATTEMPTING TO PASS ANOTHER VEHICLE ON HIGHWAY. CHECK ENGINE LIGHT CAME ON FLASHED FOR 30 SECONDS AND WENT OUT. DEALERSHIP SHOWS NO CODES OR PROBLEMS. VERY DANGEROUS SITUATION ON TWO LANE HIGHWAYS. THIS IS A 3.5 V6 ECOBOOST FORD ENGINE,
2014 Ford F-150
Owner reports · Recalls · Investigations
More warning signs than most F-150 years
Owner complaints for the 2014 Ford F-150 are substantially higher than the model-year median of 676.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-150 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1700–25K
20525–50K
21150–75K
14675–100K
167100–150K
109150K+
1,008 reports with mileage · 523 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 422 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 288 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 178 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
38 crash reports16 fire reports27 injury reports
Engine complaints
178 reports2014 FORD F150 ECOBOOST NO POWER. I WAS STOPPED IN CENTER TURN LANE WAITING TO TURN LEFT ACROSS ON COMING HIGHWAY TRAFFIC. AFTER IT WAS SAFE TO CROSS I PRESS THE ACCELERATOR I DISCOVERED MY F150 HAD NOT POWER. GAS PEDAL HAD NO RESPONSE. TRUCK WOULD ONLY MOVE AT IDEAL SPEED. VERY CLOSE TO GETTING T-BONED. THE SERVICE WRENCH SHO…
Read full complaint
2014 FORD F150 ECOBOOST NO POWER. I WAS STOPPED IN CENTER TURN LANE WAITING TO TURN LEFT ACROSS ON COMING HIGHWAY TRAFFIC. AFTER IT WAS SAFE TO CROSS I PRESS THE ACCELERATOR I DISCOVERED MY F150 HAD NOT POWER. GAS PEDAL HAD NO RESPONSE. TRUCK WOULD ONLY MOVE AT IDEAL SPEED. VERY CLOSE TO GETTING T-BONED. THE SERVICE WRENCH SHOWED UP ON THE INSTRUMENT PANEL. THE TRUCK HAD A VERY ROUGH IDEAL AS I CREEPED OFF THE HIGHWAY. I HAD THE TRUCK TOWED TO THE DEALER THAT HAD JUST REPAIRED THE TIMING CHAIN AND CAM SHAFT PHASERS THE WEEK PRIOR. DEALER RAN SEVERAL TESTS AND FOUND NO CODES. THEY DECIDED TO REPLACE THE THROTTLE BODY AND MOTOR ASSEMBLY AFTER CHECKING OASIS AND FOUND MULTIPLE HOTLINE CONTACTS WITH SIMILAR CONCERNS. WHEN PULLING TRUCK INTO SERVICE BAY THE THROTTLE BODY STUCK PARTIALLY CLOSED. I WAS VERY LUCKY TO NOT GET HIT BY ANOTHER CAR WHEN THIS HAPPENED TO ME. YOUTUBE VIDEO (2014-11-02 -2013 F150 LIMP MODE) BY MIKE WILES SHOWS EXACTLY WHAT HAPPENED WITH MY TRUCK. PLEASE HAVE FORD RECALL THIS PART BEFORE SOMEONE DIES.
2014 FORD F-150 LOOSES POWER AT RANDOM TIMES WHILE ON THE HIGHWAY. HAD THE THROTTLE BODY REPLACED IN JUNE OF 2016 BECAUSE OF SAME PROBLEM. CONTACTED FORD AND THEY SAID I'M OUT OF WARRANTY AND I WOULD HAVE TO PAY FOR ANY SERVICE REPAIRS. I DO A LOT OF TRAVELING WITH A TRAILER AND IT QUIT DANGEROUS IN HEAVY TRAFFIC TRYING TO FINE …
Read full complaint
2014 FORD F-150 LOOSES POWER AT RANDOM TIMES WHILE ON THE HIGHWAY. HAD THE THROTTLE BODY REPLACED IN JUNE OF 2016 BECAUSE OF SAME PROBLEM. CONTACTED FORD AND THEY SAID I'M OUT OF WARRANTY AND I WOULD HAVE TO PAY FOR ANY SERVICE REPAIRS. I DO A LOT OF TRAVELING WITH A TRAILER AND IT QUIT DANGEROUS IN HEAVY TRAFFIC TRYING TO FINE A SPOT TO PULL OVER. I WAS IN THE FORT PITT TWO MILE TUNNEL IN PITTSBURGH WHEN THIS HAPPENED LAST WEEK. SCREECHING TIRES AND HORNS BLOWING I LIMPED IT OUT OF THE TUNNEL. WHERE I FOUND A PLACE TO PULL OVER. WHAT CAN I DO? FRUSTRATED FORD CUSTOMER.
DRIVING IN HEAVY 5 LANE TRAFFIC AT ABOUT 50-55 MILES AN HOUR, IN THE 3RD LANE FROM THE RIGHT ON I580 EAST. I ACCELERATED TO GET INTO THE EXPRESS LANE AND WHEN I WAS STARTING TO MERGE SUDDENLY THERE WAS NO POWER. IT DIDN'T MATTER HOW MUCH I PRESSED THE GAS PEDAL IT HAD NO POWER. THE ENGINE WAS STILL RUNNING. I HAD TO QUICKLY SIGN…
Read full complaint
DRIVING IN HEAVY 5 LANE TRAFFIC AT ABOUT 50-55 MILES AN HOUR, IN THE 3RD LANE FROM THE RIGHT ON I580 EAST. I ACCELERATED TO GET INTO THE EXPRESS LANE AND WHEN I WAS STARTING TO MERGE SUDDENLY THERE WAS NO POWER. IT DIDN'T MATTER HOW MUCH I PRESSED THE GAS PEDAL IT HAD NO POWER. THE ENGINE WAS STILL RUNNING. I HAD TO QUICKLY SIGNAL AND COASTED TO THE SHOULDER OF THE FREEWAY. THERE WAS A WRENCH ICON ON THE DASH AND A WARNING THAT THE TRUCK WAS STUCK IN 4X4. I TURNED OFF THE ENGINE AND AFTER READING THE MANUAL, I STARTED THE TRUCK AND ALL SEEMED FINE UNTIL I TRIED TO MERGE AGAIN AND AGAIN NO POWER FROM THE GAS PEDAL. I HAD THE TRUCK TOWED TO A FORD DEALER.
TL* THE CONTACT OWNS A 2014 FORD F-150. WHILE ACCELERATING, THE VEHICLE SHOOK VIGOROUSLY AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE COILS AND SPARK PLUGS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WA…
Read full complaint
TL* THE CONTACT OWNS A 2014 FORD F-150. WHILE ACCELERATING, THE VEHICLE SHOOK VIGOROUSLY AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE COILS AND SPARK PLUGS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
TL* THE CONTACT OWNS A 2014 FORD F-150. WHILE DRIVING APPROXIMATELY 65 MPH, THE GEAR SHIFTED FROM SIX TO THIRD GEAR WITHOUT WARNING. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND SHUT OFF. THE VEHICLE WAS RESTARTED, BUT THE CONTACT HEARD A KNOCKING NOISE FROM THE ENGINE ALL THE WAY TO HIS RESIDENCE. THE VEHICLE WAS TOW…
Read full complaint
TL* THE CONTACT OWNS A 2014 FORD F-150. WHILE DRIVING APPROXIMATELY 65 MPH, THE GEAR SHIFTED FROM SIX TO THIRD GEAR WITHOUT WARNING. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND SHUT OFF. THE VEHICLE WAS RESTARTED, BUT THE CONTACT HEARD A KNOCKING NOISE FROM THE ENGINE ALL THE WAY TO HIS RESIDENCE. THE VEHICLE WAS TOWED TO A DEALER AND THE SPEED CONTROL SYSTEM, CAMSHAFT, TIMING BELT, AND TIMING CHAIN WERE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 148,000.
TL* THE CONTACT OWNS A 2014 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE DECELERATED INDEPENDENTLY. THE CONTACT MENTIONED THAT THERE WAS A KNOCKING NOISE THAT CAME FROM THE ENGINE. IN ADDITION, THE OIL PRESSURE LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT …
Read full complaint
TL* THE CONTACT OWNS A 2014 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE DECELERATED INDEPENDENTLY. THE CONTACT MENTIONED THAT THERE WAS A KNOCKING NOISE THAT CAME FROM THE ENGINE. IN ADDITION, THE OIL PRESSURE LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE INFORMED THE ENGINE BLEW UP DUE TO ECO BOOST. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000. THE VIN WAS NOT PROVIDED.
ENTERING THE INTERSTATE AND VEHICLE STARTED TO SHUTTERE/SHAKE AND COMPLETELY LOST POWER ANY KIND OF POWER TO THE ENGINE. THE ACCELERATIOR WOULDN'T DO ANYTHING. WARNING LIGHT, AN ORANGE WRENCH APPEARED ON THE DASH DISPLAY. VEHICLE WOULD ONLY COAST BUT DID NOT DIE. WAS ALMOST STRUCK BY A VEHICLE TRAVELING AT INTERSTATE SPEEDS AS …
Read full complaint
ENTERING THE INTERSTATE AND VEHICLE STARTED TO SHUTTERE/SHAKE AND COMPLETELY LOST POWER ANY KIND OF POWER TO THE ENGINE. THE ACCELERATIOR WOULDN'T DO ANYTHING. WARNING LIGHT, AN ORANGE WRENCH APPEARED ON THE DASH DISPLAY. VEHICLE WOULD ONLY COAST BUT DID NOT DIE. WAS ALMOST STRUCK BY A VEHICLE TRAVELING AT INTERSTATE SPEEDS AS VEHICLE WOULDN'T PULL OVER FAST ENOUGH. VEHICLE DECELERATED REALLY FAST AND IT WAS TERRIFYING WATCHING A VEHICLE APPROACHED ME AND MY CHILD AT INTERSTATE SPEED. NARROWLY ESCAPED DISASTER. VEHICLE SAT ON SIDE OF ROAD FOR ABOUT 30 SECONDS AND POWER RETURNED TO VEHICLE.
I HAVE A 2014 F-150 3.5L ECOBOOST TRUCK.... IT HAS APPROXIMATELY 72,000 MILES THAT ARE MAINLY LONG HAUL AND NOT SHORT AROUND TOWN STOP/START MILES. MY UNDERSTANDING IS THIS DOES NOT QUALIFY FOR REPAIR UNDER WARRANTY. I HAVE RECENTLY EXPERIENCED A TOTAL LOSS OF ENGINE POWER WITHOUT ANY WARNING. IF I TURN OFF THE ENGINE AND RES…
Read full complaint
I HAVE A 2014 F-150 3.5L ECOBOOST TRUCK.... IT HAS APPROXIMATELY 72,000 MILES THAT ARE MAINLY LONG HAUL AND NOT SHORT AROUND TOWN STOP/START MILES. MY UNDERSTANDING IS THIS DOES NOT QUALIFY FOR REPAIR UNDER WARRANTY. I HAVE RECENTLY EXPERIENCED A TOTAL LOSS OF ENGINE POWER WITHOUT ANY WARNING. IF I TURN OFF THE ENGINE AND RESTART THEN IT WILL GO BACK TO FULL POWER FOR A SHORT PERIOD OF TIME AND THEN CUT OUT AGAIN. THIS IS NO FUN MAKING A RIGHT HAND TURN IN RUSH HOUR TRAFFIC IN THE CITY... VERY DANGEROUS IN FACT. THIS HAS OCCURRED WHILST DRIVING ON THE HIGHWAY, DRIVING AROUND THE CITY AND SOMETIMES GOING UP A HILL. I AM NOT A VEHICLE EXPERT AND DO NOT KNOW WHAT IS THE CAUSE. I VISITED FORD AND EVEN THEY WERE NOT SURE. I WILL VISIT ANOTHER DEALER TO SEE IF I CAN GET BETTER INFORMATION. MY CONCERN IS ABOUT DRIVING ACROSS TOWN IN HEAVY TRAFFIC AND HAVING THE VEHICLE CUT OUT ON ME AGAIN.
TL* THE CONTACT OWNS A 2014 FORD F-150. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE LOST POWER. IN ADDITION, THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO ACCELERATE. THE SERVICE VEHICLE SOON WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WA…
Read full complaint
TL* THE CONTACT OWNS A 2014 FORD F-150. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE LOST POWER. IN ADDITION, THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO ACCELERATE. THE SERVICE VEHICLE SOON WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 39,000.
Official recalls
826V378000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Jun 9, 2026
Ford Motor Company (Ford) is recalling certain model year 2014 F-150 vehicles previously repaired incorrectly under recall number 24V444. A loss of signal between the transmission output shaft speed sensor and the powertrain control module (PCM) can cause the transmission to unexpectedly downshift into first gear.
Consequence & remedy
Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed July 8, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26S45. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.
24V444000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Jun 17, 2024
Ford Motor Company (Ford) is recalling certain 2014 F-150 vehicles. A loss of signal between the transmission output shaft speed sensor and the powertrain control module can cause the transmission to unexpectedly downshift into first gear, regardless of vehicle speed.
Consequence & remedy
Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed July 1, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S37.
20V332000 · Service Brakes, Hydraulic:foundation Components:master Cylinder; Service Brakes, Hydraulic:power Assist
Jun 8, 2020
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence & remedy
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:master Cylinder
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
Service Brakes, Hydraulic:power Assist
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
17V472000 · Seat Belts; Seats
Jul 25, 2017
Ford Motor Company (Ford) is recalling certain 2014 Ford F-150 and E-350, 2014-2015 Ford Escape, and 2015 Lincoln MKC vehicles. Improperly manufactured bolts may have been used to install certain seats, seatbacks, seatbelt buckles, or seatbelt anchors on these vehicles.
Consequence & remedy
Consequence: The improperly manufactured bolts may fracture. If a seat, seatback, or seatbelt anchor attaching bolt fractures, the affected component may not be properly secured, increasing the risk of injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the affected bolts, free of charge. Interim notices informing owners of the safety risk were mailed September 8, 2017. Owners will receive a second notice when remedy parts become available in the fourth quarter of 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S17.
Additional source detail variants (2)
Seats
Ford Motor Company (Ford) is recalling certain 2014 Ford F-150 and E-350, 2014-2015 Ford Escape, and 2015 Lincoln MKC vehicles. Improperly manufactured bolts may have been used to install certain seats, seatbacks, seatbelt buckles, or seatbelt anchors on these vehicles.
Consequence: The improperly manufactured bolts may fracture. If a seat, seatback, or seatbelt anchor attaching bolt fractures, the affected component may not be properly secured, increasing the risk of injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the affected bolts, free of charge. Interim notices informing owners of the safety risk were mailed September 8, 2017. Owners will receive a second notice when remedy parts become available in the fourth quarter of 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S17.
Seat Belts
Ford Motor Company (Ford) is recalling certain 2014 Ford F-150 and E-350, 2014-2015 Ford Escape, and 2015 Lincoln MKC vehicles. Improperly manufactured bolts may have been used to install certain seats, seatbacks, seatbelt buckles, or seatbelt anchors on these vehicles.
Consequence: The improperly manufactured bolts may fracture. If a seat, seatback, or seatbelt anchor attaching bolt fractures, the affected component may not be properly secured, increasing the risk of injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the affected bolts, free of charge. Interim notices informing owners of the safety risk were mailed September 8, 2017. Owners will receive a second notice when remedy parts become available in the fourth quarter of 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S17.
16V345000 · Service Brakes, Hydraulic:fluid
May 24, 2016
Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.
Consequence & remedy
Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.
14V710000 · Seats
Nov 7, 2014
Ford Motor Company (Ford) is recalling certain model year 2014 Ford F-150 and Flex vehicles manufactured March 1, 2014, to May 31, 2014. The affected vehicles were manufactured with a reduced clearance between the seat frame and the seat track assembly. This can cause the Occupant Classification System (OCS) to inaccurately register passenger weight and improperly suppress the passenger front airbag when the passenger seat is occupied by an adult passenger. Thus, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) No. 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Improper suppression of the passenger airbag increases the risk of an injury to the seat occupant in the event of a crash necessitating deployment of the front passenger airbag.
Remedy: Ford will notify owners, and dealers will widen the gap between the seat frame and seat track assembly and recalibrate the seat OCS, free of charge. The recall began November 25, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14C10.
14V709000 · Exterior Lighting:brake Lights:switch; Service Brakes, Hydraulic:pedals And Linkages
Nov 5, 2014
Ford Motor Company (Ford) is recalling certain model year 2014 F-150 vehicles manufactured March 1, 2014, to March 13, 2014. The affected vehicles may have a brake pedal position switch that is improperly adjusted. As a result, the brake lights may illuminate with a delay or not at all. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the brake lights fail to illuminate, or illuminate after a delay, there is an increased risk of a crash.
Remedy: Ford has notified owners, and dealers will adjust the brake pedal position switch, free of charge. The recall began on November 24, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14C09. Note: Until the vehicle has been remedied, owners are advised not to use their cruise control system.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
Ford Motor Company (Ford) is recalling certain model year 2014 F-150 vehicles manufactured March 1, 2014, to March 13, 2014. The affected vehicles may have a brake pedal position switch that is improperly adjusted. As a result, the brake lights may illuminate with a delay or not at all. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the brake lights fail to illuminate, or illuminate after a delay, there is an increased risk of a crash.
Remedy: Ford has notified owners, and dealers will adjust the brake pedal position switch, free of charge. The recall began on November 24, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14C09. Note: Until the vehicle has been remedied, owners are advised not to use their cruise control system.
Service Brakes, Hydraulic:pedals And Linkages
Ford Motor Company (Ford) is recalling certain model year 2014 F-150 vehicles manufactured March 1, 2014, to March 13, 2014. The affected vehicles may have a brake pedal position switch that is improperly adjusted. As a result, the brake lights may illuminate with a delay or not at all. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the brake lights fail to illuminate, or illuminate after a delay, there is an increased risk of a crash.
Remedy: Ford has notified owners, and dealers will adjust the brake pedal position switch, free of charge. The recall began on November 24, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14C09. Note: Until the vehicle has been remedied, owners are advised not to use their cruise control system.
14V316000 · Steering:electric Power Assist System
Jun 12, 2014
Ford Motor Company (Ford) is recalling certain model year 2014 Ford F-150 trucks manufactured May 26, 2014 to June 19, 2014, and equipped with Electronic Power Assist Steering (EPAS). The affected vehicles may have an incorrectly installed EPAS gear motor position sensor magnet that can lead to a total loss of steering control while driving.
Consequence & remedy
Consequence: A loss of steering control while driving increases the risk of a vehicle crash.
Remedy: Ford will notify owners, and dealers will replace the EPAS steering gear, free of charge. The recall began in July 2014. Note: Owners are advised not to drive their vehicles until they have been remedied. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S09.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ24005 · Unintended Transmission Downshift
Opened Mar 27, 2024 · Closed Jul 29, 2024
Status: closed (inferred from source dates) · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
In September 2016, Ford Motor Company (Ford) issued safety recall 16V-248 which included certain model year (MY) 2011-2012 Ford F-150 vehicles equipped with 6-speed (6R80) automatic transmissions. This recall was in response to allegations of unintended, unexpected vehicle transmission downshifting to a lower gear without warning, often accompanied by temporary rear wheel lock-up, increasing the risk of a crash and/or injury, and included approximately 153,581 vehicles. Ford identified the root cause of the unintended, unexpected vehicle transmission downshifting to a lower gear to be intermittent signal loss from the transmission’s Output Shaft Speed (OSS) sensor due to solder joint cracks on the OSS circuit board as a result of manufacturing process issues. The OSS sensor is mounted onto the molded lead frame and transmits changes in transmission shaft speed to the Powertrain Control Module (PCM). The remedy program described in safety recall 16V-248 involved reprogramming of the PCM to prevent unintended vehicle transmission downshifting from occurring. In December 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-010) to assess the scope and remedy effectiveness of safety recall 16V-248. As a result of this ODI investigation, Ford issued safety recall 19V-075 to expand the scope of 16V-248 to include MY 2011-2013 Ford F-150 vehicles equipped with 6-speed (6R80) automatic transmissions and included approximately 1,263,051 vehicles. The remedy program described in safety recall 19V-075 involved reprogramming of the PCM to prevent unintended vehicle transmission downshifting from occurring. In June 2019, Ford issued safety recall 19V-433 as the remedy program used to service MY 2013 Ford F-150 5.0L and 6.2L vehicles in accordance with safety recall 19V-075 did not contain the necessary updates to prevent unintended vehicle transmission downshifting from occurring and included approximately 107,857 vehicles. On March 27, 2024, ODI opened this Recall Query (RQ24-005) to investigate the scope of the above-described safety recalls. At the time that this investigation was opened, ODI had received 86 Vehicle Owner Questionnaires (VOQs) reporting allegations of unintended, unexpected vehicle transmission downshifting to a lower gear without warning, often accompanied by temporary rear wheel lock-up, in MY 2014 Ford F-150 vehicles. As a result of this Recall Query, Ford filled safety recall 24V-444 on June 14, 2024, to include MY 2014 Ford F-150 vehicles and expand the scope of safety recalls 16V-248, 19V-075 and 19V-433. The remedy program described in safety recall 24V-444 involved reprogramming of the PCM to prevent unintended vehicle transmission downshifting from occurring and included approximately 552,188 vehicles. In its May 2024 response to ODI’s information request, Ford concluded that a predominant root cause for the intermittent OSS signal loss has not been identified outside of the original safety recall (16V-248). Ford’s investigation also concluded that the primary causes of the defect in MY 2014 F-150 vehicles were related to the molded lead frame and the control assembly transmission main. In the May 2024 response, Ford identified 2,184 total reports that described unintended vehicle transmission downshifting and rear wheel lock-up events; 1,441 warranty claims and 743 reports from consumer complaints, field reports, consumer surveys, and lawsuits/legal claims. Note that the values presented here and in the table above represent the total number of reports which can include a single consumer with multiple reports of the same event as well as a consumer with reports of multiple distinct events. Of the 1,441 warranty claims, 551 warranty claims involved repair of the molded lead frame (38%) and 509 warranty claims involved repair of the control assembly transmission main (35%). Ford has also stated that the PCM programming used to prevent unintended vehicle transmission downshifting was implemented starting with MY 2015 vehicle #1 production and onward. In view of the safety recall action being taken by Ford, ODI is closing this Recall Query (RQ24-005). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE16003 · Master Cylinder External Leak
Opened Feb 29, 2016 · Closed Jul 26, 2016
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Additional source detail variants (4)
Service Brakes
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Service Brakes, Hydraulic:fluid
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Service Brakes, Hydraulic
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Service Brakes, Hydraulic:foundation Components:master Cylinder
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107