← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Visibility complaints

50 reports
Clear category filter
59,000 miles · Nov 23, 2016
VisibilityVisibility/wiper

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE THE VEHICLE WAS WARMING UP IN THE MORNING, THE REAR HEATED SLIDING WINDOW EXPLODED AND SHATTERED. THE VEHICLE WAS TAKEN TO THE MANUFACTURER WHERE IT WAS DIAGNOSED THAT THE HEATING ELEMENT FAILED AND THE WINDOW NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT …

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE THE VEHICLE WAS WARMING UP IN THE MORNING, THE REAR HEATED SLIDING WINDOW EXPLODED AND SHATTERED. THE VEHICLE WAS TAKEN TO THE MANUFACTURER WHERE IT WAS DIAGNOSED THAT THE HEATING ELEMENT FAILED AND THE WINDOW NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 59,000. UPDATED 01/31/17*CT

NHTSA ODI #10927618

84,000 miles · Apr 20, 2015
Visibility

2013 FORD F-150 LARIAT SUPER CREW: APRIL 17, 2015: DRIVING SOUTH ON RT 95 TO BOSTON, MY WIFE (DRIVER) TURNED ON THE REAR WINDOW DEFROSTER TO CLEAR FOG FROM WINDOWS AND SIDE MIRRORS. THERE WAS A SUDDEN LOUD "GUN SHOT" TYPE OF NOISE THAT STARTLED US BOTH. WE LOOKED AT WINDSHIELD TO SEE IF WE HAD BEEN HIT AND FOR CRACKS; THERE WAS…

Read full complaint

2013 FORD F-150 LARIAT SUPER CREW: APRIL 17, 2015: DRIVING SOUTH ON RT 95 TO BOSTON, MY WIFE (DRIVER) TURNED ON THE REAR WINDOW DEFROSTER TO CLEAR FOG FROM WINDOWS AND SIDE MIRRORS. THERE WAS A SUDDEN LOUD "GUN SHOT" TYPE OF NOISE THAT STARTLED US BOTH. WE LOOKED AT WINDSHIELD TO SEE IF WE HAD BEEN HIT AND FOR CRACKS; THERE WAS NOTHING. ONCE STOPPED AND LOOKING OVER THE TRUCK WE DISCOVERED THAT THE REAR WINDOW/BACK LITE ON DRIVER'S SIDE HAD SHATTERED. I RAN MY HAND OVER THE ENTIRE WINDOW SEARCHING FOR AN IMPACT POINT, OR MARK AND THERE WAS ABSOLUTELY NOTHING. WE BOTH WONDERED ALOUD AS TO HOW THIS WINDOW JUST SHATTERED ON ITS OWN. ONCE HOME, I WENT ON THE INTERNET TO LOOK UP POSSIBLE CAUSES AND DISCOVERED THAT THERE ARE MANY, MANY CASES OF THE EXACT SAME THING HAPPENING TO FORD PICKUPS. I CALLED FORD CUSTOMERS SERVICE TODAY AND SPOKE AT LENGTH WITH "ANGELA" WHO SEEMED TO UNDERSTAND THE SAFETY ISSUE OF WINDOWS SHATTERING WHILE DRIVING BUT AFTER PUTTING ME ON HOLD TO CHECK WITH SOMEONE, SAID THAT THERE IS NOTHING FORD CAN DO UNTIL A RECALL IS ISSUED, IF EVER. I TOLD HER THAT THERE IS NEARLY 60 COMPLAINTS ON THIS ISSUE ON THE NHTSA SITE, ALONG WITH SCORES OF OTHERS IN FORD FORUMS, ETC. THIS NUMBER APPARENTLY IS NOT ENOUGH OF A SAFETY ISSUE FOR FORD TO RESPOND, BUT COMMON SENSE DICTATES THAT ITS ONLY A MATTER OF TIME UNTIL SOMETHING VERY SERIOUS OCCURS FROM FORD F-150 WINDOWS SHATTERING WHILE DRIVING IN TRAFFIC. THIS IS A SERIOUS ISSUE! *TR

NHTSA ODI #10706720

3,000 miles · Apr 19, 2015
Visibility

THE VEHICLE HEATER KICKS OUT OF RECIRCULATION MODE AFTER 5 OR 10 MINUTES. THIS OFTEN BRINGS OUTSIDE AUTO FUMES INTO THE VEHICLE. IN ORDER TO STOP THE FUMES AND USE RECIRC AGAIN YOU HAVE TO PUSH THAT BUTTON, TAKING YOUR EYES OFF THE ROAD. THE DEALER SAYS TO USE 'MAX AIR' BUT THAT RESULTS IN HOT AIR BLOWING IN YOUR FACE. BOTH SITU…

Read full complaint

THE VEHICLE HEATER KICKS OUT OF RECIRCULATION MODE AFTER 5 OR 10 MINUTES. THIS OFTEN BRINGS OUTSIDE AUTO FUMES INTO THE VEHICLE. IN ORDER TO STOP THE FUMES AND USE RECIRC AGAIN YOU HAVE TO PUSH THAT BUTTON, TAKING YOUR EYES OFF THE ROAD. THE DEALER SAYS TO USE 'MAX AIR' BUT THAT RESULTS IN HOT AIR BLOWING IN YOUR FACE. BOTH SITUATIONS REQUIRE DISTRACTED DRIVING, A SAFETY RISK. I WOULD LIKE FOR THE RECIRC MODE TO REMAIN AS LONG AS I WANT. *TR

NHTSA ODI #10706523

36,809 miles · Apr 1, 2015
Visibility

DURING THE START UP OF MY 2013 FORD F-150 KING RANCH, I PROCEEDED TO UTILIZE THE REAR DEFROSTER TO GET THE ICE OFF THE REAR WINDOW. THE REAR WINDOW IS COMPRISED OF 3 PANELS OF GLASS, ONE ON EACH SIDE AND THE SLIDING WINDOW IN THE CENTER. THE PANEL BEHIND THE DRIVERS SIDE THEN PROCEEDED TO CRACK AND SPIDER ACROSS THE ENTIRE WINDO…

Read full complaint

DURING THE START UP OF MY 2013 FORD F-150 KING RANCH, I PROCEEDED TO UTILIZE THE REAR DEFROSTER TO GET THE ICE OFF THE REAR WINDOW. THE REAR WINDOW IS COMPRISED OF 3 PANELS OF GLASS, ONE ON EACH SIDE AND THE SLIDING WINDOW IN THE CENTER. THE PANEL BEHIND THE DRIVERS SIDE THEN PROCEEDED TO CRACK AND SPIDER ACROSS THE ENTIRE WINDOW. THE INITIAL SOUND LED ME TO BELIEVE IT WAS ANOTHER ISSUE AS IT WAS A LOUD BANG, BUT I THEN LOOKED IN MY REAR VIEW AND NOTICED THE CRACKED GLASS. IT RENDERS THE ENTIRE WINDOW USELESS AND A SAFETY HAZARD AS IT DISTORTS AND SKEWS MY VISION AND ABILITY TO SEE OUT OF IT SAFELY UNTIL I CAN ATTEMPT TO HAVE FORD RECTIFY THIS ISSUE. AFTER LOOKING ONLINE, IT APPEARS AS IF THIS IS A COMMON ISSUE, THAT REALLY SHOULD NOT HAPPEN TO BEGIN WITH. *TR

NHTSA ODI #10703226

14,320 miles · Mar 6, 2015
Visibility

REAR GLASS HAS SHATTERED ON DRIVER SIDE PANEL OUT OF THREE PANELS. THIS PROBLEM OCCURS W/ REAR GLASS THAT HAS DEFROST & SLIDER. I HAVE SPENT SOME TIME RESEARCHING THIS ISSUE & FOMOCO REFUSES TO SEE THAT THIS ISSUE DOES OR COULD EXIST. DUE TO THE FAST TEMPERATURE INCREASE FROM COLD CLIMATE CUSTOMERS USING POWER DEFROST THE DRI…

Read full complaint

REAR GLASS HAS SHATTERED ON DRIVER SIDE PANEL OUT OF THREE PANELS. THIS PROBLEM OCCURS W/ REAR GLASS THAT HAS DEFROST & SLIDER. I HAVE SPENT SOME TIME RESEARCHING THIS ISSUE & FOMOCO REFUSES TO SEE THAT THIS ISSUE DOES OR COULD EXIST. DUE TO THE FAST TEMPERATURE INCREASE FROM COLD CLIMATE CUSTOMERS USING POWER DEFROST THE DRIVER SIDE REAR GLASS PANEL CAN OR MAY SHATTER. I ENCOUNTERED THIS ISSUE YESTERDAY WHEN I CALLED SERVICE I WAS PROMPTLY TOLD THAT THIS ISSUE IS A NON-ISSUE AND IT MUST HAD BEEN VANDALISM. ALTHOUGH BEING A PROFESSION ASE ACCREDITED TECHNICIAN KNEW BETTER AFTER A LITTLE RESEARCH, ALSO THE PARTS DEPARTMENT HAVING A CURRENT ROTATING STOCK OF THESE WINDOWS ON THE SHELF SPELLED OUT THAT A ISSUE IS KNOW OF. I CHECKED ALL RECALL & TECHNICAL SERVICE BULLETINS PERTAINING TO A ISSUE LIKE THIS WITH LITTLE TO NO INFORMATION. IN MY INTERNET RESEARCH IT HAS BECAME VERY CLEAR THERE IS AN ISSUE WITH THIS SEEING HOW PEOPLE HAVE POSTED YOUTUBE VIDEOS SHOWING HOW TO REPLACE THE GLASS & GENERAL FORUM CHATTER. NO ONE GOT HURT THIS TIME BUT WHEN "SAFETY" GLASS SHATTERS IS CREATES HUNDREDS/THOUSANDS OF TINY SHARP DEBRIS. IF MY DAUGHTER WOULD HAVE BEEN IN THE VEHICLE WHEN THIS OCCURRED & WAS TOLD THIS ISN'T A "ISSUE" I PROBABLY WOULD HAVE TOLD THE SERVICE WRITER TO COME RUB HIS ARMS ACROSS THE BACK SEAT OF MY VEHICLE AND TELL ME "NO ISSUE EXISTS". *TR

NHTSA ODI #10692400

11,000 miles · Mar 5, 2015
Visibility

REMOTE STARTED TRUCK GOT IN 15 MINUTES LATER AND CLOSE THE DOOR AND THEN HEARD A LOUD BANG I LOOKED BACK THE REAR PANEL WINDOW THE DRIVERS SIDE SHATTERED AND SOMETHING SMELLED LIKE IT WAS BURNING THE WHOLE PANEL CRACKED INTO HUNDREDS OF LITTLE CRACKS, IT WAS 7 DEGREES OUTSIDE AT THE TIME. *TR

NHTSA ODI #10692215

33,000 miles · Mar 4, 2015
Visibility

WE HAVE A 2013 FORD F150. OUR BACK PASSENGER SLIDING GLASS WINDOW SUDDENLY SHATTERED ONE DAY. NO CRASH, ACCIDENT, NOTHING HIT THE VEHICLE OR THE GLASS. OUR TRUCK WAS PARKED WHEN IT HAPPENED. FEW DAYS PRIOR TO THIS I NOTICED THE REAR DEFROST WAS NOT WORKING PROPERLY. AFTER THIS INCIDENT I STARTED RESEARCHING ON-LINE TO SEE IF THE…

Read full complaint

WE HAVE A 2013 FORD F150. OUR BACK PASSENGER SLIDING GLASS WINDOW SUDDENLY SHATTERED ONE DAY. NO CRASH, ACCIDENT, NOTHING HIT THE VEHICLE OR THE GLASS. OUR TRUCK WAS PARKED WHEN IT HAPPENED. FEW DAYS PRIOR TO THIS I NOTICED THE REAR DEFROST WAS NOT WORKING PROPERLY. AFTER THIS INCIDENT I STARTED RESEARCHING ON-LINE TO SEE IF THERE WERE ANY RECALLS WE WERE NOT AWARE OF. I CAME ACROSS A WEBSITE THAT HAD MULTIPLE COMPLAINTS OF THE SAME EXACT PROBLEM! SAME WINDOW AND SAME INSTANCES ALMOST TO A TEE. LUCKILY WE WERE NOT DRIVING THE VEHICLE AT THE TIME NOR WAS MY DAUGHTER IN THE VEHICLE. WHEN I CALLED THE DEALERSHIP TO HAVE IT LOOKED AT THEY TOLD ME THEY HAVE SEEN A FEW OF THESE. WHEN I CALLED AN AUTO GLASS STORE THE EMPLOYEE TOLD ME HE HAS SEEN 15 WINDOWS EXACTLY LIKE OURS THIS YEAR AND RECENTLY WAS TOLD THE BACK GLASS FOR THESE VEHICLES WERE ON BACK ORDER. SO THAT WAS EVIDENCE TO ME THAT THIS IS A COMMON PROBLEM. ORIGINALLY FORD WAS DENYING THAT THE SHATTERED WINDOW WAS DEFECT. AFTER MULTIPLE PHONE CALLS AND COMPLAINTS TO FORD MOTOR COMPANY OUR VEHICLE IS NOW FIXED UNDER OUR WARRANTY. ACCORDING TO THE DEALERSHIP AND THE AUTO GLASS COMPANY THAT HAVE SEEN MULTIPLE VEHICLES LIKE OURS, NOT ALL OF THEM WERE COVERED UNDER THE WARRANTY. THIS SHOULD BE INVESTIGATED AND FORD NEEDS TO FIX THE PROBLEM BEFORE THE GLASS SHATTERS WITH SOMEONE IN THE BACKSEAT ESPECIALLY IF ITS A CHILD SITTING BACK THERE!!! *TR

NHTSA ODI #10692171

38,000 miles · Mar 3, 2015
Visibility

THE VEHICLE WAS PARKED IN THE DRIVEWAY AND WARMING UP. AFTER A FEW MINUTES THE REAR DRIVER SIDE WINDOW SHATTERED. *TR

NHTSA ODI #10691754

23,200 miles · Feb 24, 2015
Visibility

REMOTE STARTED VEHICLE OUTSIDE ON 0 DEGREE EVENING. ENTERED TRUCK AFTER ABOUT THE MINUTES, PUT KEY IN IGNITION, AND TURNED KEY TO ON POSITION. WHILE I WAS PREPARING TO DRIVE I HEARD LOUD POP IN THE BACK SEAT AREA OF VEHICLE. I IMMEDIATELY NOTICED THAT THE PASSENGER SIDE WINDOW PANE, IN THE THE PIECE REAR WINDOW, WAS SHATTERED. …

Read full complaint

REMOTE STARTED VEHICLE OUTSIDE ON 0 DEGREE EVENING. ENTERED TRUCK AFTER ABOUT THE MINUTES, PUT KEY IN IGNITION, AND TURNED KEY TO ON POSITION. WHILE I WAS PREPARING TO DRIVE I HEARD LOUD POP IN THE BACK SEAT AREA OF VEHICLE. I IMMEDIATELY NOTICED THAT THE PASSENGER SIDE WINDOW PANE, IN THE THE PIECE REAR WINDOW, WAS SHATTERED. *JS

NHTSA ODI #10690188

29,000 miles · Feb 11, 2015
Visibility

BACK (REAR WINDOW) STATIONARY GLASS EXPLODED WHILE DRIVING DOWN THE ROAD! FIRST, I HAD EXPERIENCED INTERMITTENT PROBLEMS WITH THE REAR DEFROST NOT FUNCTIONING THE LAST COUPLE MONTHS. THEN, THE DEFROST JUST STARTED WORKING AGAIN WITHOUT ISSUE A MONTH AGO? LAST NIGHT THE TEMPERATURE WAS ABOUT 20F. I TURNED THE REAR DEFROST ON A…

Read full complaint

BACK (REAR WINDOW) STATIONARY GLASS EXPLODED WHILE DRIVING DOWN THE ROAD! FIRST, I HAD EXPERIENCED INTERMITTENT PROBLEMS WITH THE REAR DEFROST NOT FUNCTIONING THE LAST COUPLE MONTHS. THEN, THE DEFROST JUST STARTED WORKING AGAIN WITHOUT ISSUE A MONTH AGO? LAST NIGHT THE TEMPERATURE WAS ABOUT 20F. I TURNED THE REAR DEFROST ON AND WITHIN 5 MINUTES OF DRIVING I HEARD GUNSHOT/LARGE BANG AND NOTICED MY DRIVER?S SIDE STATIONARY PANE ON THE REAR SLIDER WAS SHATTERED. I HAVE SMALL KIDS AND THANKFULLY THEY WERE NOT IN THE TRUCK AT THE TIME. SMALL SHARDS OF GLASS ENDED UP IN THE TRUCK. I CALLED DEALER AND HAVE TO BRING IN FOR THEM TO TAKE ?PICTURES? TO SEND TO FORD. THIS IS A DANGER AND SEEMS WELL DOCUMENTED ON THE INTERNET FOR 2010 MODELS UP. *TR

NHTSA ODI #10682790

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of