← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Vehicle Speed Control complaints

301 reports
Clear category filter
123,000 miles · Feb 4, 2019
EnginePower TrainVehicle Speed Control

TODAY WHILE DRIVING 70MPH MY TRUCK SHIFTED TO 1ST GEAR CAUSING THE TRUCK TO LOCK THE REAR TIRES, SWERVE FROM LEFT TO RIGHT, RPM'S TO THE MAX REV LIMIT, LOSS OF POWER, DASH CLUSTER WENT BLANK, WRENCH SYMBOL SHOWED UP, THEN WRENCH SYMBOL WAS GONE WITH A BLANK DASH CLUSTER. TRUCK THEN JUMPED TO 3RD GEAR, BACK TO 1ST, THEN BACK UP T…

Read full complaint

TODAY WHILE DRIVING 70MPH MY TRUCK SHIFTED TO 1ST GEAR CAUSING THE TRUCK TO LOCK THE REAR TIRES, SWERVE FROM LEFT TO RIGHT, RPM'S TO THE MAX REV LIMIT, LOSS OF POWER, DASH CLUSTER WENT BLANK, WRENCH SYMBOL SHOWED UP, THEN WRENCH SYMBOL WAS GONE WITH A BLANK DASH CLUSTER. TRUCK THEN JUMPED TO 3RD GEAR, BACK TO 1ST, THEN BACK UP TO 5TH GEAR. PULLED OVER TURNED OF TRUCK, TOOK OUT KEY, RE-STARTED TRUCK AND ISSUE WAS GONE. THIS HAS HAPPENED MULTIPLE TIMES, HOWEVER, I WAS AT 10-20MPH. ONCE AT 55MPH SHIFT TO 3RD GEAR, BACK TO 5TH, THEN TO 1ST, UP TO 3RD. EVERY TIME THE TRUCK WILL END UP AT 3RD GEAR. THE TRUCK WILL NOT SHIFT DOWN TO FIRST MANUALLY, YOU MUST TAKE OF IN 3RD GEAR WITHOUT ANY POWER. THERE WAS A RECALL FOR 2011-2012 FORD F150'S. THERE ARE MULTIPLE COMPLAINTS ALL OVER THE INTERNET WITH THESE SAME PROBLEMS ALL WITH YEARS RANGING FROM 2011-2017. O FEEL THIS IS AN ONGOING PROBLEM WITH A HUGE SAFETY CONCERN WITB YOUR VEHICLE GOING FROM 70MPH DOWN TO FIRST GEAR CAUSING THE WHEELS TO LOCK UP AND SWERVE ALL OVER THE HIGHWAY. DO PEOPLE HAVE TO DIE BEFORE FORD WILL RECOGNIZE THIS IS A PROBLEM WITH MANY YEARS OF THE MODEL!!!!! I'M HAPPY MY FAMILY WAS NOT IN THE TRUCK WHEN THIS HAPPENS. I CAR POOL KIDS EVERYDAY ON THE HIGHWAY. WOULD YOU FEEL SAFE DOING THIS KNOWING THAT FORD KNOWS ABOUT THIS ISSUE FROM PAST YEARS. PLEASE MAKE THESE TRUCKS SAFE!!! I TOOK IT TO A FORD DEALER AND THEY HOOKED UP THE COMPUTER TO MY TRUCK, AND THE COMPUTER SHOWED 0 CODES FOUND. EVERY TIME THIS HAPPENS YOU TURN OFF THE VEHICLE, RE-START IT (SOMETIMES YOU HAVE TO DO IT MULTIPLE TIMES) THE TRUCK WILL DRIVE PERFECT UNTIL IT DECIDES TO ACT UP AGAIN.

NHTSA ODI #11174383

100,000 miles · Jan 23, 2019
Electrical SystemVehicle Speed Control

AROUND 100K MILES. TRUCK ALL OF A SUDDEN STARTED TO HARD SHIFT. EVENTUALLY WOULD THROW ORANGE WRENCH LIGHT AND SPEEDOMETER WOULD QUIT WORKING AND WOULD HAVE TROUBLE GETTING THE SPEED UP AS IF IT WERENT SHIFTING. AIR BAG LIGHT WILL COME AND STAY ON. A REBOOT WOULD TAKE THESE PROBLEMS AWAY TEMPORARILY. I'VE READ SAME OWNERS HAVE E…

Read full complaint

AROUND 100K MILES. TRUCK ALL OF A SUDDEN STARTED TO HARD SHIFT. EVENTUALLY WOULD THROW ORANGE WRENCH LIGHT AND SPEEDOMETER WOULD QUIT WORKING AND WOULD HAVE TROUBLE GETTING THE SPEED UP AS IF IT WERENT SHIFTING. AIR BAG LIGHT WILL COME AND STAY ON. A REBOOT WOULD TAKE THESE PROBLEMS AWAY TEMPORARILY. I'VE READ SAME OWNERS HAVE EXPERIENCED SAME ISSUES ONLINE ON THE F150 FORUM.

NHTSA ODI #11171632

72,450 miles · Jan 23, 2019
Power TrainVehicle Speed Control

THE FRIGHTENING ISSUE I EXPERIENCED ON JANUARY 7, 2019 IS IDENTICAL TO THE REPORTS I HAVE SINCE READ REGARDING THIS VEHICLE AND THE FREQUENT ISSUES THAT LED TO THE RECALL FOR 2010-2012 FORD F-150'S FOR UNEXPECTED TRANSMISSION DOWNSHIFTS [NHTSA RECALL NO. / MFR RECALL NO. : 16V-248 / 16S19]. WHILE DRIVING 65-70 MPH ON THE INTE…

Read full complaint

THE FRIGHTENING ISSUE I EXPERIENCED ON JANUARY 7, 2019 IS IDENTICAL TO THE REPORTS I HAVE SINCE READ REGARDING THIS VEHICLE AND THE FREQUENT ISSUES THAT LED TO THE RECALL FOR 2010-2012 FORD F-150'S FOR UNEXPECTED TRANSMISSION DOWNSHIFTS [NHTSA RECALL NO. / MFR RECALL NO. : 16V-248 / 16S19]. WHILE DRIVING 65-70 MPH ON THE INTERSTATE, SPEEDOMETER SUDDENLY AND RAPIDLY FLUCTUATED BETWEEN 40 AND 70, THEN TRANSMISSION ABRUPTLY DROPPED FROM 6TH/5TH GEAR TO 1ST GEAR. AS A RESULT, MY WHEELS LOCKED AND CAUSED THE VEHICLE TO SKID INTO THE LANE TO MY RIGHT, FORCING OTHER CARS TO SWERVE OUT OF MY WAY TO AVOID A HIGH SPEED COLLISION. IT HAPPENED SO FAST, AND WITHOUT WARNING, THAT IT WAS DIFFICULT TO UNDERSTAND WHAT WAS ACTUALLY OCCURRING. ONCE STOPPED (IN THE MIDDLE OF THE INTERSTATE), I DROVE TO THE MEDIAN, TURNED THE ENGINE OFF, SAT FOR A FEW MINUTES TO GATHER MY THOUGHTS, RESTARTED THE VEHICLE AND DROVE IT SLOWLY TO MY FORD DEALERSHIP (NOT ON THE HIGHWAY). AFTER INSPECTING MY TRUCK, THE FORD DEALERSHIP VERIFIED THE ISSUE AND STATED THE FOLLOWING (WRITTEN REPORT ATTACHED): RAN KOEC GOT CODE P0720 OSS SENSOR CIRCUIT FAULT, RAN PINPOINT TESTS, FOUND OPEN IN OSS SENSOR WHICH IS PART OF THE MOLDED LEAD FRAME ATTACHED TO THE VALVE BODY, REMOVED THE VALVE BODY, DISSASEMBLED, CLEANED AND INSPECTED THE VALUE BODY, ALL VALVES AND BORES ARE OK, REASSEMBLED VALVE BODY WITH NEW MOLDED LEAD FRAME ASSEMBLY AND NEW REVISED SEPARATOR PLATE GASKET, INSTALLED NEW CLUTCH FEED TUBE SEALS AND SEAL BETWEEN VALVE BODY AND FLUID PUMP, INSTALLED NEW FLUID FILTER AND PAN GASKET, FILLED TRANSMISSION WITH NEW FLUID REPROGRAMMED PCM AND CLEARED DTCS, VERIFIED REPAIRS. DESPITE PARALLELS TO THE PREVIOUS RECALL ISSUE, FORD INFORMED ME IT IS NOT COVERED (THERE IS NOTHING I COULD HAVE DONE TO PREVENT IT) AND THE TOTAL COST TO ME WAS $1,418.83. PLEASE EXPAND THE RECALL - IT WILL SAVE LIVES.

NHTSA ODI #11171588

99,675 miles · Dec 28, 2018
Electrical SystemPower TrainVehicle Speed Control

WHILE DRIVING THE VEHICLE IT WILL DOWNSHIFT FROM HIGHER GEARS AND THEN NO LONGER SHIFTS OR REGISTERS SPEED - WRENCH LIGHT WILL ILLUMINATE ON DASH. THE SPEEDOMETER WILL ALSO DROP DOWN TO ZERO AND NO LONGER REGISTER ANY SPEED EVEN THOUGH THE TRUCK IS MOVING. THE DIGITAL DISPLAY WILL DISPLAY DASHES AND THE AIR BAG LIGHT INDICATOR …

Read full complaint

WHILE DRIVING THE VEHICLE IT WILL DOWNSHIFT FROM HIGHER GEARS AND THEN NO LONGER SHIFTS OR REGISTERS SPEED - WRENCH LIGHT WILL ILLUMINATE ON DASH. THE SPEEDOMETER WILL ALSO DROP DOWN TO ZERO AND NO LONGER REGISTER ANY SPEED EVEN THOUGH THE TRUCK IS MOVING. THE DIGITAL DISPLAY WILL DISPLAY DASHES AND THE AIR BAG LIGHT INDICATOR WILL STAY LITE. WHEN YOU UNBUCKLE THE SEAT BELT THE INDICATOR LIGHT WILL NOT ILLUMINATE. TOOK IT IN TO HAVE BATTERY TESTED AND HAD 100% CHARGE BUT READING INDICATED A BAD BATTERY SO HAD IT REPLACED BUT ISSUE STILL PRESENTED ITSELF AN HOUR LATER. ISSUE OCCURS INTERMITTENTLY AND WITHOUT WARNING. TOOK IT TO MECHANIC AND THEY HAD IT FOR TWO DAYS AND UNABLE TO REPLICATE SITUATION. ALSO TOOK IT TO DEALER AND WAS TOLD THEY COULDN'T DO ANYTHING IF THE ISSUE NEVER PRESENTED ITSELF WHILE THEY HAD THE TRUCK. ASKED IF ISSUE WAS EVER PRESENTED AT THAT FACILITY OR ANY KNOWN ISSUES AND WAS TOLD NO. ISSUE HAS OCCURRED ON FOUR SEPARATE OCCASIONS OVER THE LAST 20 DAYS.

NHTSA ODI #11163770

71,000 miles · Dec 18, 2018
Power TrainVehicle Speed Control

MY 2013 FORD F-150 XLT WITH 71,000 MILES IS HAVING TRANSMISSION ISSUES AND PROBLEMS WITH SHIFTING AND COMPLETELY LOSING POWER WHILE DRIVING. THIS ISSUE HAS STARTED INTERMITTANTLY ABOUT A MONTH AGO. WHILE I'M DRIVING, A GIANT WRENCH APPEARS ON THE DASHBOARD WHICH IS THEN FOLLOWED BY LOSS OF POWER AND ACCELERATION. THE VEHICLE IS …

Read full complaint

MY 2013 FORD F-150 XLT WITH 71,000 MILES IS HAVING TRANSMISSION ISSUES AND PROBLEMS WITH SHIFTING AND COMPLETELY LOSING POWER WHILE DRIVING. THIS ISSUE HAS STARTED INTERMITTANTLY ABOUT A MONTH AGO. WHILE I'M DRIVING, A GIANT WRENCH APPEARS ON THE DASHBOARD WHICH IS THEN FOLLOWED BY LOSS OF POWER AND ACCELERATION. THE VEHICLE IS THEN STUCK INTO A SINGLE GEAR AND THE SPEEDOMETER AND MILEAGE COMPUTER GO BLANK SO I NO LONGER KNOW HOW FAST I'M TRAVELLING. MY VEHICLE ISSUE SEEMS VERY SIMILAR TO THE 2011-2012 FORD F-150 TRANSMISSION DOWNSHIFTING RECALL FROM BELOW. 'FEDERAL SAFETY REGULATORS ARE INVESTIGATING WHETHER TO REOPEN AND EXPAND A PREVIOUS FORD RECALL BY MORE THAN A MILLION VEHICLES FOR UNEXPECTED DOWNSHIFTING. THE INITIAL 2016 RECALL AFFECTED MORE THAN 153,000 FORD F-150, FORD EXPEDITION, LINCOLN NAVIGATOR AND FORD MUSTANG VEHICLES FROM THE 2011-12 MODEL YEARS. A SECOND RECALL WOULD INCREASE THAT NUMBER TO AN ESTIMATED 1,375,577 VEHICLES AFFECTED, AND EXPAND INTO THE 2013 MODEL YEAR."

NHTSA ODI #11162336

103,000 miles · Dec 18, 2018
Power TrainVehicle Speed Control

PUT THE FORD F150 INTO GEAR, WOULD NOT SHIFT UP FROM 1ST GEAR. SAME ISSUE WE HAVE BEEN HAVING AND HAVE TAKEN TO THE DEALERSHIP AND THEY CANNOT FIND ANY PROBLEMS WITH THE TRANSMISSION. HAD TO TURN OFF TRUCK AND RESTART

NHTSA ODI #11162228

60,000 miles · Dec 14, 2018
Power TrainVehicle Speed Control

MY 2013 FORD F-150 ECOBOOST GETS STUCK IN 1ST GEAR SOMETIMES WHILE TRYING TO MOVE FROM A STOP. IT HAS ALSO SKIPPED 1ST AND 2ND GEAR AND GOTTEN STUCK IN 3RD GEAR AND BARELY ABLE TO MOVE MORE THAN 5 MPH. IT HAS HAPPENED FROM A DEAD STOP AS WELL AS WHILE DRIVING 40 PLUS MILES PER HOUR. TYPICALLY PULLING OVER AND TURNING THE TRUCK …

Read full complaint

MY 2013 FORD F-150 ECOBOOST GETS STUCK IN 1ST GEAR SOMETIMES WHILE TRYING TO MOVE FROM A STOP. IT HAS ALSO SKIPPED 1ST AND 2ND GEAR AND GOTTEN STUCK IN 3RD GEAR AND BARELY ABLE TO MOVE MORE THAN 5 MPH. IT HAS HAPPENED FROM A DEAD STOP AS WELL AS WHILE DRIVING 40 PLUS MILES PER HOUR. TYPICALLY PULLING OVER AND TURNING THE TRUCK OFF AND BACK ON FIXES IT. I AM AFRAID IT WILL HAPPEN AGAIN AND CAUSE AN ACCIDENT.

NHTSA ODI #11161314

89,900 miles · Dec 14, 2018
Electrical SystemPower TrainVehicle Speed Control

TRUCK SUDDENLY DROPS FROM 6TH GEAR TO 1 ST GEAR AND BARKS THE REAR TIRES WHILE TRAVELING AT 60MPH ALSO THE INSTRUMENT PANEL GOES COMPLETELY OUT EXCEPT FOR THE RPM GAUGE IT ALSO DOWN SHIFTS FROM 6TH TO 5TH AND THEN WILL NOT UPSHIFT AND ONLY DOWN SHIFTS TO 3RD GEAR ALSO IT HAS STUCK IN 1ST GEAR WHEN TAKING IFF FROM A RED LIGHT. IT…

Read full complaint

TRUCK SUDDENLY DROPS FROM 6TH GEAR TO 1 ST GEAR AND BARKS THE REAR TIRES WHILE TRAVELING AT 60MPH ALSO THE INSTRUMENT PANEL GOES COMPLETELY OUT EXCEPT FOR THE RPM GAUGE IT ALSO DOWN SHIFTS FROM 6TH TO 5TH AND THEN WILL NOT UPSHIFT AND ONLY DOWN SHIFTS TO 3RD GEAR ALSO IT HAS STUCK IN 1ST GEAR WHEN TAKING IFF FROM A RED LIGHT. IT HAS DONE EVERYTHING WHILE TRAVELING DOWN THE HIGHWAY EXCEPT FOR THE 1ST GEAR ISSUE THAT HAPPENED FROM A STOPED POSITION WHEN I STARTED TO TAKE OFF. PROBLEM DOES HAPPEN ALL THE TIME AND WHEN YOU PULL OVER AND PLACE THE VEHICLE IN PARK AND TURN THE ENGINE OFF AND RESTART THE ENGINE THE PROBLEM GOES AWAY AND THEN IT STARTS IT AGAIN TOOK THE TRUCK TO LOCAL DEALERSHIP AND WAS TOLD IT WOULD COST 985.00 TO FIX THIS PROBLEM WHEN IT IS THE SAME PROBLEM THAT WAS RECALLED ON THE PREVIOUS YEARS TRUCK SAME PROBLEM ON THE 2011 AND 2012 ALSO HAVE READ THE PROBLEM IS STILL ACCOURING ON THE 2014 MODELS AS WELL

NHTSA ODI #11161293

80,000 miles · Oct 30, 2018
Power TrainVehicle Speed ControlWheels

DRIVING DOWN INTERSTATE AND TRUCK SUDDENLY SHIFTED TO 3RD GEAR LOCKING UP MY TIRES. THANK GOD I DIDN'T LOSE CONTROL AND DROVE OFF THE ROAD TO A STOP. TURNED OFF TRUCK AND BACK ON. DROVE OK FOR A BIT. WILL KEEP DROPPING GEARS OR RANDOMLY SHIFTING UP AND DOWN. FROM A START IT COULD SOMETIME TRY TO GO INTO 5TH. AT TIMES ALL THE DAS…

Read full complaint

DRIVING DOWN INTERSTATE AND TRUCK SUDDENLY SHIFTED TO 3RD GEAR LOCKING UP MY TIRES. THANK GOD I DIDN'T LOSE CONTROL AND DROVE OFF THE ROAD TO A STOP. TURNED OFF TRUCK AND BACK ON. DROVE OK FOR A BIT. WILL KEEP DROPPING GEARS OR RANDOMLY SHIFTING UP AND DOWN. FROM A START IT COULD SOMETIME TRY TO GO INTO 5TH. AT TIMES ALL THE DASH INDICATORS FLASH AND GO TO DASHES.

NHTSA ODI #11143972

101,000 miles · Oct 25, 2018
Power TrainVehicle Speed Control

WE TOOK OUR FORD F150 IN FOR ERRATIC DOWNSHIFTING, WERE ABLE TO PROVIDE PHOTOGRAPHIC EVIDENCE OF THE PROBLEM, BUT BECAUSE NO ERROR CODES ARE POPPING UP AND THEY CAN'T REPLICATE THE PROBLEM THEY ARE RETURNING OUT VEHICLE TO US. MY ISSUE IS FORD KNOWS THIS IS AN ISSUE AND KNOWS THE FIX IS TO UPDATE THE SOFTWARE THEN LOOK FOR ERROR…

Read full complaint

WE TOOK OUR FORD F150 IN FOR ERRATIC DOWNSHIFTING, WERE ABLE TO PROVIDE PHOTOGRAPHIC EVIDENCE OF THE PROBLEM, BUT BECAUSE NO ERROR CODES ARE POPPING UP AND THEY CAN'T REPLICATE THE PROBLEM THEY ARE RETURNING OUT VEHICLE TO US. MY ISSUE IS FORD KNOWS THIS IS AN ISSUE AND KNOWS THE FIX IS TO UPDATE THE SOFTWARE THEN LOOK FOR ERROR CODES, BUT THEY ARE ACTING AS THEY HAVE NO IDEA THIS IS A KNOWN PROBLEM AMONGST THE 2011-2013 MODELS AND THEY ARE SENDING THE UNFIXED CAR BACK HOME TO BE A SAFETY HAZARD NOT ONLY TO MY FAMILY BUT THE FAMILIES ON THE ROAD AROUND US.

NHTSA ODI #11142590

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of