IllustrationCar starts off in 3rd gear.
2013 Ford F-150
Owner reports · Recalls · Investigations
More warning signs than most F-150 years
Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-150 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
3300–25K
32125–50K
46250–75K
39775–100K
454100–150K
251150K+
2,215 reports with mileage · 765 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
77 crash reports35 fire reports53 injury reports
Power Train complaints
1,335 reportsThe contact owns a 2013 Ford F-150. The contact stated that while driving approximately 70–75 MPH, the vehicle downshifted from sixth gear to third gear. The contact stated that the transmission had gone into Safe Mode. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed th…
Read full complaint
The contact owns a 2013 Ford F-150. The contact stated that while driving approximately 70–75 MPH, the vehicle downshifted from sixth gear to third gear. The contact stated that the transmission had gone into Safe Mode. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the transmission lead frame needed to be replaced. The vehicle was not repaired. The contact stated that the failure was related to NHTSA Campaign Number: 19V433000 (Power Train) however, the VIN was not included. The manufacturer was contacted and provided a case number. The failure mileage was approximately 120,000.
The contact owns a 2013 Ford F-150. The contact stated that the battery warning light remained illuminated after starting the vehicle. Later, while driving up an incline at approximately 55 MPH, the transmission erroneously downshifted, causing the speed to be reduced. The vehicle was driven to the shoulder and after turning off…
Read full complaint
The contact owns a 2013 Ford F-150. The contact stated that the battery warning light remained illuminated after starting the vehicle. Later, while driving up an incline at approximately 55 MPH, the transmission erroneously downshifted, causing the speed to be reduced. The vehicle was driven to the shoulder and after turning off and restarting the vehicle the failure self-corrected and the vehicle operated normally. The cause of the failure was not yet determined. The manufacturer was not notified of the failure. The contact was informed that the VIN was not included in NHTSA Campaign Number: 19V433000 (Power Train). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 45,000.
The contact owns a 2013 Ford F-150. The contact received notification of NHTSA Campaign Number: 19V075000 (Power Train) and the vehicle was taken to the dealer. The dealer informed the contact that the repair could not be completed unless the vehicle was experiencing failure. The contact stated while driving 45-50 MPH, the trans…
Read full complaint
The contact owns a 2013 Ford F-150. The contact received notification of NHTSA Campaign Number: 19V075000 (Power Train) and the vehicle was taken to the dealer. The dealer informed the contact that the repair could not be completed unless the vehicle was experiencing failure. The contact stated while driving 45-50 MPH, the transmission downshifted unexpectedly, and the rear wheels locked up, causing the vehicle to slide and stop. The power train warning light and the check engine warning light were illuminated. The contact stated that he turned off and restarted the vehicle, and the vehicle operated as needed. The contact stated that he turned on the hazard lights and drove back to the residence at a slower speed. The vehicle was later taken to the dealer, where it was determined that the failure was related to the recall. The dealer informed the contact that the campaign had expired. The vehicle was not repaired. Additionally, the contact related the failure to NHTSA Campaign Number: 19V075000 (Power Train); however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 122,000.
Component or system failure or malfunction: Delayed or no gear shifting. Transmission sudden downshift at low and high speeds, and failure to shift into lower or higher gear at takeoff, and/or while in motion. Safety risk: Sudden downshift at high speed caused stability and control issue at highway speed. The problem h…
Read full complaint
Component or system failure or malfunction: Delayed or no gear shifting. Transmission sudden downshift at low and high speeds, and failure to shift into lower or higher gear at takeoff, and/or while in motion. Safety risk: Sudden downshift at high speed caused stability and control issue at highway speed. The problem has been reproduced by owner and discussed with dealer by phone. The vehicle has not yet been inspected by manufacturer, police, insurance representatives or others. No warning lamps, messages or other symptoms of the problem appeared prior to the failure. A large wrench display appeared on dash at the moment of failure and reoccurs with each failure. Some dash displays zero out and/or disappear. The speedometer drops to zero and fails thereafter to register. Transmission shifting becomes random and sudden or fails entirely. Manuals shifting is sometimes possible and other times not possible. Manual shifting all the way to gear 3, followed by a mild acceleration occasionally causes the speedometer to resume function. Subsequent switching to automatic shift is then possible and automatic shifting functions initially or for varied lengths of time. Failure produces OBD code P0720 related to workings and overall condition of the output speed sensor circuit.
The contact owns a 2013 Ford F-150. The contact stated while driving 35 MPH uphill, the transmission failed to shift from 1st gear to 2nd gear, and there was a delay the response of the vehicle. The power train warning light was illuminated. A message indicating that the fuel tank would be empty in 35 miles was displayed, and se…
Read full complaint
The contact owns a 2013 Ford F-150. The contact stated while driving 35 MPH uphill, the transmission failed to shift from 1st gear to 2nd gear, and there was a delay the response of the vehicle. The power train warning light was illuminated. A message indicating that the fuel tank would be empty in 35 miles was displayed, and several unknown warning lights were illuminated. The contact veered to the side of the road, turned off, and restarted the vehicle; however, the failure persisted while driving below 50 MPH. The contact stated that the failure had been recurring more frequently. The vehicle was taken to the dealer, where it was diagnosed and determined that the failure was related to Ford Campaign Number: 19N01. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the campaign had expired. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 103,000.
The contact owns a 2013 Ford F-150. The contact stated while driving 20-30 MPH, the transmission downshifted from 3rd gear to 1st gear. Additionally, the engine revved up and the RMPS increased significantly. There was no warning light illuminated. The contact stated that the failure recurred while driving. The contact stated th…
Read full complaint
The contact owns a 2013 Ford F-150. The contact stated while driving 20-30 MPH, the transmission downshifted from 3rd gear to 1st gear. Additionally, the engine revved up and the RMPS increased significantly. There was no warning light illuminated. The contact stated that the failure recurred while driving. The contact stated that after the failure had occurred, he veered to the side of the road. The contact turned off the vehicle. The contact turned the ignition switch midway and allowed the vehicle to reset before restarting the vehicle, and the vehicle operated as needed. The contact stated that on other occasions, the vehicle was able to reset after disconnecting and reconnecting the battery. An unknown dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and informed the contact that the recall repair of NHTSA Campaign Number: 19V075000 (Power Train) was previously performed on the vehicle; however, the failure persisted. The contact also related the failure to NHTSA Campaign Number: 19V433000 (Power Train) however, the VIN was not included. The failure mileage was approximately 178,950.
The contact owns a 2013 Ford F-150. The contact stated while driving approximately 55 MPH, the vehicle unintendedly downshifted to 1st gear. The contact struggled to get the vehicle to accelerate. The contact stated that the engine revved however, the vehicle failed to respond. The contact coasted the vehicle over to the side of…
Read full complaint
The contact owns a 2013 Ford F-150. The contact stated while driving approximately 55 MPH, the vehicle unintendedly downshifted to 1st gear. The contact struggled to get the vehicle to accelerate. The contact stated that the engine revved however, the vehicle failed to respond. The contact coasted the vehicle over to the side of the road and was able to drive 15 MPH in 1st gear to the residence. The stated that the failure recurred within 5-miles while driving at various speeds. The failure was intermittent. The contact stated that odometer and transmission coolant gauge would go to zero with the wrench symbol displayed on the instrument panel. The vehicle had not been taken to the dealer nor a certified mechanic. The vehicle had not been diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 157,000.
The contact owns a 2013 Ford F-150. The contact stated while driving 50 MPH, the vehicle unintendedly downshifted without warning. The contact took the vehicle to a dealer and the contact was informed that the vehicle was not under recall. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 19V433000 (Po…
Read full complaint
The contact owns a 2013 Ford F-150. The contact stated while driving 50 MPH, the vehicle unintendedly downshifted without warning. The contact took the vehicle to a dealer and the contact was informed that the vehicle was not under recall. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 19V433000 (Power Train). The manufacturer was notified of the failure and provided the contact the same information as the dealer. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was approximately 130,000.
The contact owns a 2013 Ford F-150. The contact stated while driving at 55 MPH, there was an abnormally loud sound coming from underneath the vehicle. The contact stated that the vehicle jerked with the speed sensor and service engine warning lights illuminated. The contact stated that the gear shifter was only operable in 3rd, …
Read full complaint
The contact owns a 2013 Ford F-150. The contact stated while driving at 55 MPH, there was an abnormally loud sound coming from underneath the vehicle. The contact stated that the vehicle jerked with the speed sensor and service engine warning lights illuminated. The contact stated that the gear shifter was only operable in 3rd, 4th, and 5th gear. The vehicle was taken to the dealer and diagnosed with a failed lead frame sensor. The contact was informed that the lead frame sensor needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and advised the contact that the vehicle was not covered under a previous recall due to the age of the vehicle. The failure mileage was approximately 166,000. The VIN was unavailable.
Official recalls
319V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Jun 10, 2019
Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.
Consequence & remedy
Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.
Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.
Power Train:automatic Transmission
Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.
Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.
19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Feb 11, 2019
Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.
Consequence & remedy
Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.
Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.
Power Train:automatic Transmission
Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.
Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.
16V345000 · Service Brakes, Hydraulic:fluid
May 24, 2016
Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.
Consequence & remedy
Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ17010 · Unexpected Transmission Downshift
Opened Dec 25, 2017 · Closed Oct 22, 2019
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
Power Train:automatic Transmission
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
PE16003 · Master Cylinder External Leak
Opened Feb 29, 2016 · Closed Jul 26, 2016
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Additional source detail variants (4)
Service Brakes
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Service Brakes, Hydraulic:fluid
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Service Brakes, Hydraulic
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Service Brakes, Hydraulic:foundation Components:master Cylinder
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
PE13018 · Reduced Power During Hard Acceleration
Opened May 22, 2013 · Closed Apr 7, 2014
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling
On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of
Additional source detail variants (2)
Engine And Engine Cooling
On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of
Engine
On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of