← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Fuel/propulsion System complaints

130 reports
Clear category filter
7,800 miles · Nov 20, 2014
EngineFuel/propulsion System

PURCHASED NEW 2013 FORD ECO PICKUP. IT WAS ADVERTISED AND SOLD TO BE A HIGH EFFICIENT FUEL ECONOMICAL VEHICLE. FIRST TIME TEMPERATURES DROPPED BELOW 30 DEGREES F, MY FUEL MILEAGE DRASTICALLY DROPPED. AFTER DISCUSSION WITH DEALERSHIP, THEY SEEMED TO BE AWARE OF THE AFFECT COLD AIR HAD ON ITS FUEL MILEAGE. PRIOR TO COLD WEATHER I …

Read full complaint

PURCHASED NEW 2013 FORD ECO PICKUP. IT WAS ADVERTISED AND SOLD TO BE A HIGH EFFICIENT FUEL ECONOMICAL VEHICLE. FIRST TIME TEMPERATURES DROPPED BELOW 30 DEGREES F, MY FUEL MILEAGE DRASTICALLY DROPPED. AFTER DISCUSSION WITH DEALERSHIP, THEY SEEMED TO BE AWARE OF THE AFFECT COLD AIR HAD ON ITS FUEL MILEAGE. PRIOR TO COLD WEATHER I WAS EXPERIENCING 18 TO 24 MPG. AS SOON AS COLD WEATHER ARRIVED I WAS EXPERIENCING 12 TO 14 MPG. THIS TYPE OF MILEAGE IS CONSISTENT ALL THROUGH THE WINTER UNTIL LATE SPRING. SEEMS THE 24 MPG IS UNACHIEVABLE ANYMORE. DEALERSHIP BRIEFLY EXPLAINED THE BOOSTERS WORK BEST IN WARM WEATHER. THIS INFORMATION WAS NOT OFFERED DURING THE PURCHASE PROCESS. I EVEN SHOWED THEM A MAGAZINE ARTICLE WRITTEN ON HOW FORDS ECO BOOST HAD BEEN EXPERIENCING LOWER THAN ADVERTISED MPG. THE SALESMAN ACKNOWLEDGED THE ARTICLE AND SAID THEY HAD CORRECTED THE PROBLEM. I WAS TOLD DURING A MAINTENANCE PROCESS, THAT IT HAD TO HAVE 12,000 MILES BEFORE THEY COULD TEST IT FOR LACK OF MPG. I HAD IT INSPECTED AT 11,800 MILES AND THEY CLAIM THERE IS NOTHING THEY CAN DO. MY ADVICE TO ANYONE PURCHASING A 150 ECO BOOST EXPECTING GOOD TO ABOVE AVERAGE MPG, IT WILL NOT HAPPEN. *TR

NHTSA ODI #10659778

9,600 miles · May 9, 2014
EngineFuel/propulsion SystemPower Train

UNINTENDED ACCELERATION DESIGN DEFECT IN VEHICLES EQUIPPED WITH AN ELECTRONIC THROTTLE CONTROL SYSTEM . *TR

NHTSA ODI #10587430

8,200 miles · Feb 10, 2014
Fuel/propulsion SystemVehicle Speed Control

I WAS ACCELERATING UP A HILL AT APPROXIMATELY 50 MPH WHEN A RAPID DECELERATION OCCURRED. I HAD TO QUICKLY MERGE ONTO THE SHOULDER IN ORDER TO AVOID BEING HIT FROM BEHIND. I THEN SHUT OFF THE VEHICLE, WAITED, COMPOSED MYSELF, RESTARTED THE VEHICLE, AND DROVE SAFELY TO WORK. I DID, HOWEVER, HAVE THE "CHECK ENGINE" ILLUMINATE ON M…

Read full complaint

I WAS ACCELERATING UP A HILL AT APPROXIMATELY 50 MPH WHEN A RAPID DECELERATION OCCURRED. I HAD TO QUICKLY MERGE ONTO THE SHOULDER IN ORDER TO AVOID BEING HIT FROM BEHIND. I THEN SHUT OFF THE VEHICLE, WAITED, COMPOSED MYSELF, RESTARTED THE VEHICLE, AND DROVE SAFELY TO WORK. I DID, HOWEVER, HAVE THE "CHECK ENGINE" ILLUMINATE ON MY WAY HOME AND SEEMED TO SENSE SOME STIFFNESS IN THE BRAKES. THIS SHOULD NOT HAPPEN IN A VEHICLE WITH 8000 MILES ON IT. *TR

NHTSA ODI #10563680

12,000 miles · Nov 16, 2013
EngineFuel/propulsion SystemVehicle Speed Control

WE BOUGHT OUR 2013 F150 XLT 4X4 V6 FLEX FUEL AT DENHAM FORD IN WETASKIWIN ALBERTA. WE TRAVELED ACROSS COUNTRY TO ONTARIO. WE HAVE CONTINUED TO DRIVE IT. APPROXIMATELY 9000 KMS FOR MILEAGE OUR TRUCK HAS STEADILY LOST ACCELERATION POWER. GOING UP BURLINGTON SKYWAY AND GARDEN CITY SKYWAY (100 KM/H MAJOR HIGHWAY) TRUCK STRUGGLE TO M…

Read full complaint

WE BOUGHT OUR 2013 F150 XLT 4X4 V6 FLEX FUEL AT DENHAM FORD IN WETASKIWIN ALBERTA. WE TRAVELED ACROSS COUNTRY TO ONTARIO. WE HAVE CONTINUED TO DRIVE IT. APPROXIMATELY 9000 KMS FOR MILEAGE OUR TRUCK HAS STEADILY LOST ACCELERATION POWER. GOING UP BURLINGTON SKYWAY AND GARDEN CITY SKYWAY (100 KM/H MAJOR HIGHWAY) TRUCK STRUGGLE TO MAINTAIN 60 KM/H UPHILL WITH PEDAL TO THE FLOOR! HAD INSTRUMENTAL PANEL PROBLEMS IMPROPER DISPLAY OF AMOUNT OF GAS OR DISTANCE TO E. DRIVESHAFT CONSTANTLY CLUNKING AND TRANSMISSION SLIPPAGE. FORD REFUSED TO REPLACE AFTER TOWING OF PROBLEMS AND CONSTANT CALL INS TO CUSTOMER SERVICE. TOOK TO LOCAL DEALER AND 7-8 TECHNICIANS STOOD ROUND SCRATCHING HEAD REPLACED FUEL PUMP DID NOT MAKE A DIFFERENCE. FORD ASK FOR PAYMENT 558.08 WE NOT HAVE FUNDS AS ALL OF OUR MONEY GOING INTO GAS TO REPAIR TRUCK AND FALSE READING ON PANEL AND FORD REFUSED TO HELP US. WE FELT USED AND SCARED OF BEING REAR ENDED BY A SEMI WAS NOT SAFE. DID DIAGNOSTIC NO CODES. BEYOND CODE PROBLEM. FIRST KNOWN PROBLEM IN NORTH AMERICA...HUGE LEMON. *TR

NHTSA ODI #10552579

678 miles · Sep 18, 2013
Fuel/propulsion SystemPower TrainStructureCrash

AT OR AROUNG 500 MILES ON MY BRAND NEW 2013 FORD F150 SVT RAPTOR A MESSAGE COME UP ON THE 4.2 INCD LCD THAT READ "CHECK FUEL INLET". I WAS AT A GAS STATION PUTTING GAS IN MY TRUCK AND WHILE I WAS PUMPING GAS I CALLED HARBIN FORD AND SPOKE WITH A SERVICE REP. AND TOLD THEM WHAT HAD COME UP ON THE LCD. THE SERVICE REP. TOLD ME TO …

Read full complaint

AT OR AROUNG 500 MILES ON MY BRAND NEW 2013 FORD F150 SVT RAPTOR A MESSAGE COME UP ON THE 4.2 INCD LCD THAT READ "CHECK FUEL INLET". I WAS AT A GAS STATION PUTTING GAS IN MY TRUCK AND WHILE I WAS PUMPING GAS I CALLED HARBIN FORD AND SPOKE WITH A SERVICE REP. AND TOLD THEM WHAT HAD COME UP ON THE LCD. THE SERVICE REP. TOLD ME TO OPEN THE BACK DOOR AND LOOK UNDER THE BACK SEAT ON DRIVER SIDE AND THERE SHOULD BE A WHITE FUNNEL LOOKING OBJECT ABOUT 6 INCHES LONG. I PULLED UP AT MY HOME AND PARKED MY TRUCK UNDER OUR CARPORT WHICH HAS 2 OPEN WALLS AND ANOTHER TO ENTER THE CARPORT. ON THE NORTH END THE CARPORT IS SUPPORTED BY 3 STEEL POLES WHICH HOLDS THE CARPORT UP WHICH IS ATTACHED TO OUR HOUSE. I PLACED MY TRUCK IN (P) PARK AND LEFT THE ENGINE RUNNING, MY MOTHER WAS OUTSIDE ABOUT 10 FEET FROM MY TRUCK. AND I THOUGHT BEFORE I GOT IN MY TRUCK THAT MAYBE I SHOULD TRY THE FUNNEL DEAL MENTIONED EARLIER IN THIS DESCRIPTION. SO I JUST OPENED THE BACK DOOR BECAUSE THE FRONT WAS ALREADY OPEN BECAUSE I LEFT MY TRUCK RUNNING AND IT WAS IN THE (P) POSITION BUT I GOT THE FUNNEL AND OPENED THE FUEL DOOR AND STARTED STICKING THE FUNNEL IN AND OUT REPEATING SEVERAL TIMES. AND ABOUT THE 2ND OR 3RD TIME STICKING THE FUNNEL IN AND OUT OF THE FUEL INLET MY TRUCK ACTED LIKE SOMEONE HAD PLACED MY TRUCK IN REVERSE AND IT STARTED COMING IN REVERSE. MY MOTHER SEEN THIS AND SHE SCREAMED AT ME TO GET OUT OF THE WAY AND I JUST SEEN A OPENING BETWEEN THE DOORS AND I SOMEHOW ENDED UP IN THE DRIVER SEAT AND I HIT THE BRAKE AND TO DISBELIEF I LOOKED AT THE DRIVER SIDE DOOR AND IT WAS ALMOST RIPPED COMPLETELY OFF AND THE DRIVER SIDE FENDER WAS ALSO CRINKLED UP FROM THE DOOR CATCHING ON THE LAST POLE EXITING OUR CARPORT. I LOOKED OVER AT THE AUTO TRANSMISSION AND THE TRUCK WAS STILL IN PARK? *TR

NHTSA ODI #10544333

2,969 miles · Aug 18, 2013
Fuel/propulsion SystemPower Train

I DROVE MY F150 FOR A SHORT DISTANCE OF MAYBE 3 MILES, SHUT IT OFF, ENTERED THE POST OFFICE FOR APPROXIMATELY 5 MINUTES, DROVE THE TRUCK ACROSS THE STREET FOR A DISTANCE OF MAYBE 1/4 MILE, SHUT IT OFF AND WENT INTO A BUSINESS FOR MAYBE 5 MINUTES. UPON STARTING THE TRUCK TO RETURN HOME IT WOULD NOT SHIFT INTO DRIVE. I LOOKED AT…

Read full complaint

I DROVE MY F150 FOR A SHORT DISTANCE OF MAYBE 3 MILES, SHUT IT OFF, ENTERED THE POST OFFICE FOR APPROXIMATELY 5 MINUTES, DROVE THE TRUCK ACROSS THE STREET FOR A DISTANCE OF MAYBE 1/4 MILE, SHUT IT OFF AND WENT INTO A BUSINESS FOR MAYBE 5 MINUTES. UPON STARTING THE TRUCK TO RETURN HOME IT WOULD NOT SHIFT INTO DRIVE. I LOOKED AT THE INSTRUMENT PANEL AND SAW THE RPMS TO BE OVER 3000. I DID NOT HEAR THE ENGINE REVVING DUE TO AC BLOWER NOISE. I CHECKED THE ACCELERATOR TO SEE IF ANYTHING WAS TOUCHING IT AND NOTHING WAS NEAR THE ACCELERATOR. I SHUT THE TRUCK OFF, RESTARTED, AND IT PERFORMED NORMALLY. OTHER ISSUES: 1) SEVERAL MONTHS AGO THE RADIO WOULD NOT TURN ON WHILE DRIVING AND WHEN I SHUT THE TRUCK OFF THE OUTSIDE TEMPERATURE DISPLAY ALONG WITH THE DATE/TIME DISPLAY WAS FLASHING SYMBOLS INSTEAD OF DISPLAYING ALPHA-NUMERIC CHARACTERS. UPON RESTARTING THE TRUCK THE DISPLAY RETURNED TO NORMAL AND THE RADIO FUNCTIONED NORMALLY. 2) WHEN APPLYING FULL THROTTLE THE ENGINE BASICALLY STALLS WHICH CAN BE SOMEWHAT HAZARDOUS WHEN ENTERING AN INTERSTATE HIGHWAY WITH A SHORT ENTRANCE RAMP AND HEAVY TRAFFIC. I MENTION ALL OF THESE ITEMS BECAUSE IN MY OPINION THEY WOULD POINT TO COMPUTER ISSUES ON THE ECOBOOST. *TR

NHTSA ODI #10535974

7,000 miles · Jul 30, 2013
EngineFuel/propulsion SystemPower Train

I PURCHASED MY 2013 FORD F-150 ECOBOOST IN DECEMBER 2012. THE FIRST INCIDENT OCCURRED IN APPROXIMATELY MARCH 2013. IT WAS RAINING. I WAS ACCELERATING FROM A STOP LIGHT WHERE I HAD MADE A COMPLETE STOP. I COULD NOT GAIN SPEED VERY WELL. THE ENGINE LIGHT WAS FLASHING. THE ENGINE WAS SPUTTERING/POPPING AND THE WHOLE TRUCK WAS SHAKI…

Read full complaint

I PURCHASED MY 2013 FORD F-150 ECOBOOST IN DECEMBER 2012. THE FIRST INCIDENT OCCURRED IN APPROXIMATELY MARCH 2013. IT WAS RAINING. I WAS ACCELERATING FROM A STOP LIGHT WHERE I HAD MADE A COMPLETE STOP. I COULD NOT GAIN SPEED VERY WELL. THE ENGINE LIGHT WAS FLASHING. THE ENGINE WAS SPUTTERING/POPPING AND THE WHOLE TRUCK WAS SHAKING VIOLENTLY. THE SAME HAS OCCURRED EVER SINCE ON MORE THAN A DOZEN OCCASIONS AND AT VARIOUS SPEEDS. HOWEVER, EACH TIME WAS WHILE IT WAS RAINING. NEVER HAS HAD A PROBLEM IN FAIR WEATHER. I EXPERIENCE A TOTAL LOSS OF POWER, MANY TIMES WHEN ON THE INTERSTATE OR WHILE TRYING TO OVERCOME A VEHICLE. THE FRONT-END LURCHES, I LOSE SPEED DRAMATICALLY, THE ENGINE SHAKES VIOLENTLY WHEN I ACCELERATE. THE ENGINE SPUTTERS AND SOUNDS LIKE IT DOESN'T KNOW WHETHER TO CHOKE OUT OR BLOW UP. THE ENGINE LIGHT FLASHES FOR APPROXIMATELY 1 MINUTE EACH TIME. ALMOST SOUNDS LIKE A MISFIRE. HAPPENS SEVERAL TIMES DURING ONE TRIP OFTEN, BUT ALWAYS WHEN IT RAINS. CONTINUOUS OCCURRENCES AND BEGINNING TO BECOME MORE FREQUENT. HAVE TAKEN MY TRUCK TO 2 DEALERSHIPS, NEITHER OF WHICH CAN DETECT ANY DTCS OR ANY OTHER PROBLEM. OFFER NO ADVICE OTHER THAN TO KEEP DRIVING IT UNTIL THE ENGINE LIGHT STAYS ON PERMANENTLY. THEY HAVE NO IDEA WHAT CAUSES THE PROBLEM. I AM REALLY AFRAID THAT THE PROBLEM MAY RESULT IN A MOTOR VEHICLE ACCIDENT. HAVE NOT HAD ONE YET, BUT HAVE A HAD A COUPLE OF INCIDENTS WHERE I HAD TO PULL OVER TO AVOID AN ACCIDENT. PROBLEM IS SO PERSISTENT THAT I AM CONSIDERING TRADING VEHICLES, ESPECIALLY SINCE I HAVE BEEN OFFERED NO REMEDY FOR THE PROBLEM. I HAVE ALSO FILED A COMPLAINT WITH FORD MOTOR CO. ON 07/30/2013. *TR

NHTSA ODI #10532667

10,600 miles · Jun 11, 2013
EngineFuel/propulsion SystemPower Train

VEHICLE LOST POWER WHEN TRYING TO PASS ANOTHER VEHICLE. NOTE I WAS IN A 75 MPH AREA TRYING TO PASS A VEHICLE THAT HAD TRASH FLYING OFF TRUCK. IN ANY CASE WHEN I PUNCHED THE ACCELERATOR THE VEHICLE DID A NOSE DIVE AS IT LOST POWER. IT TOOK ABOUT 2 SECONDS FOR THE VEHICLE TO RESTORE TO NORMAL OPERATION. *TR

NHTSA ODI #10516223

9,500 miles · May 16, 2013
Fuel/propulsion SystemVehicle Speed Control

ECO BOOST ENGINE LOST POWER WHEN TRYING TO ACCELERATE AND PASS. THIS HAS HAPPENED THREE TIMES. FORD DEALER COULD NOT REPRODUCE NOW AND NO RESPONSE FROM FORD. TRAVELING SPEED 75 AND TRIED TO PASS AT 85. *TR

NHTSA ODI #10512361

75 miles · May 11, 2013
EngineFuel/propulsion SystemPower Train

NOT GETTING STICKER MPG; TOOK VEHICLE BACK AND FORD MILHAM DEALERSHIP IN EASTON PA OFF RT 33 SAID " THERE IS NOTHING WE CAN DO ABOUT IT" POWER STEERING RACK ALSO MALFUNCTIONED AT 7,000 MILES. DEALERSHIP MANAGER AGREED THERE IS AN ISSUE WITH THE VEHICLE. I DROPPED THE VEHICLE OFF ON A WEDNESDAY. THURSDAY NIGHT THEY CALLED AND ST…

Read full complaint

NOT GETTING STICKER MPG; TOOK VEHICLE BACK AND FORD MILHAM DEALERSHIP IN EASTON PA OFF RT 33 SAID " THERE IS NOTHING WE CAN DO ABOUT IT" POWER STEERING RACK ALSO MALFUNCTIONED AT 7,000 MILES. DEALERSHIP MANAGER AGREED THERE IS AN ISSUE WITH THE VEHICLE. I DROPPED THE VEHICLE OFF ON A WEDNESDAY. THURSDAY NIGHT THEY CALLED AND STATED EVERYTHING CHECKED OUT AND "FORD SAYS IT'S WITHIN RANGE". I WAS ALSO TOLD I WILL RECEIVE A SURVEY ONLINE - I NEVER RECEIVED THE EMAIL TO COMMUNICATE MY DISSATISFACTION WITH THE VEHICLE AND THE DEALERSHIP. VEHICLE NOW HAS 10,000 MILES AND NOW I GET 16 MPG ON HIGHWAY (NO CITY DRIVING). *TR

NHTSA ODI #10511508

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of