← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Engine complaints

547 reports
Clear category filter
118,661 miles · Feb 5, 2019
Engine

TRANSMISSION SHIFT FROM 5TH GEAR TO FIRST GOING 70 MPH ON INTERSTATE 285 IN ATLANTA, GA. ONE TIME STUCK IN FIRST GEAR. WOULD TEMPORARILY STOP IF VEHICLE WAS SHUT OFF AND RESTARTED. PRINTOUT FROM OUR MECHANIC DESCRIBING THE ISSUE: " VEHICLES EQUIPPED WITH A 6R80 TRANSMISSION BUILT PRIOR TO 4/8/2013 MAY EXHIBIT A TRANSMISSION E…

Read full complaint

TRANSMISSION SHIFT FROM 5TH GEAR TO FIRST GOING 70 MPH ON INTERSTATE 285 IN ATLANTA, GA. ONE TIME STUCK IN FIRST GEAR. WOULD TEMPORARILY STOP IF VEHICLE WAS SHUT OFF AND RESTARTED. PRINTOUT FROM OUR MECHANIC DESCRIBING THE ISSUE: " VEHICLES EQUIPPED WITH A 6R80 TRANSMISSION BUILT PRIOR TO 4/8/2013 MAY EXHIBIT A TRANSMISSION ENGAGEMENT IN 5TH GEAR WHEN STARTING. THE WRENCH INDICATOR AND/OR SEAT BELT MINDER MAY BE ILLUMINATED, THE SPEEDOMETER READS ZERO AND THE ODOMETER DASHES WHILE DRIVING. SYMPTOMS MAY CLEAR AFTER AN IGNITION KEY CYCLE. DIAGNOSTICS TROUBLE CODES (DTCS) PO720 AND PO722 MAY OR MAY NOT BE STORED IN THE POWERTRAIN CONTROL MODULE. THE SERVICE PROCEDURE IS TO REPLACE THE MOLDED LEADFRAME ON THE MAIN CONTROL ASSEMBLY." NALLEY FORD IN SANDY SPRINGS, GA DID THIS ON THIS VEHICLE, KNEW EXACTLY THE PROBLEM AS THEY HAD HAD TO DO THIS BEFORE. IN ATLANTA, IF YOUR VEHICLE DOWNSHIFTS THAT DRAMATICALLY, YOU COULD EASILY BE KILLED OR TERRIBLY INJURED WITH THE AMOUNT OF BIG RIGS FLYING AROUND THE PERIMETER INTERSTATE HERE IN ATLANTA. I WAS SURPRISED THAT THERE WAS NOT A RECALL ON THIS FLAW, AND OTHER SIMILAR, VEHICLES. I AM GRATEFUL THAT MY HUSBAND WAS NOT A STATISTIC. WOULD VERY MUCH LIKE TO KNOW WHAT OTHER COMPLAINTS HAVE BEEN REGISTERED REGARDING THIS, NOT TO MENTION THE NEARLY $1,200 PRICE TAG. THANK YOU.

NHTSA ODI #11174524

123,000 miles · Feb 4, 2019
EnginePower TrainVehicle Speed Control

TODAY WHILE DRIVING 70MPH MY TRUCK SHIFTED TO 1ST GEAR CAUSING THE TRUCK TO LOCK THE REAR TIRES, SWERVE FROM LEFT TO RIGHT, RPM'S TO THE MAX REV LIMIT, LOSS OF POWER, DASH CLUSTER WENT BLANK, WRENCH SYMBOL SHOWED UP, THEN WRENCH SYMBOL WAS GONE WITH A BLANK DASH CLUSTER. TRUCK THEN JUMPED TO 3RD GEAR, BACK TO 1ST, THEN BACK UP T…

Read full complaint

TODAY WHILE DRIVING 70MPH MY TRUCK SHIFTED TO 1ST GEAR CAUSING THE TRUCK TO LOCK THE REAR TIRES, SWERVE FROM LEFT TO RIGHT, RPM'S TO THE MAX REV LIMIT, LOSS OF POWER, DASH CLUSTER WENT BLANK, WRENCH SYMBOL SHOWED UP, THEN WRENCH SYMBOL WAS GONE WITH A BLANK DASH CLUSTER. TRUCK THEN JUMPED TO 3RD GEAR, BACK TO 1ST, THEN BACK UP TO 5TH GEAR. PULLED OVER TURNED OF TRUCK, TOOK OUT KEY, RE-STARTED TRUCK AND ISSUE WAS GONE. THIS HAS HAPPENED MULTIPLE TIMES, HOWEVER, I WAS AT 10-20MPH. ONCE AT 55MPH SHIFT TO 3RD GEAR, BACK TO 5TH, THEN TO 1ST, UP TO 3RD. EVERY TIME THE TRUCK WILL END UP AT 3RD GEAR. THE TRUCK WILL NOT SHIFT DOWN TO FIRST MANUALLY, YOU MUST TAKE OF IN 3RD GEAR WITHOUT ANY POWER. THERE WAS A RECALL FOR 2011-2012 FORD F150'S. THERE ARE MULTIPLE COMPLAINTS ALL OVER THE INTERNET WITH THESE SAME PROBLEMS ALL WITH YEARS RANGING FROM 2011-2017. O FEEL THIS IS AN ONGOING PROBLEM WITH A HUGE SAFETY CONCERN WITB YOUR VEHICLE GOING FROM 70MPH DOWN TO FIRST GEAR CAUSING THE WHEELS TO LOCK UP AND SWERVE ALL OVER THE HIGHWAY. DO PEOPLE HAVE TO DIE BEFORE FORD WILL RECOGNIZE THIS IS A PROBLEM WITH MANY YEARS OF THE MODEL!!!!! I'M HAPPY MY FAMILY WAS NOT IN THE TRUCK WHEN THIS HAPPENS. I CAR POOL KIDS EVERYDAY ON THE HIGHWAY. WOULD YOU FEEL SAFE DOING THIS KNOWING THAT FORD KNOWS ABOUT THIS ISSUE FROM PAST YEARS. PLEASE MAKE THESE TRUCKS SAFE!!! I TOOK IT TO A FORD DEALER AND THEY HOOKED UP THE COMPUTER TO MY TRUCK, AND THE COMPUTER SHOWED 0 CODES FOUND. EVERY TIME THIS HAPPENS YOU TURN OFF THE VEHICLE, RE-START IT (SOMETIMES YOU HAVE TO DO IT MULTIPLE TIMES) THE TRUCK WILL DRIVE PERFECT UNTIL IT DECIDES TO ACT UP AGAIN.

NHTSA ODI #11174383

83,000 miles · Jan 14, 2019
EngineFuel/propulsion SystemUnknown Or Other

WHEN I ACCELERATE ON THE HIGHWAY TO MERGE OR PASS MY TRUCK LOOSES POWER COMPLETELY CAN NOT ACCELERATE. IT SHUDDERS FOR ABOUT 45 SECONDS CHECK ENGINE LIGHT COMES ON FLASHING AND IT SUDDENLY COMES BACK TO LIFE. I TOOK IT TO MY LOCAL FORD AND THEY SAID IT WAS A HIGH PRESSURE PUMP THAT NEEDED TO BE REPLACED. I REPLACED IT AND IT IS …

Read full complaint

WHEN I ACCELERATE ON THE HIGHWAY TO MERGE OR PASS MY TRUCK LOOSES POWER COMPLETELY CAN NOT ACCELERATE. IT SHUDDERS FOR ABOUT 45 SECONDS CHECK ENGINE LIGHT COMES ON FLASHING AND IT SUDDENLY COMES BACK TO LIFE. I TOOK IT TO MY LOCAL FORD AND THEY SAID IT WAS A HIGH PRESSURE PUMP THAT NEEDED TO BE REPLACED. I REPLACED IT AND IT IS STILL HAVING THE SAME ISSUE. THIS SEEMS TO BE A COMMON ISSUE WITH THESE TRUCKS. THE MORE RESEARCH I HAVE DONE THE MORE I FIND ABOUT THIS SAME ISSUE. FORD SHOULD BE HELD LIABLE AND RECALL THESE TRUCKS FOR THIS PROBLEM. I NOW HAVE TO TAKE IT TO ANOTHER FORD DEALERSHIP HOPING THEY CAN FIGURE IT OUT. LAST FORD TRUCK I WILL EVER OWN.

NHTSA ODI #11170057

75,000 miles · Jan 14, 2019
Engine

2011 - 2015 PHASERS AND TIMING CHAIN

NHTSA ODI #11169866

98,000 miles · Dec 21, 2018
Engine

BOUGHT THE TRUCK IN SEPTEMBER 2015 WITH 60,000 MILES ON IT.NOW I HAVE 101159 MILES ON IT NOW. AT ABOUT 98,000 MILES MY CHECK ENGINE LIGHT CAME ON AND I LOST ACCELERATION POWER WHEN FIRST TAKING OFF FROM A STOP OR IF I GET ON THE GAS THE TRUCK HESITATES AND WILL EITHER ACCELERATE SLOW OR WON'T ACCELERATE AT ALL. ALMOST GOT IN AN…

Read full complaint

BOUGHT THE TRUCK IN SEPTEMBER 2015 WITH 60,000 MILES ON IT.NOW I HAVE 101159 MILES ON IT NOW. AT ABOUT 98,000 MILES MY CHECK ENGINE LIGHT CAME ON AND I LOST ACCELERATION POWER WHEN FIRST TAKING OFF FROM A STOP OR IF I GET ON THE GAS THE TRUCK HESITATES AND WILL EITHER ACCELERATE SLOW OR WON'T ACCELERATE AT ALL. ALMOST GOT IN AN ACCIDENT ABOUT A WEEK AGO WHEN MERGING ONTO THE FREEWAY DO TO LOST POWER. CONTACTED A MECHANIC AND HE CAME PICKED THE TRUCK UP AND RAN TESTING ON IT AND COUPLE HOURS LATER CALLED BACK AND SAID MY TIMING CHAINS AND PHASERS NEEDED TO BE REPLACED. WITH THAT SAID IT WILL COST ME $3,000-4,000 TO GET THIS FIXED AND I SIMPLY DO NOT HAVE AN EXTRA COUPLE THOUSAND DOLLARS TO SHELL OUT FOR THIS FIX . I HAVE BEEN DOING A LOT OF SEARCHING AND HAVE BEEN FINDING THAT A TON OF PEOPLE HAVE HAD THIS PROBLEM AND WHEN THEY CONTACT FORD, FORD IS BASICALLY SAYING THEY ARE SOL AND HAVE TO PAY OUT OF POCKET FOR THE FIX. I STILL OWE $22,000 AND THOUGHT ABOUT TRADING IT IN FOR SOMETHING ELSE BUT FEEL THEY WILL KNOCK $4,000 OFF WHAT THE VEHICLE IS WORTH. I HAVE NO IDEA WHAT TO DO AT THIS POINT. PLEASE HELP!!!

NHTSA ODI #11163036

75,000 miles · Nov 29, 2018
Electrical SystemEngineFuel/propulsion System

THE FUEL PUMP FUSE (FUSE 27) OVERHEATS AND BURNS OUT RESULTING IN THE ENTIRE TRUCK SHUTTING OFF AT SPEEDS. THIS HAPPENED TO ME AT 65 MPH ON A HIGHWAY LEAVING ME WITH NO ENGINE AT THAT SPEED.

NHTSA ODI #11154744

60,000 miles · Nov 17, 2018
Engine

ENGINE HAS GRINDING NOISE FOR 2-3 SECONDS ON DAILY INITIAL STARTUP AND WHEN ENGINE IS COLD AFTER SITTING SEVERAL HOURS. DEALER PERFORMED ENGINE DIAGNOSTIC AND DIAGNOSED THE TIMING CHAIN ISSUE. FOR TIMING CHAIN ISSUES, THIS REQUIRES THE REPLACEMENT OF TIMING CHAIN AND PHASERS. DEALER EST COST TO FIX = $4000+. THIS HAS BEEN A …

Read full complaint

ENGINE HAS GRINDING NOISE FOR 2-3 SECONDS ON DAILY INITIAL STARTUP AND WHEN ENGINE IS COLD AFTER SITTING SEVERAL HOURS. DEALER PERFORMED ENGINE DIAGNOSTIC AND DIAGNOSED THE TIMING CHAIN ISSUE. FOR TIMING CHAIN ISSUES, THIS REQUIRES THE REPLACEMENT OF TIMING CHAIN AND PHASERS. DEALER EST COST TO FIX = $4000+. THIS HAS BEEN A REPORTED ISSUE FOR THIS ENGINE OVER THE LAST 3+ YEARS. FORD HAS REFUSED TO ADDRESS ON A RECALL, OR REFUND CUSTOMERS WHO HAVE ALREADY INCURRED THIS EXPENSE.

NHTSA ODI #11152168

59,000 miles · Nov 10, 2018
Engine

PASSANGER SIDE EXHAUST MANIFOLD BOLT AS BROKE OFF CAUSING AN EXHAUST LEAK. THE VEHICLE HAS 59010 MILES AND IS A 2013. FORD WANTS OVER 1600 TO FIX SAID ISSUE. FORD IS NOT WILLING TO ACCEPT FAULT OR COVER UNDER EMISSIONS WARRANTY.

NHTSA ODI #11150707

Mileage unknown · Nov 9, 2018
EnginePower Train

MY 2013 FORD F150 IS STALLING AT AT ANY SPEED, AND THE WRENCH ICON APPEARS ON THE DASHBOARD. SOMETIMES THE ENGINE ICON ALSO APPEARS WHEN THIS HAPPENS. IT'S OFF AND ON. THE ENGINE LIGHT DOES NOT STAY ON. I TOOK IT IN FOR A CHECKUP, AND THEY SAID FUEL SYSTEM NEEDS CLEANING. ALSO, MY TRANSMISSION HAS STARTED JUMPING AT LOW SPEEDS,…

Read full complaint

MY 2013 FORD F150 IS STALLING AT AT ANY SPEED, AND THE WRENCH ICON APPEARS ON THE DASHBOARD. SOMETIMES THE ENGINE ICON ALSO APPEARS WHEN THIS HAPPENS. IT'S OFF AND ON. THE ENGINE LIGHT DOES NOT STAY ON. I TOOK IT IN FOR A CHECKUP, AND THEY SAID FUEL SYSTEM NEEDS CLEANING. ALSO, MY TRANSMISSION HAS STARTED JUMPING AT LOW SPEEDS, AND REDUCES THE VEHICLE TO AND ABSOLUTE CRAWL....LESS THAN 5MPH. IT'S NOT A HIGH SPEED PROBLEM...JUST AT LIGHTS ,COMPLETE STOPS AND STOP AND GO DRIVING/TRAFFIC.

NHTSA ODI #11150649

148,653 miles · Nov 9, 2018
EnginePower TrainWheels

DATE 11/9/2018 VEHICLE: FORD F150 2013 DRIVER: EXPERIENCED MILES: 148,653 DATE OF INCIDENT: 11/1/2018 LOCATION: SOUTH BOUND ON I-275 IN SOUTHEAST, MI ROAD CONDITION: DRY DRIVER WAS ON THE HIGHWAY GOING 73 MPH IN THE LEFT LANE PASSING A SEMI WHEN THE VEHICLE SHIFTED FROM 6TH GEAR INSTANTLY INTO 1ST GEAR. CAUSING THE VE…

Read full complaint

DATE 11/9/2018 VEHICLE: FORD F150 2013 DRIVER: EXPERIENCED MILES: 148,653 DATE OF INCIDENT: 11/1/2018 LOCATION: SOUTH BOUND ON I-275 IN SOUTHEAST, MI ROAD CONDITION: DRY DRIVER WAS ON THE HIGHWAY GOING 73 MPH IN THE LEFT LANE PASSING A SEMI WHEN THE VEHICLE SHIFTED FROM 6TH GEAR INSTANTLY INTO 1ST GEAR. CAUSING THE VEHICLES REAR END TO LOCK UP AND THROW THE VEHICLE SIDEWAYS. DRIVER WAS FACING THE SIDE OF THE TRACTOR TRAILER HEAD ON NOW WHILE THE REAR END WAS BOUNCING OFF OF THE RUMPLE STRIPS. THE MOTOR WAS WELL OVER 6800 RPMS CAUSING THE TAC TO BOUNCE BETWEEN 6500 AND 7000RPM. NOT ONLY DID THIS PUT A LOT OF STRESS ON THE MOTOR AND TURBO, THIS ALSO SHOCKED ALL OF THE DRIVELINE COMPONENTS. A SHIFT LIKE THIS IS COMMONLY REFERRED TO AS A "MONEY SHIFT" BECAUSE IT DESTROYS AN ENTIRE DRIVELINE AS WELL AS THE MOTOR. LUCKILY THE VEHICLES DRIVELINE WAS STILL INTACT AFTER THIS HARSH DOWNSHIFT AND THE DRIVER WAS ABLE TO THROW THE TRUCK INTO MANUAL MOD SHIFT THE TRUCK BACK UP TO 5TH GEAR AND COUNTER STEER 2-3 TIMES TO CORRECT FROM THE TAIL END KICKING OUT. THE DRIVER BELIEVES THAT AN AVERAGE DRIVER WOULD HAVE DIED IN THIS SAME SITUATION. THE DRIVER FEELS LUCKY TO BE ALIVE AFTER EXPERIENCING THIS. AFTER THE DRIVER PULLED THE TRUCK INTO THE NEAREST FORD DEALER AND EXPLAINED WHAT HAPPENED THEY TOLD THE DRIVER THAT THEY HAVE NOT HEARD OF THIS PROBLEM BEFORE AND THAT THEY WOULDN'T BE ABLE TO LOOK AT THE VEHICLE FOR AT LEAST A WEEK. THE DRIVE THEN CALLED FORD TO REPORT THE ISSUE AND ON THREE SEPARATE CALLS ON 11/1/2018 FORD TOLD THE DRIVER THAT THEY WILL NOT COVER THE PROBLEM, BECAUSE IT'S NOT A RE-CALL. THE DRIVER WOULD GREATLY APPRECIATE IT IF THE NHTSA CAN OPEN AN INVESTIGATING INTO THE 2013+ MODELS OF THE F150'S TRANSMISSION SUDDENLY SHIFTING FROM 6TH TO 1ST GEAR. THIS IS A VERY DEADLY MALFUNCTION ESPECIALLY WITH ICY ROADS JUST AROUND THE CORNER IN MI.

NHTSA ODI #11150301

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of