← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Engine complaints

547 reports
Clear category filter
99,000 miles · Mar 21, 2019
Electrical SystemEngine

APPROXIMATELY TWO MONTHS AGO I PURCHASED A USED 2013 FORD F-150 FROM A LOCAL DEALERSHIP IN WARREN, MICHIGAN. RECENTLY I RECEIVED A NOTICE IN THE MAIL DETAILING A RECALL REGARDING VEHICLES EQUIPPED WITH A 6R80 TRANSMISSION ' SUDDEN DOWNSHIFT (SAFETY RECALL 19S07). AFTER RECEIVING MY POWERTRAIN CONTROL MODULE SOFTWARE UPDATE AP…

Read full complaint

APPROXIMATELY TWO MONTHS AGO I PURCHASED A USED 2013 FORD F-150 FROM A LOCAL DEALERSHIP IN WARREN, MICHIGAN. RECENTLY I RECEIVED A NOTICE IN THE MAIL DETAILING A RECALL REGARDING VEHICLES EQUIPPED WITH A 6R80 TRANSMISSION ' SUDDEN DOWNSHIFT (SAFETY RECALL 19S07). AFTER RECEIVING MY POWERTRAIN CONTROL MODULE SOFTWARE UPDATE APPROXIMATELY TWO WEEKS AGO FROM SZOTT FORD IN HOLLY, MICHIGAN, I EXPECTED MY TRANSMISSION TO RUN SMOOTHLY. SIX DAYS AGO, WHILE PULLING THROUGH A BUSY INTERSECTION, MY VEHICLE WOULD NOT LEAVE FIRST GEAR. SOMEHOW, I AVOIDED BEING HIT FROM CROSSING TRAFFIC. SHORTLY AFTER AVOIDING AN ACCIDENT, THE VEHICLE THEN SWITCHED ABRUPTLY FROM FIRST GEAR TO FIFTH GEAR (GOING AROUND 10 MPH). AFTER PULLING INTO A PARKING LOT I TURNED THE CAR OFF. WHEN I RESTARTED THE CAR, IT STARTED IN FIFTH GEAR. THE CAR WOULD NOT GO INTO MANUAL AND WOULD NOT LEAVE FIFTH GEAR. AT NO POINT DURING THIS TIME DID AN ENGINE LIGHT COME ON. AFTER SWITCHING THE CAR INTO FOUR-WHEEL DRIVE EVERYTHING SEEMED TO BE WORKING SMOOTHLY AGAIN. I IMMEDIATELY TOOK MY CAR INTO THE DEALERSHIP ONCE AGAIN. THE DEALERSHIP HAS INFORMED ME THAT EVERYTHING IS WORKING PROPERLY AND SINCE NO ENGINE LIGHT CAME ON THERE ARE NO PROBLEMS TO DIAGNOSE OR FIX. SAFETY RECALL 19S07 DID NOT FIX THIS VEHICLES ISSUES. LAST NIGHT THE SAME THING HAPPENED AGAIN. IT WOULD NOT LEAVE 1ST GEAR. I PUT THE CAR IN PARK AND THE CAR WOULD SIT IN SECOND GEAR THEN JUMP TO 5TH GEAR. VERY DANGEROUS PULLING OUT IN FRONT OF ANYTHING BECAUSE THE CAR BASICALLY STALLS IN ONCOMING TRAFFIC. SAFETY RECALL 19S07 DID NOT WORK.

NHTSA ODI #11190524

106,000 miles · Mar 19, 2019
Engine

WHILE DRIVING AT FULL SPEED (50 MPH), MY FORD-F-150 WENT INTO "LIMP MODE" AND A WRENCH LIGHT APPEARED. THE TRUCK IMMEDIATELY DECELERATED WITHOUT ACTIVATING THE BRAKE LIGHTS AND ALMOST CAUSED ME TO BE REAR-ENDED ON A DARK COUNTRY ROAD. I WAS ABLE TO PULL OVER EVENTUALLY. AFTER SHUTTING OFF THE TRUCK AND RESTARTING IT, I WAS A…

Read full complaint

WHILE DRIVING AT FULL SPEED (50 MPH), MY FORD-F-150 WENT INTO "LIMP MODE" AND A WRENCH LIGHT APPEARED. THE TRUCK IMMEDIATELY DECELERATED WITHOUT ACTIVATING THE BRAKE LIGHTS AND ALMOST CAUSED ME TO BE REAR-ENDED ON A DARK COUNTRY ROAD. I WAS ABLE TO PULL OVER EVENTUALLY. AFTER SHUTTING OFF THE TRUCK AND RESTARTING IT, I WAS ABLE TO DRIVE HOME BUT THE PROBLEM REOCCURED SEVERAL TIMES BEFORE I COULD TAKE IT TO THE DEALER. AT THE DEALER - IT WAS NOTED THAT THIS IS IDENTICAL (BOTH IN TRUCK ACTIONS AND ELECTRONIC CODES) TO THE 16N02 RECALL FOR 2011-2012 FORD -F-150'S BUT THAT MINE WAS NOT COVERED DUE TO MY VIN NUMBER NOT BEING PART OF THAT BATCH. I HAD THE TRANSMISSION REPAIRED (AS OFFERED IN THE PREVIOUSLY MENTIONED WARRANTEE) SO THAT MY TRUCK WAS SAFE TO DRIVE. THERE WAS NO VISIBLE DAMAGE OR WEAR TO ANY OF THE PARTS THAT NEEDED REPLACED. LOOKING ONLINE - THIS HAS OCCURRED IN SEVERAL 2013 FORD F-150 ACCORDING TO MESSAGE BOARDS - AND WE HOPE FORD WILL CONSIDER EXPANDING THE RECALL AND PREVENTING THIS ISSUE FROM OCCURRING TO OTHER OWNERS.

NHTSA ODI #11189937

94,000 miles · Mar 14, 2019
EnginePower Train

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V075000 (POWER TRAIN). WHILE DRIVING 40-45 MPH IN FOURTH AND/OR FIFTH GEAR, THE VEHICLE DOWNSHIFTED INTO FIRST GEAR AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO LONG-LEWIS FORD LINCOLN (2551 JOHN HAWKINS …

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V075000 (POWER TRAIN). WHILE DRIVING 40-45 MPH IN FOURTH AND/OR FIFTH GEAR, THE VEHICLE DOWNSHIFTED INTO FIRST GEAR AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO LONG-LEWIS FORD LINCOLN (2551 JOHN HAWKINS PKWY, BIRMINGHAM, AL 35244, (205) 989-3673) WHERE IT WAS DIAGNOSED THAT THE SPARK PLUGS, BOOTS, AND TIMING NEEDED TO BE ADJUSTED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE DEALER STATED THAT THE RECALL SOFTWARE REMEDY WAS NOT AVAILABLE. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: CAS17397322. THE CONTACT WAS INFORMED THAT THE REGIONAL CUSTOMER SERVICE REPRESENTATIVE WOULD CALL HIM. THE FAILURE MILEAGE WAS 94,000.

NHTSA ODI #11186896

76,000 miles · Mar 8, 2019
EnginePower TrainVehicle Speed Control

WHILE DRIVING AT 70MPH NOTICED MY TRUCK HAD DOWN SHIFTED INTO 5TH GEAR, I SLOWED TO PULL OVER AND NOTED THE AIRBAG LIGHT WAS ON, THE WRENCH INDICATOR AND SPEEDOMETER WAS AT ZERO. MY TRUCK SUDDENLY DOWN SHIFTED TO 1ST GEAR AT APPROXIMATELY 25-30 MPH. I WAS ABLE TO STOP SAFELY AT THE SHOULDER AND TURNED THE IGNITION OFF AND RESTAR…

Read full complaint

WHILE DRIVING AT 70MPH NOTICED MY TRUCK HAD DOWN SHIFTED INTO 5TH GEAR, I SLOWED TO PULL OVER AND NOTED THE AIRBAG LIGHT WAS ON, THE WRENCH INDICATOR AND SPEEDOMETER WAS AT ZERO. MY TRUCK SUDDENLY DOWN SHIFTED TO 1ST GEAR AT APPROXIMATELY 25-30 MPH. I WAS ABLE TO STOP SAFELY AT THE SHOULDER AND TURNED THE IGNITION OFF AND RESTARTED. MY TRUCK STARTED NORMALLY. I WENT TO FORD HUNTINGTON BEACH AND DESCRIBED THE SITUATION. AFTER EVALUATING DEALER STATED TRANS FLUID FULL, POSS LEAD FRAME DAMAGE AND VALVES GETTING STUCK. $1600! I INFORMED THE DEALER OF THE PENDING RECALL FOR THE TRANSMISSION ON THIS VEHICLE AND WAS INFORMED THAT IT ONLY COVERED A SOFTWARE UPGRADE. DAMAGE CAUSED BY A KNOWN FAULT SHOULD BE COVERED BY THE MANUFACTURER.

NHTSA ODI #11185451

142,000 miles · Mar 8, 2019
Engine

2013 FORD F-150 WITH 142K MILES BEGAN RATTLING UPON START UP. VEHICLE HAS ALWAYS HAD THE OIL CHANGED PER SCHEDULE AND HAS ALWAYS USED FULL SYNTHETIC MOBIL 1 OIL. DEALERSHIP INDICATED THAT THIS IS A COMMON PROBLEM WITH THE 3.5'S EVEN ON WELL TAKEN CARE OF VEHICLES. REPAIR WAS ESTIMATED AT 3200.00 PLUS TAX TO REPLACE CHAIN. F-150…

Read full complaint

2013 FORD F-150 WITH 142K MILES BEGAN RATTLING UPON START UP. VEHICLE HAS ALWAYS HAD THE OIL CHANGED PER SCHEDULE AND HAS ALWAYS USED FULL SYNTHETIC MOBIL 1 OIL. DEALERSHIP INDICATED THAT THIS IS A COMMON PROBLEM WITH THE 3.5'S EVEN ON WELL TAKEN CARE OF VEHICLES. REPAIR WAS ESTIMATED AT 3200.00 PLUS TAX TO REPLACE CHAIN. F-150 WAS TAKEN IN AND W HEN THE DEALERSHIP OPENED THE ENGINE THEY INDICATED THAT IT WAS IN PRISTINE CONDITION INSIDE AND NO SIGNS OF SLUDGE OR INDICATORS THAT ENGINE WASN'T TAKEN CARE OF. DEALERSHIP ALSO INDICATED THAT THERE IS A TSB FOR THESE ENGINES.

NHTSA ODI #11185445

50,000 miles · Mar 4, 2019
EnginePower TrainVehicle Speed Control

WIDELY REPORTED- PLEASE READ CAREFULLY! VERY SIMILAR TO EXISTING RECALL*, BUT NOT THE SAME. POTENTIALLY DEADLY. CURRENT RECALL DOES NOT ADDRESS THE SUDDEN UP-SHIFTS MENTIONED HERE. 2013 FORD F-150 MFG DEFECT: MOLDED LEADFRAME ASSY IN 6R80 TRANSMISSION SYMPTOMS: INTERMITTENT LOSS OF SPEED SIGNAL CAUSES SUDDEN/UNEXPECTED SLAMMI…

Read full complaint

WIDELY REPORTED- PLEASE READ CAREFULLY! VERY SIMILAR TO EXISTING RECALL*, BUT NOT THE SAME. POTENTIALLY DEADLY. CURRENT RECALL DOES NOT ADDRESS THE SUDDEN UP-SHIFTS MENTIONED HERE. 2013 FORD F-150 MFG DEFECT: MOLDED LEADFRAME ASSY IN 6R80 TRANSMISSION SYMPTOMS: INTERMITTENT LOSS OF SPEED SIGNAL CAUSES SUDDEN/UNEXPECTED SLAMMING UPSHIFT FROM 1ST GEAR TO 5TH WHEN ACCELERATING FROM A STOP, CAUSING A COMPLETE AND UNEXPECTED LOSS OF ALL ACCELERATION. INDICATIONS: 5TH GEAR SUDDENLY INDICATED ON DISPLAY, DASHES REPLACE NUMBERS ON SPEED/MILEAGE RELATED DISPLAYS (MPG, ODOMETER). SPEEDOMETER MAY READ 0, AIRBAG SYMBOL POPS ON, LARGE ORANGE WRENCH SYMBOL MAY BRIEFLY APPEAR. PRESSING ON ACCELERATOR DOES NOT CAUSE DOWNSHIFT. MOTOR MAY STALL. REMAINS IN 5TH GEAR WITHOUT SOME OTHER CORRECTIVE ACTION. TURNING ENGINE OFF AND BACK ON WILL RESET THE COMPUTER, AND VEHICLE OPERATES NORMALLY UNTIL NEXT OCCURRENCE. DANGERS: THIS COULD BE FATAL WHEN PULLING OUT INTO ONCOMING TRAFFIC, BOTH FROM THE SIDE (PULLING OUT IN FRONT OF ONCOMING TRAFFIC FROM SIDE STREET) OR FROM REAR (SUDDEN, UNEXPECTED LOSS OF SPEED/ NO BRAKE LIGHTS). FORD CANNOT FIX THIS BY RE-PROGRAMMING THE VEHICLE TO IGNORE THE FAULTY SENSOR ANY MORE THAN YOU CAN IGNORE AN ONCOMING CEMENT TRUCK OR TRAIN. REPAIR IS APPROXIMATELY $800. IF NOT RECALLED, OWNERS MAY TRY TO LIVE WITH THE RISKS OR TRADE TO AN UNKNOWING PERSON, ENDANGERING LIVES OF OTHERS. *THIS DEFECTIVE PART IS ALSO THE ROOT CAUSE OF FORD RECALL #19S07, INVOLVING SUDDEN VIOLENT DOWN-SHIFTS (NOT UPSHIFTS). FORD IS AVOIDING THE PROBLEM BY RE-PROGRAMMING THE ECU TO IGNORE THE INTERMITTENT SPEED SIGNALS, ALLOWING THE TRANSMISSION TO FAIL MORE GRACEFULLY, DEFECTS TO BE REPAIRED AT OWNER'S EXPENSE. THIS APPROACH WILL NOT WORK FOR THE UP-SHIFT PROBLEM. THE DEFECTIVE PART SHOULD BE IMMEDIATELY REPLACED AT FORD'S EXPENSE TO CORRECT BOTH PROBLEMS.

NHTSA ODI #11184012

149,000 miles · Mar 2, 2019
EnginePower Train

WHILE DRIVING AND IN 6TH GEAR ON A 2 LANE RD, THE TRUCK SHIFTED DOWN INTO 1ST AND CAUSED ME TO SLIDE OFF THE ROAD. WHEEL ALMOST LOCKED UP. I TURNED THE TRUCK OFF AND RESTARTED ABOUT 10 MINUTES LATER. PLACED THE SHIFTER IN MANUAL AND USED MANUAL TO GET HOME. THEY NEXT DAY TRUCK RAN BUT ENGINE RUNS ROUGH AND TRANS ACTS UP NOW AND …

Read full complaint

WHILE DRIVING AND IN 6TH GEAR ON A 2 LANE RD, THE TRUCK SHIFTED DOWN INTO 1ST AND CAUSED ME TO SLIDE OFF THE ROAD. WHEEL ALMOST LOCKED UP. I TURNED THE TRUCK OFF AND RESTARTED ABOUT 10 MINUTES LATER. PLACED THE SHIFTER IN MANUAL AND USED MANUAL TO GET HOME. THEY NEXT DAY TRUCK RAN BUT ENGINE RUNS ROUGH AND TRANS ACTS UP NOW AND THEN.NO DAMAGE BUT NOW THE TRUCK DOESN'T RUN RIGHT. I CLEARED THE CODES BUT NOT MUCH BETTER.

NHTSA ODI #11183654

59,470 miles · Mar 1, 2019
EnginePower TrainVehicle Speed Control

TODAY MY WIFE WAS DRIVING MY TRUCK WITH OUR TWO KIDS DOWN INTERSTATE I79 AT 70 MILES PER HOUR AND THE TRUCK SHIFTED ITSELF TOO FIRST GEAR LOCKED UP THE REAR TIRES AND ABOUT MADE THEM WRECK. I HAD TOO LEAVE MY JOB TO GET THEM OFF THE SIDE OF THE ROAD AND DRIVE MY TRUCK BACK TOO WORK THIS IS NOT ONLY A ISSUE BUT IT COULD GET SOMEO…

Read full complaint

TODAY MY WIFE WAS DRIVING MY TRUCK WITH OUR TWO KIDS DOWN INTERSTATE I79 AT 70 MILES PER HOUR AND THE TRUCK SHIFTED ITSELF TOO FIRST GEAR LOCKED UP THE REAR TIRES AND ABOUT MADE THEM WRECK. I HAD TOO LEAVE MY JOB TO GET THEM OFF THE SIDE OF THE ROAD AND DRIVE MY TRUCK BACK TOO WORK THIS IS NOT ONLY A ISSUE BUT IT COULD GET SOMEONE SERIOUSLY HURT

NHTSA ODI #11183553

69,100 miles · Feb 19, 2019
Engine

TL* THE CONTACT OWNED A 2013 FORD F-150. WHILE DRIVING BETWEEN 30-60 MPH, THE VEHICLE DECELERATED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT A NEW OUTPUT SPEED MODULE NEEDED TO BE INSTALLED. THE VEHICLE WAS ALSO TAKEN TO JENKINTOWN FORD (1650 T…

Read full complaint

TL* THE CONTACT OWNED A 2013 FORD F-150. WHILE DRIVING BETWEEN 30-60 MPH, THE VEHICLE DECELERATED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT A NEW OUTPUT SPEED MODULE NEEDED TO BE INSTALLED. THE VEHICLE WAS ALSO TAKEN TO JENKINTOWN FORD (1650 THE FAIRWAY, JENKINTOWN, PA 19046, (888) 503-1980), BUT NO ASSISTANCE WAS PROVIDED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 69,100.

NHTSA ODI #11181174

66,621 miles · Feb 18, 2019
EngineService BrakesVehicle Speed Control

1. LOSS OF BRAKES RESULTING IN PEDAL GOING ALL WAY TO FLOOR AT 35 MPH CITY. RECALL 16S24 BUT FORD DEALERSHIP IS SAYING MY VEHICLE IS NOT INCLUDED 2. LOSS OF ENGINE POWER WHILE ATTEMPTING TO MERGE ONTO HIGHWAY AT 65 MPH, THIS HAS OCCURRED THREE TIMES. 3. RECALL 19S07: BROUGHT INTO DEALERSHIP, STATED THEY DON'T HAVE THE SOFTWAR…

Read full complaint

1. LOSS OF BRAKES RESULTING IN PEDAL GOING ALL WAY TO FLOOR AT 35 MPH CITY. RECALL 16S24 BUT FORD DEALERSHIP IS SAYING MY VEHICLE IS NOT INCLUDED 2. LOSS OF ENGINE POWER WHILE ATTEMPTING TO MERGE ONTO HIGHWAY AT 65 MPH, THIS HAS OCCURRED THREE TIMES. 3. RECALL 19S07: BROUGHT INTO DEALERSHIP, STATED THEY DON'T HAVE THE SOFTWARE YET TO REMEDY THE PROBLEM OF SUDDEN POWER TRAIN DOWNSHIFT PRIME FORD 857 PORTLAND RD SACO MAINE 04072 SERVICE MANAGER :STACEY DRUMMEY 207-571-5035

NHTSA ODI #11180730

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of