← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Electrical System complaints

322 reports
Clear category filter
51,400 miles · Dec 16, 2016
Electrical SystemVisibility/wiper

USED REMOTE START TO WARM VEHICLE AND THE 1/3 OF THE REAR GLASS (THE DRIVER'S SIDE) EXPLODED AND SPIDERED. RESEARCH SHOWS THIS IS A COMMON PROBLEM AND LIKELY DUE TO FAULTY DEFROSTER. FORD DOESN'T PART OUT THE GLASS SO THE ENTIRE REAR WINDOW NEEDS TO BE REPLACED AT A COST OF OVER $650. MY VEHICLE IS GARAGED WHEN AT HOME AND IS…

Read full complaint

USED REMOTE START TO WARM VEHICLE AND THE 1/3 OF THE REAR GLASS (THE DRIVER'S SIDE) EXPLODED AND SPIDERED. RESEARCH SHOWS THIS IS A COMMON PROBLEM AND LIKELY DUE TO FAULTY DEFROSTER. FORD DOESN'T PART OUT THE GLASS SO THE ENTIRE REAR WINDOW NEEDS TO BE REPLACED AT A COST OF OVER $650. MY VEHICLE IS GARAGED WHEN AT HOME AND IS IN EXCELLENT CONDITION WITH ONLY 51400 MILES. SINCE IT IS OVER 36000 MILES, FORD WON'T DO ANYTHING OR ASSIST WITH COSTS.

NHTSA ODI #10935640

Mileage unknown · Dec 13, 2016
Electrical SystemFireInjury

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH, THE INSTRUMENTAL PANEL CAUGHT ON FIRE AND FLAMES EMITTED THROUGH THE VENTS AND MELTED THE DASH BOARD ON THE FRONT PASSENGER SIDE AREA. THE CONTACT SUSTAINED THIRD DEGREE BURNS TO THE RIGHT HAND, THE FRONT SEAT PASSENGER SUSTAIN…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH, THE INSTRUMENTAL PANEL CAUGHT ON FIRE AND FLAMES EMITTED THROUGH THE VENTS AND MELTED THE DASH BOARD ON THE FRONT PASSENGER SIDE AREA. THE CONTACT SUSTAINED THIRD DEGREE BURNS TO THE RIGHT HAND, THE FRONT SEAT PASSENGER SUSTAINED SMOKE INHALATION, AND THE REAR PASSENGER SUFFERED EMOTIONAL STRESS THAT ALL REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED FOR FURTHER INSPECTION. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE FIRE DEPARTMENT WAS PRESENT. THE FAILURE MILEAGE WAS NOT AVAILABLE. UPDATED 02/07/2017*CT *CN

NHTSA ODI #10934956

42,564 miles · Dec 12, 2016
Electrical System

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE MAKING A RIGHT TURN AT APPROXIMATELY 20 MPH, THE VEHICLE ACCELERATED NORMALLY AND SUDDENLY STALLED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT A FUSE MELTED INSIDE THE FUSE BOX. THE VEHICLE WAS REPAIRED. THE MANUFACTU…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE MAKING A RIGHT TURN AT APPROXIMATELY 20 MPH, THE VEHICLE ACCELERATED NORMALLY AND SUDDENLY STALLED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT A FUSE MELTED INSIDE THE FUSE BOX. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 42,564.

NHTSA ODI #10934793

Mileage unknown · Dec 10, 2016
Electrical SystemEngineFireInjury

3.5 V6 ECOBOOST FIRE. COMPLETELY BURNED MY TRUCK TO THE GROUND WITH MY FAMILY DRIVING IN, WIFE AND 5 YR OLD. PASSENGER SUFFERED 3RD DEGREE BURNS, 12/10/2016. TRUCK WAS IN MOTION, WE SMELT SMOKE AND WITHIN 2 MINUTES THE TRUCK WAS COMPLETELY ENGULFED.

NHTSA ODI #10934476

65,000 miles · Nov 17, 2016
Electrical SystemFuel/propulsion System

A CRITICAL 20 AMP FUSE THAT GIVES POWER TO THE FUEL RELAY WHICH POWERS THE FUEL PUMP BLEW RENDERING MY VEHICLE IN OPERABLE. IT WOULD NOT START AT ALL. THIS IS A KNOWN ISSUE TO FORD MOTOR COMPANY. THEY HAVE A TSB ALSO KNOWN AS A TECHNICAL SERVICE BULLETIN 15'0137. THIS "FIX" MERELY RELOCATES THE FUSE SO THAT THE KNOWN POTENTIA…

Read full complaint

A CRITICAL 20 AMP FUSE THAT GIVES POWER TO THE FUEL RELAY WHICH POWERS THE FUEL PUMP BLEW RENDERING MY VEHICLE IN OPERABLE. IT WOULD NOT START AT ALL. THIS IS A KNOWN ISSUE TO FORD MOTOR COMPANY. THEY HAVE A TSB ALSO KNOWN AS A TECHNICAL SERVICE BULLETIN 15'0137. THIS "FIX" MERELY RELOCATES THE FUSE SO THAT THE KNOWN POTENTIAL FOR FAILURE DOES NOT MELT THE FUSE HOUSING. THIS DOES NOT SOLVE THE PROBLEM OF WHY THE FUSE IS BLOWING. THIS SERVICE IS ALSO NOT COVERED; AS THE DEALER EXPECTS ME TO PAY FOR THE FIX. THE FUSE HOUSING ON MY TRUCK IS MELTED AND CHARD FROM THE FAILED FUSE . TO ME THIS IS A SAFETY ISSUE BOTH FOR THE POTENTIAL OF FIRE AND LOSING PROPULSION DUE TO THE CONSEQUENTIAL LOSS OF FUEL TO THE ENGINE .

NHTSA ODI #10926781

81,221 miles · Nov 9, 2016
Electrical System

MY 2013 FORD F-150 RAPTOR HAS HAD TWO COMPLETE BURNED UP MASTER FUSE BOXES OCCUR ON MY TRUCK. THE ORIGINAL ONE BURNED OUT AND MELTED AT 36K MILES ABOUT A YEAR AGO. FORD COVERED IT UNDER FACTORY WARRANTY. THIS SECOND ONE HAS JUST BURNED UP AT 80K. SAME EXACT THING. THERE IS A SERIOUS DEFECT ON THIS VEHICLE. THIS IS ALSO AN …

Read full complaint

MY 2013 FORD F-150 RAPTOR HAS HAD TWO COMPLETE BURNED UP MASTER FUSE BOXES OCCUR ON MY TRUCK. THE ORIGINAL ONE BURNED OUT AND MELTED AT 36K MILES ABOUT A YEAR AGO. FORD COVERED IT UNDER FACTORY WARRANTY. THIS SECOND ONE HAS JUST BURNED UP AT 80K. SAME EXACT THING. THERE IS A SERIOUS DEFECT ON THIS VEHICLE. THIS IS ALSO AN ISSUE WITH MANY 2013 MODEL FORD RAPTOR F-150. ACCORING TO ONLINE REPORTS AND VARIOUS DEALER COMMENTS. FOR SAFETY PURPOSES THIS IS A SEVERE ENOUGH AND CONTINUAL ISSUE THAT A RECALL NEEDS TO BE MADE. FOUR PEOPLE I KNOW WHO HAVE OWNED THIS TRUCK BETWEEN 2011-2013 HAVE ALL HAD THE SAME ISSUE. VEHICLE WILL NOT START OR OPERATE WHEN THIS ISSUE OCCURS IT'S ABNORMAL TO HAVE SUCH AND ISSUE WITH A SAFETY RISK AND THE POTENTIAL OF THE VEHICLE CATCHING FIRE. IT HAPPENS SO OFTEN APPARENTLY THERE IS A MAJOR BACK ORDER ON THE FUSE BOX REPLACEMENT. LAST TIME I WAS TOLD IT WOULD TAKE 6MONTHS TO GET THE PART.

NHTSA ODI #10925171

43,000 miles · Oct 31, 2016
Electrical SystemVisibility/wiper

STARTED TRUCK WITH REMOTE(FOB), YESTERDAY MORNING. I NEEDED TO DEFROST MY WINDOWS AS WELL. ON MY WAY TO WORK,TWENTY MINUTES LATER, I HEARD WHAT SOUNDED LIKE A GUN BLAST. I THOUGHT SOMEONE HAD SHOT MY TRUCK OR THREW A ROCK. I LOOKED IN MY REARVIEW WINDOW AND THE REAR DRIVER SIDE WINDOW WAS SHATTERED. I PULLED INTO A PARKING LOT A…

Read full complaint

STARTED TRUCK WITH REMOTE(FOB), YESTERDAY MORNING. I NEEDED TO DEFROST MY WINDOWS AS WELL. ON MY WAY TO WORK,TWENTY MINUTES LATER, I HEARD WHAT SOUNDED LIKE A GUN BLAST. I THOUGHT SOMEONE HAD SHOT MY TRUCK OR THREW A ROCK. I LOOKED IN MY REARVIEW WINDOW AND THE REAR DRIVER SIDE WINDOW WAS SHATTERED. I PULLED INTO A PARKING LOT AND NO SIGNS OF IMPACT BY A FOREIGN OBJECT. THE WINDOW WAS COMPLETELY SHATTERED. AFTER RESEARCHING THIS, I SEE THAT THIS SEEMS TO BE A DEFECTIVE DEFROSTER CONTRIBUTING TO SPONTANEOUS SHATTERING OF REAR WINDOWS ON THE F150. I CALLED THE DEALER AND THEY'RE GIVING ME "I'VE NEVER HEARD OF THIS" I'M NOT BUYING IT. ALSO, IF THIS HAD HAPPENED TODAY, MY SMALL CHILD WOULD HAVE BEEN SITTING RIGHT THERE. THIS IS NOT OKAY AND FORD SHOULD REPAIR THESE FOR CUSTOMERS. *TR

NHTSA ODI #10920276

50,000 miles · Oct 26, 2016
Electrical SystemVisibility/wiper

DURING THE START UP OF MY 2013 FORD F-150, I PROCEEDED TO UTILIZE THE REAR DEFROSTER TO GET THE ICE OFF THE REAR WINDOW. THE REAR WINDOW IS COMPRISED OF 3 PANELS OF GLASS, ONE ON EACH SIDE AND THE SLIDING WINDOW IN THE CENTER. LAST WEEK, THE REAR DEFROSTER WORKED INTERMITTENTLY, AFTER SEVERAL ATTEMPTS AT DEPRESSING THE BUTTON IT…

Read full complaint

DURING THE START UP OF MY 2013 FORD F-150, I PROCEEDED TO UTILIZE THE REAR DEFROSTER TO GET THE ICE OFF THE REAR WINDOW. THE REAR WINDOW IS COMPRISED OF 3 PANELS OF GLASS, ONE ON EACH SIDE AND THE SLIDING WINDOW IN THE CENTER. LAST WEEK, THE REAR DEFROSTER WORKED INTERMITTENTLY, AFTER SEVERAL ATTEMPTS AT DEPRESSING THE BUTTON IT WOULD EVENTUALLY TURN ON, NOT A WEEK LATER IT DOES NOT WORK AT ALL. THINKING IT WAS POSSIBLY THE FUSE OR A PROBLEM WITH THE BUTTON ITSELF, I SEARCHED ONLINE TO FIND OUT IF THERE WAS SOMETHING I COULD DO, AND FOUND THAT THIS IS A COMMON ISSUE AND REQUIRES REPLACEMENT OF THE ENTIRE BACK GLASS AND THAT SOME HAD THIS COVERED UNDER WARRANTY. I CALLED THE FORD DEALERSHIP AND TALKED TO THE REPAIR DEPARTMENT AND WAS TOLD BY THE MANAGER THAT HE HAS THE SAME VEHICLE AND THE SAME PROBLEM AND THAT THE ONLY WAY TO GET THE REAR DEFROST TO WORK IS TO REPLACE THE ENTIRE BACK GLASS AND THAT THE COST IS AROUND $2200. SEARCHING ONLINE ON THE F150 FORUM BOARDS FINDS THAT THIS IS A COMMON PROBLEM AND THE FIX IS REPLACEMENT OF THE ENTIRE BACKGLASS. BECAUSE MY VEHICLE HAS 50,000 MILES AND IS PAST THE 36,000 MILES OF THE WARRANTY IT IS NOT FORDS PROBLEM. AS THIS IS A SAFETY ISSUE (VISIBILITY THROUGH BACK GLASS) I SEARCHED ON THE GOVERNMENTS RECALL WEBSITE HERE AND FOUND SIMILAR COMPLAINTS AND THAT MANY HAVE ALSO EXPERIENCED THE WINDOWING CRACKING, SPIDERING AND EXPLODING WHEN USING ' WHICH TELLS ME DO NOT TURN ON THE REAR DEFROST FOR FEAR OF A BROKEN WINDOW EXPLODING WHILE IM DRIVING. THIS IS A SAFETY HAZARD AS IT DISTORTS AND SKEWS MY VISION AND ABILITY TO SEE OUT OF IT SAFELY UNTIL I CAN ATTEMPT TO HAVE FORD RECTIFY THIS ISSUE. *TR

NHTSA ODI #10918982

39,800 miles · Oct 23, 2016
Electrical SystemUnknown Or Other

INTERMITTENT REAR DEFROSTER ON OCCASION. WHILE SITTING IN DRIVEWAY ATTEMPTING TO GET REAR DEFROSTER TO OPERATE THE BACK DRIVERS SIDE GLASS SHATTERED. SOUNDED LIKE A BULLET/ROCK HIT WINDOW BUT IMPOSSIBLE DUE TO DIRECTION OF WINDOW AS IT WAS FACING THE BACK OF THE GARAGE. SEEMED ODD BUT WHEN I INVESTIGATED THROUGH MY DEALERSHIP TH…

Read full complaint

INTERMITTENT REAR DEFROSTER ON OCCASION. WHILE SITTING IN DRIVEWAY ATTEMPTING TO GET REAR DEFROSTER TO OPERATE THE BACK DRIVERS SIDE GLASS SHATTERED. SOUNDED LIKE A BULLET/ROCK HIT WINDOW BUT IMPOSSIBLE DUE TO DIRECTION OF WINDOW AS IT WAS FACING THE BACK OF THE GARAGE. SEEMED ODD BUT WHEN I INVESTIGATED THROUGH MY DEALERSHIP THEY CLAIMED TO HAVE HEARD OF THE REAR DEFROSTER CAUSING THIS BUT BECAUSE IT WAS GLASS AND NOT COVERED TO CONTACT FORD. I CONTACTED FORD AND THEY ADVISED ME THAT NO RECORDS OF ANYTHING LIKE THIS WERE ON FILE AND THAT THERE WAS NO WAY TO PROVE THAT THE WINDOW WAS BROKEN BY THE DEFROSTER THUS IT WAS NOT COVERED BY MY WARRANTY OR EXTENDED WARRANTY. SINCE THIS IS A POWER THREE GLASS WINDOW WITH DEFROSTER IT WILL NEED FULL REPLACEMENT AT A COST OF OVER $1000 WITH NO GUARANTEE IT WILL NOT HAPPEN AGAIN.

NHTSA ODI #10918146

Mileage unknown · Sep 2, 2016
Electrical SystemElectronic Stability Control (esc)Engine

I BOUGHT MY TRUCK NEW FROM THE DEALER 2013. I'M CONSISTENT WITH ALL THE UP KEEPS OF MY TRUCK. HOWEVER, MID AUGUST 2016, I NOTICED THE TRUCK HESITATED TO START AT THE BEGINNING WHILE IN STATIONARY POSITION FOR A FEW DAYS, THEN OUT OF NOWHERE FROM ONE DAY TO THE NEXT, THE ENGINE DIDN'T START IN THE MORNING AGAIN WHILE IN STATION…

Read full complaint

I BOUGHT MY TRUCK NEW FROM THE DEALER 2013. I'M CONSISTENT WITH ALL THE UP KEEPS OF MY TRUCK. HOWEVER, MID AUGUST 2016, I NOTICED THE TRUCK HESITATED TO START AT THE BEGINNING WHILE IN STATIONARY POSITION FOR A FEW DAYS, THEN OUT OF NOWHERE FROM ONE DAY TO THE NEXT, THE ENGINE DIDN'T START IN THE MORNING AGAIN WHILE IN STATIONARY POSITION AND THEN THE ENGINE LIGHT CAME UP! I BOUGHT A NEW BATTERY THINKING THAT MAYBE IT NEEDED TO BE REPLACED, EVEN WITH THE NEW BATTERY THE TRUCK FAILED TO START IN STATIONARY. AFTER THAT, I TRIED STARTING MY TRUCK FOR TWO CONSECUTIVE DAYS, BY THE THIRD DAY THE TRUCK STARTED! I DROVE IT IMMEDIATELY TO AUTOZONE BUT NOTHING CAME UP WRONG WITH IT? SO, I DROVE IT BACK HOME. A WEEK LATER, I HAD NO PROBLEMS WITH THE TRUCK, LIKE NOTHING EVER HAPPEN. THEN, YESTERDAY ALL OF A SUDDEN I WAS DRIVING HOME, WHILE IN MOTION THE ENGINE DIED IN THE MIDDLE OF TRAFFIC ON A CITY STREET, SO I PULLED OVER TO THE SIDE OF THE ROAD AND IMMEDIATELY ATTEMPTED TO RESTART THE TRUCK AS IT CONTINUED TO HESITATE. FINALLY, AFTER 10 MINUTES THE TRUCK STARTED AND I DROVE TO AUTOZONE AND AGAIN NOTHING CAME UP WRONG WITH IT. SO I DROVE IT BACK HOME. THEN, TODAY, WHICH IS SEPTEMBER 2, 2016 WHILE THE TRUCK IS STATIONARY IT FAILED TO START AND THE ENGINE LIGHT, CAME UP AGAIN. SOMETHING IS WRONG WITH THIS TRUCK! I DON'T FEEL SAFE TO DRIVE IN FEAR THAT MY TRUCK WILL STOP WORKING WHILE IN MOTION AND CAUSE AN ACCIDENT. I CAN GET STRANDED ANYWHERE AT ANYTIME.

NHTSA ODI #10903403

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of