← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Electrical System complaints

322 reports
Clear category filter
50,000 miles · Jun 18, 2019
Electrical SystemElectronic Stability Control (esc)Engine

I WAS DRIVING ON THE FREEWAY IN THE FAST LANE. SUDDENLY THE WRENCH WARNING LIGHT AND CHECK ENGINE LIGHT CAME ON, AND THE CAR EXPERIENCED WHAT APPEARED TO BE A TOTAL LOSS OF ENGINE POWER. I PLACED THE HAZARD LIGHTS ON AND WAS ABLE TO NAVIGATE TO THE SHOULDER, WITH 18 WHEELERS AND OTHER CARS TRYING TO REACT TO MY SUDDEN LOSS OF …

Read full complaint

I WAS DRIVING ON THE FREEWAY IN THE FAST LANE. SUDDENLY THE WRENCH WARNING LIGHT AND CHECK ENGINE LIGHT CAME ON, AND THE CAR EXPERIENCED WHAT APPEARED TO BE A TOTAL LOSS OF ENGINE POWER. I PLACED THE HAZARD LIGHTS ON AND WAS ABLE TO NAVIGATE TO THE SHOULDER, WITH 18 WHEELERS AND OTHER CARS TRYING TO REACT TO MY SUDDEN LOSS OF POWER AND SPEED. AFTER TURNING THE CAR OFF, AND RESTARTING IT, IT APPEARS OK TO PROCEED. THIS SAME INCIDENT HAS HAPPENED NOW 8 TIMES IN THE LAST FEW DAYS. I TOOK THE CAR INTO FORD AND THEY ARE CLAIMING IT'S AN ISSUE WITH THE THROTTLE BODY. I MENTIONED THAT I SEE A THROTTLE BODY RECALL FOR 2015-2016 F-150'S, BUT FORD IS DENYING THE ISSUE, INDICATING THERE IS NO RECALL FOR MY 2013. I FIND MANY COMPLAINTS IDENTICAL TO MINE FOR F-150'S EARLIER THAN 2015. THEY ALSO CLAIM FORD DENIES THE ISSUE AND REFUSES TO FIX THE PROBLEM. MOST ALSO REFERENCE CONCERN FOR A SIGNIFICANT SAFETY ISSUE, FEELING THAT FORD WILL ONLY FIX THIS ONCE PEOPLE DIE. I TOOK MY F-150 TO THE LOCAL FORD DEALER TODAY AND THEY VERIFIED IT WAS THE THROTTLE BODY, AND ARE CHARGING ME $650 TO FIX IT. I HAVE READ FROM OTHERS THAT THE COMPONENT USED TO FIX THE PROBLEM IS THE ORIGINAL FAULTY COMPONENT, SO THERE IS NO REASON TO FEEL THAT THE PROBLEM WILL NOT HAPPEN AGAIN EVENTUALLY. I HAVE EXPERIENCED FOUR TIMES ON THE FREEWAY AT 65MPH, AND SEVERAL TIMES ON CITY STREETS AT 30MPH. I WAS DRIVING STRAIGHT, NOT BRAKING.

NHTSA ODI #11221049

Mileage unknown · Jun 14, 2019
Electrical SystemPower TrainUnknown Or Other

I RECEIVED NOTICE OF RECALL TO SCHEDULE REPAIR (SOFTWARE) UPGRADE. I CONTACTED THE DEALER SEVERAL TIMES TO ONLY BE TOLD TO KEEP CALLING BACK TO SEE IF THEY HAVE RECEIVED THE SOFTWARE UPGRADE FROM FORD. THEY SAID THERE IS NO PROBLEM WITH CONTINUING TO DRIVE THE TRUCK UNTIL THE PROBLEM IS REPAIRED.

NHTSA ODI #11220038

58,000 miles · Jun 13, 2019
Electrical SystemPower TrainCrash

I WAS ON MY WAY TO WORK AS A FIREFIGHTER FOR MY SHIFT WHEN WITH NO WARNING MY TRUCK WENT FROM HIGH GEAR STRAIGHT DOWN TO FIRST GEAR THEN TO PARK CAUSING SUDDEN STOP AND A MINOR ACCIDENT ON I275 CINCINNATTI THEN COMING HOME IT INSTANTLY WENT INTO PARK ON US ROUTE 50 CAUSING MY TRUCK TO GO OUT OF CONTROL AND SWERVED OVER INTO T…

Read full complaint

I WAS ON MY WAY TO WORK AS A FIREFIGHTER FOR MY SHIFT WHEN WITH NO WARNING MY TRUCK WENT FROM HIGH GEAR STRAIGHT DOWN TO FIRST GEAR THEN TO PARK CAUSING SUDDEN STOP AND A MINOR ACCIDENT ON I275 CINCINNATTI THEN COMING HOME IT INSTANTLY WENT INTO PARK ON US ROUTE 50 CAUSING MY TRUCK TO GO OUT OF CONTROL AND SWERVED OVER INTO THE ONCOMING LANE ALMOST HITTING SOMEONE HEAD ON THEN COULD NOT MOVE THE TRUCK AS IT WAS STUCK IN PARK SITTING SIDEWAYS BETWEEN BOTH LANES I FINALLY WAS ABLE TO GET IT TO MOVE AGAIN BUT IT BARELY MOVED AS IT WAS IN HIGH GEAR STUCK THERE. I WAS ABLE TO BARELY REMOVE IT FROM THE ROAD AND HAD TO HAVE A TOW TRUCK RETRIEVE IT AND BRING IT TO MY HOUSE THIS IS A REAL SAFETY ISSUE THAT FORD IS NOT IN A HURRY TO FIX ON A RECALL ISSUE ON THE TRANSMISSIONS THEREFORE LEAVING ME WITHOUT A TRUCK OR VEHICLE TO DRIVE ALMOST HAD A SERIOUS CRASH TWICE NOW. PLUS MY TRANSMISSION IS COMPLETELY OUT OF MY TRUCK NOW NO MOVEMENT FOR ANY LOADING ETC.

NHTSA ODI #11219855

66,287 miles · Jun 11, 2019
Electrical SystemEngine

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING 65 MPH, THE VEHICLE LOST POWER AND STALLED. THE VEHICLE WAS ABLE TO RESTART AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO GIRARD FORD (450 W THAMES ST, NORWICH, CT 06360, (860) 889-2601) WHERE IT WAS DIAGNOSED THAT THE FUSE WAS MELTED AND NEEDED TO BE …

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING 65 MPH, THE VEHICLE LOST POWER AND STALLED. THE VEHICLE WAS ABLE TO RESTART AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO GIRARD FORD (450 W THAMES ST, NORWICH, CT 06360, (860) 889-2601) WHERE IT WAS DIAGNOSED THAT THE FUSE WAS MELTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE CONTACT STATED THAT THE VEHICLE WAS COVERED BY NHTSA ID NUMBER: 10074713/MANUFACTURER COMMUNICATION NUMBER: 15-0137 (ENGINE). THE FAILURE MILEAGE WAS 66,287.

NHTSA ODI #11219342

66,200 miles · Jun 11, 2019
Electrical SystemFuel/propulsion System

WHILE DRIVING ON MAJOR HIGHWAY I LOST POWER TO MY 2013 F150 6.2L. I HAD A TRACTOR TRAILER ON MY RIGHT SIDE AND A JERK TAILGATING ME. I FINALLY MANAGED TO GET THE VEHICLE TO THE BREAKDOWN LANE. I REALLY THOUGHT I WAS GOING TO BE IN A MAJOR ACCIDENT.

NHTSA ODI #11219340

Mileage unknown · Jun 3, 2019
Electrical System

2013 FORD F150. CONSUMER WRITES IN REGARDS TO DEFECTIVE KEY IN IGNITION WARNING CHIME. *LD THE CONSUMER STATED THE IGNITION WARNING WOULD NOT ALERT THAT THEY KEY WAS LEFT IN THE IGNITION ONCE THE DOOR HAS OPENED, WHILE THE ENGINE WAS RUNNING. THE CONSUMER SUGGEST AN ALERT FOR DRIVERS TO REMEMBER TO TURN ON HEADLIGHTS AND TO R…

Read full complaint

2013 FORD F150. CONSUMER WRITES IN REGARDS TO DEFECTIVE KEY IN IGNITION WARNING CHIME. *LD THE CONSUMER STATED THE IGNITION WARNING WOULD NOT ALERT THAT THEY KEY WAS LEFT IN THE IGNITION ONCE THE DOOR HAS OPENED, WHILE THE ENGINE WAS RUNNING. THE CONSUMER SUGGEST AN ALERT FOR DRIVERS TO REMEMBER TO TURN ON HEADLIGHTS AND TO REPEAL RIGHT TURN ON RED LAW. *JS

NHTSA ODI #11209874

70,350 miles · Jun 2, 2019
Electrical SystemEnginePower Train

I HAVE FILE WITH YOU ABOUT THIS BEFORE AND IT HAS BEEN A RECALL FOR THIS PROBLEM BUT THE FORD COMPANY HAS NOT TAKEN CARE OF THIS PROBLEM NOR HAVE THEY TAKEN CARE OF A SECOND RECALL FOR ANOTHER PROBLEM WITH THIS TRUCK BOTH OF THESE PROBLEMS TOGETHER HAVE ALMOST CAUSE 3 VERY NEAR ACCIDENTS FOR ME THE MOST RECENT I WAS PULLING A TR…

Read full complaint

I HAVE FILE WITH YOU ABOUT THIS BEFORE AND IT HAS BEEN A RECALL FOR THIS PROBLEM BUT THE FORD COMPANY HAS NOT TAKEN CARE OF THIS PROBLEM NOR HAVE THEY TAKEN CARE OF A SECOND RECALL FOR ANOTHER PROBLEM WITH THIS TRUCK BOTH OF THESE PROBLEMS TOGETHER HAVE ALMOST CAUSE 3 VERY NEAR ACCIDENTS FOR ME THE MOST RECENT I WAS PULLING A TRAILER AND ENTERING AND ON RAMP TO INTERSTATE I-94 ON ENTERING AS NORMAL I TRIED TO EXHILARATE TO HIGHWAY SPEED WHEN ALL OF A SUDDEN ALL POWER TO THE DRIVE TRAIN STOPPED AND THE TRUCK WENT INTO A NATURAL MODE (LIKE PUSHING THE CLUTCH IN ON A STANDARD SHIFT TRANSMISSION) AT THAT POINT I WAS IN THE DRIVE LANE RIGHT SIDE BUT 2 SEMIS ONE PASSING THE OTHER WERE BARROWING DOWN ON ME I HAD TO CUT SHARPLY TO THE RIGHT AND OFF THE SHOULDER OF THE HIGHWAY TO KEEP FROM BEING HIT BUY ONE OF THE SEMI'S THE FORD COMPANY STATED THEY WOULD HAVE THE PARTS AND THE SOFT WEAR TO FIX THIS PROBLEM BY THE 2ND QUARTER OF 2019 IT IS NOW THE SECOND HALF AND THE PROBLEM CONTINUES TO GET WORSE IT NOW CLUCKS WHEN SHIFTING UP FROM 3 TO 4 AND SOMETIMES DOWN SHIFTING AND WHEN TAKEN YOUR FOOT OFF THE GAS PEDAL FOR A FEW SECONDS THEN THEN PUSH ON THE GAS PEDAL AGAIN THE TRANS WILL CLUNK AGAIN WHEN I TEST DROVE THIS TRUCK BEFORE I BOUGHT IT I TOLD THEM THERE WAS SOMETHING WRONG WITH THE DRIVETRAIN AND THEY TOLD ME THERE WAS NOTHING WRONG WITH IT THAT I NEEDED TO LEARN HOW TO DRIVE A SIX SPEED TRANSMISSION THE THING ABOUT THAT AND THEY DON'T KNOW ME BEFORE I RETIRED I WAS THE FLOOR AND OPERATIONS MANAGER FOR THE COMMUNITY GARAGE OF BATTLE CREEK MICH. I HAVE HAD THIS TRUCK IN TO THEM 2 DIFFERENT TIMES AND 2 DIFFERENT DEALERSHIPS PLUS I.VE TAKEN IT IN 3 OTHER TIMES BUT AFTER MAKING AND APPOINTMENT AND TELLING THEM I WOULD NEED A LONER WHICH THE WARRANTY COVERS THEN WHEN I GET THERE NO LONER PLUS I WOULD HAVE TO PAY A $100 FEE ON THE WARRANTY FOR THE THING THEY NEVER FIXED (19V-075)

NHTSA ODI #11217432

72,000 miles · May 22, 2019
Electrical SystemPower TrainVehicle Speed Control

I RECEIVED MY FORD RECALL NOTICE ON THE NEED TO REPROGRAM POWER TRAIN MODULE ON OR ABOUT APRIL 1ST 2019. MY FIRST INSTANCE OF MY 2013 F150 STX SUPERCAB, GOING INTO SUDDEN DOWNSHIFT MODE AND THEN LIMP MODE (BLUE WRENCH SIGNAL) OCCURRED AROUND APRIL 12, 2019. I WAS DRIVING AT ABOUT 30 MILES AN HOUR ON A CITY STREET WHEN MY TRU…

Read full complaint

I RECEIVED MY FORD RECALL NOTICE ON THE NEED TO REPROGRAM POWER TRAIN MODULE ON OR ABOUT APRIL 1ST 2019. MY FIRST INSTANCE OF MY 2013 F150 STX SUPERCAB, GOING INTO SUDDEN DOWNSHIFT MODE AND THEN LIMP MODE (BLUE WRENCH SIGNAL) OCCURRED AROUND APRIL 12, 2019. I WAS DRIVING AT ABOUT 30 MILES AN HOUR ON A CITY STREET WHEN MY TRUCK WHEN THE TRUCK DOWNSHIFTED BY ITSELF AND THE BLUE WRENCH LIGHT APPEARED. MY TRUCK WENT INTO LIMP MODE AND I WAS UNABLE TO DRIVE. AFTER PULLING OVER TO THE SIDE OF THE STREET, I TURNED OFF MY TRUCK, WAITED A FEW MINUTES AND THEN THE ISSUE RESOLVED ITSELF. I TOOK MY VEHICLE INTO THE FORD DEALERSHIP ON APRIL 18, 2019 WHERE RECALL 19S07 6R80 (REPROGRAM POWER TRAIN MODULE) WORK WAS COMPLETED. ON MAY 17, 2019, WHILE DRIVING ABOUT 30 MILES AN HOUR ON A CITY STREET (WITHOUT NOTICE OR CAUSE) MY TRUCK AGAIN WENT INTO DOWNSHIFT MODE, LIMP MODE AND THE BLUE WRENCH LIGHT CAME ON. SAME AS THE FIRST INSTANCE, I PULLED OVER TO THE SIDE OF THE STREET, TURNED OFF MY TRUCK, WAITED A FEW MINUTES AND WHEN I TURNED ON THE TRUCK AGAIN THE ISSUE WAS RESOLVED. IT WAS CLEAR THAT THIS ISSUE WAS ELECTRICAL AND NO MECHANICAL AND THE ORIGINAL RECALL WORK COMPLETED BY THE DEALERSHIP DID NOT RESOLVE THE ISSUE. ON 05/19/2019, I AGAIN TOOK MY TRUCK TO THE FORD DEALERSHIP WHERE THIS TIME THE MODULE LEAD FRAME WAS REPLACED AFTER CODE P0722 WAS IDENTIFIED. I WANT THE RECORD TO REFLECT THAT THE FIRST RECALL, REPROGRAMMING OF THE POWER TRAIN MODULE DID NOT WORK, AND LEFT ME AT RISK OF A SECOND DOWNSHIFTING INCIDENT OCCURRING. MY TRUCK HAD A SECOND INCIDENT AND AFTER RETURNING TO THE DEALERSHIP A SECOND TIME THE LEADFRAME WAS REPLACED. I ALSO WANT TO NOTE THAT THE DEALERSHIP'S DATA THAT THE ORIGINAL RECALL WORK WAS COMPLETED ON 04/26/2019 IS INACCURATE. THE ORIGINAL RECALL WORK WAS PERFORMED BY THE DEALERSHIP ON 04/18/2019.

NHTSA ODI #11209277

73,160 miles · May 20, 2019
Electrical System

MY REAR SLIDING WINDOW DEFROST STOPPED WORKING AND THE INDICATOR LIGHT DID NOT COME ON. I DROVE THE TRUCK ON A COUNTY ROAD (55 MPH) ABOUT 5 MILES( 10 MINUTES) AND I LOOKED IN THE REARVIEW MIRROR AND SAW SMOKE COMING OUT FROM BEHIND THE PASSENGER SIDE HEADREST AGAINST THE GLASS. A FEW SECONDS LATER I HEARD A LOUD POP AND THE RIGH…

Read full complaint

MY REAR SLIDING WINDOW DEFROST STOPPED WORKING AND THE INDICATOR LIGHT DID NOT COME ON. I DROVE THE TRUCK ON A COUNTY ROAD (55 MPH) ABOUT 5 MILES( 10 MINUTES) AND I LOOKED IN THE REARVIEW MIRROR AND SAW SMOKE COMING OUT FROM BEHIND THE PASSENGER SIDE HEADREST AGAINST THE GLASS. A FEW SECONDS LATER I HEARD A LOUD POP AND THE RIGHT SIDE REAR WINDOW PANE SHATTERED. I WAS ABLE TO SAFELY PULL TO THE SIDE OF THE ROAD AND I PULLED THE RELAY FUSE FOR THE WINDOW DEFROST. THE GLASS STAYED INTACT EXCEPT FOR A FEW SHARDS OF GLASS THAT I FOUND ON THE SEAT.

NHTSA ODI #11208833

102,000 miles · May 17, 2019
Electrical SystemFuel/propulsion System

MY TRUCK FAILED TO START, AND WHEN I INVESTIGATED THE ISSUE I FOUND FUSE 27 (LOCATED IN THE BATTERY JUNCTION BOX AT THE FRONT OF THE ENGINE BAY) MELTED CAUSING CIRCUIT FOR THE FUEL PUMP TO OPEN WHICH LEFT THE TRUCK WITHOUT A FUNCTIONING FUEL SYSTEM (FUSE 27 IS PART OF THE CIRCUIT FOR THE FUEL PUMP). REPLACING THE DAMAGED FUSE RE…

Read full complaint

MY TRUCK FAILED TO START, AND WHEN I INVESTIGATED THE ISSUE I FOUND FUSE 27 (LOCATED IN THE BATTERY JUNCTION BOX AT THE FRONT OF THE ENGINE BAY) MELTED CAUSING CIRCUIT FOR THE FUEL PUMP TO OPEN WHICH LEFT THE TRUCK WITHOUT A FUNCTIONING FUEL SYSTEM (FUSE 27 IS PART OF THE CIRCUIT FOR THE FUEL PUMP). REPLACING THE DAMAGED FUSE RESOLVED THE ISSUE WHILE A MORE ROBUST SOLUTION IS DETERMINED. IF THIS HAD HAPPENED DURING OPERATION THE VEHICLE WOULD HAVE LOST POWER, BEEN UNABLE TO STEER DUE TO AN ELECTRIC ASSISTED STEERING SYSTEM AND BECOME A HAZARD FOR OTHER VEHICLES WHILE PUTTING THE OCCUPANTS OF THE TRUCK, AND ANY VEHICLE THAT COLLIDES WITH IT, AT RISK FOR INJURY OR DEATH. FORD ISSUED A TECHNICAL SERVICE BULLETIN (TSB 15-0137), BUT THIS IS NOT COMMONLY KNOWN OUTSIDE OF VEHICLE-SPECIFIC SOCIAL MEDIA PLATFORMS ON THE INTERNET (HTTPS://WWW.FORD-TRUCKS.COM/FORUMS/1449733-TSB-15-0137-FUEL-PUMP-FUSE.HTML). FORD KNOWS ABOUT THE ISSUE AND THE CONSEQUENCES ARE OBVIOUS. THE FIX FORD RECOMMENDS IS INEXPENSIVE (UNDER $30 IN PARTS) AND NOT VERY TIME CONSUMING (0.6 FLAG HOURS).

NHTSA ODI #11208164

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of