IllustrationCONTROL SWITCH HAS A SHORTED IN IT BATTER LIGHT COME ON WHILE DRIVER LONG
2008 Ford F-150
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2008 Ford F-150 do not stand out strongly from the model-year median of 676.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-150 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
770–25K
5725–50K
5750–75K
4875–100K
53100–150K
28150K+
320 reports with mileage · 49 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 50 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
39 crash reports12 fire reports28 injury reports
What owners actually said
369 reportsWHEN I BRAKE THE ENGINE SOUNDS LIKE ITS RACING LOUDER AND LOUDER AND SEEMS LIKE I'M EXCELLERATING INSTEAD OF STOPPING. ITS VERY HARD TO STOP IN TIME AT A STOP SIGN AND I CAN'T. I ALMOST IT A CROSSING CAR.THIS PROBLEM HAPPENED SEVERAL TIMES WITH MYSELF AND ALSO WHEN MY HUSBAND DROVE THE TRUCK.WE TOOK IT TO A MECHANIC. THE SAME HA…
Read full complaint
WHEN I BRAKE THE ENGINE SOUNDS LIKE ITS RACING LOUDER AND LOUDER AND SEEMS LIKE I'M EXCELLERATING INSTEAD OF STOPPING. ITS VERY HARD TO STOP IN TIME AT A STOP SIGN AND I CAN'T. I ALMOST IT A CROSSING CAR.THIS PROBLEM HAPPENED SEVERAL TIMES WITH MYSELF AND ALSO WHEN MY HUSBAND DROVE THE TRUCK.WE TOOK IT TO A MECHANIC. THE SAME HAPPENED TO 2 MECHANICS AT THE SHOP ON TEST DRIVES. THEY HAVE A THEORY IT IS HAPPENING BECAUSE WHEN WE TAKE OUR FOOT OFF THE GAS PEDAL AND PUT IT ON THE BRAKE TO BRAKE WE ARE TOO CLOSE TO THE GAS PEDAL AND ARE UNKNOWINGLY PRESSING BOTH AT THE SAME TIME. I DIDN'T FEEL LIKE THAT WAS HAPPENING, BUT MAYBE IT WAS BEC NOW WHEN I BRAKE , I PLACE MY FOOT MUCH FURTHER FROM THE GAS PEDAL. I'VE HEARD THIS IS A COMMON PROBLEM IN TRUCKS, BUT I WASN'T WARNED AND I DON'T THINK THIS IS SAFE.
STEERING BINDS IN THE UPPER U-JOINT ON STEERING ROD. IT STARTED ON THE HIGHWAY. I DIDN'T WANT TO DRIVE IT ANYMORE THAN I HAVE TO IN FEAR OF DOING MORE DAMGGE TO IT.
2008 FORD F 150. CONSUMER WRITES IN REGARDS TO NON OPERATIONAL MIDDLE PASSENGER SEATBELT. CONSUMER IS ALSO SEEKING A REFUND FOR VEHICLE. *LD THE CONSUMER STATED THE DEALER KNOWINGLY SOLD THE VEHICLE WITH DEFECTIVE SEAT BELTS. *JS
TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE DRIVING 35 MPH, THE POWER STEERING FAILED. THERE WERE NO WARNING INDICATORS ILLUMINATED PRIOR TO THE FAILURE. THE VEHICLE WAS ABLE TO BE DRIVEN BACK TO THE CONTACT'S RESIDENCE. THE CONTACT CALLED MERCEDES-BENZ OF CALDWELL (230 BLOOMFIELD AVE, FAIRFIELD, NJ 07004, (973) 227-3600) AND …
Read full complaint
TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE DRIVING 35 MPH, THE POWER STEERING FAILED. THERE WERE NO WARNING INDICATORS ILLUMINATED PRIOR TO THE FAILURE. THE VEHICLE WAS ABLE TO BE DRIVEN BACK TO THE CONTACT'S RESIDENCE. THE CONTACT CALLED MERCEDES-BENZ OF CALDWELL (230 BLOOMFIELD AVE, FAIRFIELD, NJ 07004, (973) 227-3600) AND WAS ADVISED TO CALL BACK ON MARCH 19, 2018 TO INQUIRE ABOUT HAVING THE VEHICLE TOWED BACK TO THE DEALER FOR REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 30,000.
TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT THE SPARE WHEEL WAS RUSTED AND TRANSMISSION FLUID WAS LEAKING. IN ADDITION, THE TIRE PRESSURE INDICATOR WAS ILLUMINATED. THE CONTACT CALLED CHAPMAN FORD (1485 MANHEIM PIKE FRNT, LANCASTER, PA 17601) WHERE A SERVICE APPOINTMENT WAS SCHEDULED. THE VEHICLE WAS NOT DIAG…
Read full complaint
TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT THE SPARE WHEEL WAS RUSTED AND TRANSMISSION FLUID WAS LEAKING. IN ADDITION, THE TIRE PRESSURE INDICATOR WAS ILLUMINATED. THE CONTACT CALLED CHAPMAN FORD (1485 MANHEIM PIKE FRNT, LANCASTER, PA 17601) WHERE A SERVICE APPOINTMENT WAS SCHEDULED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 79,542. *TT *JS
TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE THE VEHICLE WAS PARKED, THE CONTACT ATTEMPTED TO START THE VEHICLE, BUT IT FAILED TO START. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE CONTACT WAS INFORMED THAT THE FUEL PUMP RELAY HOUSING AND COVER RUSTED THROUGH, WHICH CAUSED AN ELECTRICAL SHORT THAT MADE THE FUEL PUMP B…
Read full complaint
TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE THE VEHICLE WAS PARKED, THE CONTACT ATTEMPTED TO START THE VEHICLE, BUT IT FAILED TO START. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE CONTACT WAS INFORMED THAT THE FUEL PUMP RELAY HOUSING AND COVER RUSTED THROUGH, WHICH CAUSED AN ELECTRICAL SHORT THAT MADE THE FUEL PUMP BECOME INOPERABLE. THE VEHICLE WAS REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED CASE NUMBER: CAS [XXX]. THE APPROXIMATE FAILURE MILEAGE WAS 109,000. *TT INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
FUEL PUMP CONTROL MODULE FAILURE
OK WHEN I TURN MY STEERING WHEEL TO TURN IT STICKS AND HAVE ALMOST HIT OTHER CARS HAVE TO TURN WHEEL BACK LIKE THE POWER STEERING GOES OUT BUT MOSTLY AT LOW SPEEDS.. THIS IS VERY DANGEROUS .. I HAVE DONE SOME CHECKING AT IT APPEARS TO BE THE STEERING SHAFT U JOINTS FREEZE UP DUE TO LACK OF ABLE TO GREASE THEM AND BAD DESIGN MY T…
Read full complaint
OK WHEN I TURN MY STEERING WHEEL TO TURN IT STICKS AND HAVE ALMOST HIT OTHER CARS HAVE TO TURN WHEEL BACK LIKE THE POWER STEERING GOES OUT BUT MOSTLY AT LOW SPEEDS.. THIS IS VERY DANGEROUS .. I HAVE DONE SOME CHECKING AT IT APPEARS TO BE THE STEERING SHAFT U JOINTS FREEZE UP DUE TO LACK OF ABLE TO GREASE THEM AND BAD DESIGN MY TRUCK ONLY HAS 49,000 MILES ON IT AND SHOULD NOT HAVE THIS PROBLEM I SEE MANY HAVE HAD SAME ISSUE I THINK IT SHOULD BE RECALLED AND REPAIRED BY FORD FOR SAFETY BECAUSE STEERING STICKS WHEN TURNING .
TL* THE CONTACT OWNS A 2008 FORD F-150. ON SEVERAL OCCASIONS, WHILE DRIVING, THE FRONT PASSENGER SIDE MIRROR BLOCKED THE CONTACT'S VISION. THE CONTACT WAS CONCERNED THAT A PEDESTRIAN COULD BE INJURED DUE TO THE LACK OF VISIBILITY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE MIRROR WAS REPLACED WITH A SMALLER MIRRO…
Read full complaint
TL* THE CONTACT OWNS A 2008 FORD F-150. ON SEVERAL OCCASIONS, WHILE DRIVING, THE FRONT PASSENGER SIDE MIRROR BLOCKED THE CONTACT'S VISION. THE CONTACT WAS CONCERNED THAT A PEDESTRIAN COULD BE INJURED DUE TO THE LACK OF VISIBILITY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE MIRROR WAS REPLACED WITH A SMALLER MIRROR. THE VEHICLE WAS NOT DIAGNOSED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED AND ADVISED THE CONTACT TO CALL NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 10,000. THE VIN WAS UNAVAILABLE.
Official recalls
108V523000 · Engine And Engine Cooling
Oct 8, 2008
ROUSH IS RECALLING 213 MY 2007-2008 FORD F-150 TRUCKS ALTERED TO OPERATE USING LIQUID PROPANE INJECTION. THE HYDRO-CARBON PAPER AFFIXED TO THE INSIDE OF THE AIRBOX LID WITH ADHESIVE MAY BECOME DISLODGED DURING OPERATION.
Consequence & remedy
Consequence: THIS FAILURE MAY RESULT IN A LOSS OF PERFORMANCE, ILLUMINATION OF THE MALFUNCTION INDICATOR LAMP (MIL) AND, IN EXTREME CASES, A STALLING OF THE VEHICLE DURING OPERATION WITHOUT NOTICE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE AIRBOX LID WITH A NEW ONE THAT INCLUDES THE HYDRO-CARBON PAPER WHICH HAS BEEN AFFIXED USING AN ADHESIVE PROMOTER AND GREATER PRESSURE AS RECOMMENDED BY THE MANUFACTURER FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 21, 2008. OWNERS MAY CONTACT ROUSH AT 1-866-307-6788.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO