IllustrationCONSUMER TOOK VEHICLE IN FOR OIL CHANGE, AND MECHANIC POINTED OUT A HOLE INSIDE OF THE OIL PAN. FORD USED RECYCLEED OIL PANS. OIL PAN WAS LEAKING OUT OIL FROM UNDERNEATH. HE CONTACTED FORD AT THIS TIME THERE IS A SOLUTION.*AK THE GASKET AND THE OIL PAN FAILED DUE TO INCORRECT METAL USED BY MANUFACTURER. *YH
1994 Ford F-150
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1994 Ford F-150 do not stand out strongly from the model-year median of 676.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-150 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 132 of 676 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 139 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 94 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
60 crash reports101 fire reports43 injury reports
Engine And Engine Cooling complaints
52 reportsWHEN I TAKE OFF, IT SEEMS LIKE SOMETHING IS HOLDING ME BACK. I SUSPECT THIS IS RELATED TO CLOGGED EXHAUST OR BAD CATALYTIC CONVERTER
OIL PAN IS EXPERINCING SEVERE PROBLEM WITH RUST/CORROSION, CAUSING OIL LEAKAGES; DEALER/MANUFACTURER NOTIFIED, AND INFORMED CONSUMER THAT ITEM WAS NOT COVER UNDER A RECALL AND IT OUT OF WARRANTY. FEEL FREE TO PROVIDE FURTHER DETAILS. *AK
NO SUMMARY LISTED FOR ABOV EVEHICLE. *AK
DESIGN OF OIL PAN ,WHICH IS MADE WITH A LIGHTER SHEET OF METAL TO MAKE THE VEHICLE WEIGH LESS, CAUSES THE OIL PAN TO RUST THROUGH, AND HAVE AN OIL LEAK. THIS MAY RESULT IN A FIRE IF THERE WAS A SOURCE OF IGNITION. ALSO BRAKE PROPORTIONAL VALVE/DRUM ON PASSENGER'S SIDE/STARTER, AND ENGINE HEAD AND BLOCK RUSTED *AK
BRAKES : HYDRAULIC: DIFFERENTIAL PROPORTIONAL VALVE/ENGINE OIL PAN/STARTER MOTOR, AND ONE BRAKE DRUM HAVE RUSTED THROUGH DUE TO POOR METAL. MANUFACTURE IS AWARE OF DEFECT. *AK
TOOK VEHICLE IN FOR A NORMAL OIL CHANGE WAS TOLD BY THE MECHANIC OIL PAN NEEDED TO BE REPLACED. PAINT FALLING OFF OF OIL PAN, MAKING IT RUST FROM THE OUTSIDE IN. SMALL PIN HOLE IN PAN, CAUSING IT TO LEAK. *AK *ML
THE OIL PAN IS RUSTING THROUGH, AND REQUIRES REPLACEMENT. BY CALLING THE DEALERSHIP, ANOTHER REPAIR FACILITY, AND THROUGH ANNECDOTAL EVIDENCE, I HAVE LEARNED OF 13 OTHER 93-94 F150 TRUCKS (AS WELL AS SOME VANS OF THOSE MODEL YEARS) THAT HAVE HAD THEIR OIL PANS REPLACED THIS YEAR ALONE. I HAVE NEVER HAD AN OIL PAN RUST OUT BEFO…
Read full complaint
THE OIL PAN IS RUSTING THROUGH, AND REQUIRES REPLACEMENT. BY CALLING THE DEALERSHIP, ANOTHER REPAIR FACILITY, AND THROUGH ANNECDOTAL EVIDENCE, I HAVE LEARNED OF 13 OTHER 93-94 F150 TRUCKS (AS WELL AS SOME VANS OF THOSE MODEL YEARS) THAT HAVE HAD THEIR OIL PANS REPLACED THIS YEAR ALONE. I HAVE NEVER HAD AN OIL PAN RUST OUT BEFORE, SO THE EVIDENCE AT HAND LEADS ME TO BELIEVE THAT THERE IS AN OVERALL MANUFACTURING DEFECT. SAFETY ISSUE: I COULD LOOSE ALL OF MY OIL WITHOUT WARNING (THE RUSTY AREA IS BRITTLE & OOZING OIL), AND THE ENGINE COULD BE DESTROYED. *AK
FORD CLAIMS THAT THE ENGINE CAN LEAK 1QT/900 MILES UNDER NORMAL USE AND STILL BE WITHIN TOLLERANCES. THEY CLAIMED THIS WAS IN MY OWNERS MANUAL. IT IS NOT. IT IS IN A BOOK THEY KEEP IN THEIR OFFICE WHICH THE CONSUMER DOES NOT SEE. THIS KIND OF LEAKAGE IS UNACCEPTABLE!!!
WHEN DRIVING AND STOPPING AT A LIGHT AND PULLING OFF FROM THE LIGHT, THE VEHICLE LOSES ALL POWER AND DIES OUT. *AK
Official recalls
605V388000 · Vehicle Speed Control
Sep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A FIRE AT THE SWITCH COULD OCCUR.
Remedy: BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
96V064000 · Seats
Apr 16, 1996
THE WIRE HARNESS FOR THE POWER LUMBAR FEATURE ON THE SEAT IS UNDERNEATH THE FRONT SEAT CUSHION SUPPORT WIRES. THE SUPPORT WIRES ON THE DRIVER SEAT CAN CONTACT AND DAMAGE THE INSULATION HARNESS RESULTING IN A HIGH RESISTANCE ELECTRICAL SHORT THROUGH THE SUPPORT WIRES.
Consequence & remedy
Consequence: CONSEQUENCE OF DEFECT: OVER HEATING OF THE SUPPORT WIRES COULD RESULT, AND MELTING, SMOKE, OR POSSIBLE IGNTION OF THE SURROUNDING MATERIALS COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE SEATS ON THE AFFECTED VEHICLES. IF NO DAMAGE IS FOUND, THE DRIVER SEAT WIRE HARNESS WILL BE COVERED WITH A PROTECTIVE CONVOLUTE TUBING, WRAPPED WITH ELECTRICAL TAPE AND THE HARNESS WILL BE REROUTED. IF DAMAGE IS FOUND, THE WIRE HARNESS WILL BE REPLACED.
94V169001 · Parking Brake:conventional
Sep 7, 1994
THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Consequence & remedy
Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.
94V018000 · Structure:body:bumpers
Jan 2, 1994
THE U-CLIP STYLE NUTS THAT RETAIN THE FRONT BUMPERS TO THE FRONT BUMPER INNER ARMS CAN FRACTURE.
Consequence & remedy
Consequence: IF ONE OF THE U-CLIP NUTS FRACTURES, THE BUMPER WILL LOOSEN AND RATTLE CAUSING FRACTURE OF THE REMAINING U-CLIP NUTS, RESULTING IN SEPARATION OF THE BUMPER FROM THE VEHICLE. IF THE BUMPER WERE TO DETACH FROM THE VEHICLE WHILE IT IS BEING DRIVEN, A VEHICLE COLLISION COULD RESULT.
Remedy: INSPECTION AND REPLACEMENT OF THE FOUR U-CLIP NUTS AND THE ASSOCIATED BOLTS.
93V184000 · Air Bags
Nov 10, 1993
THESE VEHICLES WERE BUILT WITH NONFUNCTIONAL AIR BAG DIAGNOSTIC MODULES INTENDED FOR CERTAIN VEHICLES OVER 8,500 BLS. GVWR.
Consequence & remedy
Consequence: THE AIR BAG SUPPLEMENTAL RESTRAINT AND THE AIR BAGWARNING LIGHT WILL NOT FUNCTION. THIS COULD RESULT IN REDUCED OCCUPANTPROTECTION IN THE EVENT OF A COLLISION THAT SHOULD ACTIVATE THE AIR BAGSUPPLEMENTAL RESTRAINT SYSTEM.
Remedy: DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, INSTALL THE CORRECT AIR BAG DIAGNOSTIC MODULE.
93V155000 · Air Bags
Sep 24, 1993
THE DESIGN OF THE AIR BAG DIAGNOSTIC MONITOR CAUSES THE DRIVER'S SIDE AIR BAG TO DEPLOY WHEN THE PASSENGER DOOR IS SLAMMED WHILE THE IGNITION KEY IS TURNED TO THE START POSITION.
Consequence & remedy
Consequence: INADVERTENT DEPLOYMENT OF THE AIR BAG CAN RESULT ININJURY TO THE DRIVER.
Remedy: INSTALL A REDESIGNED AIR BAG DIAGNOSTIC MONITOR.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA05005 · Engine Compartment Fires
Opened Mar 22, 2005 · Closed Aug 2, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:front Underhood; Vehicle Speed Control:cruise Control
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
Additional source detail variants (21)
Electrical System
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
Electrical System
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
Electrical System
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
Electrical System
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
Electrical System
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
Electrical System
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
Electrical System
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
Electrical System:wiring:front Underhood
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
Electrical System:wiring:front Underhood
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
Electrical System:wiring:front Underhood
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
Electrical System:wiring:front Underhood
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
Electrical System:wiring:front Underhood
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
Electrical System:wiring:front Underhood
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
Electrical System:wiring:front Underhood
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
Vehicle Speed Control:cruise Control
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
Vehicle Speed Control:cruise Control
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
Vehicle Speed Control:cruise Control
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
Vehicle Speed Control:cruise Control
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
Vehicle Speed Control:cruise Control
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
Vehicle Speed Control:cruise Control
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
Vehicle Speed Control:cruise Control
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
RQ98006 · Inadvertent Air Bag Deployment
Opened Mar 18, 1998 · Closed Aug 15, 2000
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available