The contact owns a 1993 Ford F-150. The contact became aware that the VIN was included in NHTSA Campaign Number: 05V017000 (Vehicle Speed Control); however, the part to do the recall repair was not yet available. The contact stated that while replacing the brake master cylinder, the contact noticed that there was brake fluid lea…
Read full complaint
The contact owns a 1993 Ford F-150. The contact became aware that the VIN was included in NHTSA Campaign Number: 05V017000 (Vehicle Speed Control); however, the part to do the recall repair was not yet available. The contact stated that while replacing the brake master cylinder, the contact noticed that there was brake fluid leaking onto a connector. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and contacted the dealer. The failure mileage was approximately 156,000. Parts distribution disconnect.
NHTSA ODI #11613783
360,000 miles · Jun 24, 2024
Fuel System, GasolineVehicle Speed Control
The contact owns a 1993 Ford F-150. The contact became aware that the VIN was included in NHTSA Campaign Numbers: 00V424000 (Fuel System, Gasoline) and 05V017000 (Vehicle Speed Control); however, the parts to do the recall repairs were not yet available. The contact stated that while inspecting the fuel tanks, he noticed that fu…
Read full complaint
The contact owns a 1993 Ford F-150. The contact became aware that the VIN was included in NHTSA Campaign Numbers: 00V424000 (Fuel System, Gasoline) and 05V017000 (Vehicle Speed Control); however, the parts to do the recall repairs were not yet available. The contact stated that while inspecting the fuel tanks, he noticed that fuel had transferred from one tank to the other, nearly causing the tank to overfill. The local dealer was contacted and advised the contact that the vehicle was not covered under the recalls because the VIN was not included; however, the VIN tool indicated that the VIN was included. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and advised the contact that the VIN was not included in the recalls due to the manufactured date of the vehicle. The failure mileage was approximately 360,000. Parts distribution disconnect.
NHTSA ODI #11596212
180,000 miles · Mar 15, 2010
Vehicle Speed Control
TL*THE CONTACT OWNS A 1993 FORD F150. WHILE DRIVING APPROXIMATELY 65 MPH THE CONTACT ATTEMPTED TO ACTIVATE THE CRUISE CONTROL AND NOTICED THAT IT FAILED TO ENGAGED . PRIOR TO THE RECENT FAILURE THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHERE NHTSA CAMPAIGN ID NUMBER 08V051000 (VEHICLE SPEED CONTROL: CRUISE CONTROL) WAS PERFORMED…
Read full complaint
TL*THE CONTACT OWNS A 1993 FORD F150. WHILE DRIVING APPROXIMATELY 65 MPH THE CONTACT ATTEMPTED TO ACTIVATE THE CRUISE CONTROL AND NOTICED THAT IT FAILED TO ENGAGED . PRIOR TO THE RECENT FAILURE THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHERE NHTSA CAMPAIGN ID NUMBER 08V051000 (VEHICLE SPEED CONTROL: CRUISE CONTROL) WAS PERFORMED ON THE VEHICLE. THE CONTACT STATED THAT THE CRUISE CONTROL OPERATED PROPERLY BEFORE THE RECALL SERVICE REPAIR. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT NO FAILURES COULD BE FOUND. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS 180,000. UPDATED 4/26/10 *CN UPDATED 05/06/10. *JB
NHTSA ODI #10319924
Mileage unknown · Mar 24, 2008
Vehicle Speed Control
TL*THE CONTACT OWNS A 1993 FORD F150. THE CONTACT RECEIVED A SAFETY RECALL NOTICE IN AUGUST OF 2007 FOR THE VEHICLE SPEED CONTROL. HE CALLED FORD EVERY MONTH THEREAFTER AND WAS INFORMED THAT THE PART WOULD BE AVAILABLE THE FOLLOWING MONTH. THE CURRENT MILEAGE WAS 132,000. UPDATED 04/16/08. *LJ
NHTSA ODI #10222117
Mileage unknown · Mar 18, 2008
Vehicle Speed Control
FAX FROM SENATOR ON BEHALF OF CONSTITUENT RE PROBLEMS WITH FORD VEHICLE CRUISE CONTROL FIRES. *KB THE CONSUMER RECEIVED A RECALL NOTICE FOR HIS 1993 FORD F150 IN AUGUST 2007. THE CONSUMER HAS BEEN UNABLE TO GET THE PROBLEM FIXED, DUE TO LACK OF PARTS. *JB
NHTSA ODI #10221688
Mileage unknown · Mar 3, 2008
Vehicle Speed Control
TL*THE CONTACT OWNS A 1993 FORD F150. THE CONTACT RECEIVED A RECALL NOTICE FOR THE VEHICLE SPEED CONTROL: CRUISE CONTROL. HE WAS INFORMED THAT THE PARTS FOR THE RECALL REPAIR WILL BE UNAVAILABLE UNTIL JUNE OF 2008. THERE HAD BEEN NO FAILURE TO DATE. THE RECALL NUMBER WAS UNKNOWN. THE CURRENT MILEAGE WAS 64,500.
NHTSA ODI #10219946
Mileage unknown · Feb 26, 2008
Vehicle Speed Control
TL*THE CONTACT OWNS A 1993 FORD F150. THE CONTACT RECEIVED A FORD RECALL NOTICE (05S28) IN AUGUST OF 2007 FOR THE VEHICLE SPEED CONTROL. HE STATED THAT THE REPAIR HAS EXCEEDED A REASONABLE AMOUNT OF TIME. THE DEALER STATED THAT THE PART WAS UNAVAILABLE AND DID NOT KNOW WHEN IT WOULD ARRIVE. THERE HAD BEEN NO FAILURE TO DATE.…
Read full complaint
TL*THE CONTACT OWNS A 1993 FORD F150. THE CONTACT RECEIVED A FORD RECALL NOTICE (05S28) IN AUGUST OF 2007 FOR THE VEHICLE SPEED CONTROL. HE STATED THAT THE REPAIR HAS EXCEEDED A REASONABLE AMOUNT OF TIME. THE DEALER STATED THAT THE PART WAS UNAVAILABLE AND DID NOT KNOW WHEN IT WOULD ARRIVE. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 163,385.
NHTSA ODI #10219166
Mileage unknown · Feb 25, 2008
Vehicle Speed Control
REF; FORD MOTOR CO. RECALL #08S01. THIS RECALL CONCERNS A FUSED JUMPER HARNESS THAT COULD CAUSE A FIRE EVEN IF THE MOTOR IS NOT RUNNING. THE DEALER SAYS THEY HAVE BEEN WAITING FOR THE PART TO CORRECT THIS SITUATION FOR A COUPLE OF MONTHS AND THEN DON'T EXPECT TO GET IT FOR ANOTHER COUPLE OF MONTHS. WHY DO THEY EVEN BOTHER ISSUIN…
Read full complaint
REF; FORD MOTOR CO. RECALL #08S01. THIS RECALL CONCERNS A FUSED JUMPER HARNESS THAT COULD CAUSE A FIRE EVEN IF THE MOTOR IS NOT RUNNING. THE DEALER SAYS THEY HAVE BEEN WAITING FOR THE PART TO CORRECT THIS SITUATION FOR A COUPLE OF MONTHS AND THEN DON'T EXPECT TO GET IT FOR ANOTHER COUPLE OF MONTHS. WHY DO THEY EVEN BOTHER ISSUING THE RECALL WHEN THE DEALERS CAN NOT GET THE PARTS NEEDED? *TR
NHTSA ODI #10219062
Mileage unknown · Feb 20, 2008
Vehicle Speed Control
1993 FORD F-150 SPEED CONTROL RECALL. CONSUMER STATES THAT THE DEALER KEEPS TELLING HIM THAT THE PARTS ARE NOT IN YET. *KB
NHTSA ODI #10219430
Mileage unknown · Jan 25, 2008
Vehicle Speed Control
LTR FROM CONGRESSMAN ON BEHALF OF CONSTITUENT WHO IS CONCERNED ABOUT THE LACK OF PARTS AVAILABLE FOR 1993 FORD F-150 SPEED CONTROL RECALL. *KB
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS AND CAB CHASSIS EQUIPPED WITH GASOLINE ENGINES AND DUAL FUEL TANKS. THE CARBON STEEL FUEL PRESSURE REGULATOR IN THE FUEL SYSTEM CAN WEAR OUT DURING THE LIFE OF THE VEHICLE. IF THE FUEL PRESSURE REGULATOR MALFUNCTIONS, IT CAN CAUSE HIGH FUEL SYSTEM PRESSURE, WHICH DAMAGES THE FUEL PUMP CHECK VALVE. THIS ALLOWS FUEL TO BE TRANSFERRED FROM ONE TANK TO THE OTHER, POSSIBLY OVERFILLING THE NON-OPERATING TANK, RESULTING IN FUEL OVERFLOW PAST THE FILLER CAP.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL HAVE A STAINLESS STEEL FUEL PRESSURE REGULATOR INSTALLED. OWNER NOTIFICATION BEGAN JULY 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332. (SEE PREVIOUS NHTSA RECALL 93V-125/FORD RECALL 93S68).
THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Consequence & remedy
Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.
THE U-CLIP STYLE NUTS THAT RETAIN THE FRONT BUMPERS TO THE FRONT BUMPER INNER ARMS CAN FRACTURE.
Consequence & remedy
Consequence: IF ONE OF THE U-CLIP NUTS FRACTURES, THE BUMPER WILL LOOSEN AND RATTLE CAUSING FRACTURE OF THE REMAINING U-CLIP NUTS, RESULTING IN SEPARATION OF THE BUMPER FROM THE VEHICLE. IF THE BUMPER WERE TO DETACH FROM THE VEHICLE WHILE IT IS BEING DRIVEN, A VEHICLE COLLISION COULD RESULT.
Remedy: INSPECTION AND REPLACEMENT OF THE FOUR U-CLIP NUTS AND THE ASSOCIATED BOLTS.
A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE.
Consequence & remedy
Consequence: SPILLED FUEL CAN RESULT IN A FIRE WHEN EXPOSED TO ASOURCE OF IGNITION.
Remedy: REPLACEMENT OF THE FUEL PRESSURE REGULATOR AND INSTALLATION OF REDUNDANT CHECK VALVES.
THE TRANSFER CASES HAVE BEEN BUILT WITH THE WRONG ELECTRIC SHIFT MOTOR. THE TRANSFER CASES CAN SLIP OUT OF THE 4 X 4 HIGH GEAR POSITION DURING COASTING IN FORWARD GEARS OR WITH POWER APPLIED IN REVERSE GEAR.
Consequence & remedy
Consequence: IF THIS OCCURS, THE VEHICLE CAN ROLL FREELY AS IF INNEUTRAL POSITION REGARDLESS OF THE TRANSMISSION GEAR SELECTOR POSITION. THIS CANRESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Remedy: REPLACE DEFECTIVE TRANSFER CASES WITH THE CORRECT VERSION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA99032 · Dual Fuel Tank Crossflow/leakage
Opened Nov 4, 1999 · Closed Dec 6, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Additional source detail variants (2)
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
THESE VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO A MALFUNCTIONING FUEL PUMP.FROM THE INFORMATION GATHERED TO DATE, IT APPEARS THAT THERE CAN BE MULTIPLE CAUSES AND/OR A COMBINATION OF CAUSES FOR FUEL CROSS FLOW AND THAT THE RECALL REMEDY MAY BE INADEQUATE.FURTHER INVESTIGATION IS NEEDED.THIS INVESTIGATION IS UPGRADED TO EA99-032.CLICK ON DOCUMENT SEARCH BUTTON FOR ADDITIONAL INFORMATION.
1993 Ford F-150 Problems, Complaints & Recalls | Skip That Year
Illustration