IllustrationWHEN TURNING ON AIR CONDITIONING SAW A PUFF OF SMOKE COME FROM VENTS WHERE AIR BLOWS THROUGH. THEN, SMELLED SOMETHING ELECTRICAL BURNING LIKE WIRES. NEXT THE WHOLE VEHICLE CAUGHT ON FIRE. VEHICLE WAS TOTALLED. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
1993 Ford F-150
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1993 Ford F-150 do not stand out strongly from the model-year median of 676.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-150 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 81 of 586 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 260 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 77 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
22 crash reports21 fire reports10 injury reports
Electrical System complaints
34 reportsWHEN STARTING VEHICLE FOR FIRST TIME IT WILL NOT START. CONSUMER WOULD HAVE TO TRY A FEW TIMES. ALSO, WHILE TRAVELING VEHICLE WOULD RUN OUT OF GAS DUE TO FUEL TRAVELING INTO 2ND TANK. *AK *SLC
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
DUE TO DESIGN OF CLUTCH PEDAL ASSEMBLY WHICH IS LOCATED UNDER DASH, CLIP ON ROD IS HELD BY BRACKETS WHICH ARE PLASTIC, AND THEY BROKE OFF, CAUSING VEHICLE NOT TO ENGAGE IN GEAR, WHICH MAY RESULT IN A CRASH. *AK THE LEVER USED TO MOVE THE SEAT FORWARD BROKE AT 70,000 MILES. THE CONSUMER STATES THAT THE CLUTCH SLAVE, T…
Read full complaint
DUE TO DESIGN OF CLUTCH PEDAL ASSEMBLY WHICH IS LOCATED UNDER DASH, CLIP ON ROD IS HELD BY BRACKETS WHICH ARE PLASTIC, AND THEY BROKE OFF, CAUSING VEHICLE NOT TO ENGAGE IN GEAR, WHICH MAY RESULT IN A CRASH. *AK THE LEVER USED TO MOVE THE SEAT FORWARD BROKE AT 70,000 MILES. THE CONSUMER STATES THAT THE CLUTCH SLAVE, THREE ALTERNATORS, POWER WINDOWS AND HEATER HAD BEEN REPLACED. *YH
KEY CAN BE REMOVED FROM IGNITION SWITCH WHILE VEHICLE IS RUNNING. PLEASE GIVE ANY FURTHER DETAILS.*AK
STALLS , LOSS OF POWER WHILE DRIVING AT 65 MPH DEALER TESTED AND UNABLE TO DUPLICATE
VEHICLE STALLS NO COMPUTER CODES INDICATING PROBLEMS
HEADLIGHT'S ARE WORKING INTERMITTENTLY DUE TO THE WIRE HARNESS WHICH HAS MELTED. *AK
ANYTIME TRUCK IS STARTED, UPON REACHING 20MPH THE TRUCK WONT ACCELERATE EVEN IF YOU FLOOR IT, AND THE ENGINE ACTS LIKE IT WANTS TO CUT OUT AND THEN SUDDENLY THE ENGING/TRANSMISSION ENGAGES AND ROCKETS FORWARD AND IF I'M NOT ON TOP OF THIS I COULD HIT SOMEONE, ESPECIALLY WHEN AT STOPLIGHTS WHILE THE TRUCK IS ACTING UP. ADDITION…
Read full complaint
ANYTIME TRUCK IS STARTED, UPON REACHING 20MPH THE TRUCK WONT ACCELERATE EVEN IF YOU FLOOR IT, AND THE ENGINE ACTS LIKE IT WANTS TO CUT OUT AND THEN SUDDENLY THE ENGING/TRANSMISSION ENGAGES AND ROCKETS FORWARD AND IF I'M NOT ON TOP OF THIS I COULD HIT SOMEONE, ESPECIALLY WHEN AT STOPLIGHTS WHILE THE TRUCK IS ACTING UP. ADDITIONALLY, I CAN REMOVE MY KEY FROM THE IGNITION WITHOUT TURNING THE IGNITION OFF, WITH THE TRUCK STILL RUNNING. IS THE IGNITION PROBLEM DANGEROUS?? I DEFINITELY KNOW THAT THE ENGINE HESITATION AND LURCH FORWARD IS VERY DANGEROUS, HOWEVER, THIS PROBLEM IS INTERMITTENT AND WILL NOT REPRODUCE ITSELF CONSISTENTLY, AND I THERFORE AM HAVING TROUBLE WITH MY MECHANIC DETERMINING WHAT NEEDS TO BE REPLACED (I REFUSE TO TAKE THE VEHICLE TO THE DEALERSHIP TO SPEND A LOT OF MONEY AND NOT GET THIS PROBLEM FIXED) AND AM MORE CONFIDENT IN MY OWN MECHANIC. IF YOU HAVE ANY DETAILS ON HOW TO FIX THIS PROBELM, PLEASE CALL ME AT ANY TIME AT THE LISTED PHONE #.
THE 4WHEEL DRIVE, U/JOINTS AND DRIVE TRAIN HAVE GONE OUT ON THE TRUCK 4 TIMES, THE ELECTRICAL SYSTEM HAS NEVER WORKED RIGHT FROM DAY ONE AND HAS BEEN TAKEN INTO DEALER SEVERAL TIMES WITH COMPLAINTS BUT NEVER FIXED (AUTOLOCKS ON DOORS AND WINDOWS DON'T WORK AFTER HEAVY RAIN OR WET, HEAVY SNOW STORM) THE LAST TIME THE 4WHEEL DRIV…
Read full complaint
THE 4WHEEL DRIVE, U/JOINTS AND DRIVE TRAIN HAVE GONE OUT ON THE TRUCK 4 TIMES, THE ELECTRICAL SYSTEM HAS NEVER WORKED RIGHT FROM DAY ONE AND HAS BEEN TAKEN INTO DEALER SEVERAL TIMES WITH COMPLAINTS BUT NEVER FIXED (AUTOLOCKS ON DOORS AND WINDOWS DON'T WORK AFTER HEAVY RAIN OR WET, HEAVY SNOW STORM) THE LAST TIME THE 4WHEEL DRIVE WENT OUT, THE FRONT DRIVERS WHEEL FLEW OFF THE TRUCK WHILE TRAVELING ON THE HIGHWAY. LUG NUTS AND POSTS WERE NOT LOOSE NOR SHEARED OFF. UPON CONTACTING FORD CUSTOMER SERVICE EACH TIME TRUCK TAKEN IN, HAVE BEEN TOLD THAT THERE HAVE BEEN "NO" RECALLS OF ANY TYPE ON OUR VEHICLE EXCEPT FOR ONE TO CHECK THE BOLTS ON THE FRONT BUMPER. THE FOLLOWING HAVE SHOWN OCCASSIONAL PROBLEMS SINCE 1993, BUT HAVE CONSISTENTLY BECOME WORSE WITH THE AGE/MILEAGE OF TRUCK: INTERMITTEN WIPERS DO NOT WORK, DIMMER LIGHT AND OTHER GAUGES DO NOT WORK IN DASH. THE TRANSMISSION HAS A LOT OF BACKLASH/KICK WHEN PUTTING INTO GEAR. THE IGNITION AND ALTERNATOR ARE CONSISTENTLY GETTING WORSE, SOMETIMES IT TAKES TURNING THE KEY UP TO TEN OR MORE TIMES TO GET THE TRUCK TO START. CURRENTLY, ONCE THE ENGINE GETS HOT, THE TRUCK SPITS AND SPUTTERS, ALMOST KILLING WHEN YOU SLOW DOWN AND THEN ATTEMPT TO ACCELERATE AGAIN. THE TRUCK RECENTLY HAD A COMPLETE TUNE-UP AND REPLACEMENT OF ALL PARTS WITH FORD AUTHORIZED PARTS.
Official recalls
708V051000 · Vehicle Speed Control:cruise Control
Feb 4, 2008
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
07V336000 · Vehicle Speed Control
Aug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
00V424000 · Fuel System, Gasoline:storage:tank Assembly
Dec 29, 2000
VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS AND CAB CHASSIS EQUIPPED WITH GASOLINE ENGINES AND DUAL FUEL TANKS. THE CARBON STEEL FUEL PRESSURE REGULATOR IN THE FUEL SYSTEM CAN WEAR OUT DURING THE LIFE OF THE VEHICLE. IF THE FUEL PRESSURE REGULATOR MALFUNCTIONS, IT CAN CAUSE HIGH FUEL SYSTEM PRESSURE, WHICH DAMAGES THE FUEL PUMP CHECK VALVE. THIS ALLOWS FUEL TO BE TRANSFERRED FROM ONE TANK TO THE OTHER, POSSIBLY OVERFILLING THE NON-OPERATING TANK, RESULTING IN FUEL OVERFLOW PAST THE FILLER CAP.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL HAVE A STAINLESS STEEL FUEL PRESSURE REGULATOR INSTALLED. OWNER NOTIFICATION BEGAN JULY 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332. (SEE PREVIOUS NHTSA RECALL 93V-125/FORD RECALL 93S68).
94V169001 · Parking Brake:conventional
Sep 7, 1994
THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Consequence & remedy
Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.
94V018000 · Structure:body:bumpers
Jan 2, 1994
THE U-CLIP STYLE NUTS THAT RETAIN THE FRONT BUMPERS TO THE FRONT BUMPER INNER ARMS CAN FRACTURE.
Consequence & remedy
Consequence: IF ONE OF THE U-CLIP NUTS FRACTURES, THE BUMPER WILL LOOSEN AND RATTLE CAUSING FRACTURE OF THE REMAINING U-CLIP NUTS, RESULTING IN SEPARATION OF THE BUMPER FROM THE VEHICLE. IF THE BUMPER WERE TO DETACH FROM THE VEHICLE WHILE IT IS BEING DRIVEN, A VEHICLE COLLISION COULD RESULT.
Remedy: INSPECTION AND REPLACEMENT OF THE FOUR U-CLIP NUTS AND THE ASSOCIATED BOLTS.
93V125000 · Fuel System, Gasoline:storage:tank Assembly
Aug 2, 1993
A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE.
Consequence & remedy
Consequence: SPILLED FUEL CAN RESULT IN A FIRE WHEN EXPOSED TO ASOURCE OF IGNITION.
Remedy: REPLACEMENT OF THE FUEL PRESSURE REGULATOR AND INSTALLATION OF REDUNDANT CHECK VALVES.
93V089000 · Power Train:transfer Case (4-WHEEL Drive)
May 17, 1993
THE TRANSFER CASES HAVE BEEN BUILT WITH THE WRONG ELECTRIC SHIFT MOTOR. THE TRANSFER CASES CAN SLIP OUT OF THE 4 X 4 HIGH GEAR POSITION DURING COASTING IN FORWARD GEARS OR WITH POWER APPLIED IN REVERSE GEAR.
Consequence & remedy
Consequence: IF THIS OCCURS, THE VEHICLE CAN ROLL FREELY AS IF INNEUTRAL POSITION REGARDLESS OF THE TRANSMISSION GEAR SELECTOR POSITION. THIS CANRESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Remedy: REPLACE DEFECTIVE TRANSFER CASES WITH THE CORRECT VERSION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA99032 · Dual Fuel Tank Crossflow/leakage
Opened Nov 4, 1999 · Closed Dec 6, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Additional source detail variants (2)
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
RQ98008 · Ford F-SERIES Dual Fuel Tank Leakage
Opened May 29, 1998 · Closed Nov 4, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
THESE VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO A MALFUNCTIONING FUEL PUMP.FROM THE INFORMATION GATHERED TO DATE, IT APPEARS THAT THERE CAN BE MULTIPLE CAUSES AND/OR A COMBINATION OF CAUSES FOR FUEL CROSS FLOW AND THAT THE RECALL REMEDY MAY BE INADEQUATE.FURTHER INVESTIGATION IS NEEDED.THIS INVESTIGATION IS UPGRADED TO EA99-032.CLICK ON DOCUMENT SEARCH BUTTON FOR ADDITIONAL INFORMATION.