Engine And Engine CoolingFuel System, GasolinePower Train
AT 30,951 MILES THIS VEHICLE HAD TO HAVE A NEW OIL PAN PUT IN, AND A NEW GAS TANK AS THE OTHER ONE WAS LEAKING WHICH CAN POSE A DANGER ANYWHERE AT ANYTIME JUST BY A SIMPLE CIGARETT TO THE GROUND. I DON'T THINK OIL PANS SHOULD RUST OUT. I WAS TOLD THIS WAS NOT AN UNCOMMON PROBLEM WITH FORD. THEY DID NOT WANT TO DEAL WITH ME …
Read full complaint
AT 30,951 MILES THIS VEHICLE HAD TO HAVE A NEW OIL PAN PUT IN, AND A NEW GAS TANK AS THE OTHER ONE WAS LEAKING WHICH CAN POSE A DANGER ANYWHERE AT ANYTIME JUST BY A SIMPLE CIGARETT TO THE GROUND. I DON'T THINK OIL PANS SHOULD RUST OUT. I WAS TOLD THIS WAS NOT AN UNCOMMON PROBLEM WITH FORD. THEY DID NOT WANT TO DEAL WITH ME FURTHER CLAIMING MY VEHICLE WAS OLD. IN YEARS MAYBE, BUT NOT IN MILEAGE. THE TRANSMISSION LEAK HAS NOT BEEN FIXED YET. THEY DO NOT STAND BEHIND THEIR PRODUCTS AS IT IS EVIDENT THESE ARE INDEED FAULTY PARTS USED BY FORD. HOW CAN AN OIL PAN RUST OUT? A FUEL TANK RUSTING OUT AT THE SAME TIME? ALSO A TRANSMISSION LEAK? I HAVE SENT LETTERS TO NO AVAIL. THEY JUST SAY IT IS BEING FORWARDED. WE ALL KNOW WHAT THAT MEANS. I DON'T THINK THEY SHOULD BE ALLOWED TO DO THIS TO US, THE COMSUMERS. WE WILL NOT FEEL SAFE IN ANY FORD VEHICLE. WHAT WOULD HAVE HAPPENDED IF THE OIL PAN DECIDED TO GO WHILE WE WERE DRIVING ON THE HIGHWAY WITH OTHER DRIVERS. I SHUDDER TO THINK OF A DISASTER THAT COULD HAVE BEEN. THANK YOU FOR ALLOWING ME THE OPPORTUNITY TO VOICE MYSELF. BUT, CAN YOU HELP ME? SINCERELY, SCOTT WILSON. *AK
NHTSA ODI #701409
Mileage unknown · May 18, 1998
Power Train
CLUTCH PEDAL IS NO LONGER CONNECTED TO THE CLUTCH.
NHTSA ODI #535844
Mileage unknown · Oct 22, 1997
Power Train
WHEN DEPRESSING CLUTCH, ON COLD MORNINGS, ALL FLUID LEAKS OUT, TRANSMISSION WILL ENGAGE IN GEAR, CAUSING TRUCK TO MOVE ON ITS OWN, NEARLY CAUSED CRASH, DEALERSHIP HAS NOT DISCOVERED PROBLEM. *AK *SLC
NHTSA ODI #817418
Mileage unknown · Aug 15, 1997
Power Train
SHIFT INDICATOR ASSEMBLY FAILED.
NHTSA ODI #521068
Mileage unknown · Jul 15, 1997
Power Train
CONSUMER HAS HAD TO REPLACE SIX BUSHINGS WITHIN THE LAST 10 DAYS. THE PLASTIC BUSHINGS THAT HOLD THE CLUTCH ROD WHEN APPLIED PRESSURE IS ON THE BUSHINGS, WILL BRAKE, LEAVING THE VEHICLE UNMANAGEABLE BY THE DRIVER. *AK
NHTSA ODI #814235
Mileage unknown · Mar 16, 1997
Fuel System, GasolinePower Train
WIRING FOR OVERDRIVE ON GEAR SHIFT FAILED.
NHTSA ODI #516492
Mileage unknown · Mar 12, 1997
Power Train
THE TRANSMISSION GEARS STICK, MAKING IT HARD TO SWITCH GEARS, COULD CAUSE AN ACCIDENT WHEN SWITCHING GEARS. WHILE ON THE THIRD GEAR, IT MAKES A GRINING NOISE. DEALER SAID THE PROBLEM IS THE TRANSMISSION "BLOCKS". *AK
NHTSA ODI #809919
Mileage unknown · Nov 14, 1996
Power TrainService Brakes, Hydraulic
NOISY BRAKES. TRANSMISSION TAIL SHAFT SEAL LEAKS.
NHTSA ODI #511387
Mileage unknown · Oct 2, 1996
Power Train
AUTOMATIC TRANSMISSION EXPERIENCES HARSH REVERSE ENGAGEMENT AND HARSH THIRD GEAR ENGAGEMENT. *AK
NHTSA ODI #509348
Mileage unknown · Sep 23, 1996
Power Train
ENGINE STALLS WHEN TRANSMISSION GEAR IS PUT INTO DRIVE OR REVERSE.
THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Consequence & remedy
Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.
A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE.
Consequence & remedy
Consequence: SPILLED FUEL CAN RESULT IN A FIRE WHEN EXPOSED TO ASOURCE OF IGNITION.
Remedy: REPLACEMENT OF THE FUEL PRESSURE REGULATOR AND INSTALLATION OF REDUNDANT CHECK VALVES.
WATER CAN ENTER THE DOOR LATCH RELEASE CABLE. IF THE VEHICLE IS OPERATED IN BELOW FREEZING TEMPERATURES, THE WATER IN THE DOOR LATCH RELEASE CABLE CAN FREEZE AND CAUSE THE LATCH MECHANISM TO MALFUNCTION.
Consequence & remedy
Consequence: THE MALFUNCTION OF THE DOOR LATCH RELEASE CAN RESULT INTHREE DIFFERENT PROBLEMS: 1) THE DOOR WILL NOT BE ABLE TO BE RELATCHED, 2) THEINSIDE DOOR HANDLE CAN BECOME INOPERATIVE, AND 3) THE DOOR COULD APPEAR TO BELATCHED WHEN IT IS NOT, ALLOWING THE DOOR TO OPEN UNEXPECTEDLY IF IT IS JARRED,AND INCREASING THE RISK OF INJURY TO THE ADJACENT SEAT OCCUPANT.
Remedy: REVISED DOOR RELEASE CABLES AND WATER SHIELDS WILL BE INSTALLED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8
EA99032 · Dual Fuel Tank Crossflow/leakage
Opened Nov 4, 1999 · Closed Dec 6, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Additional source detail variants (2)
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
THESE VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO A MALFUNCTIONING FUEL PUMP.FROM THE INFORMATION GATHERED TO DATE, IT APPEARS THAT THERE CAN BE MULTIPLE CAUSES AND/OR A COMBINATION OF CAUSES FOR FUEL CROSS FLOW AND THAT THE RECALL REMEDY MAY BE INADEQUATE.FURTHER INVESTIGATION IS NEEDED.THIS INVESTIGATION IS UPGRADED TO EA99-032.CLICK ON DOCUMENT SEARCH BUTTON FOR ADDITIONAL INFORMATION.
EA93022 · Idle Air Spd Ctrl Vlv Malf
Opened Jul 30, 1993 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93020 · Parking Brake Failure
Opened Jul 28, 1993 · Closed Sep 23, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE93015 · Parking Brake Failure
Opened Mar 9, 1993 · Closed Jul 27, 1993
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE93010 · Idle Air Spd Ctrl Vlv Malf
Opened Mar 2, 1993 · Closed Jul 30, 1993
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93001 · Fuel Expulsion
Opened Jan 7, 1993 · Closed Aug 20, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92077 · Fuel Expulsion
Opened Sep 9, 1992 · Closed Jan 7, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
1992 Ford F-150 Problems, Complaints & Recalls | Skip That Year
Illustration