TL* THE CONTACT OWNS A 1992 FORD F-150. THE CONTACT STATED THAT WHILE ATTEMPTING TO APPLY THE PARKING BRAKE, IT COULD NOT BE ENGAGED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE VEHICLE WAS NOT REPAIRE…
Read full complaint
TL* THE CONTACT OWNS A 1992 FORD F-150. THE CONTACT STATED THAT WHILE ATTEMPTING TO APPLY THE PARKING BRAKE, IT COULD NOT BE ENGAGED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 103,256. UPDATED 04/19/12*LJ THE CONSUMER STATED WHEN HE APPLIED THE FOOT PEDAL PARKING BRAKE, IT WOULD SKIP SOME TEETH AND GO FREE WHEEL. HE HAD TO RELEASE THE BRAKE AND TRY AGAIN. UPDATED 05/07/12
NHTSA ODI #10451193
199,000 miles · Nov 16, 2007
Parking Brake
THE PARKING BREAK ON MY 1992 FORD F-150 IS NOT WORKING PROPERLY. ON OCCASION IT CATCHES BUT MOST OF THE TIME IT SLIPS OVER THE TEETH AND DOES NOT CATCH AT ALL. *TR
NHTSA ODI #10209175
105,000 miles · Jan 26, 2006
Fuel System, GasolineParking Brake
DT*: THE CONTACT STATED THE FUEL PUMP VALVE MALFUNCTIONED CAUSING FUEL SPILLAGE. ALSO, THE PARKING BRAKE WILL NOT HOLD THE VEHICLE. THERE IS A NHTSA RECALL, # 93V125000 AND 94V169001, REGARDING THE STORAGE TANK ASSEMBLY AND PARKING BRAKE. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALLS; HOWEVER IT IS NOT INCLUDED …
Read full complaint
DT*: THE CONTACT STATED THE FUEL PUMP VALVE MALFUNCTIONED CAUSING FUEL SPILLAGE. ALSO, THE PARKING BRAKE WILL NOT HOLD THE VEHICLE. THERE IS A NHTSA RECALL, # 93V125000 AND 94V169001, REGARDING THE STORAGE TANK ASSEMBLY AND PARKING BRAKE. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALLS; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE VEHICLE HAS NOT BEEN TAKEN TO THE LOCAL DEALERSHIP FOR INSPECTION.
NHTSA ODI #10148760
Mileage unknown · Apr 30, 2001
Fuel System, GasolineParking Brake
CONSUMER HAD CONTACTED DEALER IN REFERENCE TO RECALLS 94 V 169 000 AND 93 V 125 000. CONSUMER BELIEVED RECALL WORK WAS NOT DONE CORRECTLY AS FUEL TANK WAS LEAKING. DEALER BOB BELL FORD 7125 RICHIE HWY. GLEN BURNIE, MD. 410-766-3600. *AK THE DEALER FAILED TO REMOVE THE LEAKING FUEL TANK, AND THE CONSUMER STATED THAT THE …
Read full complaint
CONSUMER HAD CONTACTED DEALER IN REFERENCE TO RECALLS 94 V 169 000 AND 93 V 125 000. CONSUMER BELIEVED RECALL WORK WAS NOT DONE CORRECTLY AS FUEL TANK WAS LEAKING. DEALER BOB BELL FORD 7125 RICHIE HWY. GLEN BURNIE, MD. 410-766-3600. *AK THE DEALER FAILED TO REMOVE THE LEAKING FUEL TANK, AND THE CONSUMER STATED THAT THE PROBLEM WAS DANGEROUS UNLESS ACTION WAS TAKEN. *YH
NHTSA ODI #887153
Mileage unknown · Dec 21, 2000
Parking BrakeCrashInjury
A YEAR AGO PARKING BRAKE RELEASED, AND CONSUMER WAS RUN OVER BY OWN TRUCK. *AK
NHTSA ODI #876878
Mileage unknown · Jun 13, 2000
Parking Brake
WHEN CONSUMER PUTS EMERGENCY BRAKE UP CABLE DOESN'T HOLD AT ALL. *AK
NHTSA ODI #863492
Mileage unknown · Mar 17, 2000
Parking BrakePower Train
THE PARKING BRAKE EQULIZER IS A C CHANNEL THAT CONNECTS THE CABLE FROM THE PEDAL ASSEMBLY TO THE TWO CABLES GOING TO THE REAR WHEELS. I HAVE HAD TWO EQULIZERS FAIL. THE FIRST ONE AT38000 MILES. THE SECOND AT 125000 MILES OR ABOUT 80000 MILES LATER. IN BOTH CASES THE EQULIZER BROKE WHERE THE PEDAL ASSEMBLY ATTACHES TO THE EQULIZ…
Read full complaint
THE PARKING BRAKE EQULIZER IS A C CHANNEL THAT CONNECTS THE CABLE FROM THE PEDAL ASSEMBLY TO THE TWO CABLES GOING TO THE REAR WHEELS. I HAVE HAD TWO EQULIZERS FAIL. THE FIRST ONE AT38000 MILES. THE SECOND AT 125000 MILES OR ABOUT 80000 MILES LATER. IN BOTH CASES THE EQULIZER BROKE WHERE THE PEDAL ASSEMBLY ATTACHES TO THE EQULIZER. THE TRUCK WAS PARKED WITH THE PARKING BRAKE APPLIED AND THE TRANSMISSION IN REVERSE. THE TRUCK HAS A STANDARD TRANSMISSION. THE NEXT MORNING I FOUND THE PARKING BRAKE PEDAL WOULDN'T MOVE WHEN RELEASED. I LOOKED UNDER THE TRUCK. THE BRAKE CABLE WAS LOOSE AND LAYING ON THE GROUND.THE ONLY THING KEEPING MY TRUCK FROM ROLLING DOWN MY DRIVE WAS THE TRANSMISSION. BOTH TIMES THE EQULIZER FAILED UNDER SIMILAR CIRCUMSTANCES. THIS IS A VERY UNSAFE CONDITION. I THINK THE EQULIZER SHOULD BE MADE FROM HEAVIER STEEL TO LAST THE LIFE OF THE VEHICLE. *AK
NHTSA ODI #720265
Mileage unknown · Mar 15, 2000
Parking Brake
THIS PART CONNECTS THE PARKING BRAKE PEDAL TO THE TWO CABLES THAT GO TO THE REAR WHEELS. THE BRAKE WAS APPLIED AND THEN THE PART FAILED LEAVING THE TRUCK FREE TO ROLL. THIS IS THE SECOND EQULIZER I HAVE HAD. THE FIRST ONE FAILED IN THE SAME PLACE AND THE SAME WAY. I DON'T THINK IT IS MADE OUT OF HEAVY ENOUGH STEEL. *AK
RECALL 94V169001/ MANUFACTURER RECALL 94S91. THE EMERGENCY PARKING BRAKE WILL NOT HOLD. IT'S THE PEDAL THAT DRIVER STEPS ON AND WILL NOT STAY DOWN. DEALER WAS CONTACTED . INFORMATION RECEIVED FROM FOR TSB WAS THAT LOCKED IN WEDGE. CONSUMER 'S VEHICLE IS NOT INCLUDED IN THE RECALL. *AK
THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Consequence & remedy
Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.
A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE.
Consequence & remedy
Consequence: SPILLED FUEL CAN RESULT IN A FIRE WHEN EXPOSED TO ASOURCE OF IGNITION.
Remedy: REPLACEMENT OF THE FUEL PRESSURE REGULATOR AND INSTALLATION OF REDUNDANT CHECK VALVES.
WATER CAN ENTER THE DOOR LATCH RELEASE CABLE. IF THE VEHICLE IS OPERATED IN BELOW FREEZING TEMPERATURES, THE WATER IN THE DOOR LATCH RELEASE CABLE CAN FREEZE AND CAUSE THE LATCH MECHANISM TO MALFUNCTION.
Consequence & remedy
Consequence: THE MALFUNCTION OF THE DOOR LATCH RELEASE CAN RESULT INTHREE DIFFERENT PROBLEMS: 1) THE DOOR WILL NOT BE ABLE TO BE RELATCHED, 2) THEINSIDE DOOR HANDLE CAN BECOME INOPERATIVE, AND 3) THE DOOR COULD APPEAR TO BELATCHED WHEN IT IS NOT, ALLOWING THE DOOR TO OPEN UNEXPECTEDLY IF IT IS JARRED,AND INCREASING THE RISK OF INJURY TO THE ADJACENT SEAT OCCUPANT.
Remedy: REVISED DOOR RELEASE CABLES AND WATER SHIELDS WILL BE INSTALLED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8
EA99032 · Dual Fuel Tank Crossflow/leakage
Opened Nov 4, 1999 · Closed Dec 6, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Additional source detail variants (2)
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
THESE VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO A MALFUNCTIONING FUEL PUMP.FROM THE INFORMATION GATHERED TO DATE, IT APPEARS THAT THERE CAN BE MULTIPLE CAUSES AND/OR A COMBINATION OF CAUSES FOR FUEL CROSS FLOW AND THAT THE RECALL REMEDY MAY BE INADEQUATE.FURTHER INVESTIGATION IS NEEDED.THIS INVESTIGATION IS UPGRADED TO EA99-032.CLICK ON DOCUMENT SEARCH BUTTON FOR ADDITIONAL INFORMATION.
EA93022 · Idle Air Spd Ctrl Vlv Malf
Opened Jul 30, 1993 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93020 · Parking Brake Failure
Opened Jul 28, 1993 · Closed Sep 23, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE93015 · Parking Brake Failure
Opened Mar 9, 1993 · Closed Jul 27, 1993
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE93010 · Idle Air Spd Ctrl Vlv Malf
Opened Mar 2, 1993 · Closed Jul 30, 1993
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93001 · Fuel Expulsion
Opened Jan 7, 1993 · Closed Aug 20, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92077 · Fuel Expulsion
Opened Sep 9, 1992 · Closed Jan 7, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
1992 Ford F-150 Problems, Complaints & Recalls | Skip That Year
Illustration