IllustrationVEHICLE HAS PROBLEM WITH GAS FREQUENTLY PUMPING FROM THE BACK FUEL TANK TO THE FRONT TANK. *MR THIS OFTEN HAPPENED WHEN THE FRONT TANK WAS FULL AND GAS WOULD EXPELLED FROM THE FRONT GAS TANK. THE CONSUMER'S WAS TOLD THAT THE VIN DID NOT MATCH WITH THE RECALL. *SCC *JB
1992 Ford F-150
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1992 Ford F-150 do not stand out strongly from the model-year median of 676.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-150 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 49 of 470 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 231 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports38 fire reports11 injury reports
Fuel System, Gasoline complaints
231 reportsDEALER PERFORMED FORD RECALL 93S68 TWICE ON MY VEHICLE WHICH DID NOT CORRECT PROBLEM. FUEL CROSSFLOW STILL OCCURRED FROM REAR TANK TO FRONT TANK RESULTING IN A HAZARDOUS CONDITION THAT THE RECALL WAS MEANT TO CORRECT. RETURNED TRUCK TO FORD DEALER FOR A THIRD TIME TO CORRECT THE SAME PROBLEM. I WAS CHARGED $602.90 TO REPLACE FRO…
Read full complaint
DEALER PERFORMED FORD RECALL 93S68 TWICE ON MY VEHICLE WHICH DID NOT CORRECT PROBLEM. FUEL CROSSFLOW STILL OCCURRED FROM REAR TANK TO FRONT TANK RESULTING IN A HAZARDOUS CONDITION THAT THE RECALL WAS MEANT TO CORRECT. RETURNED TRUCK TO FORD DEALER FOR A THIRD TIME TO CORRECT THE SAME PROBLEM. I WAS CHARGED $602.90 TO REPLACE FRONT FUEL PUMP. THIS SHOULD HAVE BEEN COVERED UNDER THE RECALL, BECAUSE THE ORIGINAL RECALL DID NOT ALLEVIATE THE HAZARDOUS CONDITION. *LA
PER MANUFACTURER'S SYSTEM RECALL 01I008000 FOR THE FUEL DUEL TANK LEAKAGE WAS PERFORMED. CONSUMER NEVER RECEIVED A RECALL LETTER, SO VEHICLE WAS NEVER TAKEN INTO DEALERSHIP TO HAVE RECALL DONE. DEFECT HAS NOW OCCURRED, BUT VEHICLE IS NOW OVER THE MILEAGE INDICATED IN THE RECALL. *AK *NLM
THE VEHICLES RECALL RELATED TO THE CHECK VALVE IN THE FUEL PUMP FAILED. *NLM
THE VEHICLE EXPERIENCED PROBLEMS WITH THE FUEL SYSTEM. THE CONSUMER STATED THAT THERE WAS A RECALL ISSUED WHICH WAS NEVER RECEIVED AND THAT NOW WHEN THEY TOOK THE VEHICLE IN FOR THE RECALL THEY WERE OVER 6000 MILES OVER THE LIMIT FOR THE RECALL. DEALER AND MANUFACTURER WERE NOT CONTACTED AT THE TIME OF THIS CALL. *NLM
THE VEHICLE HAS DUAL TANK THE FRONT TANK EMPTY INTO THE SECOND TANK AND SPILLING OUT OF THE GASOLINE TANK. PLEASE PROVIDE ADDITIONAL INFORMATION DEALER IS AWARE OF THE PROBLEM. TS
UEL IS BEING TRANSFERRED FROM REAR TANK TO FRONT TANK WITHOUT VEHICLE BEING ENGAGED. CONSUMER HAD VEHICLE REPAIRED TWICE UNDER SAFETY CAMPAIGN. THIS CONDITION CAUSE GAS TO LEAK OUT OF TANK WHILE DRIVING. CONSUMER WAS INFORMED THAT BECAUSE FUEL IS TRANSFERRING WHEN VEHICLE IS NOT ENGAGED, ONCE VEHICLE IS DRIVEN AND FUEL TRANSFE…
Read full complaint
UEL IS BEING TRANSFERRED FROM REAR TANK TO FRONT TANK WITHOUT VEHICLE BEING ENGAGED. CONSUMER HAD VEHICLE REPAIRED TWICE UNDER SAFETY CAMPAIGN. THIS CONDITION CAUSE GAS TO LEAK OUT OF TANK WHILE DRIVING. CONSUMER WAS INFORMED THAT BECAUSE FUEL IS TRANSFERRING WHEN VEHICLE IS NOT ENGAGED, ONCE VEHICLE IS DRIVEN AND FUEL TRANSFER IS INITIATED FRONT TANK IS OVERFLOWING.*AK
RECEIVED RECALL 01I008000; FUEL WOULD COME OUT OF THE FRONT TANK WHILE DRIVING. ALSO OWNER CAN SMELL FUMES INSIDE THE CAB OF THE TRUCK. PROBLEM HAPPENS WHETHER FUEL TANK IS FULL OR WHEN WEATHER IS HOT. OWNER HAS TAKEN TRUCK TO DEALERSHIP TWICE. HE WAS INFORMED THAT CHECK VALVE WAS NOT PART OF RECALL, AND REFUSE TO DO R…
Read full complaint
RECEIVED RECALL 01I008000; FUEL WOULD COME OUT OF THE FRONT TANK WHILE DRIVING. ALSO OWNER CAN SMELL FUMES INSIDE THE CAB OF THE TRUCK. PROBLEM HAPPENS WHETHER FUEL TANK IS FULL OR WHEN WEATHER IS HOT. OWNER HAS TAKEN TRUCK TO DEALERSHIP TWICE. HE WAS INFORMED THAT CHECK VALVE WAS NOT PART OF RECALL, AND REFUSE TO DO RECALL REPAIRS. PLEASE DESCRIBE DETAILS. *AK
CONSUMER'S VEHICLE WAS HAVING THE SAME PROBLEM WITH FUEL LEAKAGE AS STATED IN RECALL 01 F 105 000. BUT DEALERSHIP REFUSED TO FIX IT, WARRANTY EXPIRED, AND THEY DID NOT KNOW HOW TO FIX IT.*AK CONSUMER STATED THAT WHEN THE BACK TANK WAS PUSHING FUEL THROUGH THE FRONT TANK, THE FRONT FUEL TANK WAS LEAKING. TOOK THE VEHICLE TO THE …
Read full complaint
CONSUMER'S VEHICLE WAS HAVING THE SAME PROBLEM WITH FUEL LEAKAGE AS STATED IN RECALL 01 F 105 000. BUT DEALERSHIP REFUSED TO FIX IT, WARRANTY EXPIRED, AND THEY DID NOT KNOW HOW TO FIX IT.*AK CONSUMER STATED THAT WHEN THE BACK TANK WAS PUSHING FUEL THROUGH THE FRONT TANK, THE FRONT FUEL TANK WAS LEAKING. TOOK THE VEHICLE TO THE DEALER TO FIX BUT, THE PROBLEM STILL EXIST. *YH
THIS DEFECT WAS THE SUBJECT OF NHTSA RECALL CAMPAIGN ID # 011008000. THE CORRECTIVE SUMMARY IN THE RECALL NOTICE STATES THE DEALER IS TO "REPAIR THE CONDITION FREE OF CHARGE." HOWEVER, THE DEALER CHARGED ME SOME $500 FOR THE REPAIR, WHICH SEEMD TO DEFEAT THE PURPOSE OF THE RECALL.*AK
Official recalls
394V169001 · Parking Brake:conventional
Sep 7, 1994
THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Consequence & remedy
Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.
93V125000 · Fuel System, Gasoline:storage:tank Assembly
Aug 2, 1993
A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE.
Consequence & remedy
Consequence: SPILLED FUEL CAN RESULT IN A FIRE WHEN EXPOSED TO ASOURCE OF IGNITION.
Remedy: REPLACEMENT OF THE FUEL PRESSURE REGULATOR AND INSTALLATION OF REDUNDANT CHECK VALVES.
92V006000 · Structure:body:door
Jan 14, 1992
WATER CAN ENTER THE DOOR LATCH RELEASE CABLE. IF THE VEHICLE IS OPERATED IN BELOW FREEZING TEMPERATURES, THE WATER IN THE DOOR LATCH RELEASE CABLE CAN FREEZE AND CAUSE THE LATCH MECHANISM TO MALFUNCTION.
Consequence & remedy
Consequence: THE MALFUNCTION OF THE DOOR LATCH RELEASE CAN RESULT INTHREE DIFFERENT PROBLEMS: 1) THE DOOR WILL NOT BE ABLE TO BE RELATCHED, 2) THEINSIDE DOOR HANDLE CAN BECOME INOPERATIVE, AND 3) THE DOOR COULD APPEAR TO BELATCHED WHEN IT IS NOT, ALLOWING THE DOOR TO OPEN UNEXPECTEDLY IF IT IS JARRED,AND INCREASING THE RISK OF INJURY TO THE ADJACENT SEAT OCCUPANT.
Remedy: REVISED DOOR RELEASE CABLES AND WATER SHIELDS WILL BE INSTALLED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8EA99032 · Dual Fuel Tank Crossflow/leakage
Opened Nov 4, 1999 · Closed Dec 6, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Additional source detail variants (2)
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
RQ98008 · Ford F-SERIES Dual Fuel Tank Leakage
Opened May 29, 1998 · Closed Nov 4, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
THESE VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO A MALFUNCTIONING FUEL PUMP.FROM THE INFORMATION GATHERED TO DATE, IT APPEARS THAT THERE CAN BE MULTIPLE CAUSES AND/OR A COMBINATION OF CAUSES FOR FUEL CROSS FLOW AND THAT THE RECALL REMEDY MAY BE INADEQUATE.FURTHER INVESTIGATION IS NEEDED.THIS INVESTIGATION IS UPGRADED TO EA99-032.CLICK ON DOCUMENT SEARCH BUTTON FOR ADDITIONAL INFORMATION.
EA93022 · Idle Air Spd Ctrl Vlv Malf
Opened Jul 30, 1993 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93020 · Parking Brake Failure
Opened Jul 28, 1993 · Closed Sep 23, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE93015 · Parking Brake Failure
Opened Mar 9, 1993 · Closed Jul 27, 1993
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE93010 · Idle Air Spd Ctrl Vlv Malf
Opened Mar 2, 1993 · Closed Jul 30, 1993
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93001 · Fuel Expulsion
Opened Jan 7, 1993 · Closed Aug 20, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92077 · Fuel Expulsion
Opened Sep 9, 1992 · Closed Jan 7, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available