NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
149 reportsClear category filter170,000 miles · Mar 16, 2010
Fuel System, Gasoline
TL* THE CONTACT OWNS A 1991 FORD F-150. THE VEHICLE WAS EQUIPPED WITH A DUAL FUEL TANK. THE CONTACT OBSERVED FUEL LEAKAGE IN THE SECOND FUEL TANK SPILLING FUEL INTO THE FIRST FUEL TANK AND CAUSING AN EXCESSIVE OVERFLOW. THERE WERE TWO RECALLS UNDER NHTSA CAMPAIGN ID NUMBERS 01I008000 (FUEL SYSTEM, GASOLINE) AND 93V125000 (FUEL …
Read full complaint
TL* THE CONTACT OWNS A 1991 FORD F-150. THE VEHICLE WAS EQUIPPED WITH A DUAL FUEL TANK. THE CONTACT OBSERVED FUEL LEAKAGE IN THE SECOND FUEL TANK SPILLING FUEL INTO THE FIRST FUEL TANK AND CAUSING AN EXCESSIVE OVERFLOW. THERE WERE TWO RECALLS UNDER NHTSA CAMPAIGN ID NUMBERS 01I008000 (FUEL SYSTEM, GASOLINE) AND 93V125000 (FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY). THE VIN WAS EXCLUDED FROM THE SAFETY RECALL. THE VEHICLE HAD NOT BEEN REPAIRED. THE CONTACT HAD CONCERN OF THE POTENTIAL SAFETY HAZARD. THE FAILURE MILEAGE WAS 170,000. THE CURRENT MILEAGE WAS 182,000.
NHTSA ODI #10320094
200,000 miles · Nov 13, 2008
Fuel System, Gasoline
TL*- THE CONTACT OWNS A 1991 FORD F150 PURCHASED MARCH 2007. THE VEHICLE HAD DUAL FUEL STORAGE TANKS THAT BEGAN LEAKING. THE CONTACT WAS ADVISED THAT FUEL WAS LEAKING FROM THE VEHICLE AND THEN NOTICED THAT IT HAD LEAKED ONTO THE DRIVEWAY. ALTHOUGH THERE WAS A RECALL ON THE VEHICLE NHTSA CAMPAIGN NUMBER 93V125000) THE VIN WAS N…
Read full complaint
TL*- THE CONTACT OWNS A 1991 FORD F150 PURCHASED MARCH 2007. THE VEHICLE HAD DUAL FUEL STORAGE TANKS THAT BEGAN LEAKING. THE CONTACT WAS ADVISED THAT FUEL WAS LEAKING FROM THE VEHICLE AND THEN NOTICED THAT IT HAD LEAKED ONTO THE DRIVEWAY. ALTHOUGH THERE WAS A RECALL ON THE VEHICLE NHTSA CAMPAIGN NUMBER 93V125000) THE VIN WAS NOT INCLUDED IN THE RECALL. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 200,000. UPDATED 12-15-08 *BF GAS FILL UP FRONT TANK FROM THE REAR TANK AND OVER FLOWS OUT OF THE FILLER NECK OF THE FRONT TANK. UPDATED 12/17/08. *JB
NHTSA ODI #10248688
70,000 miles · Sep 3, 2008
Fuel System, Gasoline
TL*THE CONTACT OWNS A 1991 FORD F150 4X4 XLT 300. THE VEHICLE HAS DUAL TANKS AND CAN TRAVEL APPROXIMATELY 100 MILES ON ONE TANK. WHEN SWITCHING TO THE OTHER TANK, THE VEHICLE COULD ONLY TRAVEL APPROXIMATELY 20 MILES BEFORE RUNNING OUT OF FUEL. THROUGH RESEARCH, THE CONTACT DISCOVERED THAT THE CHECK VALVE WITHIN THE FUEL PUMP …
Read full complaint
TL*THE CONTACT OWNS A 1991 FORD F150 4X4 XLT 300. THE VEHICLE HAS DUAL TANKS AND CAN TRAVEL APPROXIMATELY 100 MILES ON ONE TANK. WHEN SWITCHING TO THE OTHER TANK, THE VEHICLE COULD ONLY TRAVEL APPROXIMATELY 20 MILES BEFORE RUNNING OUT OF FUEL. THROUGH RESEARCH, THE CONTACT DISCOVERED THAT THE CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSED A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK WAS EXCEEDED. FORD STATED THAT NHTSA CAMPAIGN ID NUMBER 93V125000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY) WAS VOID AND THE CONTACT WOULD BE LIABLE FOR THE RECALL REPAIRS AFTER TEN YEARS. FORD ALSO STATED THAT THE RECALL REPAIRS WERE ALREADY COMPLETED. THE CONTACT STATED THAT IF THE REPAIRS WERE DONE, THE FAILURE WOULD NOT BE PRESENT. THE FAILURE MILEAGE WAS 70,000 AND CURRENT MILEAGE WAS 74,561.
NHTSA ODI #10240803
105,000 miles · Aug 20, 2008
Fuel System, Gasoline
RECALL 93V125000. MY 1991 FORD F150 IS EXPERIENCING THE PROBLEM THIS RECALL ADDRESSED. I CALLED THE FORD 800# AND THEY COULD NOT AND WOULD NOT TELL ME IF MY VEHICLE HAD THIS RECALL PERFORMED ON IT, TO CONTACT A DEALER. I CONTACTED A DEALER WHO SAID THEY COULD NOT TELL ME EITHER. I HAVE OWNED THE VEHICLE ITS ENTIRE LIFE. L…
Read full complaint
RECALL 93V125000. MY 1991 FORD F150 IS EXPERIENCING THE PROBLEM THIS RECALL ADDRESSED. I CALLED THE FORD 800# AND THEY COULD NOT AND WOULD NOT TELL ME IF MY VEHICLE HAD THIS RECALL PERFORMED ON IT, TO CONTACT A DEALER. I CONTACTED A DEALER WHO SAID THEY COULD NOT TELL ME EITHER. I HAVE OWNED THE VEHICLE ITS ENTIRE LIFE. LOCAL FORD DEALER, GWINNETT PLACE FORD. THIS SAFETY RELATED RECALL INVOLVES SPILLAGE OF GASOLINE ON OUR ROADS/ENVIRONMENTS, MUCH LESS A SAFETY ISSUE CAUSING AN EXPLOSION AND/OR DEATH. I CAN NOT GET ANY HELP FROM FORD CORPORATE OR LOCAL FORD DEALER. *TR
NHTSA ODI #10239034
69,362 miles · Aug 9, 2007
Fuel System, Gasoline
1991 FORD F150 PICK UP WITH FUEL TANK SYSTEMS PROBLEMS. CUSTOMER STATES THAT A RECALL WAS DONE IN 1994 FOR THE FUEL TANK DELIVERY SYSTEM AND NOW IT IS GONE BAD AGAIN AND HE WANTS TO BE REIMBURSED FOR THE REPAIRS DONE**CC *JB
NHTSA ODI #10199221
110,629 miles · Mar 20, 2007
Fuel System, Gasoline
TL* THE CONTACT OWNS A 1991 FORD F150. THE CONTACT CALLED REGARDING RECALL # 93V125000. THE VEHICLE WAS MIXING GASOLINE IN THE OTHER VALVE. THE CONTACT STATED THAT THE SITUATION WAS MESSY AND HAZARDOUS. THE CURRENT AND FAILURE MILEAGE WERE 110629.*AK THE CUSTOMER STATES THIS VEHICLE HAS DUAL TANKS WHILE OPERATING THE VEHI…
Read full complaint
TL* THE CONTACT OWNS A 1991 FORD F150. THE CONTACT CALLED REGARDING RECALL # 93V125000. THE VEHICLE WAS MIXING GASOLINE IN THE OTHER VALVE. THE CONTACT STATED THAT THE SITUATION WAS MESSY AND HAZARDOUS. THE CURRENT AND FAILURE MILEAGE WERE 110629.*AK THE CUSTOMER STATES THIS VEHICLE HAS DUAL TANKS WHILE OPERATING THE VEHICLE GAS MAY SPILL OUT OF THE REAR GAS TANK DUE TO CLOSE OFF VALVE TO REAR GAS TANK NOT STOPPING GAS FROM FRONT TANK GOING INTO REAR TANK. UPDATE 4/9 *TR
NHTSA ODI #10185691
107,000 miles · Dec 20, 2006
Fuel System, Gasoline
F150 FORD FUEL TANK VALVES TRANSFERRED FRONT TANK FUEL TO REAR TANK MAKING REAR TANK OVERFLOW. CITY TRUCK STOPPED ME TO TELL ME THAT GAS WAS POURING ALL OVER THE STREET. *JB
NHTSA ODI #10176629
98,000 miles · Jan 23, 2006
Fuel System, Gasoline
DT*: THE CONTACT STATED THE FUEL PUMP IS CAUSING THE UNUSED FUEL FROM ONE TANK TO RETURN TO THE SECONDARY TANK CAUSING SPILLAGE. THERE IS A NHTSA RECALL, # 93V125000, REGARDING THE FUEL SYSTEM TANK ASSEMBLY. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN. …
Read full complaint
DT*: THE CONTACT STATED THE FUEL PUMP IS CAUSING THE UNUSED FUEL FROM ONE TANK TO RETURN TO THE SECONDARY TANK CAUSING SPILLAGE. THERE IS A NHTSA RECALL, # 93V125000, REGARDING THE FUEL SYSTEM TANK ASSEMBLY. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE VEHICLE WAS TAKEN TO THE LOCAL DEALERSHIP FOR REPAIRS.
NHTSA ODI #10148341
137,000 miles · Aug 26, 2005
Fuel System, Gasoline
DT: HAD A PROBLEM WITH THE VEHICLE AND TOOK IT TO THE LOCAL MECHANIC THAT SAID THERE WAS A RECALL. CONTACTED FORD, AND THEY SAID THE RECALL EXPIRED AT 150,000 OR 12 YEARS. THE FUEL WAS RUNNING THROUGH THE ENGINE. THE VEHICLE WOULD NOT START. THERE WAS A DEFECTIVE CHECK VALUE. DRIVING DOWN THE ROAD AND THE VEHICLE JUST QUIT.…
Read full complaint
DT: HAD A PROBLEM WITH THE VEHICLE AND TOOK IT TO THE LOCAL MECHANIC THAT SAID THERE WAS A RECALL. CONTACTED FORD, AND THEY SAID THE RECALL EXPIRED AT 150,000 OR 12 YEARS. THE FUEL WAS RUNNING THROUGH THE ENGINE. THE VEHICLE WOULD NOT START. THERE WAS A DEFECTIVE CHECK VALUE. DRIVING DOWN THE ROAD AND THE VEHICLE JUST QUIT. THIS HAPPENED ON JULY 12, 2005. *AK THE FUEL PUMP SYSTEM DRAINED THE FRONT TANK TO THE REAR CAUSING SPILLAGE OF FUEL. *JB
NHTSA ODI #10128771
135,000 miles · Jul 9, 2005
Fuel System, Gasoline
I OWN A 1991 F150 PICKUP. SOMETHING IS HAPPINING WITH FUEL TANKS. ITS LIKE FUEL FROM THE FRONT TANK IS BEING TRANSFERED TO THE BACK TANK, RESULTING IN OVERFLOWING FUEL FROM THE BACK. I THINK THE MFG. SHOULD REPAIR THE PROBLEM AS IT IS A BAD SAFETLY ISSUE.
NHTSA ODI #10128177
NHTSA investigations
12EA99032 · Dual Fuel Tank Crossflow/leakage
Opened Nov 4, 1999 · Closed Dec 6, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Additional source detail variants (2)
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
RQ98008 · Ford F-SERIES Dual Fuel Tank Leakage
Opened May 29, 1998 · Closed Nov 4, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
THESE VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO A MALFUNCTIONING FUEL PUMP.FROM THE INFORMATION GATHERED TO DATE, IT APPEARS THAT THERE CAN BE MULTIPLE CAUSES AND/OR A COMBINATION OF CAUSES FOR FUEL CROSS FLOW AND THAT THE RECALL REMEDY MAY BE INADEQUATE.FURTHER INVESTIGATION IS NEEDED.THIS INVESTIGATION IS UPGRADED TO EA99-032.CLICK ON DOCUMENT SEARCH BUTTON FOR ADDITIONAL INFORMATION.
EA93022 · Idle Air Spd Ctrl Vlv Malf
Opened Jul 30, 1993 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
PE93010 · Idle Air Spd Ctrl Vlv Malf
Opened Mar 2, 1993 · Closed Jul 30, 1993
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93001 · Fuel Expulsion
Opened Jan 7, 1993 · Closed Aug 20, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92077 · Fuel Expulsion
Opened Sep 9, 1992 · Closed Jan 7, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA92029 · Front Seat Back Failure
Opened Aug 27, 1992 · Closed Oct 29, 1993
Status: closed (inferred from source dates) · Seats
There is no summary currently available
PE92042 · Fnt Reclning Seat Bck Fail
Opened Apr 17, 1992 · Closed Aug 27, 1992
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
There is no summary currently available
EA91044 · Loss Of Brake Effectivenes
Opened Oct 30, 1991 · Closed Oct 30, 1992
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
===
EA91031 · Fuel Expulsion
Opened Jun 26, 1991 · Closed Nov 1, 1991
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE91077 · Loss Of Brake Effectivenes
Opened May 23, 1991 · Closed Oct 31, 1991
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE91064 · Transmission Fluid Fires
Opened Apr 9, 1991 · Closed Jul 5, 1991
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
Illustration