2023 Ford F-150 Lightning Bev

Dealer identified Water intrusion into the rear wiring, harnesses is causing corrosion in the PIN connectors, which therefore leads to flickering tail lights which could be mis interpreted as braking or a turning. I also experienced random acceleration from slow speeds and a failure to decelerate. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2023 Ford F-150 Lightning, VIN [XXX], 42,370 mi. The rear light bar has microcracks allowing moisture intrusion. Water droplets are visible inside the red lens across the tailgate and inside the white reverse lamp (photos attached, taken 5/30/2026). This is the warning condition named in recall 25SB6 (NHTSA 25V731) and predecessor 23S30 (NHTSA 23V418): water droplets in the lightbar outer lens, which can cause inoperative or flickering reverse lamps. On 6/15/2026 I took the truck to Koons Baltimore Ford, 6970 Security Blvd, Baltimore MD 21244, Advisor Rahim King, RO [XXX]. The dealer's own repair order Line B states: RECALL 25SB6 REVERSING LAMP INSPECTION, VERIFIED OPEN RECALL, at $0 warranty pay. After verifying the open recall on this VIN, the dealer still refused to replace the moisture-failed light bar under the recall. Instead, they have charged me $190 customer-pay to check and advise on water in the red bar and white reverse light, the identical defect the recall fixes for free. The dealer also tried to bill my third-party extended service plan and told me to file an auto insurance claim. All three are improper: a federal recall remedy must be provided free by the manufacturer (49 USC 30120), not charged to the customer, an insurer, or a service contract. SAFETY RISK: A truck backing up without working reverse lamps is more likely to strike a pedestrian or a child below the driver's sightline, since others are not alerted the vehicle is reversing. Reverse lamps are federally required. This failure can result in serious injury or death. REQUEST: Please document (1) the recurring light bar moisture and reverse-lamp defect, (2) the dealer's refusal to remedy a verified open recall free of charge, (3) the improper $190 diagnostic charge, and (4) attempts to shift recall cost to the customer, a service contract, and auto insurance. I can provide RO [XXX] and photos. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I own a 2023 Ford F-150 Lightning that is subject to an active safety recall involving electrical components and exterior lighting (potential water intrusion leading to lighting failure, including rear/reverse lamps). I was notified of the recall around October/2025 and contacted a Ford dealer shortly after. The dealer confirmed the recall is active but stated that no remedy is available. I have followed up multiple times with both the dealer and Ford corporate, and as of today, there is still no repair available and no timeline has been provided. This has persisted for approximately 6 months. Ford communicated a fix in Q1 of 2026. This defect affects critical lighting and electrical systems necessary for safe operation and visibility. Operating the vehicle under these conditions presents a safety risk. Despite this, Ford has not provided a repair, interim solution, or clear guidance. Due to the unresolved recall, I have been unable to reasonably use the vehicle. The vehicle is also used for business purposes, resulting in financial loss. I continue to incur a monthly loan obligation of approximately $2,000 while the vehicle remains effectively unusable. Ford has not offered a loaner vehicle, compensation, or alternative remedy. Complaint with Ford CXXX was submitted, with stated return calls, my repeated follow-ups, and no resolution. I am submitting this complaint to document that the manufacturer has issued a safety recall but has failed to provide a timely remedy, leaving the vehicle unusable and creating ongoing safety concerns and financial harm. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My f150 lightning won't drive wben put in Drive. Then all the sudden it goes forward when not expecting it and we almost was in an accident. This happened many times and has been in service for over 3 months. They aren't able to fix it. We are trying to get them to take it back. The computer we noticed was defective the day after we bought it and inquired about it immediately. ​delayed engagement followed by a sudden lurch or unintended acceleration—matches several reports from other F-150 Lightning owners. Because this vehicle is fully electric, "revving" effectively signals the electric motors to apply instant torque, which can lead to dangerous lunges if the software or sensors are out of sync.I mentioned the safety issues and it was not addressed Our computer goes in and out and blacks out when driving. Anything you ask of it has not worked. This isn't the biggest deal but the safety issue. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Earlier this year, I filed NHTSA ID 11663872 when I noticed moisture collecting in the brake light assembly on my truck and Ford called this "normal", despite earlier issuing a recall for this very thing happening under NHTSA action 23V-418. Now, the brake light has failed completely, and Ford is denying coverage of this under my extended warranty with the following explanation: "your claim is denied due to water intrusion. A subject matter expert advised that Ford and Lincoln Protect will not participate in this claim as the lighting option only covers electrical failures on incandescent bulbs, halogen bulbs, High Intensity Discharge (HID) and [Light-Emitting Diode] LED lamp assemblies. A mechanical failure of a lamp assembly that allows water intrusion (fogging/moisture) is not a covered failure. A resulting electrical failure from this moisture/water would be consequential to the mechanical failure and would not be covered." Having inoperable brake lighting and possibly reverse lighting as well is an obvious danger to the public and there is no messaging system in the vehicle to tell you those components are not working properly, and clearly the previous recall campaign that replaced the lens assembly the first time did not work.

The rear light bar in the tailgate that also includes my back up lights is defective. The light bar was defective at delivery of vehicle and this is the second time this light bar has been deemed defective by a Ford Dealership Service Department. The first repair on this defect was covered under a recall. This issue is a safety concern as it causes the rear light bar to flicker on and off and it has disabled the back up lights. There was no warning lights or alerts, I was pulled over by law enforcement and given a verbal warning to resolve the issue. The vehicle is currently at Red McCombs Ford in San Antonio, TX and Ford is denying any issue with the vehicle.