2023 Ford F-150 Lightning Bev

The contact owns a 2023 Ford F-150. The contact stated that upon charging the vehicle, the charge was reduced by 40 miles. The contact stated that the vehicle failed to charge properly with a low-volume charger but charged as needed while using the high-volume charger. The contact stated that while driving 55 MPH and overtaking another vehicle, the vehicle accelerated to 65 MPH as intended, but the vehicle temporarily lost motive power. The vehicle restarted independently, and the contact was able to drive to the residence. The vehicle was towed to the dealer, where the cause of the failure was not determined. The vehicle was not repaired. The contact stated that the failure persisted. The contact was a field engineer and determined that the high voltage battery power module had failed, causing the main 12-Volt battery charging failure and a computer failure. The contact notified the dealer and the manufacturer that the high-voltage battery needed to be replaced. The contact was awaiting a response from the manufacturer. The vehicle was not repaired. The failure mileage was approximately 16,000.

I was driving at 45 miles an hour. With no warning, the car had 28 warnings pop up and it just died with no warning. No power steering, no brake assist at all, no lights (not even emergency light would turn on). I was not able to put it into neutral so I was just stuck. Ford roadside was not able to get moving so I was just stuck. I called a tow and it was dragged up. The dealer determined it was a faulty 12v battery.

My f150 lightning won't drive wben put in Drive. Then all the sudden it goes forward when not expecting it and we almost was in an accident. This happened many times and has been in service for over 3 months. They aren't able to fix it. We are trying to get them to take it back. The computer we noticed was defective the day after we bought it and inquired about it immediately. ​delayed engagement followed by a sudden lurch or unintended acceleration—matches several reports from other F-150 Lightning owners. Because this vehicle is fully electric, "revving" effectively signals the electric motors to apply instant torque, which can lead to dangerous lunges if the software or sensors are out of sync.I mentioned the safety issues and it was not addressed Our computer goes in and out and blacks out when driving. Anything you ask of it has not worked. This isn't the biggest deal but the safety issue. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The rear light bar in the tailgate that also includes my back up lights is defective. The light bar was defective at delivery of vehicle and this is the second time this light bar has been deemed defective by a Ford Dealership Service Department. The first repair on this defect was covered under a recall. This issue is a safety concern as it causes the rear light bar to flicker on and off and it has disabled the back up lights. There was no warning lights or alerts, I was pulled over by law enforcement and given a verbal warning to resolve the issue. The vehicle is currently at Red McCombs Ford in San Antonio, TX and Ford is denying any issue with the vehicle.

The front traction motor on my 2023 Ford F-150 Lightning failed without warning, causing the vehicle to lose all-wheel drive capability. The truck automatically limited available power to about 67%, which I later learned indicates the front motor was disabled and the vehicle was operating in rear-wheel drive only. The failure occurred with no warning lamps, messages, or prior symptoms on the dashboard or in the FordPass app. I assumed AWD was functioning, which could have caused a serious accident in snow, ice, or gravel conditions because the loss of front-wheel traction significantly reduces vehicle stability. The component/system is still available for inspection. At this time, the issue has NOT been reproduced or confirmed by a dealer, and the vehicle has NOT yet been inspected by the manufacturer or any other party. Cause of failure is UNKNOWN. This lack of a warning or alert to the driver represents a major safety hazard because it changes how the vehicle handles without the driver’s knowledge.

While braking slowly to park at my home, my 2023 Ford F-150 Lightning XLT suddenly accelerated forward without any throttle input. The vehicle struck a wall. My foot was on the brake and I did not touch the accelerator. There were no warning messages prior to the incident. This could have caused serious injury or worse if anyone was in front of the vehicle. I believe this may be a critical safety defect.

The truck's remote access app is not able to communicate with the truck during the entire period I own the truck. This features worked 20% of time only. I am not able to unlock or lock the truck remotely. I am not able to find out its location and I am not able to remotely start its cooling system to keep battery cool during charging. I have brought the issue to the dealer I purchased the truck from at least 3 time in the last 2 years. Even though the truck's key was locked in it at the dealer, this issue was not resolved due to cost of its repair. Other trucks were repaired with a new modem. The truck was advertised as a remotely accessible EV truck, I am concerned about my safety if this feature is not available and I am at a urgent situation when it is necessary to use the features.