2021 Ford F-150 Hybrid

The vehicle is currently at Kayser Automotive Group located at 2303 West Beltline Hwy Madison, WI 53713, their direct line is [XXX], since the diagnoses of the corrosion of the DCN. SYSTEMS & COMPONENTS THAT FAILED: A faulty or clogged engine bay drain plug failed to divert water, causing significant water accumulation that routed into the interior cabin. This water intrusion directly soaked interior carpeting and exposed the Data Communication Network (DCN) connector and Body Control Module (BCM) wiring harness to moisture, resulting in severe pin corrosion and electrical communication faults. The vehicle and all affected components are fully available for inspection upon request. SAFETY RISK: The DCN connector and Body Control Module control critical vehicle operations, exterior lighting, instrument clusters, and safety/driver-assistance systems. Water corrosion on these communication buses causes unpredictable, uncommanded electrical failures and module communication dropouts while operating the vehicle at speed, creating a severe crash hazard to occupants and surrounding traffic. DEALER CONFIRMATION & INSPECTIONS: The issue was physically inspected and confirmed by an authorized Ford dealership service department, Kayser Automotive Group located at 2303 West Beltline Hwy Madison, WI 53713. Dealership technicians verified the water accumulation path, identified the faulty/clogged drain pathway, and documented physical corrosion on the DCN wiring connector. A Technical Assistance Center (TAC) case was requested to escalate the defect to Ford Corporate. WARNING LAMPS & PRIOR SYMPTOMS: Initial symptoms appeared as heavily saturated interior floor carpets and standing water pooling near the cowl/dash area. Shortly thereafter, intermittent electrical glitches, warning lamps on the instrument cluster, and network communication Diagnostic Trouble Codes (DTCs) appeared as the corrosion worsened. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Good Afternoon. The Pro Power Onboard high-voltage electrical system has experienced a permanent malfunction, locking out with a "Ground Fault Detected" warning. The vehicle is a 2021 Ford F-150 Rocky Ridge conversion. This failure stems directly from a defective or incomplete execution of Safety Recall 23S35 (NHTSA Campaign 23V613000).The initial remedy applied by the dealership consisted only of adding protective tape to the rear wiring harness. However, due to the increased travel and ride height of the official Rocky Ridge suspension lift, the wiring harness pulled out of its factory retaining side clip. This caused excessive tension and stretching on the high-voltage lines, completely exposing the bare interior colored wires and leaving them vulnerable to road moisture and friction against the metal frame.The system now triggers a permanent short-to-ground error, creating an imminent risk of an electrical short circuit or vehicle fire under the high-voltage (120V/240V) lines. The Ford dealership and corporate customer care refuse to remedy this recurring safety hazard under the recall warranty because it was previously marked as completed, even though the applied remedy failed to safely secure the harness. The component is available for inspection.

2021 Ford F-150 PowerBoost Hybrid, VIN [XXX]. At 112,000 miles — just 1,000 miles outside of warranty — the vehicle experienced catastrophic failure of the hybrid battery system. Ford's own technician diagnosed a short in the high voltage battery system that caused damage to the hybrid electric drive unit. Repair estimate is $19,000. Ford declined goodwill warranty coverage despite the vehicle being only 1,000 miles outside warranty and the failure occurring on a known problematic system. This is a $72,000 vehicle purchased new in 2021 that has suffered a catastrophic drivetrain failure at only 3 years old. The high voltage battery short and hybrid drive unit failure represent a potential safety hazard to drivers and other motorists. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle Information 2021 Ford F-150 PowerBoost VIN: [XXX] Complaint Description While driving approximately 70 mph on a highway, my 2021 Ford F-150 PowerBoost suddenly displayed a “Stop Safely Now” message and immediately lost propulsion. The engine shut down without warning while I was in active traffic. After the shutdown, the vehicle automatically shifted into park and would not allow me to shift into neutral. This left me unable to move the vehicle out of a live traffic lane. I was forced to shut the vehicle off while still in a dangerous roadway position. This incident created a serious safety hazard, as I was traveling at highway speed and could have been rear-ended due to the sudden loss of power and inability to move the vehicle. This issue appears to match Ford Technical Service Bulletin (TSB) 23-2317, which describes “Stop Safely Now” warnings, no-start conditions, and gateway module (GWM) software faults. This indicates a known defect that can cause sudden loss of propulsion. A claim has already been opened with Ford Motor Company under case number [XXX], and the vehicle is currently at a Ford dealership for diagnosis. At this time, the issue has not been resolved. This failure occurred without warning and presents a significant risk to driver safety and others on the road. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My Ford F150 was traveling on I95 North in Maryland when an emergency notice on the dashboard told be to pull over. The truck would not restart and had to be towed to a Ford dealer. I have since been told a controller module caught fire and damaged the hybrid battery and both would need to be replaced at a cost of over $10,000. This is a know issue and other Ford F150 Hybrid trucks as well as other Ford cars have already been recalled. Ford claims that my VIN was not included in the recall even though I experienced exactly what the recall was suppose to prevent. My wife and I could have been killed while traveling on the highway at 70 MPH and the vehicle was on fire without our knowledge.

The contact owns a 2021 Ford F-150. The contact stated while driving 45 MPH, the vehicle stalled. While at a stoplight, the accelerator pedal was depressed, but the vehicle failed to move or respond as needed. The contact stated that several unknown warning lights were illuminated. The vehicle was towed to the local dealer, who informed the contact that the failure might be battery-related. The vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed that there was no warranty coverage on the vehicle. The failure mileage was approximately 140,000.

I purchased a 2021 Ford F-150 Powerboost Lariat in November 2022. It was advertised as a Gold Certified Used vehicle. In October I stopped and put the truck in park, and when I got back in the truck it wouldn’t shift out of Park. The Message in the instrument panel said to shift into Park to start. However, the shift lever was stuck in Park with the yellow light flashing next to P. I had to spend $100 to have my truck towed to Young Ford in Ogden, Utah which is the closest dealership to my home. They had my truck there for two days and then called me and let me know my truck was ready to be picked up. They told me the problem was a software update and once they had completed the update, everything was working fine. They then charged me approximately $360 for the update. So essentially, I just spent $460 for a software update on my truck that is set to automatically download and install updates several times each week. The technician at the dealership checked my vehicle history and verified that I was up to date with all available updates. In just under two years of ownership, I have now had to take it to the dealership twice for software updates, and even more times for multiple recalls. This latest issue is infuriating because a simple software upgrade cost me two days of use, towing charges, and $360 to diagnose and download the update. Why does a software update completely disable a vehicle, and why is it not Ford’s responsibility? What if this happened during driving on the freeway? I should not have to take it to the dealership to be updated so that the vehicle will operate. In my mind this is no different than a recall. If a car becomes inoperable because of a problem from the dealer than the dealer should be financially responsible and not pass those costs to the consumer!