2006 Ford Explorer

TL*THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT WHEN ATTEMPTING TO ADD GASOLINE TO THE FUEL TANK, HE NOTICED THAT THE PUMP WOULD SHUT OFF AT TEN CENT INTERVALS WHICH MADE IT DIFFICULT TO ADD FUEL IN A TIMELY MANNER. THE FAILURE OCCURRED EVERY TIME HE ADDED FUEL TO THE VEHICLE. THE CANISTER AND HOSE WERE REPAIRED BY A MECHANIC BUT THE FAILURE CONTINUED. THE VEHICLE WAS NOT REPAIRED WHEN THE COMPLAINT WAS FILED. THE MANUFACTURER WAS NOT NOTIFIED. THE CURRENT MILEAGE WAS APPROXIMATELY 110,000. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000.

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. WHILE FILLING THE VEHICLE WITH GASOLINE, THE VEHICLE WOULD SPEW GAS BACK OUT OF THE FILLER TUBE, AND THEN DRAIN BACK INTO THE FUEL TANK. THE VEHICLE WAS TAKEN TO THE DEALER WHERE HE WAS ADVISED THERE WERE NO RECALLS ON HIS VEHICLE AND REPAIRS WOULD BE AT THE OWNERS EXPENSE. THE CONTACT FELT THIS COULD POTENTIALLY RISK HIS SAFETY. THE FAILURE MILEAGE WAS 48,000 AND THE CURRENT WAS 53,000.

BOUGHT 2006 EXPLORER NEW. AROUND 14,000 MILES ENGINE PROBLEMS STARTED, HAVE TAKEN CAR IN TO FORD DEALER WHERE CAR WAS PURCHASED ABOUT 7 TIMES FOR BASICALLY SAME PROBLEM ~ ENGINE LIGHT / CAR ENGINE LUNGING . MECHANICS DID DIFFERENT THINGS; REPLACED ONE DEFECTED PART WHILE UNDER WARRANTY, RESET COMPUTER, BUT PROBLEM ALWAYS CAME BACK. SOMETIMES HAPPENING BEFORE I MADE IT HOME. SOME TIMES MONTHS LATER. NOW THEY THINK MAYBE IT COULD BE THE THROTTLE BODY. *TR

I OWN A 2006 FORD EXPLORER XLT WITH A 4.0 V6. RECENTLY I WAS FILLING UP WITH GAS AND IT BEGAN CLICKING OFF EVERY 1/2 GALLON. I EVENTUALLY FILLED UP AFTER ABOUT 20 MINUTES. I TRIED AGAIN THE NEXT DAY, THINKING IT WAS THE PUMP, SAME PROBLEM. ENDED UP TAKING APART THE WHOLE FUEL LINE SYSTEM LOOKING FOR A CLOG. NO SUCH LUCK. FINALLY DECIDED IT MUST BE THE EVAP/CHARCOAL CANISTER. THERE IS A TSB ON THIS ISSUE, SO FORD OBVIOUSLY KNOWS ABOUT IT. BUT I HAD TO WAIT FOR THE PART TO COME IN, AND HAD NO OTHER VEHICLE TO DRIVE, SO I JUST CONTINUED FILLING UP FOR 30 MINUTES JUST TO GET A FULL TANK. THE WORST PART WAS THAT YOU COULD HEAR THE BUBBLING DOWN THE LINE, SINCE THE CHARCOAL CANISTER WOULD NOT PROPERLY RELEASE PRESSURE FROM THE TANK. SOMETIMES THE GAS WOULD EVEN COME BACK OUT THE FILL HOLE AND SPRAY ME WITH GAS (A REAL SAFETY ISSUE). I ENDED UP GETTING THE PART VERY CHEAP OFF OF AN JUNKED EXPLORER. BUT THE PART FROM A DEALER WAS OVER $400. DEFINITELY A SAFETY ISSUE WHICH NEEDS TO BE ADDRESSED. THANK YOU. *TR

THE FILLING OF GAS IN THE VEHICLE IS ALMOST IMPOSSIBLE- THE GAS SHUTS OFF EVERY 2-3 GALLONS THEN SPITS GAS BACK OUT ALL OVER THE PERSON TRYING TO FILL IT. RESULTING IN GAS BEING SPILLED OUT EVERYWHERE ON THE VEHICLE, THE DRIVER, THE GROUND. THIS BEGAN HAPPENING EVERY FEW TIMES GETTING GAS AND NOW IT IS EVERYTIME. I LOOKED THIS UP ONLINE TO FIND A TSB 07-25-3 PROBLEM ACCOMPANIED BY DTC P0451 SAYING THIS HAPPENS ALOT ON FORD EXPLORERS BUILT BEFORE 11/27/07. I CALLED THE FORD DEALER SERVICE DEPARTMENT THEY SAID THIS HAPPENS ALL THE TIME. THAT THE EVAP CANISTER AND VAPOR LINE WILL HAVE TO BE REPLACED. WHY IS THIS NOT A RECALL? IT'S NOT SAFE TO HAVE GAS SPRAYED ON YOU AND THE CAR AND GROUND EVERYTIME YOU TRY TO GET GAS. THANK YOU FOR YOUR CONCERN. *TR

TL*THE CONTACT OWNS A 2006 FORD EXPLORER. IN DECEMBER OF 2008, THE CONTACT ATTEMPTED TO FILL THE VEHICLE WITH FUEL, BUT THE FUEL WOULD COME BACK OUT OF THE FILLER NECK. IT TOOK APPROXIMATELY 15 MINUTES TO PLACE FIVE GALLONS OF FUEL IN THE VEHICLE. THE VEHICLE WAS DRIVEN TO THE DEALER AND THEY STATED THAT THEY REPAIRED THE VEHICLE. WHEN THE CONTACT ATTEMPTED TO FILL THE VEHICLE WITH FUEL THE SAME DAY, HE CONTINUED TO EXPERIENCE THE SAME FAILURE. THE VEHICLE WAS DRIVEN TO ANOTHER DEALER AND THEY STATED THAT THE FRESH AIR HOSE, WHICH WAS CONNECTED TO THE FUEL HOUSING UNIT, WAS NOT ALLOWING THE FUEL SYSTEM TO VENT PROPERLY. THE MECHANIC STATED THAT THE RESERVOIR EVAP CANISTER AND THE FUEL VAPOR HOSE NEEDED TO BE REPLACED IN ORDER FOR THE VEHICLE TO BE REPAIRED. THE MANUFACTURER STATED THAT THEY WERE NOT LIABLE FOR THE REPAIRS. THE CURRENT MILEAGE WAS 50,787 AND FAILURE MILEAGE WAS 48,000. UPDATED 03-09-09 *BF UPDATED 03/13/09. *JB

PURCHASED A 2006 FORD EXPLORER ON 5/6/06 AND TOOK A ROAD TRIP TO ALABAMA AND ON THE WAY BACK AROUND OCALA,FL, WE STARTED SMELLING GAS SMELL AS WE GOT OUT OF THE CAR AND WALKED AROUND IT. WE WERE ALWAYS STOPPED AT CONVENIENT STORES, WHICH HAVE GAS PUMPS AND DIDN'T THINK MUCH OF IT. WE DID LOOK UNDER VEHICLE AND DIDN'T SEE ANYTHING. WE KEPT DRIVING SOUTH TO COME HOME AND AROUND TAMPA,FL.. THE SMELL GOT A LITTLE MORE STRONG. LUCKILY WE MADE IT HOME W/OUT BLOWING UP. ONCE WE PULLED IN OUR DRIVEWAY, THE SMELL WAS REALLY BAD. MY HUSBAND GOT HIS FLASHLIGHT AND LOOKED UNDER THE VEHICLE AND GAS WAS DRIPPING OUT PRETTY STEADY. IT WAS MIDNIGHT ON SUNDAY AND WE NEW THAT THE FORD DEALERSHIP WAS CLOSED AT THAT TIME, SO WE WENT TO BED AND FIRST THING MONDAY MORNING, WE CALLED THE DEALERSHIP AND THEN THE TOWING TRUCK. THEY TOLD US TO GET FIRE DEPT OUT HERE TO DRAIN GAS . THE FIRE DEPT CAME AND USED PUTTY TO STOP LEAK SO WE COULD HAVE TRUCK TOWED. WE HAD TRUCK TOWED TO THE FORD DEALERSHIP TO BE FIXED AND ONCE THEY LOOKED AT IT, WE WERE TOLD THAT IT WAS OUR FAULT AND THEY WOULD NOT COVER UNDER WARRANTY. THEY SAID WE RAN OVER SOMETHING. WE WOULD HAVE KNOWN IF WE RAN OVER SOMETHING AND IF WE HIT ROCKS OR PEBBLES WHILE GOING DOWN INTERSTATE AND IT CAUSED THAT, THEN FORD HAS SOME SERIOUS FUEL TANK ISSUES. WE ENDED UP TURNING OVER TO OUR INSURANCE CO AND PAID TO GET TRUCK FIXED, WHICH IS FINE. WHEN OUR INSURANCE ADJUSTER LOOKED AT TRUCKS FUEL TANK, HE MADE US AWARE THAT THERE WAS NEVER A SKID PLATE PUT ON TO PROTECT FUEL TANK. PER DEALERSHIP, THIS IS OPTIONAL AND WE WERE NEVER TOLD ABOUT IT. SUPPOSEDLY, THE FUEL TANKS ARE BUILT NOW WHERE THEY DO NOT REQUIRE A SKID PLATE UNLESS IT IS A FOUR WHEEL DRIVE. MY FAMILIES SAFETY WAS PUT AT RISK AND NOBODY AT FORD THAT WE TALKED TO SEEMED TO CARE AND I THINK THIS SHOULD BE INVESTIGATED A LITTLE FURTHER, WHICH IS WHY I AM WRITING THIS AND LETTING YOU ALL KNOW. *JB