2005 FORD EXPLORER - EVERYTIME I FILL THE GAS TANK FULL - THE FUEL GAUGE STICKS AND GOES DOWN TO EMPTY. *TR
2005 Ford Explorer
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Ford Explorer do not stand out strongly from the model-year median of 609.
About this comparison →How this year compares
Owner complaints by model year
Compare all Explorer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
430 reports with mileage · 67 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 151 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 99 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Other complaints
11 reportsWE FILL THE TRUCK UP. THE NEXT DAY THE GAUGE SHOWS FULL. GREAT FOR A LONG DISTANCE TRIP. *TR
2005 FORD EXPLORER FUEL SENSOR FAILURE. *TR
WHEN I FILL MY GAS TANK, OCCASIONALLY THE ARROW DOES NOT GO TO FULL. I ALSO HAVE AN ELECTRONIC NOTIFICATION ON MY DASHBOARD THAT TELLS ME HOW MANY MILES I HAVE LEFT TO DRIVE BEFORE I AM ON EMPTY. THIS ALSO DOES NOT CHANGE. THIS HAS HAPPENED NO MORE THAN FIVE TIMES AND TAKES A DAY OR TWO FOR GAUGE TO READ FULL. *TR
2005 FORD EXPLORER - FUEL PUMP FAILURE WHILE DRIVING VEHICLE SHUTS OFF AND ALSO FUEL GAUGE READS E THEN EMISSION LIGHT COMES ON. THIS IS A SAFETY HAZARD AND A KNOWN DEFECT. MY VEHICLE HAD THIS TO HAPPEN AT 32,800 MILES AND I ALMOST WAS INVOLVED IN A MAJOR HIGHWAY ACCIDENT. BY MY CHACKS FORD IS AWARE BUT IS NOT CONCERNED SHOUL…
Read full complaint
2005 FORD EXPLORER - FUEL PUMP FAILURE WHILE DRIVING VEHICLE SHUTS OFF AND ALSO FUEL GAUGE READS E THEN EMISSION LIGHT COMES ON. THIS IS A SAFETY HAZARD AND A KNOWN DEFECT. MY VEHICLE HAD THIS TO HAPPEN AT 32,800 MILES AND I ALMOST WAS INVOLVED IN A MAJOR HIGHWAY ACCIDENT. BY MY CHACKS FORD IS AWARE BUT IS NOT CONCERNED SHOULD BE A RECALL. *TR
THE FUEL GAUGE SUDDENLY DROPS TO EMPTY EVEN WHEN THE FUEL TANK IS FULL. I HAVE A 2005 FORD EXPLORER THAT HAD THIS REPAIRED UNDER WARRANTY BECAUSE IT HAPPENED BEFORE 36000 MILES. MY HUSBAND HAS A 2005 FORD EXPLORER THAT WE JUST BOUGHT IN APRIL 2007. HIS JUST HIT 37,000 MILES AND THIS HAS HAPPENED TO HIM AS WELL. IT ALSO HAPPENED …
Read full complaint
THE FUEL GAUGE SUDDENLY DROPS TO EMPTY EVEN WHEN THE FUEL TANK IS FULL. I HAVE A 2005 FORD EXPLORER THAT HAD THIS REPAIRED UNDER WARRANTY BECAUSE IT HAPPENED BEFORE 36000 MILES. MY HUSBAND HAS A 2005 FORD EXPLORER THAT WE JUST BOUGHT IN APRIL 2007. HIS JUST HIT 37,000 MILES AND THIS HAS HAPPENED TO HIM AS WELL. IT ALSO HAPPENED IN MY COWORKER'S 2003 FORD EXPLORER. THERE IS A RECALL ON THE 2002 FORD EXPLORERS WITH V6 ENGINE COVERING THIS EXACT SAME PROBLEM. HOWEVER THE 2005S ARE NOT IN THE RECALL AND SHOULD BE. *TR
FUEL SYSTEM, CHECK ENGINE LIGHT. I JUST FILLED MY CAR UP WITH GAS AND I DROVE FOR LESS THAN A MILE AND THE FUEL GAUGE FAILED TO EMPTY AND THE CHECK ENGINE LIGHT CAME ON. AFTER I DROVE TO THE DEALERSHIP TO HAVE THE PROBLEM CHECK OUT, THEY WERE UNABLE TO DUPLICATE THE PROBLEM THAT DAY AND THE NEXT DAY IT WENT BACK TO NORMAL. *…
Read full complaint
FUEL SYSTEM, CHECK ENGINE LIGHT. I JUST FILLED MY CAR UP WITH GAS AND I DROVE FOR LESS THAN A MILE AND THE FUEL GAUGE FAILED TO EMPTY AND THE CHECK ENGINE LIGHT CAME ON. AFTER I DROVE TO THE DEALERSHIP TO HAVE THE PROBLEM CHECK OUT, THEY WERE UNABLE TO DUPLICATE THE PROBLEM THAT DAY AND THE NEXT DAY IT WENT BACK TO NORMAL. *TR
SERVICE ENGINE SOON LIGHT COMES ON AND SAYS I HAVE NO GAS WHEN THERE IS A FULL TANK OR LESS. *JB
DT: THE CONTACT OWNS A 2005 FORD EXPLORER. SAFETY COMPLAINT WAS THAT LIGHT CAME ON THAT SAID HAVE YOUR VEHICLE CHECKED IMMEDIATELY. THE CONTACT TOOK VEHICLE BACK TO DEALER TO HAVE THE FUEL PUMP FIXED. DEALER FIXED THE FUEL PUMP. NO CRASHES. NO POLICE REPORTS. NO FIRES. THE CONTACT WAS DRIVING ON ROAD WHEN LIGHT CAME ON. ALS…
Read full complaint
DT: THE CONTACT OWNS A 2005 FORD EXPLORER. SAFETY COMPLAINT WAS THAT LIGHT CAME ON THAT SAID HAVE YOUR VEHICLE CHECKED IMMEDIATELY. THE CONTACT TOOK VEHICLE BACK TO DEALER TO HAVE THE FUEL PUMP FIXED. DEALER FIXED THE FUEL PUMP. NO CRASHES. NO POLICE REPORTS. NO FIRES. THE CONTACT WAS DRIVING ON ROAD WHEN LIGHT CAME ON. ALSO, BEFORE THE GAS GAUGE WAS NOT WORKING PROPERLY. *AK
MY GAS GAUGE ALL OF A SUDDEN READ E AND MY SERVICE ENGINE SOON CAME ON, ON A THREE MONTH OLD 2005 FORD EXPLORER WITH 2200 MILES. I HAVE TO GUESSTIMATE HOW MUCH GAS I HAVE AND IF SOMETHING DOES GO WRONG WITH THE ENGINE I WILL NOT KNOW AS THE LIGHT IS PERPETUALLY ON. THE DEALER STATES THE FUEL SENDING UNIT IS BAD AND THE PART IS…
Read full complaint
MY GAS GAUGE ALL OF A SUDDEN READ E AND MY SERVICE ENGINE SOON CAME ON, ON A THREE MONTH OLD 2005 FORD EXPLORER WITH 2200 MILES. I HAVE TO GUESSTIMATE HOW MUCH GAS I HAVE AND IF SOMETHING DOES GO WRONG WITH THE ENGINE I WILL NOT KNOW AS THE LIGHT IS PERPETUALLY ON. THE DEALER STATES THE FUEL SENDING UNIT IS BAD AND THE PART IS BACKORDERED, I 'VE BEEN WAITING 3 WEEKS ALREADY. THE DEALER STATES THEY ARE WAITING ON 20 OF THEM FOR THIS SAME PROBLEM. I'VE CONTACTED THE MANUFACTURER AND THEY CLAIM TO HAVE NO KNOWLEDGE OF THE PROBLEM, THAT MY SITUATION IS THE FIRST THEY'VE HEARD OF IT. THIS CAN'T BE TRUE AS THE DEALER I TOOK MY CAR TO IS WAITING ON THE PART TO FIX 20 EXPLORERS WITH THIS SAME PROBLEM. I'VE ALSO FOUND THIS PROBLEM POSTED IN NUMEROUS FORUMS ONLINE. I DON'T THINK IT'S SAFE TO DRIVE AROUND NOT KNOWING FOR SURE HOW MUCH GAS YOU HAVE OR WHETHER OR NOT YOUR ENGINE IS ALSO MALFUNCTIONING. FORD SHOULD ISSUE A RECALL AND EXPEDITE THE MANUFACTURE OF THIS BACKORDERED PART. *NM
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA09013 · Vehicle Rollaway Allegations
Opened Aug 18, 2009 · Closed Feb 12, 2013
Status: closed (inferred from source dates) · Power Train:automatic Transmission:gear Position Indication (prndl); Power Train:automatic Transmission:lever And Linkage:column Shift; Steering; Steering:column; Steering:column LOCKING:ANTI-THEFT Device
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
Additional source detail variants (5)
Power Train:automatic Transmission:gear Position Indication (prndl)
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
Power Train:automatic Transmission:lever And Linkage:column Shift
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
Steering:column
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
Steering:column LOCKING:ANTI-THEFT Device
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
Steering
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
PE09020 · Vehicle Rollaway Allegations
Opened Apr 21, 2009 · Closed Aug 19, 2009
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:column LOCKING:ANTI-THEFT Device
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), FORD STATED CONSUMER REPORTS OF HIGHER THAN EXPECTED EFFORTS WHEN SHIFTING INTO AND OUT OF PARK COULD BE A RESULT OF A GROOVE BEING WORN INTO THE SWING ARM RAMP OF THE STEERING COLUMN. THE SWING ARM IS A COMPONENT BOLTED TO THE STEERING COLUMN THAT ASSISTS IN SHIFTING THROUGH THE TRANSMISSION GEARS.AN ENGINEERING EVALUATION CONDUCTED BY FORD OF RETURNED STEERING COLUMNS FOUND THE GROOVE COULD BE CREATED OVER TIME IF CONSUMER SHIFT MORE QUICKLY FROM THE DRIVE OR REVERSE TO PARK THAN THE BRAKE SHIFT INTERLOCK (BSI) SOLENOID PIN RETRACTS AFTER THE BRAKE PEDAL IS APPLIED. IN NOVEMBER OF 2004, FORD RELEASED A REDESIGNED BSI SOLENOID WITH A SHORTER PIN RETRACTING TIME AS A SERVICEABLE COMPONENT. FORD HAS NOTED THE SHORTER RETRACTION TIME SIGNIFICANTLY LESSENS THE LIKELIHOOD OF BSI SOLENOID PIN TO SWING ARM CONTACT EVEN WITH RAPID CONSUMER SHIFTS.FORD ALSO ISSUED A TECHNICAL SERVICE BULLETIN, TSB 04-22-12, TO INSTRUCT SERVICE TECHNICIANS ON THE PROPER DIAGNOSIS AND VEHICLE REPAIR. REVIEWING COMPLAINTS TO ODI AND DATA SUBMITTED BY FORD, ODI HAS IDENTIFIED 200 ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT AFTER CONSUMERS BELIEVE THEY HAVE SHIFTED THE VEHICLE INTO PARK, RESULTING IN 85 ALLEGED CRASHES AND 32 ALLEGED INJURIES.IN ADDITION TO THE REPORTS OF ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT, ODI HAS ALSO IDENTIFIED 883 REPORTS OF CONSUMERS ALLEGING DIFFICULTY OR THE INABILITY TO SHIFT THE VEHICLE INTO PARK.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-013) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (3)
Steering:column
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), FORD STATED CONSUMER REPORTS OF HIGHER THAN EXPECTED EFFORTS WHEN SHIFTING INTO AND OUT OF PARK COULD BE A RESULT OF A GROOVE BEING WORN INTO THE SWING ARM RAMP OF THE STEERING COLUMN. THE SWING ARM IS A COMPONENT BOLTED TO THE STEERING COLUMN THAT ASSISTS IN SHIFTING THROUGH THE TRANSMISSION GEARS.AN ENGINEERING EVALUATION CONDUCTED BY FORD OF RETURNED STEERING COLUMNS FOUND THE GROOVE COULD BE CREATED OVER TIME IF CONSUMER SHIFT MORE QUICKLY FROM THE DRIVE OR REVERSE TO PARK THAN THE BRAKE SHIFT INTERLOCK (BSI) SOLENOID PIN RETRACTS AFTER THE BRAKE PEDAL IS APPLIED. IN NOVEMBER OF 2004, FORD RELEASED A REDESIGNED BSI SOLENOID WITH A SHORTER PIN RETRACTING TIME AS A SERVICEABLE COMPONENT. FORD HAS NOTED THE SHORTER RETRACTION TIME SIGNIFICANTLY LESSENS THE LIKELIHOOD OF BSI SOLENOID PIN TO SWING ARM CONTACT EVEN WITH RAPID CONSUMER SHIFTS.FORD ALSO ISSUED A TECHNICAL SERVICE BULLETIN, TSB 04-22-12, TO INSTRUCT SERVICE TECHNICIANS ON THE PROPER DIAGNOSIS AND VEHICLE REPAIR. REVIEWING COMPLAINTS TO ODI AND DATA SUBMITTED BY FORD, ODI HAS IDENTIFIED 200 ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT AFTER CONSUMERS BELIEVE THEY HAVE SHIFTED THE VEHICLE INTO PARK, RESULTING IN 85 ALLEGED CRASHES AND 32 ALLEGED INJURIES.IN ADDITION TO THE REPORTS OF ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT, ODI HAS ALSO IDENTIFIED 883 REPORTS OF CONSUMERS ALLEGING DIFFICULTY OR THE INABILITY TO SHIFT THE VEHICLE INTO PARK.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-013) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Steering:column LOCKING:ANTI-THEFT Device
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), FORD STATED CONSUMER REPORTS OF HIGHER THAN EXPECTED EFFORTS WHEN SHIFTING INTO AND OUT OF PARK COULD BE A RESULT OF A GROOVE BEING WORN INTO THE SWING ARM RAMP OF THE STEERING COLUMN. THE SWING ARM IS A COMPONENT BOLTED TO THE STEERING COLUMN THAT ASSISTS IN SHIFTING THROUGH THE TRANSMISSION GEARS.AN ENGINEERING EVALUATION CONDUCTED BY FORD OF RETURNED STEERING COLUMNS FOUND THE GROOVE COULD BE CREATED OVER TIME IF CONSUMER SHIFT MORE QUICKLY FROM THE DRIVE OR REVERSE TO PARK THAN THE BRAKE SHIFT INTERLOCK (BSI) SOLENOID PIN RETRACTS AFTER THE BRAKE PEDAL IS APPLIED. IN NOVEMBER OF 2004, FORD RELEASED A REDESIGNED BSI SOLENOID WITH A SHORTER PIN RETRACTING TIME AS A SERVICEABLE COMPONENT. FORD HAS NOTED THE SHORTER RETRACTION TIME SIGNIFICANTLY LESSENS THE LIKELIHOOD OF BSI SOLENOID PIN TO SWING ARM CONTACT EVEN WITH RAPID CONSUMER SHIFTS.FORD ALSO ISSUED A TECHNICAL SERVICE BULLETIN, TSB 04-22-12, TO INSTRUCT SERVICE TECHNICIANS ON THE PROPER DIAGNOSIS AND VEHICLE REPAIR. REVIEWING COMPLAINTS TO ODI AND DATA SUBMITTED BY FORD, ODI HAS IDENTIFIED 200 ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT AFTER CONSUMERS BELIEVE THEY HAVE SHIFTED THE VEHICLE INTO PARK, RESULTING IN 85 ALLEGED CRASHES AND 32 ALLEGED INJURIES.IN ADDITION TO THE REPORTS OF ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT, ODI HAS ALSO IDENTIFIED 883 REPORTS OF CONSUMERS ALLEGING DIFFICULTY OR THE INABILITY TO SHIFT THE VEHICLE INTO PARK.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-013) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Steering
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), FORD STATED CONSUMER REPORTS OF HIGHER THAN EXPECTED EFFORTS WHEN SHIFTING INTO AND OUT OF PARK COULD BE A RESULT OF A GROOVE BEING WORN INTO THE SWING ARM RAMP OF THE STEERING COLUMN. THE SWING ARM IS A COMPONENT BOLTED TO THE STEERING COLUMN THAT ASSISTS IN SHIFTING THROUGH THE TRANSMISSION GEARS.AN ENGINEERING EVALUATION CONDUCTED BY FORD OF RETURNED STEERING COLUMNS FOUND THE GROOVE COULD BE CREATED OVER TIME IF CONSUMER SHIFT MORE QUICKLY FROM THE DRIVE OR REVERSE TO PARK THAN THE BRAKE SHIFT INTERLOCK (BSI) SOLENOID PIN RETRACTS AFTER THE BRAKE PEDAL IS APPLIED. IN NOVEMBER OF 2004, FORD RELEASED A REDESIGNED BSI SOLENOID WITH A SHORTER PIN RETRACTING TIME AS A SERVICEABLE COMPONENT. FORD HAS NOTED THE SHORTER RETRACTION TIME SIGNIFICANTLY LESSENS THE LIKELIHOOD OF BSI SOLENOID PIN TO SWING ARM CONTACT EVEN WITH RAPID CONSUMER SHIFTS.FORD ALSO ISSUED A TECHNICAL SERVICE BULLETIN, TSB 04-22-12, TO INSTRUCT SERVICE TECHNICIANS ON THE PROPER DIAGNOSIS AND VEHICLE REPAIR. REVIEWING COMPLAINTS TO ODI AND DATA SUBMITTED BY FORD, ODI HAS IDENTIFIED 200 ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT AFTER CONSUMERS BELIEVE THEY HAVE SHIFTED THE VEHICLE INTO PARK, RESULTING IN 85 ALLEGED CRASHES AND 32 ALLEGED INJURIES.IN ADDITION TO THE REPORTS OF ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT, ODI HAS ALSO IDENTIFIED 883 REPORTS OF CONSUMERS ALLEGING DIFFICULTY OR THE INABILITY TO SHIFT THE VEHICLE INTO PARK.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-013) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Illustration