NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
375 reports240,000 miles · Oct 8, 2015
Steering
WAS MAKING A RIGHT HAND TURN FROM A CITY STREET INTO MY COMMUNITY AND ABOUT 90 DEGREES INTO THE TURN THE STEERING LOCKED UP AND I WAS HEADED FOR THE MEDIAN. I STOPPED WITH THE BRAKES AND LOOKED DOWN AT THE DASH AND THE BATTERY PICTURE WAS RED WHICH HELPED ME TO REALIZE THE CAR HAD TURNED OFF. I PUT THE CAR IN PARK AND THEN START…
Read full complaint
WAS MAKING A RIGHT HAND TURN FROM A CITY STREET INTO MY COMMUNITY AND ABOUT 90 DEGREES INTO THE TURN THE STEERING LOCKED UP AND I WAS HEADED FOR THE MEDIAN. I STOPPED WITH THE BRAKES AND LOOKED DOWN AT THE DASH AND THE BATTERY PICTURE WAS RED WHICH HELPED ME TO REALIZE THE CAR HAD TURNED OFF. I PUT THE CAR IN PARK AND THEN STARTED IT UP AND THE PROBLEM WAS GONE.
NHTSA ODI #10780911
166,694 miles · Oct 8, 2015
Seat BeltsSeatsStructure
TL* THE CONTACT OWNS A 2001 FORD EXPLORER. WHILE DRIVING, THE FRONT DRIVER SIDE SEAT BELT WOULD SUDDENLY UNLOCK. IN ADDITION, THE DRIVER SIDE AND PASSENGER SIDE FRONT SEATS WOULD MOVE FORWARD WHEN MAKING A SUDDEN STOP AND THE PASSENGER SIDE DOOR AND HATCH DOOR WOULD NOT OPEN. THE VEHICLE WAS NOT DIAGNOSED AND REPAIRED. THE MANUF…
Read full complaint
TL* THE CONTACT OWNS A 2001 FORD EXPLORER. WHILE DRIVING, THE FRONT DRIVER SIDE SEAT BELT WOULD SUDDENLY UNLOCK. IN ADDITION, THE DRIVER SIDE AND PASSENGER SIDE FRONT SEATS WOULD MOVE FORWARD WHEN MAKING A SUDDEN STOP AND THE PASSENGER SIDE DOOR AND HATCH DOOR WOULD NOT OPEN. THE VEHICLE WAS NOT DIAGNOSED AND REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 166,694.
NHTSA ODI #10780714
109,400 miles · Sep 17, 2015
Steering
ON DRIVING MY TRUCK IT SLOWED DOWN ALMOST TO A STOP THEN MOVED BUT CONTINUED TO PUTTER AND SLOW DOWN--I GOT SCARED AND GOT IT IN MY DRIVEWAY AND CALLED AA TO TOW TO MY SERVICE MECHANIC--THE MECHANIC HAD IT FOR 2 DAYS AND COULD FIND NOTHING WRONG WITH IT---I TOLD HIM I FELT IT WAS IN THE GEARSHIFT AUTOMATIC AS WHEN I PUT IT IN P …
Read full complaint
ON DRIVING MY TRUCK IT SLOWED DOWN ALMOST TO A STOP THEN MOVED BUT CONTINUED TO PUTTER AND SLOW DOWN--I GOT SCARED AND GOT IT IN MY DRIVEWAY AND CALLED AA TO TOW TO MY SERVICE MECHANIC--THE MECHANIC HAD IT FOR 2 DAYS AND COULD FIND NOTHING WRONG WITH IT---I TOLD HIM I FELT IT WAS IN THE GEARSHIFT AUTOMATIC AS WHEN I PUT IT IN P IT LUNGES FORWARD AND I HAVE TO PUT MY FOOT ON THE BRAKE AGAIN--ALSO WHEN I HAVE IT IN D THE GEARSHIFT DOES NOT STAY IN THE MIDDLE, AS IT ALWAYS DID. HE SAID IT MIGHT BE WATER IN THE GAS, WHICH I SAID NO TO. I KNOW MY VEHICLE AS I HAD IT FROM DAY ONE AND IT DID NOT DRIVE LIKE THAT. IT HAS ONLY 110,000 MILES ON IT AND I TOOK GOOD CARE OF IT FOR UPKEEP AND NOW THAT I AM RETIRED AND AGE 70, MONEY TO REPAIR DOES NOT COME EASY WITH SMALL PENSION AND SOCIAL SECURITY.
NHTSA ODI #10764649
99,776 miles · Sep 12, 2015
Structure
FRAME /BODY MOUNTS, CREAK, SQUAWK CRUNCH , THE NOISE IS MOST NOTICEBLE WHEN TURNING OR HITTING BUMPS. SOME PEPLE ALSO DESCRIBE THE NOISE A HAMMER BEATING UNDER THE VEHICLE, THE CAUSE IS DETERIORATE BODY TO FRAME MOUNT CUSHIONS, THESE CUSHIONS APPER TO HAVE BEEN MADE OF SUBSTANDARD MATERIAL, MUCH LIKE CHINESE VALVE STEMS THAT CAU…
Read full complaint
FRAME /BODY MOUNTS, CREAK, SQUAWK CRUNCH , THE NOISE IS MOST NOTICEBLE WHEN TURNING OR HITTING BUMPS. SOME PEPLE ALSO DESCRIBE THE NOISE A HAMMER BEATING UNDER THE VEHICLE, THE CAUSE IS DETERIORATE BODY TO FRAME MOUNT CUSHIONS, THESE CUSHIONS APPER TO HAVE BEEN MADE OF SUBSTANDARD MATERIAL, MUCH LIKE CHINESE VALVE STEMS THAT CAUSE SO MUCH TROUBLE AFTER A FEW YEARS THE BODY MOUNTS DRY ROT , CRUMBLE AND LITERALLY FALL APART, THIS A TERRIBLE, THIS CAN PROVOKED A ACCIDENT.
NHTSA ODI #10763311
Mileage unknown · Jun 15, 2015
Electrical SystemEngineFire
TL* THE CONTACT OWNS A 2001 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN AN UNKNOWN MANUFACTURER RECALL. THE DEALER PERFORMED THE REPAIR, BUT THE FAILURE RECURRED. THE CONTACT NOTICED SMOKE NEAR THE ENGINE COMPARTMENT THAT ENTERED THE VEHICLE NEAR THE DASHBOARD. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. TH…
Read full complaint
TL* THE CONTACT OWNS A 2001 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN AN UNKNOWN MANUFACTURER RECALL. THE DEALER PERFORMED THE REPAIR, BUT THE FAILURE RECURRED. THE CONTACT NOTICED SMOKE NEAR THE ENGINE COMPARTMENT THAT ENTERED THE VEHICLE NEAR THE DASHBOARD. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE NHTSA CAMPAIGN NUMBER WAS UNAVAILABLE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #10725337
188,093 miles · Apr 24, 2015
Engine And Engine CoolingFire
I WAS SITTING IN A RESTAURANT DRIVE THRU WHEN THE CAR TURNED OFF. I TURNED THE CAR BACK ON & INCHED A BIT FORWARD IN LINE. MOMENTS AFTER THAT WHILE IN DRIVE, BUT NOT MOVING, I HEARD A LOUD POP. AFTER THAT, I SAW FLAMES SHOOTING TOWARDS THE FRONT WINDSHIELD COMING FROM UNDER THE HOOD ON MY SIDE. I PUT THE CAR IN PARK, TURNED OFF …
Read full complaint
I WAS SITTING IN A RESTAURANT DRIVE THRU WHEN THE CAR TURNED OFF. I TURNED THE CAR BACK ON & INCHED A BIT FORWARD IN LINE. MOMENTS AFTER THAT WHILE IN DRIVE, BUT NOT MOVING, I HEARD A LOUD POP. AFTER THAT, I SAW FLAMES SHOOTING TOWARDS THE FRONT WINDSHIELD COMING FROM UNDER THE HOOD ON MY SIDE. I PUT THE CAR IN PARK, TURNED OFF THE CAR AND TOOK THE KEY OUT OF THE IGNITION AND FLED. THE RESTAURANT WORKERS CAME TO MY AID AND PUT THE FIRE OUT BEFORE IT SPREAD. WHEN I WENT BACK TO SAY THANK YOU, THEY TOLD ME THAT THEY HEARD A SECOND POP BEFORE THEY PUT OUT THE FIRE. I HAVE REPORTED THIS TO FORD HEADQUARTERS. THEY CHECKED MY VIN AND TOLD ME THAT THE VEHICLE WAS UNDER RECALL FOR A DEFECT THAT CAUSES FIRES. I TOOK THE CAR TO A FORD DEALERSHIP A COUPLE MONTHS PRIOR TO THIS INCIDENT AND THEY DID NOT TELL ME ANYTHING ABOUT A RECALL ON THE CAR. ALSO, THE CAR OIL WAS LAST CHANGED 3/5/2015 AND WAS BELOW THE MILEAGE FOR ANOTHER OIL CHANGE, SO I AM SO CONFUSED AS TO WHY THIS HAPPENED. *TR
NHTSA ODI #10712749
107,000 miles · Nov 19, 2014
Equipment Adaptive/mobilityStructureSuspension
REAR END OF CAR THUMPED EVERY TIME YOU WOULD GO OVER THE SMALLEST SEPARATION IN THE ROAD AND ALSO ON A BUMPY ROAD. REPLACED REAR END SHOCKS. STILL HAVE THE SAME PROBLEM OF THUMPING. SOME TIMES IT FEELS LIKE I'M GOING TO LOOSE THE REAR END OF THE VEHICLE. I WAS TOLD POSSIBLY NOW THAT BACK BUSHINGS HOLDING THE BODY TO THE F…
Read full complaint
REAR END OF CAR THUMPED EVERY TIME YOU WOULD GO OVER THE SMALLEST SEPARATION IN THE ROAD AND ALSO ON A BUMPY ROAD. REPLACED REAR END SHOCKS. STILL HAVE THE SAME PROBLEM OF THUMPING. SOME TIMES IT FEELS LIKE I'M GOING TO LOOSE THE REAR END OF THE VEHICLE. I WAS TOLD POSSIBLY NOW THAT BACK BUSHINGS HOLDING THE BODY TO THE FRAME MAY BE DISINTEGRATED. VEHICLE HAS ALWAYS BEEN WELL MAINTAINED AND GARAGED. I HAVE FOUND OUT THAT THERE HAVE BEEN MANY COMPLAINTS ABOUT THIS OCCURRING NOW WITH THIS 2001 MODEL. YOU WOULD THINK THERE WOULD BE A SAFETY RECALL BY FORD TO FIX THESE BUSHING PROBLEMS. *TR
NHTSA ODI #10659595
100,000 miles · Nov 3, 2014
Structure
TL* THE CONTACT OWNS A 2001 FORD EXPLORER. THE CONTACT STATED THAT THE BODY MOUNTS CORRODED WHICH CAUSED THE FRAME TO BECOME DETACHED FROM THE BODY OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER AND THE REAR BODY MOUNTS WERE REPLACED. THE FRONT PARTS WERE NOT REPLACED DUE TO THE PARTS BEING UNAVAILABLE. THE MANUFACTURER WAS N…
Read full complaint
TL* THE CONTACT OWNS A 2001 FORD EXPLORER. THE CONTACT STATED THAT THE BODY MOUNTS CORRODED WHICH CAUSED THE FRAME TO BECOME DETACHED FROM THE BODY OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER AND THE REAR BODY MOUNTS WERE REPLACED. THE FRONT PARTS WERE NOT REPLACED DUE TO THE PARTS BEING UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10652220
87,372 miles · Oct 16, 2014
Fuel/propulsion SystemPower TrainUnknown Or Other
THE FORD EXPLORER 2001 XLS 4.0L REAR WHEEL DRIVE TRANSMISSION IS DEFECTIVE IN SLIP 4 TO 5 GEAR IN 75000 MILES. *TR
NHTSA ODI #10648140
187,000 miles · Jun 21, 2014
Power Train
I TOOK MY CAR TO ASTORIA FORD LATE LAST YEAR, BECAUSE IT WAS STALLING AND LOSING POWER. THE CHARGED ME ALMOST $1,000.00 AND THE PROBLEM PERSISTS. THE O/D ON OFF LIGHT WILL STOP AND START. WHEN IT COMES ON WHICH JUST STARTED TODAY, THE CAR IN ANY GEAR WHILE ONLY GO FORWARD. IN REVERSE AND NEUTRAL, ONLY FORWARD. AS A POLICE OFFICE…
Read full complaint
I TOOK MY CAR TO ASTORIA FORD LATE LAST YEAR, BECAUSE IT WAS STALLING AND LOSING POWER. THE CHARGED ME ALMOST $1,000.00 AND THE PROBLEM PERSISTS. THE O/D ON OFF LIGHT WILL STOP AND START. WHEN IT COMES ON WHICH JUST STARTED TODAY, THE CAR IN ANY GEAR WHILE ONLY GO FORWARD. IN REVERSE AND NEUTRAL, ONLY FORWARD. AS A POLICE OFFICER THIS IS VERY DANGEROUS, AND I CANNOT DRIVE THE VEHICLE. MANY HAVE SUBMITTED COMPLAINTS ABOUT THIS TO FORD, THEY CALL IT A PHANTOM PROBLEM. I HOPE THIS PHANTOM PROBLEM DOES NOT OCCUR IN FRONT OF A DAY CARE. *TR
NHTSA ODI #10605000
Official recalls
6Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Aug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Aug 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL AND 4.0L SOHC ENGINES, IF THE STRAND COVER ON THE SPEED CONTROL CABLE BECOMES FLARED AT THE END, THE SPEED CONTROL CABLE MAY BIND WHEN THE SPEED CONTROL IS ACTIVATED.
Consequence & remedy
Consequence: THE THROTTLE RETURN SPRING FORCE MAY NOT BE SUFFICIENT TO OVERCOME THE BINDING CONDITION WHEN THE SPEED CONTROL IS DISENGAGED. BRAKING FUNCTION WOULD BE MAINTAINED THOUGH STOPPING DISTANCES MAY BE INCREASED.
Remedy: DEALERS WILL INSPECT THE SPEED CONTROL CABLE AND, IF NECESSARY, REPLACE IT. OWNER NOTIFICATION BEGAN AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Aug 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT, THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. IF THE BOLT FRACTURES AND DOES NOT JAM IN THE SEAT BACK FRAME, THE SEAT BACK MAY RECLINE UNTIL IT MAKES CONTACT WITH AN OBJECT BEHIND THE SEAT, SUCH AS THE SECOND ROW SEAT CUSHION.
Consequence & remedy
Consequence: THE DRIVER COULD POTENTIALLY LOSE CONTACT WITH THE STEERING WHEEL OR FOOT PEDALS DURING SUCH AN EVENT, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE DRIVER SEAT UPPER BOLT WITH A METAL SPACER AND BOLT. IN ADDITION, SEATS WITH TUBULAR BACK FRAMES WILL HAVE THE FULLY THREADED LOWER RECLINER BOLT REPLACED WITH A PARTIALLY THREADED BOLT. OWNER NOTIFICATION BEGAN ON AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Oct 17, 2000
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567.4, "CERTIFICATION." THESE VEHICLES WERE SHIPPED FROM THE ASSEMBLY PLANT WITHOUT SAFETY CERTIFICATION LABELS.
Consequence & remedy
Consequence: INCORRECT TIRE INFLATION PRESSURE COULD RESULT IN TIRE TREAD SEPARATION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE CERTIFICATION LABELS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP05005 · Spark Plug Ejection From Cylinder Head
Opened Sep 22, 2005 · Closed Jan 4, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Additional source detail variants (3)
Engine And Engine Cooling:engine
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
PE03020 · Front Seat Back Recliner Attachment
Opened May 21, 2003 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
BY LETTER DATED AUGUST 4, 2003, FORD NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V281) INVOLVING CERTAIN MODEL YEAR (MY) 1998-2001 FORD EXPLORER / MERCURY MOUNTAINEER 4-DOOR, MY 1998-2000 FORD EXPLORER 2-DOOR AND MY 2001-2002 FORD EXPLORER SPORT AND SPORT TRAC VEHICLES EQUIPPED WITH HIGH BACK SEATS.COMPLAINTS ALLEGE THAT THE DRIVER'S SEAT BACK RECLINED WITHOUT WARNING.A BOLT BETWEEN THE UPPER SEAT RECLINER ATTACHMENT AND THE SEAT BACK FRAME MAY FRACTURE.FORD WILL REPLACE THE BOLT THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME ON THE DRIVER SIDE SEAT.BASED ON FORD'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Illustration