1996 Ford Explorer

TRAVELING HOME ON HIGHWAY 509 AROUND 3:00 PM IN MY 1996 FORD EXPLORER, CONDITIONS WERE CLEAR AND DRY, PASSED A CAR GOING 40 MPH IN A 55MPH ZONE, UPON PASSING THE ACCELERATOR WENT STRAIGHT TO THE FLOOR AND STUCK THERE. TRIED TO PLACE MY FOOT UNDER THE PEDAL TO LIFT UP, COULD'NT. SUV STEADILYGAINING SPEED,LAS TIME I GLANCED DOWN I WAS GOING APPROX. 95MPH, TRIED TO APPLY BRAKES TO SLOW DOWN ENOUGH SO I COULD GET ON THE SHOULDER OF THE ROAD SAFLEY,SUV WENT OFF THE ROAD DID A FLIP IN MID AIR ROLLED HITTING ON THE PASSENGER SIDE AND CAME TO REST ON DRIVERS SIDE. AIR BAGS DID NOT DEPLOY, ENGINE WAS STILL RUNNING WIDE OPEN, MANAGED TO SOMEHOW REACH THE IGNITION KEY TO TURN ENGINE OFF, IT TOOK FIRE RESCUE 35 MINUTERS TO CUT ME OUT OF THE SUV,I WAS TAKEN TO THE HOSPITAL WITH MINOR INJURIES,AS OF 12/10/04 I AM STILL GOING THROUGH THERAPY WITH MY NECK AND SHOULDERS, SUV WAS A TOTAL LOSS.HAD TO PURCHASE A NEW AUTOMOBILE.*AK

WHILE DRIVING VEHICLE SUDDENLY ACCELERATED UNCONTROLLABLY. THE CONSUMER APPLIED THE BRAKES AND PEDAL WENT TO THE FLOOR. THE VEHICLE CONTINUED TO ACCELERATE WITH SPEED. THE CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, PULLED OVER, AND TURNED THE VEHICLE OFF. THE CONSUMER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION, AND THE MECHANIC DETERMINED THAT THE SPEED SENSOR CABLE NEEDED TO BE REPLACED. *AK THE CONSUMER WAS ENTERING A RAMP WHEN THE VEHICLE HAD TAKEN OFF VERY FAST. THE CONSUMER FELT THE EXPERIENCE WAS LIKE THE CRUISE CONTROL HAD TAKEN OVER. THE CONSUMER STATED THAT HER FOOT WAS ALL THE WAY DOWN ON THE BRAKE PEDAL . THE CONSUMER MANAGED TO SLOW THE VEHICLE DOWN, VEERED OFF OF THE HIGHWAY, SHIFTED THE GEAR TO PARK WITH THE VEHICLE STILL MOVING, THEN APPLIED THE EMERGENCY BRAKE WITH ONLY SECONDS TO SPARE. *SC

THE BRACKET HOLDING THE FOOT ACCELERATOR PEDAL ON MY 1996 FORD EXPLORER BROKE OFF WHILE DRIVING THE VEHILE. AS A RESULT OF THIS FAILURE I LOST COMPLETE CONTROL OF THE ABILITY TO ADD FUEL TO THE ENGINE AND ACCELERATE OR HOLD SPEED. THE BRACKET APPEARED TO HAVE BEEN WELDED TO THE FIREWALL AS PART OF THE MANUFACTURING PROCESS. ALL 3 WELDS BROKE. AT THE TIME I WAS NOT DOING ANYTHING OUT OF THE ORDINARY AND HAD NOT PUT ANY ABNORMAL STRAIN OR PRESSURE ON THE FOOT FEED PEDAL OR THE BRACKET. THERE IS NO APPEARANCE OF CORROSION SO I SUSPECT THE WELDS FAILED FARILY RECENTLY. IF THIS FAILURE HAD OCCURED AS I WAS PULLING INTO OR ACCROSS TRAFFIC A SERIOUS ACCIDENT COULD HAVE RESULTED. *AK

I WAS DRIVING 75 ON I76 IN COLORADO. I HAD THE SPEED CONTROL SET TO 75 MPH. ALL OF A SUDDEN, I COULDN'T CANCEL SPEED CONTROL AND THE SPEED STARTED INCREASING. I TRIED EVERYTHING TO CANCEL IT - NO LUCK. I SLAMMED ON THE BRAKES AND BROUGHT THE CAR TO A SLOWER SPEED MOVING STRAIGHT BEFORE TURNING THE KEY AND ENGINE OFF - I KNEW THE STEERING WHEEL WOULD LOCK, THAT'S WHY I STRAIGHTENED THE CAR OUT ON THE SHOULDER BEFORE I TURNED IT OFF.*AK

MY 1996 EXPLORER IS A 5.0 LITRE AWD EDDIE BAUR PURCHSED USED. AFTER DRIVING USING THE CRUISE CONTROL WITHOUT INCIDENT, I PULLED INTO A PARKING LOT. COASTING SLOWLY INTO A PARKING SLOT APPLYING THE BRAKES, THE ENGINE APPEARED TO INCREASE POWER MAKING IT DIFFICULT TO STOP. THE MORE I PRESSED THE BRAKE PEDAL THE MORE THE ENGINE POWER INCREASED PREVENTING THE VEHICLE FROM STOPPING UNTIL COLLIDING WITH A VEHICLE IN FRONT. WITH THE BRAKE STILL APPLIED, THE ENGINE RACED WHEN PUT IN NUETRAL UNTIL SWITCHING THE IGNITION OFF. THE BRAKE AND ACCELERATOR OPERATED NORMALLY AFTER RESTARTING. DAMAGE RESULTED TO THE EXPLORER BUMPER. I DID NOT OBSERVE THE GAS PEDAL POSITION DURING THE INCIDENT BUT ASSUMED IT COULD HAVE BEEN DRIVEN BY THE CRUISE CONTROL CABLE UNDER UNCOMMANDED OPERATION AND SEVERED THE CRUISE CABLE BEFORE PROCEDING. A SIMILAR PROBLEM HAD OCCURED DURING A PRIOR STOP THE SAME TRIP BUT ABRUPTLY RETURNED TO NORMAL OPERATION POSSIBLY AFTER HAVING PUMPED THE BRAKES TO CHECK THEM. THE SAME TYPE PROBLEM WITH ENGINE POWER SURGE DURING BRAKING TO A STOP OCCURED ON PRIOR DAYS WHEN THE CRUISE CONTROL HAD NOT BEEN USED AND MAY HAVE CORRECTED AFTER PUMPING THE BRAKE. REVIEWING NHSTA COMPLAINT ODI ID 736277 AND SUBSEQUENT EXPERIMENT ON MY VEHICLE, IT APPEARS THE PROBLEM COULD POTENTIALLY RESULT FROM INADVERTANT PRESSING THE GAS PEDAL DURING BRAKING DUE TO PROXIMITY OF THE PEDALS BUT I CAN'T RULE OUT UNCOMMANDED CRUISE CONTROL OPERATION ACTIVATED BY A BRAKE SIGNAL. PLEASE ADVISE IF INVESTIGATION AND DISCOVERY HAVE RESULTED IN ANY PROBABLE CAUSES AND RECOMMENDATIONS FOR CORRECTIVE MAINTENANCE FOR THIS SAFETY HAZARD. DOES NOT DISPLAY SYMPTOMS CORRECTED BY RECALLS FOR THROTTLE BODY STICKING AND JAMMED CRUISE CONTROL CABLE.*AK

RECALL 97V074000 CONCERNING THROTTLE BODY FAILURE. DURING THE WINTER MONTHS WHILE REVVING UP THE ENGINE IT WILL RACE VERY VIOLENTLY. ENGINE WOULD RACE TO THE POINT WHEN IT WOULD BE NECESSARY TO PRESS THE BRAKES REAL HARD TO KEEP THE VEHICLE FROM MOVING FORWARD. THIS HAPPENED TEN TIMES IN 2003 . THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK

TRUCK WAS IN PARK. PUT MY FOOT ON BRAKE, SHIFTED INTO DRIVE, TRUCK IMMEDIATELY MOVED FORWARD WITH FOOT STILL ON BRAKE, AT APPROX 2- 5 MPH. PUSHED CONTINUALLY HARDER ON BRAKE WITH NO RESPONSE. LIFTED FOOT COMPLETELY OFF BRAKE AND PUSHED AGAIN, THEN TRUCK STOPPED. WENT THROUGH A GARAGE DOOR IN THE PROCESS, COULDN'T STOP UNTIL TRUCK WAS FULLY THROUGH.*AK