IllustrationPE00 020; CONSUMER WAS TRAVELING ABOUT 55MPH ON HIGHWAY AND VEHICLE STARTED SHAKING. SHE WAS ABLE TO PULL VEHICLE OVER TO SAFETY. LEFT REAR FIRESTONE TIRE TREAD SEPARATED FROM RIM. CONSUMER DID NOT PROVIDE TIRE BRAND OR SIZE. *SLC
1996 Ford Explorer
Owner reports · Recalls · Investigations
More warning signs than most Explorer years
Owner complaints for the 1996 Ford Explorer are substantially higher than the model-year median of 609.
About this comparison →How this year compares
Owner complaints by model year
Compare all Explorer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 153 of 1,450 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Tires. Review the 570 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 148 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 120 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
195 crash reports37 fire reports179 injury reports
Tires complaints
570 reportsNOTICED HAIRLINE CRACK CIRCLING TIRE AT BOTTOM OF TREAD. I CONTACTED FIRESTONE, INITIALLY I WAS OFFERED 1 REPLACEMENT TIRE OF THE SAME TYPE AS THE FAILED TIRE IF AN INSPECTION OF THE PROBLEM TIRE VERIFIED MY CONCERN REGARDING THE BEGINNING OF TREAD SEPARATION PROBLEM. I INFORMED THE FIRESTONE HOTLINE AND DEALER REP THAT THIS WA…
Read full complaint
NOTICED HAIRLINE CRACK CIRCLING TIRE AT BOTTOM OF TREAD. I CONTACTED FIRESTONE, INITIALLY I WAS OFFERED 1 REPLACEMENT TIRE OF THE SAME TYPE AS THE FAILED TIRE IF AN INSPECTION OF THE PROBLEM TIRE VERIFIED MY CONCERN REGARDING THE BEGINNING OF TREAD SEPARATION PROBLEM. I INFORMED THE FIRESTONE HOTLINE AND DEALER REP THAT THIS WAS UNACCEPTABLE, I WANTED ALL TIRES REPLACED EVEN THOUGH THESE WERE NOT UNDER RECALL. I INFORMED THEM THAT IT WAS LUDICROUS TO BE PUT IN A SITUATION WHERE I WOULD BE FORCED TO CONTINUE CHECKING ALL TIRES EVERY THREE DAYS. I WOULD NOT BE PUT IN THAT SITUATION. BEING PERSISTANT, I WAS ADVISED TO CONTACT DIST MGR. NO TOLL FREE #, AT MY OWN EXPENSE (PHONE) I CONTACTED DIST MGR. HE APPROVED ALL REPLACEMENT, WHEN CONFIRMED. CONFIRMED BY COMPANY OWNED TIRE STORE 11/13/00. ALL FIVE REPLACED 11/14/00 WITH BRIDGESTONE DUELER AT. I AM SATISFIED AT THIS TIME. I SIMPLY WANTED TO REPORT FAILURE OF TIRE MADE IN WILSON, NC. AFTER BEING PUSHED, BRIDGESTONE/FIRESTONE DID THE RIGHT THING, ALTHOUGH THEY HAD TO BE PUSHED, AFTER THE FIRST LINE OF CONTACT TRIED TO MINIMIZE AND DEFLECT. I PRAISE FIRESTONE FOR EVENTUALLY DOING THE RIGHT THING. *AK (DOT NUMBER: W2HLIPYL08 TIRESIZE: P235/75R15)
FIRESTONE WILDERNESS AT TIRES (P255 70 R16) ARE EXPERIENCING SIDEWALL AND TREAD SEPARATION. *SLC
THE FIRESTONE ATX P 234/75R15 105S M/S DOT VDHL 1PM-435 TIRES WERE REPLACED PRIOR TO RECALL (00T-005) DUE TO VIBRATION PROBLEMS, CONSUMER HAD PREVIOUS REPAIRS TO THE SUSPENSION SYSTEM TO TRY AND REMEDY VIBRATION WITHOUT REMEDY, CONSUMER REQUESTING REIMBURSEMENT. *MJS
CONSUMER WAS TRAVELING ABOUT 55MPH ON HIGHWAY AND HEARD A THUMPING SOUND. THEN, HE SLID, BUT WAS ABLE TO BRING VEHICLE TO SAFETY. HE NOTICED THAT RIGHT REAR TIRE TREAD SEPARATED FROM RIM. ALSO, THERE WAS DAMAGE TO VEHICLE. FIRESTONE, #AT, P235/75R15 #DOT VDHL. THERE WERE NO INJURIES, AND FIRESTONE HAS REPLACED TIRE…
Read full complaint
CONSUMER WAS TRAVELING ABOUT 55MPH ON HIGHWAY AND HEARD A THUMPING SOUND. THEN, HE SLID, BUT WAS ABLE TO BRING VEHICLE TO SAFETY. HE NOTICED THAT RIGHT REAR TIRE TREAD SEPARATED FROM RIM. ALSO, THERE WAS DAMAGE TO VEHICLE. FIRESTONE, #AT, P235/75R15 #DOT VDHL. THERE WERE NO INJURIES, AND FIRESTONE HAS REPLACED TIRES.*AK *SLC
CONSUMER TOOK THE VEHICLE IN FOR RECALL (00T-005) REPLACEMENT TIRES, THE DEALERSHIP REPLACED THEM WITH MICHELIN TIRES, CONSUMER IS HAVING TROUBLE OBTAINING RECALL REIMBURSEMENT. *MJS
THE FIRESTONE TIRES ON THE VEHICLE WERE REPLACED PRIOR TO RECALL (OOT-005) DUE TO VIBRATION AND BLOWOUT WHICH RESULTED IN MINOR ACCIDENT WHEN THE CONSUMER LOST CONTROL OF THE VEHICLE, WHICH CAUSED DAMAGE TO THE FRONT PANEL AND DRIVERS DOOR. CONSUMER HAD PRIOR PROBLEMS WITH VIBRATION AND WENT TO THE FIRESTONE DEALER ON THREE OCC…
Read full complaint
THE FIRESTONE TIRES ON THE VEHICLE WERE REPLACED PRIOR TO RECALL (OOT-005) DUE TO VIBRATION AND BLOWOUT WHICH RESULTED IN MINOR ACCIDENT WHEN THE CONSUMER LOST CONTROL OF THE VEHICLE, WHICH CAUSED DAMAGE TO THE FRONT PANEL AND DRIVERS DOOR. CONSUMER HAD PRIOR PROBLEMS WITH VIBRATION AND WENT TO THE FIRESTONE DEALER ON THREE OCCASIONS WITHOUT REMEDY (1998-1999). *MJS
CONSUMER REPLACED FIRESTONE TIRE DUE TO IRREGULAR TIRE WEAR AND VIBRATION WHILE DRIVING, CONSUMER REQUEST REIMBURSEMENT BUT WAS DENIED BECAUSE THEY WERE PURCHASED FROM A COMPETITOR PRIOR TO AUGUST 9, 2000. NLM
FIRESTONE ATX TIRES EXPEREINCED SEPARATION FOLLOWED BY A BLOWOUT OF THE LEFT REAR TIRE WHICH CAUSED THE VEHICLE TO SWERVE INTO OPPOSING LAND AND RUN OFF THE ROAD, AFTER THE CAR RAN OFF THE ROAD THE VEHICLE ROLLED OVER NUMEROUS TIMES, INJURIES ARE UNDER REVIEW (ATTORNEY FOR CLIENT). NLM
THE BELT OF THE FIRESTONE TIRES WERE BROKEN RESULTING IN A ROUGH RIDE, CONSUMER REPLACED ALL FOUR TIRES AND REQUEST REIMBURSEMENT BUT WAS DENIED BECAUSE THE REPLACEMENT TIRE WERE PURCHASED FROM A COMPETITOR PRIOR TO AUGUST 9, 2000. NLM
Official recalls
609V399000 · Vehicle Speed Control
Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
00V402000 · Suspension
Nov 28, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER CERTAIN CONDITIONS, A FRONT SWAY BAR LINK CAN FRACTURE.
Consequence & remedy
Consequence: VEHICLE HANDLING COULD BE AFFECTED, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE BOTH THE LEFT AND RIGHT FRONT SWAY BAR LINKS.
97V137000 · Structure:body:hatchback/liftgate:support Device/strut
Aug 19, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES. THE LIFTGATE ASSIST GAS CYLINDER BRACKET ON THE RIGHT HAND BODYSIDE OUTER PANEL WAS INCORRECTLY WELDED.
Consequence & remedy
Consequence: THE GAS CYLINDER BRACKET MAY NOT PROPERLY SUPPORT THE LIFTGATE INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REINFORCE THE BRACKET ATTACHMENT WITH TWO POP RIVETS.
97V074000 · Vehicle Speed Control
Apr 30, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH 5.0L ENGINES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, IDAHO, IOWA, MAINE, MICHIGAN (UPPER PENINSULA ONLY), MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. THESE VEHICLES, WHEN OPERATED FOR EXTENDED PERIODS OF TIME AT HIGHWAY SPEEDS AND TEMPERATURES BELOW -20 DEGREES FARENHEIT, DO NOT RETURN TO IDLE DUE TO ICE IN THE THROTTLE BODY.
Consequence & remedy
Consequence: ALTHOUGH THE VEHICLE CAN BE CONTROLLED BY EITHER APPLYING THE SERVICE BRAKES OR SHIFTING THE TRANSMISSION TO NEUTRAL, INCREASED BRAKE PEDAL EFFORTS OR SOME INCREASE IN STOPPING DISTANCE CAN RESULT.
Remedy: DEALERS WILL INSTALL A REVISED PCV SYSTEM WITH WATER HEATED VACUUM SOURCE.
96V161000 · Equipment:other:labels
Aug 29, 1996
THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: INCORRECT INFLATION PRESSURES COULD CAUSE PREMATURE WEAR OF THE REAR TIRES. .
Remedy: OWNERS WILL BE PROVIDED WITH CORRECT CERTIFICATION LABELS AND INSTRUCTIONS FOR INSTALLING THESE LABELS. DEALERS CAN INSTALL THIS LABEL IF THE OWNER SO DESIRES.
96V070000 · Latches/locks/linkages:doors:latch
Apr 22, 1996
WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence & remedy
Consequence: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE00039 · Front Suspension Stabilizer Bar Link
Opened Sep 20, 2000 · Closed Nov 30, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE99068 · Accelerator Pedal
Opened Nov 1, 1999 · Closed Mar 9, 2000
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
PE97010 · Electrical Fire In Center Console
Opened Mar 13, 1997 · Closed Sep 4, 1997
Status: closed (inferred from source dates) · Electrical System
THIS INVESTIGATION REVEALED THAT CONSOLE FIRES IN THE SUBJECT VEHICLES MOST OFTEN OCCURRED WHILE VEHICLES EQUIPPED WITH THE LAMP OUTAGE MODULE (LOM), WHICH IS PART OF THE MESSAGE CENTER, WERE TOWING A TRAILER AND WHICH HAD BEEN MODIFIED BY ADDING AN AFTERMARKET TRAILER WIRING HARNESS INTO THE VEHICLE'S TAILLIGHT CIRCUITS.THE OWNER'S MANUAL STATES NEVER AND MORE THAN OTHER TRAILER LIGHT BULB TO ONE CIRCUIT HOWEVER TRAILERS FREQUENTLY CONTAIN SEVERAL BULBS.THE RESULTING EXCESS CURRENT PASSING THROUGH THE LOM COULD CAUSE IT TO OVERHEAT RESULTING IN A FIRE.PROPER AFTERMARKET INSTALLATION OF TRAILER WIRING REQUIRES THE USE OF A BYPASS MODULE, WHICH OBTAINS POWER FOR THE TRAILER LIGHTS DIRECTLY FROM THE BATTERY RATHER THAN FROM THE VEHICLE'S TAIL LIGHT AND STOP LAMP CIRCUITS, OR THE USE OF THE MANUFACTURER'S WIRING HARNESS.IN A LETTER DATED SEPTEMBER 2, 1997, FORD NOTIFIED ODI THAT IT INTENDS TO TAKE ACTION TO PRECLUDE FURTHER INCIDENTS INCLUDING ISSUING A TECHNICAL SERVICE BULLETIN TO ITS DEALERS, NOTIFYING TRAILER RENTAL ASSOCIATIONS AND AGENCIES WHERE KNOWN, AND ADVISING OWNERS BY LETTER OF THE PROPER METHOD FOR CONNECTION OF TRAILER TOW WIRING ON THE SUBJECT VEHICLES.THERE WAS NO DEFECT TREND IN THE SUBJECT VEHICLES IDENTIFIED AS A RESULT OF THIS INVESTIGATION, AND FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT WARRANTED TO CONTINUE THE INVESTIGATION.