I CURRENTLY OWN A 1996 FORD EXPLORER XLT, 4X4, 5-SPEED MANUAL TRANSMISSION. ONE THING I HAVE NOTICED WITH THIS VEHICLE IS WHEN I AM EITHER STOPPING MODERATELY HARD/FAST OR MAKING SHARP RIGHT TURNS, THE ENGINE TENDS TO STALL. THIS ONLY HAPPENS WHEN THE TRANSMISSION IS IN NEUTRAL OR I HAVE THE CLUTCH IN. THE MAIN REASON THIS…
Read full complaint
I CURRENTLY OWN A 1996 FORD EXPLORER XLT, 4X4, 5-SPEED MANUAL TRANSMISSION. ONE THING I HAVE NOTICED WITH THIS VEHICLE IS WHEN I AM EITHER STOPPING MODERATELY HARD/FAST OR MAKING SHARP RIGHT TURNS, THE ENGINE TENDS TO STALL. THIS ONLY HAPPENS WHEN THE TRANSMISSION IS IN NEUTRAL OR I HAVE THE CLUTCH IN. THE MAIN REASON THIS IS A PROBLEM IS BECAUSE WHEN THE VEHICLE IS STALLED, THE POWER STEERING IS OFF. MOST OF MY PROBLEMS HAVE BEEN ON OFF RAMPS WHERE I'M TRAVELING REALITIVELY FAST AND A RIGHT TURN. TOWARDS THE END OF THE RAMP I START TO STRAIGTEN OUT THE WHEEL AND REALIZE I CAN'T MOVE IT. GENERALLY I AM FORCED TO SLAM ON THE BREAKS BEFORE RUNNING INTO SOMETHING OR IF I HAVE ENOUGH TIME, I WILL QUICKLY ATTEMPT TO START IT. THERE WAS NO SPECIFIC INCIDENT DATE. THIS DID NOT START TO HAPPEN UNTIL AFTER MY 30-DAY WARRANTY WAS UP AT FROM THE DEALER SO I HAVE NOT HAD ANYTHING DONE TO ATTEMPT TO FIX IT. I HAVE FOUND ON THE INTERNET THAT SEVERAL EXPLORERS HAVE HAD THIS PROBLEM. SOME PEOPLE BLAMED IT ON A VALVE. BELOW ARE LISTED WEBSITES WHERE PEOPLE HAVE SUBMITTED TO FORUMS. THESE ARE PEOPLE IN SIMILAR SITUATIONS AS MYSELF. THANKS HTTP://WWW.CARCONSUMERS.COM/FORD_EXPLORER.HTML HTTP://WWW.CBSNEWS.COM/STORIES/2001/04/13/NATIONAL/MAIN285613.SHTML HTTP://WWW.CBSNEWS.COM/STORIES/2000/10/10/NATIONAL/MAIN240067.SHTML HTTP://WWW.CARTRACKERS.COM/FORUMS/LIVE/GREMLINS/191.HTML HTTP://WWW.THECOMPLAINTSTATION.COM/CGI-BIN/DATACGI/DATABASE.CGI/FORUM/SUBTOPIC/TOPICID=0351/SUBTOPICID=0000857 7/FIRSTRECORD=0/FINALRECORD=14/ HTTP://FORUMS.VMAG.COM/PM-1001/MESSAGES/3445.HTML. *AK
NHTSA ODI #10060684
75,000 miles · Oct 14, 2003
Power Train
WHILE PULLING OUT OF A PARKING LOT VEHICLE DIED. VEHICLE WOULD NOT GO INTO REVERSE OR DRIVE. *AK
NHTSA ODI #10042904
153,000 miles · Jul 16, 2003
Power TrainVehicle Speed Control
WHILE DRIVING VEHICLE SUDDENLY HESITATED TO ACCELERATE, TRANSMISSION HAD GONE BAD, PER DEALERSHIP.*AK
NHTSA ODI #10029406
Mileage unknown · May 7, 2003
Power TrainSteeringSuspension
WE PURCHASED OUR VEHICLE USED IN 1999 WITH 33000 MILES. 6 MONTHS AFTER THE PURCHASE WE NEEDED A NEW TRANSMISSION, ANOTHER NEW TRANSMISSION LAST YEAR (2002), NEW BALL JOINTS, AND NOW WE ARE BEING TOLD THE RACK AND PINION NEEDS TO BE REPLACED. FORD HAS NOT OFFERED ANY RECALLS ON THIS PART BUT I HAVE SEEN OTHER COMPLAINTS REGARDI…
Read full complaint
WE PURCHASED OUR VEHICLE USED IN 1999 WITH 33000 MILES. 6 MONTHS AFTER THE PURCHASE WE NEEDED A NEW TRANSMISSION, ANOTHER NEW TRANSMISSION LAST YEAR (2002), NEW BALL JOINTS, AND NOW WE ARE BEING TOLD THE RACK AND PINION NEEDS TO BE REPLACED. FORD HAS NOT OFFERED ANY RECALLS ON THIS PART BUT I HAVE SEEN OTHER COMPLAINTS REGARDING THIS. MY VEHICLE IS CONSTANTLY SHAKING (FEELS LIKE I AM GOING OVER RUMBLE STRIPS) WHEN I AM OVER 30-40 MPH. WE ALSO JUST HAD OUR VEHICLE ALIGNED AND IT IS OUT OF ALIGNMENT AGAIN BECAUSE OF THIS PROBLEM. *JB
NHTSA ODI #10018347
74,000 miles · Feb 17, 2003
Power Train
WE HAVE A 1996 FORD EXPLORER WITH ONLY 74,000 MILES. WHEN WE BOUGHT THE VEHICLE IT HAD ONLY 25,000 MILES. THE MAINTENANCE ON THE TRANSMISSION WAS DONE ACCORDING TO THE MAINTENANCE BOOK. WHEN THE VEHICLE IS PUT INTO GEAR IT SLIPS IN EACH FORWARD GEAR. REVERSE GEAR NO LONGER WORKS. WHEN IN REVERSE ITS AS THOUGH IN PARK. THE …
Read full complaint
WE HAVE A 1996 FORD EXPLORER WITH ONLY 74,000 MILES. WHEN WE BOUGHT THE VEHICLE IT HAD ONLY 25,000 MILES. THE MAINTENANCE ON THE TRANSMISSION WAS DONE ACCORDING TO THE MAINTENANCE BOOK. WHEN THE VEHICLE IS PUT INTO GEAR IT SLIPS IN EACH FORWARD GEAR. REVERSE GEAR NO LONGER WORKS. WHEN IN REVERSE ITS AS THOUGH IN PARK. THE OVERDRIVE LIGHT FLASHES RAPIDLY.
NHTSA ODI #10007679
78,000 miles · Jan 16, 2003
Engine And Engine CoolingPower Train
1) NO HEAT, ONLY BLOWS COLD AIR. 2) TRANSMISSION DOES NOT SHIFT SMOOTHLY FROM REVERSE TO DRIVE.
NHTSA ODI #10002776
Mileage unknown · Nov 6, 2002
Power Train
WHILE DRIVING VEHICLE WILL SKIP GEARS. VEHICLE WILL SHIFT FROM FIRST TO THIRD GEAR. CONSUMER HAD VEHICLE SERVICED AND WAS INFORMED BY THE MECHANIC THAT THE 2ND GEAR BAND HAD BROKEN. VEHICLE HAS AN AUTOMACTIC TRANSMISSION. MR
NHTSA ODI #8022311
Mileage unknown · May 7, 2002
Power Train
TRANSMISSION FAILED. *AK
NHTSA ODI #761642
Mileage unknown · May 3, 2002
Engine And Engine CoolingPower TrainService Brakes, Air
WHILE DRIVING, VEHICLE MAKES A LOUD HUMMING SOUND WHICH COMES FROM FRONT END OF VEHICLE. ALSO, TRANSMISSION HAS FAILED. CONSUMER CONSTANTLY HAS TO TAKE VEHICLE TO DEALER. *AK THE CHECK ENGINE LIGHT ILLUMINATED. THE SPEED SENSOR AND THE O2 SENSOR WERE REPLACED. JG
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES. THE LIFTGATE ASSIST GAS CYLINDER BRACKET ON THE RIGHT HAND BODYSIDE OUTER PANEL WAS INCORRECTLY WELDED.
Consequence & remedy
Consequence: THE GAS CYLINDER BRACKET MAY NOT PROPERLY SUPPORT THE LIFTGATE INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REINFORCE THE BRACKET ATTACHMENT WITH TWO POP RIVETS.
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH 5.0L ENGINES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, IDAHO, IOWA, MAINE, MICHIGAN (UPPER PENINSULA ONLY), MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. THESE VEHICLES, WHEN OPERATED FOR EXTENDED PERIODS OF TIME AT HIGHWAY SPEEDS AND TEMPERATURES BELOW -20 DEGREES FARENHEIT, DO NOT RETURN TO IDLE DUE TO ICE IN THE THROTTLE BODY.
Consequence & remedy
Consequence: ALTHOUGH THE VEHICLE CAN BE CONTROLLED BY EITHER APPLYING THE SERVICE BRAKES OR SHIFTING THE TRANSMISSION TO NEUTRAL, INCREASED BRAKE PEDAL EFFORTS OR SOME INCREASE IN STOPPING DISTANCE CAN RESULT.
Remedy: DEALERS WILL INSTALL A REVISED PCV SYSTEM WITH WATER HEATED VACUUM SOURCE.
THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: INCORRECT INFLATION PRESSURES COULD CAUSE PREMATURE WEAR OF THE REAR TIRES. .
Remedy: OWNERS WILL BE PROVIDED WITH CORRECT CERTIFICATION LABELS AND INSTRUCTIONS FOR INSTALLING THESE LABELS. DEALERS CAN INSTALL THIS LABEL IF THE OWNER SO DESIRES.
WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence & remedy
Consequence: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
PE00039 · Front Suspension Stabilizer Bar Link
Opened Sep 20, 2000 · Closed Nov 30, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE99068 · Accelerator Pedal
Opened Nov 1, 1999 · Closed Mar 9, 2000
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
PE97010 · Electrical Fire In Center Console
Opened Mar 13, 1997 · Closed Sep 4, 1997
Status: closed (inferred from source dates) · Electrical System
THIS INVESTIGATION REVEALED THAT CONSOLE FIRES IN THE SUBJECT VEHICLES MOST OFTEN OCCURRED WHILE VEHICLES EQUIPPED WITH THE LAMP OUTAGE MODULE (LOM), WHICH IS PART OF THE MESSAGE CENTER, WERE TOWING A TRAILER AND WHICH HAD BEEN MODIFIED BY ADDING AN AFTERMARKET TRAILER WIRING HARNESS INTO THE VEHICLE'S TAILLIGHT CIRCUITS.THE OWNER'S MANUAL STATES NEVER AND MORE THAN OTHER TRAILER LIGHT BULB TO ONE CIRCUIT HOWEVER TRAILERS FREQUENTLY CONTAIN SEVERAL BULBS.THE RESULTING EXCESS CURRENT PASSING THROUGH THE LOM COULD CAUSE IT TO OVERHEAT RESULTING IN A FIRE.PROPER AFTERMARKET INSTALLATION OF TRAILER WIRING REQUIRES THE USE OF A BYPASS MODULE, WHICH OBTAINS POWER FOR THE TRAILER LIGHTS DIRECTLY FROM THE BATTERY RATHER THAN FROM THE VEHICLE'S TAIL LIGHT AND STOP LAMP CIRCUITS, OR THE USE OF THE MANUFACTURER'S WIRING HARNESS.IN A LETTER DATED SEPTEMBER 2, 1997, FORD NOTIFIED ODI THAT IT INTENDS TO TAKE ACTION TO PRECLUDE FURTHER INCIDENTS INCLUDING ISSUING A TECHNICAL SERVICE BULLETIN TO ITS DEALERS, NOTIFYING TRAILER RENTAL ASSOCIATIONS AND AGENCIES WHERE KNOWN, AND ADVISING OWNERS BY LETTER OF THE PROPER METHOD FOR CONNECTION OF TRAILER TOW WIRING ON THE SUBJECT VEHICLES.THERE WAS NO DEFECT TREND IN THE SUBJECT VEHICLES IDENTIFIED AS A RESULT OF THIS INVESTIGATION, AND FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT WARRANTED TO CONTINUE THE INVESTIGATION.
Illustration