ON 09/23/01 MY 24YR. OLD SONINLAW WAS KILLED WHEN HE LOST CONTROL AND HIT A MEIDIAN AND TREE WAS ON TWO TIRES THEN WENT 30FT THRU THE AIR BEFORE THE EXPLORER HE WAS DRIVING ROLLED AND THREW HIM OUT THE DRIVER WINDOW. HE WAS WEARING SEAT BELT WHICH HE HAD HAD TROUBLE WITH SINCE PURCHASE FAILED AND HE WAS EJECTED ALSO HIS BROTHER…
Read full complaint
ON 09/23/01 MY 24YR. OLD SONINLAW WAS KILLED WHEN HE LOST CONTROL AND HIT A MEIDIAN AND TREE WAS ON TWO TIRES THEN WENT 30FT THRU THE AIR BEFORE THE EXPLORER HE WAS DRIVING ROLLED AND THREW HIM OUT THE DRIVER WINDOW. HE WAS WEARING SEAT BELT WHICH HE HAD HAD TROUBLE WITH SINCE PURCHASE FAILED AND HE WAS EJECTED ALSO HIS BROTHER IN PASSENGER SIDE COULDNT GET HIS BELT TO LATCH BUT HE WAS LUCKY AND WALKED AWAY. THE TRUCK WAS ALSO EQUIPPED WITH AIRBAGS ON BOTH SIDES WHICH DIDNT DEPLOY EITHER. MY SON IN LAW DIED THAT NIGHT WHEN HE WAS EJECTED AND THE TRUCK LANDED ON HALF OF HIS FACE. HE LEFT BEHIND A WIFE AND 2SONS AND A 1 MONTH OLD DAUGHTER. THESE EXPLORERS ARE DEATH TRAPS PLEASE DO NOT PURCHASE ONE.*AK
NHTSA ODI #752765
Mileage unknown · Jul 26, 2001
Air BagsCrashInjury
THE FORD EXPLORER WAS HIT ON THE FREEWAY IN THE FRONT RIGHT SECTION WHICH PUSHED THE CAR LEFT THE CAR WAS THEN BROADSIDED BY ANOTHER CAR AND THE FRONT DRIVER SIDED DOOR FLEW OPEN IT WAS FORTUNATE THAT MY SON HAD ON HIS SEATBELT SO HE WOULD NOT BE THROWN FORM THE CAR, BUT WITH THE DOOR FLYING OPEN HIS ARM, LEG OR HEAD COULD HAVE …
Read full complaint
THE FORD EXPLORER WAS HIT ON THE FREEWAY IN THE FRONT RIGHT SECTION WHICH PUSHED THE CAR LEFT THE CAR WAS THEN BROADSIDED BY ANOTHER CAR AND THE FRONT DRIVER SIDED DOOR FLEW OPEN IT WAS FORTUNATE THAT MY SON HAD ON HIS SEATBELT SO HE WOULD NOT BE THROWN FORM THE CAR, BUT WITH THE DOOR FLYING OPEN HIS ARM, LEG OR HEAD COULD HAVE BEEN SEVERILY DAMAGED IF IT HAD BEEN IN THE WAY WHEN THE DOOR FLOEW BACK TO CLOSE. THE AIR BAGS DID NOT DEPLOY EITHER, IT SEEMS THAT THEY WOULD HAVE SINCE THE BOTH HITS WERE AT SPEEDS OF APPROX. 55 MPH. *AK
NHTSA ODI #749277
Mileage unknown · Jun 6, 2001
Air Bags
AIRBAG LIGHT HAS COME ON, NOT TAKEN TO DEALER YET.*AK
NHTSA ODI #889887
Mileage unknown · May 22, 2001
Air BagsCrash
DURING A SPIN OUT AT HIGHWAY SPEED OF APPROXIMATELY 50 MPH IN RAINY CONDITIONS, A 1998 FORD EXPLORER IMPACTED A CONCRETE DIVIDER ON THE RIGHT FRONT FENDER, FOLLOWED BY THE RIGHT REAR QUARTER PANEL. THE VEHICLE CAME TO A STOP AND TIPPED OVER ONTO THE LEFT SIDE OF THE VEHICLE. BOTH AIRBAGS FAILED TO DEPLOY. NO MAINTENANCE HAS EVER…
Read full complaint
DURING A SPIN OUT AT HIGHWAY SPEED OF APPROXIMATELY 50 MPH IN RAINY CONDITIONS, A 1998 FORD EXPLORER IMPACTED A CONCRETE DIVIDER ON THE RIGHT FRONT FENDER, FOLLOWED BY THE RIGHT REAR QUARTER PANEL. THE VEHICLE CAME TO A STOP AND TIPPED OVER ONTO THE LEFT SIDE OF THE VEHICLE. BOTH AIRBAGS FAILED TO DEPLOY. NO MAINTENANCE HAS EVER BEEN DONE ON THE AIRBAG SYSTEM, NOR HAS THERE BEEN A RECALL.*AK
NHTSA ODI #745719
Mileage unknown · Mar 20, 2001
Air BagsCrashInjury
WHILE DRIVING ABOUT 50 MPH ANOTHER VEHICLE CROSSED A STOP SIGN AND CONSUMER STRUCK OTHER VEHICLE IN MIDDLE. BOTH VEHICLES WERE TOTALED, BUT NEITHER OF AIR BAGS DEPLOYED.*AK
NHTSA ODI #883563
Mileage unknown · Feb 23, 2001
Air BagsSuspensionCrashInjury
THE DRIVER OF THE VEHICLE WAS INVOLVED IN A ACCIDENT, THE VEHICLE WAS HIT ON THE REAR LEFT SIDE WHICH CAUSED THE DRIVER TO LOOSE CONTROL OF THE VEHICLE RESULTING IN IT ROLLING OVER 3 1/4 TIMES, THE PASSENGER WAS KILLED AND THE DRIVER SUSTAINED EXTENSIVE INJURIES INCLUDING A BROKEN NECK, THE CONSUMER BELIEVES THAT THE RECALL 00V…
Read full complaint
THE DRIVER OF THE VEHICLE WAS INVOLVED IN A ACCIDENT, THE VEHICLE WAS HIT ON THE REAR LEFT SIDE WHICH CAUSED THE DRIVER TO LOOSE CONTROL OF THE VEHICLE RESULTING IN IT ROLLING OVER 3 1/4 TIMES, THE PASSENGER WAS KILLED AND THE DRIVER SUSTAINED EXTENSIVE INJURIES INCLUDING A BROKEN NECK, THE CONSUMER BELIEVES THAT THE RECALL 00V-402 FOR FRONT SWAY BARS MAY OR MAY NOT HAVE CONTRIBUTED TO THE ACCIDENT AND WAS RECEIVED AFTER THE ACCIDENT OCCURED, DURING THE ACCIDENT NEITHER AIR BAGS DEPLOYED. NLM
NHTSA ODI #559917
Mileage unknown · Jan 7, 2001
Air BagsCrashInjury
AIR BAGS DID NOT DEPLOY IN ACCIDENT. STOPPED AT TRAFFIC LIGHT, HIT IN REAR BY CAR TRAVELING AT ABOUT 40 MPH, CAR PUSHED FORWARD INTO CAR IN FRONT OF ME, THIRD CAR PUSHED INTO FOURTH, FOURTH INTO FIFTH, AND FIFTH INTO SIXTH CAR. FRONT AND REAR BUMPERS DESTROYED, SIGNIFICANT FRONT AND REAR DAMAGE, AIR BAGS DID NOT DEPLOY. *AK
NHTSA ODI #738944
Mileage unknown · Nov 13, 2000
Air BagsEquipmentSeats
I BOUGHT THIS SUV USED AND I THOUGHT I WAS GETTING A GREAT VEHICLE, BOY WAS I WRONG. IT HAS BEEN ONE THING AFTER ANOTHER WITH THIS SUV. PLEASE CHECK ALL OF MY COMPLAINTS THIS IS AN INTERIOR PROBLEM, THESE THINGS CANNOT BE CAUSED BY EVEY DAY USE. THE PROBLEMS I AM HAVING ARE, BACK SEAT DOOR HANDLES ARE BROKE, THE SPARE TIRE RELE…
Read full complaint
I BOUGHT THIS SUV USED AND I THOUGHT I WAS GETTING A GREAT VEHICLE, BOY WAS I WRONG. IT HAS BEEN ONE THING AFTER ANOTHER WITH THIS SUV. PLEASE CHECK ALL OF MY COMPLAINTS THIS IS AN INTERIOR PROBLEM, THESE THINGS CANNOT BE CAUSED BY EVEY DAY USE. THE PROBLEMS I AM HAVING ARE, BACK SEAT DOOR HANDLES ARE BROKE, THE SPARE TIRE RELEASE BROKE THE FIRST TIME IT WAS USED, THE AIR BAG LIGHT WENT OFF AND CAUSED AN INCONVIENCE TO MY FAMILY, THE TIRES HAVE BEEN REPLACED AND THE ALINGMENT HASEN'T BEEN RIGHT SENSE I'VE OWNED IT, THE BACK SEAT DOESN'T WORK PROPERLY, IT WILL NOT RELEASE TO FOLD FORWARD, AND THE MOTOR ON THE HATCH HASEN'T WORKED PROPERLY FROM DAY ONE OF MY OWNERSHIP. PLEASE HELP ME WITH THIS MATTER. THANK FOR ALL YOU DO. MARGIE HULSEY. ML
NHTSA ODI #736209
Mileage unknown · Sep 11, 2000
Air BagsTiresCrash
DRIVING 65MPH & HEARD A THUMPING NOISE AGAINST VEHICLE. IT STARTED TO FISHTAIL. DRIVER LOST CONTROL. IT VEERED HARD TO RIGHT & HIT ANOTHER VEHICLE WITH FRONT , AND AIR BAGS FAILED TO DEPLOY. WENT TO RIGHT SIDE OF ROAD & THEN FLIPPED & ROLLED OVER TWICE. VEHICLE LANDED ON ITS ROOF. LEFT REAR TIRE HAD ITS TREAD PEELED COMPLETELY …
Read full complaint
DRIVING 65MPH & HEARD A THUMPING NOISE AGAINST VEHICLE. IT STARTED TO FISHTAIL. DRIVER LOST CONTROL. IT VEERED HARD TO RIGHT & HIT ANOTHER VEHICLE WITH FRONT , AND AIR BAGS FAILED TO DEPLOY. WENT TO RIGHT SIDE OF ROAD & THEN FLIPPED & ROLLED OVER TWICE. VEHICLE LANDED ON ITS ROOF. LEFT REAR TIRE HAD ITS TREAD PEELED COMPLETELY OFF. HAVE THE TIRE & TREAD. ALSO HAVE COPY OF POLICE REPORT. VEHICLE REGISTERED IN TEXAS, BUT PHYSICALLY LOCATED IN CALIFORNIA. VEHICLE WAS TOTALED. FIRESTONE, RADIAL ATX, P235/75R15 DOT VDHL WITH 46,000 MILES ON THEM.*AK
NHTSA ODI #870171
Mileage unknown · May 8, 2000
Air BagsVehicle Speed ControlCrashInjury
PRIOR TO RECALL NOTIFICATION, VEHICLE EXPERIENCED THE CRUISE CONTROL STICKING/THROTTLE BODY FAILURE, VEHICLE ACCIDENT RESULTING FROM ACCELERATION, NO DEPLOYMENT OF THE AIR BAGS DURING COLLISION RESULTING IN INJURY TO CONSUMER. *MJS
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES. THE LIFTGATE ASSIST GAS CYLINDER BRACKET ON THE RIGHT HAND BODYSIDE OUTER PANEL WAS INCORRECTLY WELDED.
Consequence & remedy
Consequence: THE GAS CYLINDER BRACKET MAY NOT PROPERLY SUPPORT THE LIFTGATE INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REINFORCE THE BRACKET ATTACHMENT WITH TWO POP RIVETS.
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH 5.0L ENGINES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, IDAHO, IOWA, MAINE, MICHIGAN (UPPER PENINSULA ONLY), MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. THESE VEHICLES, WHEN OPERATED FOR EXTENDED PERIODS OF TIME AT HIGHWAY SPEEDS AND TEMPERATURES BELOW -20 DEGREES FARENHEIT, DO NOT RETURN TO IDLE DUE TO ICE IN THE THROTTLE BODY.
Consequence & remedy
Consequence: ALTHOUGH THE VEHICLE CAN BE CONTROLLED BY EITHER APPLYING THE SERVICE BRAKES OR SHIFTING THE TRANSMISSION TO NEUTRAL, INCREASED BRAKE PEDAL EFFORTS OR SOME INCREASE IN STOPPING DISTANCE CAN RESULT.
Remedy: DEALERS WILL INSTALL A REVISED PCV SYSTEM WITH WATER HEATED VACUUM SOURCE.
THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: INCORRECT INFLATION PRESSURES COULD CAUSE PREMATURE WEAR OF THE REAR TIRES. .
Remedy: OWNERS WILL BE PROVIDED WITH CORRECT CERTIFICATION LABELS AND INSTRUCTIONS FOR INSTALLING THESE LABELS. DEALERS CAN INSTALL THIS LABEL IF THE OWNER SO DESIRES.
WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence & remedy
Consequence: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
PE00039 · Front Suspension Stabilizer Bar Link
Opened Sep 20, 2000 · Closed Nov 30, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE99068 · Accelerator Pedal
Opened Nov 1, 1999 · Closed Mar 9, 2000
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
PE97010 · Electrical Fire In Center Console
Opened Mar 13, 1997 · Closed Sep 4, 1997
Status: closed (inferred from source dates) · Electrical System
THIS INVESTIGATION REVEALED THAT CONSOLE FIRES IN THE SUBJECT VEHICLES MOST OFTEN OCCURRED WHILE VEHICLES EQUIPPED WITH THE LAMP OUTAGE MODULE (LOM), WHICH IS PART OF THE MESSAGE CENTER, WERE TOWING A TRAILER AND WHICH HAD BEEN MODIFIED BY ADDING AN AFTERMARKET TRAILER WIRING HARNESS INTO THE VEHICLE'S TAILLIGHT CIRCUITS.THE OWNER'S MANUAL STATES NEVER AND MORE THAN OTHER TRAILER LIGHT BULB TO ONE CIRCUIT HOWEVER TRAILERS FREQUENTLY CONTAIN SEVERAL BULBS.THE RESULTING EXCESS CURRENT PASSING THROUGH THE LOM COULD CAUSE IT TO OVERHEAT RESULTING IN A FIRE.PROPER AFTERMARKET INSTALLATION OF TRAILER WIRING REQUIRES THE USE OF A BYPASS MODULE, WHICH OBTAINS POWER FOR THE TRAILER LIGHTS DIRECTLY FROM THE BATTERY RATHER THAN FROM THE VEHICLE'S TAIL LIGHT AND STOP LAMP CIRCUITS, OR THE USE OF THE MANUFACTURER'S WIRING HARNESS.IN A LETTER DATED SEPTEMBER 2, 1997, FORD NOTIFIED ODI THAT IT INTENDS TO TAKE ACTION TO PRECLUDE FURTHER INCIDENTS INCLUDING ISSUING A TECHNICAL SERVICE BULLETIN TO ITS DEALERS, NOTIFYING TRAILER RENTAL ASSOCIATIONS AND AGENCIES WHERE KNOWN, AND ADVISING OWNERS BY LETTER OF THE PROPER METHOD FOR CONNECTION OF TRAILER TOW WIRING ON THE SUBJECT VEHICLES.THERE WAS NO DEFECT TREND IN THE SUBJECT VEHICLES IDENTIFIED AS A RESULT OF THIS INVESTIGATION, AND FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT WARRANTED TO CONTINUE THE INVESTIGATION.
Illustration