NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
75 reportsClear category filterMileage unknown · Aug 11, 2000
Service Brakes, HydraulicTires
REAR PASSENGER'S TIRE TREAD SEPARATED AT 65-70MPH, CAUSING DRIVER TO LOSE CONTROL. TIRE SIZE P235 ORIGINAL EQUIPMENT. *AK PRIOR TO RECALL (00T-005) CONSUMER REPLACED TWO FIRESTONE TIRES. THE CONSUMER WANTS TO BE REIMBURSED FOR THE COST OF TWO TIRES REPLACED BEFORE THE FIRESTONE RECALL. CONSUMER ALSO EXPERIENCED NOISE WHEN…
Read full complaint
REAR PASSENGER'S TIRE TREAD SEPARATED AT 65-70MPH, CAUSING DRIVER TO LOSE CONTROL. TIRE SIZE P235 ORIGINAL EQUIPMENT. *AK PRIOR TO RECALL (00T-005) CONSUMER REPLACED TWO FIRESTONE TIRES. THE CONSUMER WANTS TO BE REIMBURSED FOR THE COST OF TWO TIRES REPLACED BEFORE THE FIRESTONE RECALL. CONSUMER ALSO EXPERIENCED NOISE WHEN BRAKING DUE TO PRMATURE WEARING OF BRAKE PADS AND BAD ROTORS WHICH REPLACED. *YH
NHTSA ODI #867477
Mileage unknown · Jun 27, 2000
Service Brakes, Hydraulic
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #724656
Mileage unknown · Apr 25, 2000
Service Brakes, HydraulicCrash
STARTED TO APPLY THE BRAKES TO SLOW DOWN WHEN ABS BRAKES LOCKED UP. VEHICLE SPUN AROUND TO THE RIGHT & THEN BACK TO THE LEFT. IT FLIPPED OVER & SLID DOWN THE ROAD. VEHICLE HIT GUARDRAIL. DRIVER HAD SEAT BELT ON AT TIME OF PROBLEM. VEHICLE TOWED TO DEALERSHIP. *AK
NHTSA ODI #860947
Mileage unknown · Apr 25, 2000
Service Brakes, Hydraulic
BRAKE PADS AND ROTORS ARE PREMATURELY WEARING OUT, CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS. *AK
NHTSA ODI #860894
Mileage unknown · Apr 12, 2000
Service Brakes, HydraulicStructure
HYDRAULIC CYLINDER FAILURE CAUSED DOORS NOT TO OPEN PROPERLY. ALSO, WHEN APPLYING BRAKES AND COMING TO A STOP, BRAKE PEDAL WOULD PULSATE AND GO TO THE FLOOR, RESULTING IN EXTENDED STOPPING DISTANCE. CONTACTED DEALER.
NHTSA ODI #860214
Mileage unknown · Apr 7, 2000
Service Brakes, HydraulicCrashInjury
WHILE DRIVING VEHICLE ON DIRT ROAD GOING DOWN HILL APPLIED BRAKES HIT BUMP BRAKES LOCKED, LOSS OF CONTROL THEN VEHICLE ROLLED ON SIDE. VEHICLE IS A TOTAL LOSS ACCORDING TO BODY SHOP. *AK
NHTSA ODI #711280
Mileage unknown · Mar 9, 2000
Service Brakes, HydraulicInjury
CONSUMER WAS DRIVING DOWNHILL ON GRAVEL ROAD 10-20 MPH, BRAKES WERE APPLIED BUT FAILED TO SLOW THE VEHICLE, VEHICLE STARTED TO FISH TAIL BECAME UNBALANCED AND ROLLED. *ET
NHTSA ODI #784547
Mileage unknown · Jun 1, 1999
Service Brakes, Hydraulic
WHILE DRIVING BRAKING SYSTEM MALFUNCTIONED, CAUSING BRAKE PEDAL TO TRAVEL TO THE FLOOR AND NO BRAKING ABILITY, WHICH MAY HAVE RESULTED IN A CRASH. HAPPENED TWICE, SECOND TIME ON MAY WITH 53,000. DEALER CANNOT DETERMINE THE PROBLEM. PLEASE PROVIDE FURTHER INFORMATION AND VIN#. *AK
NHTSA ODI #838674
Mileage unknown · Jan 11, 1999
Service Brakes, Hydraulic
VEHICLE WAS TAKEN IN FOR CHECK UP. THE BRAKE ROTORS WERE CRACKED CAUSING FAILURE. HAD THEM REPLACED. *AK
NHTSA ODI #833301
Mileage unknown · Jun 11, 1998
Service Brakes, HydraulicStructure
WHEN OWNER TOOK TRUCK FOR STATE INSPECTION THE FRONT ROTORS AND BRAKE PADS HAD TO BE REPLACED BECAUSE THE SURFACE ON THE ROTORS WERE PEELING OFF IN CHUNCKS. OWNER DID NOT EXPERIENCE ANY BRAKING PROBLEMS. ALSO, THE UNDERSIDE OF THE EXPLORER , THE FRONT LINK PIN FELL OFF, WAS MISSING. *AK
NHTSA ODI #823700
Official recalls
5Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Nov 28, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER CERTAIN CONDITIONS, A FRONT SWAY BAR LINK CAN FRACTURE.
Consequence & remedy
Consequence: VEHICLE HANDLING COULD BE AFFECTED, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE BOTH THE LEFT AND RIGHT FRONT SWAY BAR LINKS.
Nov 3, 1999
VEHICLE DESCRIPTION: ON CERTAIN SPORT UTILITY VEHICLES, THE HYDRAULIC LIFT CYLINDER BRACKET WELDS COULD FRACTURE.
Consequence & remedy
Consequence: WITH A BROKEN BRACKET WELD, THERE IS A POTENTIAL FOR THE LIFTGATE BRACKET TO GRADUALLY BEND INWARD ALLOWING THE LIFT CYLINDER BALL STUD TO DISENGAGE, UNEXPECTEDLY ALLOWING THE LIFTGATE TO FALL FROM AN OPEN POSITION.
Remedy: DEALERS WILL INSTALL LIFTGATE REINFORCEMENT BRACKETS. DEPENDING UPON THE CONDITION OF THE LIFTGATE SHEET METAL IN THE AREA OF THE BRACKET, DEALERS MAY ALSO INSTALL A LARGER REINFORCEMENT.
Mar 15, 1995
IN SOME OF THE VEHICLES, BRAKE TUBES WERE MISROUTED BETWEEN THE MASTER CYLINDER AND THE HYDRAULIC CONTROL UNIT AND RESULTS IN EXCEEDING THE ALLOWABLE STOPPING DISTANCES AS REQUIRED BY FMVSS NO. 105, "HYDRAULIC BRAKE SYSTEMS." IN ADDITION, SEALS WITHIN THE MASTER CYLINDER COULD BE ABRADED BY THIS CONDITION OVER TIME RESULTING IN AN INTERNAL LEAK AND A FURTHER REDUCTION IN BRAKE PERFORMANCE.
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: STOPPING DISTANCES COULD BE LONGER THAN INTENDED RESULTING IN INCREASED POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REROUTE THE BRAKE TUBES.
Mar 15, 1995
THE INNER TIE ROD ASSEMBLIES WERE IMPROPERLY MANUFACTURED AND CAN FRACTURE CAUSING SHAKING OR SHIMMY AT LOW SPEEDS.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE WHEEL ON THE SIDE WITH THE BROKEN TIE ROD TO TUCK INWARD OR OUTWARD AND SLIDE RESULTING IN AN INCREASED POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT THE INNER TIE RODS AND REPLACE THE SUSPECT TIE RODS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA02011 · Safety Belt Assembly Failure
Opened Jul 2, 2002 · Closed May 21, 2003
Status: closed (inferred from source dates) · Seat Belts
ODI RECEIVED 18 CONSUMER COMPLAINTS AND FORD IDENTIFIED ANOTHER FOUR REPORTS ASSOCIATED WITH THE ALLEGED DEFECT.MOST OF THE COMPLAINTS INDICATE INABILITY TO LATCH THE DRIVER SEAT BELT BUCKLE CAUSED BY A BROKEN LATCH RELEASE SPRING.NONE OF THESE 22 REPORTS RESULTED IN ANY INJURIES OR CRASHES.NO COMPLAINTS HAVE BEEN RECEIVED IN THE PAST 6 MONTHS.FORD CONDUCTED LIFE-CYCLE TESTING ON 6 FIELD SAMPLE BUCKLE ASSEMBLIES.THE RESULTS OF THAT TESTING DEMONSTRATED THAT THE TESTED BUCKLE ASSEMBLIES COULD BE EXPECTED TO OPERATE PROPERLY BEYOND THE EXPECTED LIFE OF THE VEHICLE.BASED ON THE LIMITED NUMBER OF REPORTS AND COMPLAINTS RECEIVED, AND A DECLINING COMPLAINT TREND, THIS INVESTIGATION IS CLOSED.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT EXIST DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ADDITIONAL INFORMATION
PE02007 · Safety Belt Assembly
Opened Jan 23, 2002 · Closed Jul 2, 2002
Status: closed (inferred from source dates) · Seat Belts
No summary supplied.
PE00039 · Front Suspension Stabilizer Bar Link
Opened Sep 20, 2000 · Closed Nov 30, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE99068 · Accelerator Pedal
Opened Nov 1, 1999 · Closed Mar 9, 2000
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
RQ99016 · Liftgate Support Bracket Failure
Opened Jul 29, 1999 · No close date supplied
Status: open (inferred from source dates) · Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Additional source detail variants (2)
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
PE97010 · Electrical Fire In Center Console
Opened Mar 13, 1997 · Closed Sep 4, 1997
Status: closed (inferred from source dates) · Electrical System
THIS INVESTIGATION REVEALED THAT CONSOLE FIRES IN THE SUBJECT VEHICLES MOST OFTEN OCCURRED WHILE VEHICLES EQUIPPED WITH THE LAMP OUTAGE MODULE (LOM), WHICH IS PART OF THE MESSAGE CENTER, WERE TOWING A TRAILER AND WHICH HAD BEEN MODIFIED BY ADDING AN AFTERMARKET TRAILER WIRING HARNESS INTO THE VEHICLE'S TAILLIGHT CIRCUITS.THE OWNER'S MANUAL STATES NEVER AND MORE THAN OTHER TRAILER LIGHT BULB TO ONE CIRCUIT HOWEVER TRAILERS FREQUENTLY CONTAIN SEVERAL BULBS.THE RESULTING EXCESS CURRENT PASSING THROUGH THE LOM COULD CAUSE IT TO OVERHEAT RESULTING IN A FIRE.PROPER AFTERMARKET INSTALLATION OF TRAILER WIRING REQUIRES THE USE OF A BYPASS MODULE, WHICH OBTAINS POWER FOR THE TRAILER LIGHTS DIRECTLY FROM THE BATTERY RATHER THAN FROM THE VEHICLE'S TAIL LIGHT AND STOP LAMP CIRCUITS, OR THE USE OF THE MANUFACTURER'S WIRING HARNESS.IN A LETTER DATED SEPTEMBER 2, 1997, FORD NOTIFIED ODI THAT IT INTENDS TO TAKE ACTION TO PRECLUDE FURTHER INCIDENTS INCLUDING ISSUING A TECHNICAL SERVICE BULLETIN TO ITS DEALERS, NOTIFYING TRAILER RENTAL ASSOCIATIONS AND AGENCIES WHERE KNOWN, AND ADVISING OWNERS BY LETTER OF THE PROPER METHOD FOR CONNECTION OF TRAILER TOW WIRING ON THE SUBJECT VEHICLES.THERE WAS NO DEFECT TREND IN THE SUBJECT VEHICLES IDENTIFIED AS A RESULT OF THIS INVESTIGATION, AND FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT WARRANTED TO CONTINUE THE INVESTIGATION.
Illustration