NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
144 reports10,812 miles · Oct 28, 2003
Engine And Engine Cooling
WHILE MERGING ONTO A FREEWAY, COULDN'T GET OVER 2,000 RPM AND THUS COULDN'T GET ENOUGH SPEED TO MERGE ON AT OVER 25MPH. VEHICLE STALLED SEVERAL TIMES WHILE TRYING TO GET OFF THE FREEWAY. NEW VEHICLE HAS 10812 MILES. FORD MAINTENANCE DEPT STATED THEY COULDN'T FIND ANYTHING WRONG, IT RAN FINE FOR THEM. MY HUSBAND WENT TO PICK …
Read full complaint
WHILE MERGING ONTO A FREEWAY, COULDN'T GET OVER 2,000 RPM AND THUS COULDN'T GET ENOUGH SPEED TO MERGE ON AT OVER 25MPH. VEHICLE STALLED SEVERAL TIMES WHILE TRYING TO GET OFF THE FREEWAY. NEW VEHICLE HAS 10812 MILES. FORD MAINTENANCE DEPT STATED THEY COULDN'T FIND ANYTHING WRONG, IT RAN FINE FOR THEM. MY HUSBAND WENT TO PICK UP THE VEHICLE AND IN DRIVE IT RAN, IN NEUTRAL COULDN'T GET MORE THAN 2,000 RPM, MECHANIC SAID IT WAS THE GOVERNOR, NEEDLESS TO SAY, MY HUSBAND SAID FIX THE CAR. THEY STILL HAVE MY TRUCK.*AK
NHTSA ODI #10043761
16,573 miles · Oct 27, 2003
Electrical SystemEngine And Engine CoolingSeats
WHILE DRIVING AT VARIOUS SPEEDS BLACK SMOKE WOULD CAME FROM THE TAIL PIPE. CONSUMER COULD SMELL GAS FUMES INSIDE THE VEHICLE. .*AK DRIVERS REAR DOOR WILL NOT OPEN FROM THE INSIDE. DRIVERS SIDE SEAT MOLDING IS FALLING OFF. CENTER DUCT LOOSE ON DASH. DRIVERS SEAT CUSHION LOST ITS FORM. *TS
NHTSA ODI #10042339
700 miles · Oct 2, 2003
Electrical System
CONSUMER CALLED COMPLAINING ABOUT STALLING PROBLEMS. VEHICLE COMPLETELY SHUT DOWN MORE THAN A DOZEN TIMES WHILE DRIVING AT MORE THAN 40 MPH. MANUFACTURER WAS CONTACTED AND STATED THAT THIS WAS THE FIRST TIME THAT THEY HEARD OF THIS PROBLEM. DEALER WAS CONTACTED, AND VEHICLE HAD BEEN AT THE DEALER FOUR DIFFERENT TIMES, AND TH…
Read full complaint
CONSUMER CALLED COMPLAINING ABOUT STALLING PROBLEMS. VEHICLE COMPLETELY SHUT DOWN MORE THAN A DOZEN TIMES WHILE DRIVING AT MORE THAN 40 MPH. MANUFACTURER WAS CONTACTED AND STATED THAT THIS WAS THE FIRST TIME THAT THEY HEARD OF THIS PROBLEM. DEALER WAS CONTACTED, AND VEHICLE HAD BEEN AT THE DEALER FOUR DIFFERENT TIMES, AND THEY STILL COULDN'T FIND WHAT WAS WRONG WITH THE VEHICLE. *AK
NHTSA ODI #10042197
4,683 miles · Sep 18, 2003
Engine And Engine Cooling
ENGINE STALLED AT 4683 MILES ON THE ODOMETER. DATE: 7 OCTOBER 2002. I NOTED THAT IT NOW IDLES AT 600 RPM. I DON'T KNOW WHAT THAT MEANS. *JB
NHTSA ODI #10039116
4,372 miles · Sep 18, 2003
Engine And Engine Cooling
4405 MILES, 9:05 A.M., SEPTEMBER 1, 2002, CAR STALLED AGAIN. *JB
NHTSA ODI #10039115
4,122 miles · Sep 18, 2003
Electrical System
FORD EXPLORER SPORT TRAC, 2002. AT 4,122 MI BATTERY LIGHT FLASHED THREE TIMES, AND TRUCK NEARLY STALLED. *JB
NHTSA ODI #10039112
Mileage unknown · Sep 2, 2003
Fuel System, Other
WHILE DRIVING VEHICLE DIES OUT, BUT WILL RESTART. TOOK VEHICLE TO DEALER, AND THE DEALER REPROGRAMMED THE FUEL SYSTEM. *AK THE FIRST TWO FAILURE, THE VEHICLE STARTED UP IN 3 TO 5 MIN. THE THIRD FAILURE, THE MOST SERIOUS, IT TOOK APPROX. 10 MIN. TO START IN HEAVY TRAFFIC. CONSUMER TOOK TO DEALER. TWO MONTHS LATER, VEHICLE QUIT…
Read full complaint
WHILE DRIVING VEHICLE DIES OUT, BUT WILL RESTART. TOOK VEHICLE TO DEALER, AND THE DEALER REPROGRAMMED THE FUEL SYSTEM. *AK THE FIRST TWO FAILURE, THE VEHICLE STARTED UP IN 3 TO 5 MIN. THE THIRD FAILURE, THE MOST SERIOUS, IT TOOK APPROX. 10 MIN. TO START IN HEAVY TRAFFIC. CONSUMER TOOK TO DEALER. TWO MONTHS LATER, VEHICLE QUIT RUNNING AT 45 MPH. CONSUMER LIMPED HOME AT 5 MPH, LET IDLE FOR 10 MIN. THEN IT RAN FINE AGAIN. *PH
NHTSA ODI #10030131
19,000 miles · Aug 20, 2003
Power Train
BOUGHT FROM DEALER, USED WITH 15000 MILES. AFTER 300 MILES HAD TO HAVE TRANSMISSION REBUILT (TRANNY WARNING LIGHT AND VIBRATION UNDER ACCELERATION, UPSHIFT 1ST TO 2ND OR 2ND TO 3RD). ONLY HAPPENED OCCASIONALLY. THREE WEEKS AFTER REBUILD NOTICED VIBRATION AT SLOW SPEEDS, BUT COULD NOT REPLICATE ON DEMAND. DEALER COULD NOT REP…
Read full complaint
BOUGHT FROM DEALER, USED WITH 15000 MILES. AFTER 300 MILES HAD TO HAVE TRANSMISSION REBUILT (TRANNY WARNING LIGHT AND VIBRATION UNDER ACCELERATION, UPSHIFT 1ST TO 2ND OR 2ND TO 3RD). ONLY HAPPENED OCCASIONALLY. THREE WEEKS AFTER REBUILD NOTICED VIBRATION AT SLOW SPEEDS, BUT COULD NOT REPLICATE ON DEMAND. DEALER COULD NOT REPEAT VIBRATION AND RETURNED IT WITH NO ACTION. ONE WEEK LATER TRANSMISSION WARNING LIGHT ILLUMINATED ON 2 DIFFERENT DAYS. TAKEN TO DEALER FOR EVALUATION TODAY. I'M CONCERNED THAT THERE MAY BE AN INHERENT PROBLEM WITH THE TRANSMISSION
NHTSA ODI #10033190
18 miles · May 18, 2003
Power Train
I OWN A 2002 SPORT TRAC, AT ABOUT 46000 MILES MI TRANSMISSION STARTED TO MISS SHIFTS FROM 2ND TO 3RD GEAR, IT TOOK ABOUT 3 TO 4 SECONDS FOR THE TRANSMISSION TO GET INTO THE NEXT GEAR, SO I TOOK IT TO THE DEALER WHERE I USUALLY HAVE THE TRUCK SERVICED THINKING THAT IT JUST NEEDED A FLUID CHECK DUE TO THE FACT THEY PERFORMED A TRA…
Read full complaint
I OWN A 2002 SPORT TRAC, AT ABOUT 46000 MILES MI TRANSMISSION STARTED TO MISS SHIFTS FROM 2ND TO 3RD GEAR, IT TOOK ABOUT 3 TO 4 SECONDS FOR THE TRANSMISSION TO GET INTO THE NEXT GEAR, SO I TOOK IT TO THE DEALER WHERE I USUALLY HAVE THE TRUCK SERVICED THINKING THAT IT JUST NEEDED A FLUID CHECK DUE TO THE FACT THEY PERFORMED A TRANSMISSION FLUID CHANGE AT ABOUT 30000. WHEN I WENT BACK TO THE DEALER I WAS ADVISED THAT THE TRANSMISSION HAD A PROBLEM ON THE FLUID LINES AND THE TRANSMISSION HAD TO BE TAKEN OUT TO BE REBUILT, SO I ASKED WHY WAS THIS HAPPENING AND THEY STATED THAT THERE WAS A PROBLEM WITH THE GASKETS BEEN WORN OUT INSIDE THE TRANSMISSION. BUT THEY COULDN'T SPECIFY IF THIS WAS A FACTORY PROBLEM OR A OWNER ABUSE PROBLEM, SO WHEN I ASKED IF THERE WAS A TRANSMISSION RECALL BY THE MANUFACTURER (FORD) ON THIS TYPE OF TRUCKS THE ANSWER WAS NO. THEN I WAS ADVISED THAT MY TRUCK WAS OUT OF FACTORY WARRANTY WHICH IS 3 YEARS OR 36000 MILES AND IF I WANTED TO HAVE THE JOB DONE IT HAD TO BE SELF FINANCED, SO I ASKED FOR AN ESTIMATE WHICH WAS ABOUT 18 HOURS LABOR @ $100 P/H AND $500 IN PARTS TOTALING $2300 AND FINALLY AFTER CALLING FORD AND COMPLAINING ABOUT THIS $30000 TRUCK HAVING A FAULTY TRANSMISSION AND GETTING A "YOUR TRUCK IS OUT OF WARRANTY, AND WE DON'T HAVE ANY OTHER TRUCKS WITH THE SAME PROBLEM" I FINALLY PAID THE REPAIRS OUT OF MY POCKET WHICH I PERSONALLY THINK SHOULD NOT BE HAPPENING ON A ALMOST BRAND NEW TRUCK. *JB
NHTSA ODI #10018893
18,730 miles · Apr 30, 2003
Service Brakes, HydraulicCrash
I'VE HAD TWO INCIDENTS WHERE THE LEFT REAR BRAKES HAS LOCKED UP: FIRST, AFTER ENTERING PARKING GARAGE FROM SNOW COVERED STREETS 02/21/03. SECOND, MAKING A LEFT TURN FROM A COMPLETE STOP WHILE RAINING. LOSES TRACTION OVER BUMPY ROAD ARES AND DIPS.
NHTSA ODI #10016772
Official recalls
2Aug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Aug 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT, THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. IF THE BOLT FRACTURES AND DOES NOT JAM IN THE SEAT BACK FRAME, THE SEAT BACK MAY RECLINE UNTIL IT MAKES CONTACT WITH AN OBJECT BEHIND THE SEAT, SUCH AS THE SECOND ROW SEAT CUSHION.
Consequence & remedy
Consequence: THE DRIVER COULD POTENTIALLY LOSE CONTACT WITH THE STEERING WHEEL OR FOOT PEDALS DURING SUCH AN EVENT, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE DRIVER SEAT UPPER BOLT WITH A METAL SPACER AND BOLT. IN ADDITION, SEATS WITH TUBULAR BACK FRAMES WILL HAVE THE FULLY THREADED LOWER RECLINER BOLT REPLACED WITH A PARTIALLY THREADED BOLT. OWNER NOTIFICATION BEGAN ON AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE09020 · Vehicle Rollaway Allegations
Opened Apr 21, 2009 · Closed Aug 19, 2009
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:column LOCKING:ANTI-THEFT Device
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), FORD STATED CONSUMER REPORTS OF HIGHER THAN EXPECTED EFFORTS WHEN SHIFTING INTO AND OUT OF PARK COULD BE A RESULT OF A GROOVE BEING WORN INTO THE SWING ARM RAMP OF THE STEERING COLUMN. THE SWING ARM IS A COMPONENT BOLTED TO THE STEERING COLUMN THAT ASSISTS IN SHIFTING THROUGH THE TRANSMISSION GEARS.AN ENGINEERING EVALUATION CONDUCTED BY FORD OF RETURNED STEERING COLUMNS FOUND THE GROOVE COULD BE CREATED OVER TIME IF CONSUMER SHIFT MORE QUICKLY FROM THE DRIVE OR REVERSE TO PARK THAN THE BRAKE SHIFT INTERLOCK (BSI) SOLENOID PIN RETRACTS AFTER THE BRAKE PEDAL IS APPLIED. IN NOVEMBER OF 2004, FORD RELEASED A REDESIGNED BSI SOLENOID WITH A SHORTER PIN RETRACTING TIME AS A SERVICEABLE COMPONENT. FORD HAS NOTED THE SHORTER RETRACTION TIME SIGNIFICANTLY LESSENS THE LIKELIHOOD OF BSI SOLENOID PIN TO SWING ARM CONTACT EVEN WITH RAPID CONSUMER SHIFTS.FORD ALSO ISSUED A TECHNICAL SERVICE BULLETIN, TSB 04-22-12, TO INSTRUCT SERVICE TECHNICIANS ON THE PROPER DIAGNOSIS AND VEHICLE REPAIR. REVIEWING COMPLAINTS TO ODI AND DATA SUBMITTED BY FORD, ODI HAS IDENTIFIED 200 ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT AFTER CONSUMERS BELIEVE THEY HAVE SHIFTED THE VEHICLE INTO PARK, RESULTING IN 85 ALLEGED CRASHES AND 32 ALLEGED INJURIES.IN ADDITION TO THE REPORTS OF ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT, ODI HAS ALSO IDENTIFIED 883 REPORTS OF CONSUMERS ALLEGING DIFFICULTY OR THE INABILITY TO SHIFT THE VEHICLE INTO PARK.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-013) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (3)
Steering:column
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), FORD STATED CONSUMER REPORTS OF HIGHER THAN EXPECTED EFFORTS WHEN SHIFTING INTO AND OUT OF PARK COULD BE A RESULT OF A GROOVE BEING WORN INTO THE SWING ARM RAMP OF THE STEERING COLUMN. THE SWING ARM IS A COMPONENT BOLTED TO THE STEERING COLUMN THAT ASSISTS IN SHIFTING THROUGH THE TRANSMISSION GEARS.AN ENGINEERING EVALUATION CONDUCTED BY FORD OF RETURNED STEERING COLUMNS FOUND THE GROOVE COULD BE CREATED OVER TIME IF CONSUMER SHIFT MORE QUICKLY FROM THE DRIVE OR REVERSE TO PARK THAN THE BRAKE SHIFT INTERLOCK (BSI) SOLENOID PIN RETRACTS AFTER THE BRAKE PEDAL IS APPLIED. IN NOVEMBER OF 2004, FORD RELEASED A REDESIGNED BSI SOLENOID WITH A SHORTER PIN RETRACTING TIME AS A SERVICEABLE COMPONENT. FORD HAS NOTED THE SHORTER RETRACTION TIME SIGNIFICANTLY LESSENS THE LIKELIHOOD OF BSI SOLENOID PIN TO SWING ARM CONTACT EVEN WITH RAPID CONSUMER SHIFTS.FORD ALSO ISSUED A TECHNICAL SERVICE BULLETIN, TSB 04-22-12, TO INSTRUCT SERVICE TECHNICIANS ON THE PROPER DIAGNOSIS AND VEHICLE REPAIR. REVIEWING COMPLAINTS TO ODI AND DATA SUBMITTED BY FORD, ODI HAS IDENTIFIED 200 ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT AFTER CONSUMERS BELIEVE THEY HAVE SHIFTED THE VEHICLE INTO PARK, RESULTING IN 85 ALLEGED CRASHES AND 32 ALLEGED INJURIES.IN ADDITION TO THE REPORTS OF ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT, ODI HAS ALSO IDENTIFIED 883 REPORTS OF CONSUMERS ALLEGING DIFFICULTY OR THE INABILITY TO SHIFT THE VEHICLE INTO PARK.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-013) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Steering:column LOCKING:ANTI-THEFT Device
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), FORD STATED CONSUMER REPORTS OF HIGHER THAN EXPECTED EFFORTS WHEN SHIFTING INTO AND OUT OF PARK COULD BE A RESULT OF A GROOVE BEING WORN INTO THE SWING ARM RAMP OF THE STEERING COLUMN. THE SWING ARM IS A COMPONENT BOLTED TO THE STEERING COLUMN THAT ASSISTS IN SHIFTING THROUGH THE TRANSMISSION GEARS.AN ENGINEERING EVALUATION CONDUCTED BY FORD OF RETURNED STEERING COLUMNS FOUND THE GROOVE COULD BE CREATED OVER TIME IF CONSUMER SHIFT MORE QUICKLY FROM THE DRIVE OR REVERSE TO PARK THAN THE BRAKE SHIFT INTERLOCK (BSI) SOLENOID PIN RETRACTS AFTER THE BRAKE PEDAL IS APPLIED. IN NOVEMBER OF 2004, FORD RELEASED A REDESIGNED BSI SOLENOID WITH A SHORTER PIN RETRACTING TIME AS A SERVICEABLE COMPONENT. FORD HAS NOTED THE SHORTER RETRACTION TIME SIGNIFICANTLY LESSENS THE LIKELIHOOD OF BSI SOLENOID PIN TO SWING ARM CONTACT EVEN WITH RAPID CONSUMER SHIFTS.FORD ALSO ISSUED A TECHNICAL SERVICE BULLETIN, TSB 04-22-12, TO INSTRUCT SERVICE TECHNICIANS ON THE PROPER DIAGNOSIS AND VEHICLE REPAIR. REVIEWING COMPLAINTS TO ODI AND DATA SUBMITTED BY FORD, ODI HAS IDENTIFIED 200 ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT AFTER CONSUMERS BELIEVE THEY HAVE SHIFTED THE VEHICLE INTO PARK, RESULTING IN 85 ALLEGED CRASHES AND 32 ALLEGED INJURIES.IN ADDITION TO THE REPORTS OF ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT, ODI HAS ALSO IDENTIFIED 883 REPORTS OF CONSUMERS ALLEGING DIFFICULTY OR THE INABILITY TO SHIFT THE VEHICLE INTO PARK.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-013) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Steering
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), FORD STATED CONSUMER REPORTS OF HIGHER THAN EXPECTED EFFORTS WHEN SHIFTING INTO AND OUT OF PARK COULD BE A RESULT OF A GROOVE BEING WORN INTO THE SWING ARM RAMP OF THE STEERING COLUMN. THE SWING ARM IS A COMPONENT BOLTED TO THE STEERING COLUMN THAT ASSISTS IN SHIFTING THROUGH THE TRANSMISSION GEARS.AN ENGINEERING EVALUATION CONDUCTED BY FORD OF RETURNED STEERING COLUMNS FOUND THE GROOVE COULD BE CREATED OVER TIME IF CONSUMER SHIFT MORE QUICKLY FROM THE DRIVE OR REVERSE TO PARK THAN THE BRAKE SHIFT INTERLOCK (BSI) SOLENOID PIN RETRACTS AFTER THE BRAKE PEDAL IS APPLIED. IN NOVEMBER OF 2004, FORD RELEASED A REDESIGNED BSI SOLENOID WITH A SHORTER PIN RETRACTING TIME AS A SERVICEABLE COMPONENT. FORD HAS NOTED THE SHORTER RETRACTION TIME SIGNIFICANTLY LESSENS THE LIKELIHOOD OF BSI SOLENOID PIN TO SWING ARM CONTACT EVEN WITH RAPID CONSUMER SHIFTS.FORD ALSO ISSUED A TECHNICAL SERVICE BULLETIN, TSB 04-22-12, TO INSTRUCT SERVICE TECHNICIANS ON THE PROPER DIAGNOSIS AND VEHICLE REPAIR. REVIEWING COMPLAINTS TO ODI AND DATA SUBMITTED BY FORD, ODI HAS IDENTIFIED 200 ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT AFTER CONSUMERS BELIEVE THEY HAVE SHIFTED THE VEHICLE INTO PARK, RESULTING IN 85 ALLEGED CRASHES AND 32 ALLEGED INJURIES.IN ADDITION TO THE REPORTS OF ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT, ODI HAS ALSO IDENTIFIED 883 REPORTS OF CONSUMERS ALLEGING DIFFICULTY OR THE INABILITY TO SHIFT THE VEHICLE INTO PARK.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-013) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
DP05005 · Spark Plug Ejection From Cylinder Head
Opened Sep 22, 2005 · Closed Jan 4, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Additional source detail variants (3)
Engine And Engine Cooling:engine
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
PE03020 · Front Seat Back Recliner Attachment
Opened May 21, 2003 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
BY LETTER DATED AUGUST 4, 2003, FORD NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V281) INVOLVING CERTAIN MODEL YEAR (MY) 1998-2001 FORD EXPLORER / MERCURY MOUNTAINEER 4-DOOR, MY 1998-2000 FORD EXPLORER 2-DOOR AND MY 2001-2002 FORD EXPLORER SPORT AND SPORT TRAC VEHICLES EQUIPPED WITH HIGH BACK SEATS.COMPLAINTS ALLEGE THAT THE DRIVER'S SEAT BACK RECLINED WITHOUT WARNING.A BOLT BETWEEN THE UPPER SEAT RECLINER ATTACHMENT AND THE SEAT BACK FRAME MAY FRACTURE.FORD WILL REPLACE THE BOLT THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME ON THE DRIVER SIDE SEAT.BASED ON FORD'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Illustration