NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
118 reports130,200 miles · Oct 9, 2019
Electrical SystemEngineVehicle Speed Control
IDENTICAL TO NUMEROUS OTHER REGISTERED COMPLAINTS (JUNE 4, 2018 NHTSA ID NUMBER: 11099593, SEPTEMBER 26, 2018 NHTSA ID NUMBER: 11131784, JUNE 14, 2018 NHTSA ID NUMBER: 11101913, APRIL 9, 2018 NHTSA ID NUMBER: 11084000, AUGUST 8, 2016 NHTSA ID NUMBER: 10894005): SUDDEN DECELERATION WITH GAUGES FLASHING - WRENCH LIGHT ON, MILES T…
Read full complaint
IDENTICAL TO NUMEROUS OTHER REGISTERED COMPLAINTS (JUNE 4, 2018 NHTSA ID NUMBER: 11099593, SEPTEMBER 26, 2018 NHTSA ID NUMBER: 11131784, JUNE 14, 2018 NHTSA ID NUMBER: 11101913, APRIL 9, 2018 NHTSA ID NUMBER: 11084000, AUGUST 8, 2016 NHTSA ID NUMBER: 10894005): SUDDEN DECELERATION WITH GAUGES FLASHING - WRENCH LIGHT ON, MILES TO ZERO WITH NO NUMBERS, SPEEDOMETER FAILS. AT THE SAME TIME, THE CAR BEGINS BUCKING WITH SUDDEN ACCELERATION AND DECELERATION, BUT ULTIMATELY THE VEHICLE IS LOSING POWER AND ACCELERATION IS LIMITED OR USELESS. SEVERAL TIMES I COULD RESET THE ENGINE PROBLEM BY TURNING THE VEHICLE OFF AND RESTARTING. THE LAST TWO TIMES IT OCCURED WHEN ACCELERATING FROM A STOP AND THE VEHICLE REFUSED TO SHIFT FROM 1ST GEAR. I ATTEMPTED TO RESTART IT AFTER PULLING OFF THE ROAD BUT IT DID NOT FIX IT THIS TIME. (AND ON THESE OCCASIONS THE DASH LIGHTS DID NOT CHANGE RIGHT AWAY/FIRST). I PULLED OVER 3 MORE TIMES AND TRIED SHIFTING THROUGH ALL THE GEARS MANUALLY, INCLUDING USING THE 4WD TOGGLE, AND THAT FINALLY ALLOWED THE CAR TO SHIFT NORMALLY. THIS IS EXTREMELY DANGEROUS AND AT HIGHER SPEEDS CAN CAUSE THE CAR TO LOSE TRACTION. I'VE BEEN FORTUNATE THAT THIS HAS ONLY HAPPENED TWICE AT 65MPH AND I WAS IN A POSITION TO GET TO THE SIDE OF THE ROAD WITHOUT INCIDENT. THE TOTAL NUMBER OF TIMES HAS BEEN 8 IN APPROXIMATELY 2,000 MILES OF DRIVING. IF THIS HAPPENS NOW THAT SNOW AND ICE ARE ON THE ROAD, IT COULD CAUSE A CATASTROPHIC CRASH.
NHTSA ODI #11267256
103,000 miles · Sep 16, 2019
Unknown Or Other
THIS HAS HAPPENED NOW A FEW TIMES: THE SPEEDOMETER HAS DROPPED 0, VEHICLE BEGINS JERKING FORWARD AND LOSES SPEED. I PULLED OVER SEVERAL TIMES HOPING THE ISSUE WOULD CORRECT ITSELF. EVENTUALLY THE PIC OF A WRENCH AND SERVICE ENGINE LIGHT APPEARED ON THE DASHBOARD ALL OF WHICH DISAPPEARED ONCE I TURNED THE ENGINE OFF AND RE-START…
Read full complaint
THIS HAS HAPPENED NOW A FEW TIMES: THE SPEEDOMETER HAS DROPPED 0, VEHICLE BEGINS JERKING FORWARD AND LOSES SPEED. I PULLED OVER SEVERAL TIMES HOPING THE ISSUE WOULD CORRECT ITSELF. EVENTUALLY THE PIC OF A WRENCH AND SERVICE ENGINE LIGHT APPEARED ON THE DASHBOARD ALL OF WHICH DISAPPEARED ONCE I TURNED THE ENGINE OFF AND RE-STARTED IT. THE TRANSMISSION FLUSH HAS BEEN DONE AND THE RECALL FOR THE TRANSMISSION DOWNSHIFTING HAS ALSO BEEN ADDRESSED. BUT THE AFOREMENTIONED SYMPTOMS HAVE TAKEN PLACE AT LEAST TWO TIMES BEFORE THE TRANSMISSION RECALL WAS ADDRESSED AND THE TRANSMISSION FLUSH WAS DONE AND AT LEAST THREE TIMES (SO FAR) AFTER THE TRANSMISSION RECALL ISSUE WAS ADDRESSED AND AFTER THE TRANSMISSION FLUSH WAS DONE. COULD IT BE DEFECTIVE FAN CLUTCHES THAT ARE CAUSING THESE ISSUES ON EXPEDITIONS?
NHTSA ODI #11255795
Mileage unknown · Aug 18, 2019
Child Seat
I HAVE THE GRACO MY RIDE 65. I HAD TO PUT THE SEAT IN MY MOTHER IN LAWS CAR AND CAN'T GET IT OUT NOW. IT SEEMS LIKE THE LATCH IT LOCKED OR STUCK. IT WILL NOT FEED ANY SLACK TO HELP REMOVE HE SEAT. NORMALLY THIS SEAT IS IN MY EXPEDITION AND A BIT EASIER TO GET OUT HOWEVER STILL VERY HARD. I HATE TO TAKE THIS SEAT OUT AND RE INSTA…
Read full complaint
I HAVE THE GRACO MY RIDE 65. I HAD TO PUT THE SEAT IN MY MOTHER IN LAWS CAR AND CAN'T GET IT OUT NOW. IT SEEMS LIKE THE LATCH IT LOCKED OR STUCK. IT WILL NOT FEED ANY SLACK TO HELP REMOVE HE SEAT. NORMALLY THIS SEAT IS IN MY EXPEDITION AND A BIT EASIER TO GET OUT HOWEVER STILL VERY HARD. I HATE TO TAKE THIS SEAT OUT AND RE INSTALL OFTEN BECAUSE OF THIS SITUATION. AT THE MOMENT THE SEAT IS CURRENTLY STILL STUCK IN THE CAR. I CAN CUT THE STRAPS HOWEVER DON?T WANT TO DO THAT IF I DON'T HAVE TOO! (RELATED VEHICLE INFORMATION: MODEL YEAR=2012, MAKE=EXPEDITION , MODEL=FORD) *DT *DT *TR *DT NO VIN, NO ATTACHMENTS.*JB
NHTSA ODI #11244762
34,000 miles · Jul 22, 2019
Structure
PAINT BUBBLING APPEARS ON REAL TAILGATE AND EDGE OF HOOD. RUST PIN SPOTS NOTICEABLE ON DOOR PANELS UNDER CLEAR COAT.
NHTSA ODI #11233997
173,000 miles · Feb 21, 2019
Power Train
WHILE DRIVING AT FREEWAY SPEEDS (60-65MPH) THERE'S A VERY NOTICEABLE "CLANK" WHEN THE TRANSMISSION SHIFTS. ESPECIALLY WHEN DRIVING AT AN INCLINE AT 1,800-2,000 RPM. I HAVE TO KEEP VEHICLE ABOVE THAT SPEED OR AT A DIFFERENT RPM RANGE.
NHTSA ODI #11181687
147,000 miles · Jan 18, 2019
Power Train
THERE HAVE BEEN SEVERAL INSTANCES. THE FIRST ONE I WAS PULLING OUT OF A PARKING LOT ONTO A MAIN ROAD WHEN THE TRANSMISSION STOPPED PULLING, ACTED LIKE IT WAS IN NEUTRAL. I PULLED OVER TURNED OFF THE ENGINE AND RESTARTED IT AND IT WAS FINE. THE NEXT WAS ON A 2 LANE HIGHWAY CRUISING AT ABOUT 50 MPH, THE VEHICLE JERKED, LOCKED UP…
Read full complaint
THERE HAVE BEEN SEVERAL INSTANCES. THE FIRST ONE I WAS PULLING OUT OF A PARKING LOT ONTO A MAIN ROAD WHEN THE TRANSMISSION STOPPED PULLING, ACTED LIKE IT WAS IN NEUTRAL. I PULLED OVER TURNED OFF THE ENGINE AND RESTARTED IT AND IT WAS FINE. THE NEXT WAS ON A 2 LANE HIGHWAY CRUISING AT ABOUT 50 MPH, THE VEHICLE JERKED, LOCKED UP THE REAR TIRES, WENT INTO LIMP MODE, CHECK ENGINE LIGHT CAME ON AND CODE WAS P0270 FOR THE OUTPUT SPEED SENSOR. SYSMPTONS ARE THE SAME AS DESCRIBED IN FORDS RECALL #16S19 BUT I WAS TOLD BY FORD THAT MY VEHICLE WAS NOT COVERED UNDER THE RECALL BECAUSE OF THE BUILD DATE ALTHOUGH THE SAME TRANSMISSION A D COMPONENTS WERE USED. THE INSTANCE HAPPENED AGAIN TODAY WITH MY WIFE AND 3 YOUNG CHILDREN IN THE VEHICLE, CRUISING APPROX 60 MPH ON THE HIGHWAY, REAR WHEELS LOCKED UP, TRANSMISSION DOWNSHIFTS TO FIRST GEAR, VEHICLE SKIDS TOWARD THE EDGE OF AN EMBANKMENT, JUST BEFORE GETTING THERE THE WHEELS UNLOCK AND MY WIFE IS ABLE TO MAKE IT TO A NEAR BY CHURCH PARKING LOT TO PULL OVER AND TURN THE ENGINE OFF.
NHTSA ODI #11170882
111,628 miles · Jan 15, 2019
Power Train
TL* THE CONTACT OWNS A 2012 FORD EXPEDITION. WHILE DRIVING 60 MPH, THE TRANSMISSION SEIZED AND THE VEHICLE SKIDDED DOWN THE ROADWAY. THE CONTACT WAS ASSISTED BY A POLICE OFFICER WITH DIVERTING TRAFFIC TO HAVE THE VEHICLE SAFELY MOVED OFF OF THE ROADWAY. ADDITIONALLY, WHILE DRIVING 45 MPH, THE FAILURE RECURRED. THE VEHICLE WAS TA…
Read full complaint
TL* THE CONTACT OWNS A 2012 FORD EXPEDITION. WHILE DRIVING 60 MPH, THE TRANSMISSION SEIZED AND THE VEHICLE SKIDDED DOWN THE ROADWAY. THE CONTACT WAS ASSISTED BY A POLICE OFFICER WITH DIVERTING TRAFFIC TO HAVE THE VEHICLE SAFELY MOVED OFF OF THE ROADWAY. ADDITIONALLY, WHILE DRIVING 45 MPH, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO BELL ROAD FORD (LOCATED AT 2401 W. BELL ROAD, PHOENIX, AZ 85023, (602)457-2144) WHERE IT WAS DIAGNOSED THAT THE POWER TRAIN CONTROL MODULE NEEDED TO BE REPROGRAMMED. THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 16V248000 (POWER TRAIN); HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 111,628. *BF *TR
NHTSA ODI #11170206
Mileage unknown · Dec 14, 2018
Structure
THE TAILGATE HAS PEELING PAINT IN SEVERAL SPOTS
NHTSA ODI #11161381
180,000 miles · Nov 24, 2018
Power Train
WHILE DRIVING MY VEHICLE OFF OF HOMESTEAD RDMY TRUCK SLAMS INTO 1ST GEAR JUST RANDOMLY SOMETIMES WHILE IM DRIVING FAST AND SOMETIME WHEN I'M DRIVING SLOW I THINK THE BACK WHEELS LOCKED AT ONE POINT PUTTING ME INTO ONCOMING TRAFFIC BUT IT RELEASED JUST IN THE NICK OF TIME TO GET OUT OF THE WAY I WAS VERY SCARED I'M STILL WORRIED …
Read full complaint
WHILE DRIVING MY VEHICLE OFF OF HOMESTEAD RDMY TRUCK SLAMS INTO 1ST GEAR JUST RANDOMLY SOMETIMES WHILE IM DRIVING FAST AND SOMETIME WHEN I'M DRIVING SLOW I THINK THE BACK WHEELS LOCKED AT ONE POINT PUTTING ME INTO ONCOMING TRAFFIC BUT IT RELEASED JUST IN THE NICK OF TIME TO GET OUT OF THE WAY I WAS VERY SCARED I'M STILL WORRIED TO DRIVE IT BUT AS OF RIGHT NOW IT'S MY ONLY MEANS OF TRANSPORTATION SO I JUST DRIVE CAREFULLY I'VE HEARD OF OTHER TRUCKS LIKE MINE DOING THIS BUT MINE ISN'T RECALLED ONLY OTHER ONES
NHTSA ODI #11153556
82,000 miles · Nov 23, 2018
Seat BeltsStructureCrashInjury
B POST FAILED CAUSING SEAT BELT TO RIP OUT. I CAN SEND MORE PICTURES IF NEEDED.
NHTSA ODI #11153432
Official recalls
3Apr 27, 2016
Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford F-150 trucks, 2012 Ford Expedition, Lincoln Navigator, and Ford Mustang vehicles. The affected vehicles are equipped with an automatic transmission that may unexpectedly downshift to first gear, regardless of vehicle speed.
Consequence & remedy
Consequence: An unexpected downshift into first gear can cause the vehicle to slow down suddenly without warning and the rear tires may slide or lock, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module with updated software, free of charge. The recall began on September 19, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S19.
May 3, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 2011-2012 FORD F-150, 2012 EXPEDITION AND LINCOLN NAVIGATOR, AND 2012-2013 MUSTANG VEHICLES, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NOS. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT" AND 108 LAMPS, REFLECTIVE DEVICES AND ASSOCIATED EQUIPMENT. THESE VEHICLES MAY HAVE A TRANSMISSION RANGE SENSOR (TRS) THAT WAS CALIBRATED OUT OF SPECIFICATION FOR REVERSE GEAR.
Consequence & remedy
Consequence: IF THIS CONDITION EXISTS, THE TRANSMISSION MAY NOT GO INTO REVERSE OR WHEN THE DRIVER PUSHES THE SHIFT LEVER IN THE REVERSE R POSITION AND THE VEHICLES TRANSMISSION DOES GO IN REVERSE, THE R MAY NOT ILLUMINATE ON THE DASHBOARD OF THE F-150, EXPEDITION, OR NAVIGATOR MODELS AND/OR THE BACKUP LAMP ON THE REAR OF THE F-150, EXPEDITION, NAVIGATOR, OR MUSTANG VEHICLES MAY NOT ILLUMINATE. THESE CONDITIONS INCREASE THE RISK OF A CRASH OR A PEDESTRIAN BEING STRUCK DUE TO THE VEHICLES NOT SIGNALING IT IS IN REVERSE.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE TRS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 11, 2012. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Additional source detail variants (2)
Exterior Lighting:back Up Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011-2012 FORD F-150, 2012 EXPEDITION AND LINCOLN NAVIGATOR, AND 2012-2013 MUSTANG VEHICLES, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NOS. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT" AND 108 LAMPS, REFLECTIVE DEVICES AND ASSOCIATED EQUIPMENT. THESE VEHICLES MAY HAVE A TRANSMISSION RANGE SENSOR (TRS) THAT WAS CALIBRATED OUT OF SPECIFICATION FOR REVERSE GEAR.
Consequence: IF THIS CONDITION EXISTS, THE TRANSMISSION MAY NOT GO INTO REVERSE OR WHEN THE DRIVER PUSHES THE SHIFT LEVER IN THE REVERSE R POSITION AND THE VEHICLES TRANSMISSION DOES GO IN REVERSE, THE R MAY NOT ILLUMINATE ON THE DASHBOARD OF THE F-150, EXPEDITION, OR NAVIGATOR MODELS AND/OR THE BACKUP LAMP ON THE REAR OF THE F-150, EXPEDITION, NAVIGATOR, OR MUSTANG VEHICLES MAY NOT ILLUMINATE. THESE CONDITIONS INCREASE THE RISK OF A CRASH OR A PEDESTRIAN BEING STRUCK DUE TO THE VEHICLES NOT SIGNALING IT IS IN REVERSE.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE TRS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 11, 2012. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
FORD IS RECALLING CERTAIN MODEL YEAR 2011-2012 FORD F-150, 2012 EXPEDITION AND LINCOLN NAVIGATOR, AND 2012-2013 MUSTANG VEHICLES, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NOS. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT" AND 108 LAMPS, REFLECTIVE DEVICES AND ASSOCIATED EQUIPMENT. THESE VEHICLES MAY HAVE A TRANSMISSION RANGE SENSOR (TRS) THAT WAS CALIBRATED OUT OF SPECIFICATION FOR REVERSE GEAR.
Consequence: IF THIS CONDITION EXISTS, THE TRANSMISSION MAY NOT GO INTO REVERSE OR WHEN THE DRIVER PUSHES THE SHIFT LEVER IN THE REVERSE R POSITION AND THE VEHICLES TRANSMISSION DOES GO IN REVERSE, THE R MAY NOT ILLUMINATE ON THE DASHBOARD OF THE F-150, EXPEDITION, OR NAVIGATOR MODELS AND/OR THE BACKUP LAMP ON THE REAR OF THE F-150, EXPEDITION, NAVIGATOR, OR MUSTANG VEHICLES MAY NOT ILLUMINATE. THESE CONDITIONS INCREASE THE RISK OF A CRASH OR A PEDESTRIAN BEING STRUCK DUE TO THE VEHICLES NOT SIGNALING IT IS IN REVERSE.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE TRS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 11, 2012. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Feb 2, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 2012 EXPEDITION AND LINCOLN NAVIGATOR VEHICLES, MANUFACTURED FROM NOVEMBER 19, 2011, THROUGH DECEMBER 2, 2011, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 202, "HEAD RESTRAINTS." THESE VEHICLES MAY HAVE INADEQUATE WELDS ON THE HEAD RESTRAINT SUPPORT BRACKETS FOR THE SECOND ROW, RIGHT-HAND SEAT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT HEAD RESTRAINT MAY NOT PROVIDE THE REQUIRED STRENGTH, INCREASING THE RISK OF INJURY.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE HEAD RESTRAINTS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 21, 2012. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ17010 · Unexpected Transmission Downshift
Opened Dec 25, 2017 · Closed Oct 22, 2019
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
Power Train:automatic Transmission
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
Illustration