Electrical System. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Seat Belts. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Gasoline. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

19 crash reports61 fire reports14 injury reports

What owners actually said

327 reports

Mileage unknown · Aug 19, 2004

Service Brakes, HydraulicVehicle Speed ControlCrashInjury

Read full complaint

FATALITY INVOLVING 1991 FORD ESCORT. *MR THE CONSUMERS AUNT WAS DRIVING AND WAS SEVERELY INJURED AND THE CONSUMERS MOTHER WAS KILLED IN THE ACCIDENT. THE CONSUMER REQUESTED TO KNOW IF THE VEHICLE WAS CHECKED OR CORRECTED FOR THE PROBLEM. (INSPECT THE BOLT LENGTH BEFORE DRIVEN OR DEMONSTRATED OR DELIVERED THE VEHICLE UNTIL THEY HAVE BEEN INSPECTED) THIS WAS THE CONSUMER'S AUNT'S FIRST ACCIDENT UNTIL THE PROBLEM WITH THE ACCELERATOR. THE THROTTLE LINKAGE WAS POSSIBLY DEFECTIVE. RECALL# 90V076000 *SC THERE WAS ALSO A LEAKAGE PRESENT AT THE RIGHT FRONT BRAKE CALIPER UPON INSPECTION. *JB

NHTSA ODI #10089429

136,000 miles · Jul 30, 2004

Electrical SystemFire

Read full complaint

MY DAUGHTER WAS DRIVING A 1991 FORD ESCORT IN DOWNTOWN PITTSBURGH WHEN SMOKE BEGAN POURING OUT OF THE DASHBOARD BEHIND THE SPEEDOMETER SECTION. SHE PULLED OVER AND EXITED THE CAR AFTER TURNING OFF THE IGNITION SWITCH. THE SMOKE CEASED AND A POLICE OFFICER STOPPED BY TO ASSIST. HE REMAINED TO DIRECT TRAFFIC UNTIL THE TOW TRUCK CAME TO RETURN THE VEHICLE TO MY HOUSE. THE VEHICLE HAS LIABILITY INSURANCE ONLY. I WAS NOT ABLE TO INVESTIGATE THE CAUSE OF THE SMOKE FOR A FEW DAYS. I NEEDED MORE INFORMATION IN HOW TO GET BEHIND THE DASHBOARD. UPON OPENING THE DASHBOARD, I FOUND THE WIRING BUNDLE LEADING TO THE DASHBOARD METERING WAS MELTED INTO A BUNDLE AND THE WIRES WERE NOT DISTINGUISHABLE IN COLOR ANY MORE. THE MELTED SECTION OF WIRING WAS FURTHER FOUND IN LEADING INTO THE LARGER BUNDLE GOING DEEPER INTO THE DASHBOARD AND INTO THE ENGINE WELL. I CONTACTED FORD CONCERNING THIS AND WAS REFERED BY THEM TO MY INSURANCE AGENT. THE CONSUMER SAFETY COMMISSION SENT ME IN YOUR DIRECTION. IS THERE ANYTHING I CAN DO BESIDES TRASH THE CAR?*AK

NHTSA ODI #10082982

Mileage unknown · Apr 17, 2004

Electrical System

IGNITION SWITCH FAILURE TO TURN OFF ENGINE. SMOKE COMING INTO THE INSIDE OF VEHICLE FROM THE ENGINE. *AK

NHTSA ODI #10066376

135,000 miles · Mar 3, 2004

Seat Belts

AUTOMATIC PASSIVE RESTRAINT SYSTEM FAILED TO OPERATE WHEN OPENING THE DOOR. MECHANISM JAMMED, AND HAD TO BE MANUALLY DISCONNECTED TO GET IN AND OUT OF THE VEHICLE. *AK *NM

NHTSA ODI #10057240

Mileage unknown · Feb 19, 2004

Electrical System

THE CONSUMER WAS MAKING A LEFT HAND TURN WHEN THE IGNITION LOCK CYLINDER FELL ONTO THE FLOOR. THE STEERING WHEEL LOCKED UP AND THE CONSUMER WAS FORCED TO COME TO A STOP. THE DEALER HAD BEEN CONTACTED. PLEASE DESCRIBE FURTHER. *JB *MR

NHTSA ODI #10051613

149,000 miles · Jan 29, 2004

Seat Belts

DRIVER'S AUTOMATIC SHOULDER BELT WOULD NOT RETRACT BACK TO THE LOCKING POSITION. CONSUMER IS UNABLE TO WEAR THE SEAT BELT PROPERLY. *AK

NHTSA ODI #10056065

Mileage unknown · Sep 12, 2003

Seat Belts

THE FRONT SEAT BELTS WERE INOPERATIVE. *JB THE VEHICLE CAME EQUIPPED WITH THE AUTOMATIC SEAT BELTS, THE SEAT BELTS FAILED IN THE OPEN POSITION.*SCC *JB

NHTSA ODI #10032458

Mileage unknown · Jul 8, 2003

Seat BeltsCrash

WHILE TRAVELING ABOUT 50MPH AND WITHOUT PRIOR WARNING CONSUMER'S VEHICLE HIT ANOTHER VEHICLE FROM BEHIND, AND DRIVER SIDE STRAP BROKE FROM THE FRAME OF THE SEAT BELT. *AK

NHTSA ODI #10026763

132,000 miles · Jun 25, 2003

Electrical SystemFuel System, Gasoline

CONSUMER STATES THAT THE WIRING ASSEMBLY TO THE FUEL PUMP HAS BURNED UP 3X IN THE LAST MONTH. DEALER DIAGNOSED PROBLEM AS INCORRECT SPECIFIED 30AMP FUSE FOR FUEL PUMP.*AK

NHTSA ODI #10024878

Mileage unknown · Jun 3, 2003

Fuel System, Other

VEHICLE WAS HAVING THE SAME PROBLEM AS MENTIONED IN RECALL#92V17000 CONCERNING FUEL TANK. DEALER WILL NOT REPAIR VEHICLE BECAUSE IT IS NOT COVERED UNDER RECALL DUE TO VIN. *AK

NHTSA ODI #10022205

Official recalls

93V057000 · Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module

Apr 15, 1993

THE ROLL PINS SECURING THE IGNITION LOCK IN THE STEERING COLUMN HOUSING CAN SEPARATE OR MOVE OUT OF POSITION.

Consequence & remedy

Consequence: THE IGNITION LOCK CYLINDER MAY DISENGAGE FROM THESTEERING COLUMN HOUSING WHICH COULD CAUSE THE STEERING COLUMN TO LOCK UP,RESULTING IN LOSS OF VEHICLE CONTROL AND A POSSIBLE ACCIDENT.

Remedy: IF ONE OR BOTH OF THE ROLL PINS ARE MISSING OR NOT FULLY INSERTED, THE IGNITION LOCK HOUSING WILL BE REPLACED, ALONG WITH THE DOOR-LOCKS AND THE LIFTGATE OR DECK-LID LOCKS SO THAT KEY COMPATIBILITY IS MAINTAINED. IF BOTH PINS ARE PRESENT AND FULLY INSERTED, A PLASTIC SNAP-ON SLEEVE WILL BE INSTALLED AS A PRECAUTION TO PREVENT THE ROLL PINS FROM COMING OUT.

92V117000 · Fuel System, Gasoline

Aug 19, 1992

FATIGUE CRACKS CAN DEVELOP IN THE SOLDER JOINT BETWEEN THE FUEL RETURN TUBE AND THE FUEL PUMP SENDING UNIT LOCATED AT THE TOP OF THE FUEL TANK.

Consequence & remedy

Consequence: SHOULD A CRACK DEVELOP, FUEL VAPOR CAN ESCAPE FROM THETANK WHEN THE TANK IS FULL, AND A SMALL AMOUNT OF FUEL CAN LEAK FROM THE CRACK.FUEL LEAKS CAN RESULT IN FIRE WHEN EXPOSED TO A SOURCE OF IGNITION.

Remedy: INSTALL A NEW FUEL PUMP SENDING ASSEMBLY.

90V076000 · Vehicle Speed Control:accelerator Pedal

Apr 17, 1990

INTERFERENCE OCCUR BETWEEN BOLT THAT SECURES A FUEL LINE SHIELD TO THE LOWER PORTION OF THE DASH PANEL AND THE ACCELERATOR PEDAL.

Consequence & remedy

Consequence: THIS COULD CAUSE THE ACCELERATOR PEDAL TO STICK AT THE WIDE OPEN THROTTLE POSITION AND RESULT IN LOSS OF CONTROL WITH THE RISK OF A VEHICLE ACCIDENT.

Remedy: CUT OFF EXTRA LENGTH OF BOLT THAT PROTRUDES ABOVE SURFACE OF WELD NUT TO PREVENT INTERFERENCE.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗