IllustrationEngine frequently overheating, this was recall for my model/ year/vehicle and I was told vin# doesn't associate with recall. I would like to know why.
2013 Ford Escape
Owner reports · Recalls · Investigations
More warning signs than most Escape years
Owner complaints for the 2013 Ford Escape are substantially higher than the model-year median of 996.
About this comparison →How this year compares
Owner complaints by model year
Compare all Escape years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
3000–25K
25025–50K
42050–75K
43775–100K
457100–150K
104150K+
1,968 reports with mileage · 781 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 1,265 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 401 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 339 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
49 crash reports90 fire reports46 injury reports
Engine complaints
1,265 reportsThe contact owns a 2013 Ford Escape. The contact stated while in the vehicle with the engine idling for 10 minutes, the contact then attempted to park the vehicle however, the vehicle lost motive power and stalled. There were no warning lights illuminated. The vehicle was restarted and taken to an independent mechanic to be diag…
Read full complaint
The contact owns a 2013 Ford Escape. The contact stated while in the vehicle with the engine idling for 10 minutes, the contact then attempted to park the vehicle however, the vehicle lost motive power and stalled. There were no warning lights illuminated. The vehicle was restarted and taken to an independent mechanic to be diagnosed; however, the mechanic was unable to determine the cause of the failure. The failure had recurred twice. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 104,575.
The controls in the driver side door stopped working. No window or door locks could be activated. The car was taken in to the Ford dealership and it was repaired so the controls worked. A few months later, while driving on the interstate at 70 MPH the engine turned off with no warning. All the warning lights in the electrical p…
Read full complaint
The controls in the driver side door stopped working. No window or door locks could be activated. The car was taken in to the Ford dealership and it was repaired so the controls worked. A few months later, while driving on the interstate at 70 MPH the engine turned off with no warning. All the warning lights in the electrical panel lit up after the engined turned off. After getting off the road and sitting for a few minutes the car started with no problem. After driving 20 minutes, we stopped and tried to use the controls in the driver side door to put the window down. No controls in the driver door functioned. I took the car in for repair but there were no loaner cars and was told they would have to keep the car at least two weeks. I needed transportation so I waited to take the car in. The engine turned off two additional times while i was driving with no warning. I took the car in to the Ford dealership again. They said the door control problem was a fuse and they would have to try to find what was shorting out the fuse. They did not have any comment about the engine stalling out which I reported. They have had the car 4 weeks. I see that some 2013 escape models have been recalled for the engine stalling. I think my car should be added to the recall. I really need my transportation. I am borrowing my mother's car. There is no other car at my house.
The contact owns a 2013 Ford Escape. The contact stated while driving 5-10 MPH, the vehicle stalled inadvertently. There were no warning lights illuminated. The contact was unable to veer to the side of the road. The contact was able to restart the vehicle after several attempts. The contact stated that he continued to drive the…
Read full complaint
The contact owns a 2013 Ford Escape. The contact stated while driving 5-10 MPH, the vehicle stalled inadvertently. There were no warning lights illuminated. The contact was unable to veer to the side of the road. The contact was able to restart the vehicle after several attempts. The contact stated that he continued to drive the vehicle; however, the failure reoccurred the next day while pulling out of a parking spot. The contact stated that the failure reoccurred several times while driving. The vehicle was taken to the dealer twice and the dealer informed the contact that they could not replicate the failure. The contact stated that the failure had been reoccurring increasingly, 2-3 times per day. The vehicle was taken back to the dealer who informed the contact that they could not replicate the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 125,000.
The contact owns a 2013 Ford Escape. The contact stated that coolant was leaking from under the hood of the vehicle onto the engine. The check engine warning light was illuminated. Additionally, the vehicle would overheat occasionally with a message to pull over, stop, turn off the vehicle, and allow the engine to cool down. The…
Read full complaint
The contact owns a 2013 Ford Escape. The contact stated that coolant was leaking from under the hood of the vehicle onto the engine. The check engine warning light was illuminated. Additionally, the vehicle would overheat occasionally with a message to pull over, stop, turn off the vehicle, and allow the engine to cool down. The contact was informed by the dealer that the failure was related to NHTSA Campaign Number: 12V336000 (Fuel System, Gasoline) and 13V583000 (Engine) however, the VIN was not included. The vehicle was not repaired. The failure mileage was unknown. Case number [XXX} INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).”
The computer issues a high engine temperature warning without physical indication of high temperature on the dash thermometer. This results in reducing engine power into “limp mode”. The temperature indicator immediately rises to maxim high. The engine does not shut off but there is no power. The safety concern is: if this condi…
Read full complaint
The computer issues a high engine temperature warning without physical indication of high temperature on the dash thermometer. This results in reducing engine power into “limp mode”. The temperature indicator immediately rises to maxim high. The engine does not shut off but there is no power. The safety concern is: if this condition would occur while in fast moving traffic around a city belt-way, the sudden loss of power and speed reduction could make the vehicle susceptible to a rear end collision or endanger other drivers trying to avoid a slow moving vehicle tryin to get off the road.
The contact owns a 2013 Ford Escape. The contact stated while her husband was driving 25 MPH, the engine overheating warning light was illuminated before the vehicle stalled. The driver was able to restart the vehicle. The driver added engine coolant but continue to experience failure. The vehicle was not drivable. The driver to…
Read full complaint
The contact owns a 2013 Ford Escape. The contact stated while her husband was driving 25 MPH, the engine overheating warning light was illuminated before the vehicle stalled. The driver was able to restart the vehicle. The driver added engine coolant but continue to experience failure. The vehicle was not drivable. The driver towed the vehicle to an independent mechanic and was informed that the head gasket needed to be replaced. The mechanic also noticed that the engine was cracked. The vehicle was not diagnosed or repaired. A dealer was not contacted. The contact attempted to call the manufacturer but was unable to speak to a representative. The failure mileage was approximately 130,000. There was a faulty fuel injector which caused it to not pass emissions. After taking care of that problem, the coolant would run dry very quickly, in a matter of minutes. At this point, the engine light came on and the car just stopped dead in the middle of the street. Consumer sold the vehicle due to hazard.
My son was driving up a hill on January 26, 2022 and the car stalled. I called the Ford dealer and they said I had to take it in and pay for the repairs. This is a 2013 Ford Escape and I was reading on the internet that these cars have these problems. My son said there was no warning lights before this happened, it just stalle…
Read full complaint
My son was driving up a hill on January 26, 2022 and the car stalled. I called the Ford dealer and they said I had to take it in and pay for the repairs. This is a 2013 Ford Escape and I was reading on the internet that these cars have these problems. My son said there was no warning lights before this happened, it just stalled on a busy, dangerous highway. Thank God he was not hurt. I don't know what else to do. This problem should get taken care of with so many people having the same issue.
The sensor for cooling system goes off for low coolant even though there is a full amount of coolant in the vehicle. Causes a bunch of codes to activate and throws vehicle into "limp" mode while saying the vehicle needs to be turned off immediately. Only some vehicles received recall notice per automotive service center, but o…
Read full complaint
The sensor for cooling system goes off for low coolant even though there is a full amount of coolant in the vehicle. Causes a bunch of codes to activate and throws vehicle into "limp" mode while saying the vehicle needs to be turned off immediately. Only some vehicles received recall notice per automotive service center, but others do not even though there is plenty of complaints online about the same issue. Having a vehicle go into "limp" mode while driving in traffic and/or on highway is extremely dangerous.
I bought my car at the end of winter in 2018, and every winter, when it gets 20 degrees or below, every few weeks, my engine overheating light will come on after 10 minutes of driving it. When I look at my coolant, it is right at the minimum line every time. I have since learned to keep a bottle of coolant in my car as well as a…
Read full complaint
I bought my car at the end of winter in 2018, and every winter, when it gets 20 degrees or below, every few weeks, my engine overheating light will come on after 10 minutes of driving it. When I look at my coolant, it is right at the minimum line every time. I have since learned to keep a bottle of coolant in my car as well as a funnel to fill it just a little. Afterward, it would drive okay. Every shop I have taken it to states there are no leaks, and it was working just fine. I've also been told that it's a common issue with the 2013 Ford Escape, and I will have to continue to fill it. This has been an issue as I have been stuck on the freeway with my 3 and 7 year old numerous times trying to get under my hood with the car shut off in negative degree weather. I DO NOT feel safe getting out of the car to fill the coolant with my children in the backseat on a freeway with cars flying past me. Winter of 2022, the issue became worse. I was turning and saw smoke pouring out of my hood, and my check engine light came on. Luckily, I was right by my destination, where it quit working altogether and coolant emptied altogether. My husband, a former mechanic, is replacing the overflow coolant reservoir hose, which broke. The head gasket appears to be okay; however, he believes there may be tiny cracks in the head gasket which would explain why all of the shops I've been to state there is no leak. My vehicle is available for inspection upon request. My kids safety, my safety, and those on the road are at risk every time my vehicle stalls, especially with no heat. At times, my hood is frozen shut, and I cannot open it right away, so my kids and I freeze until I can get the hold open while I hope no one hits my car while the roads are icy. No one has been able to reproduce the issue at a shop. My check engine light comes on periodically every winter but will disappear the same day. It also came on moments before the hose burst.
Official recalls
1826V011000 · Equipment:electrical:engine Block Heater
Jan 15, 2026
Ford Motor Company (Ford) is recalling certain 2013-2018 Focus, 2013-2019 Escape, and 2015-2016 MKC vehicles equipped with a 2.0L engine. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed March 6, 2026. Additional letters will be sent once the final remedy is available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S01. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on January 16, 2026.
22V413000 · Power Train:automatic Transmission:gear Position Indication (prndl); Power Train:shift Linkage/cable/rod
Jun 10, 2022
Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles. The bushing that attaches the shifter cable to the transmission may degrade or detach.
Consequence & remedy
Consequence: A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, and cause the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.
Remedy: Dealers will replace the under hood shift bushing and add a protective cap over the shift cable bushing, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed July 1, 2022. Remedy parts are expected to be available in 4th Quarter 2022. Owner notification letters were mailed October 27, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S43.
Additional source detail variants (2)
Power Train:shift Linkage/cable/rod
Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles. The bushing that attaches the shifter cable to the transmission may degrade or detach.
Consequence: A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, and cause the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.
Remedy: Dealers will replace the under hood shift bushing and add a protective cap over the shift cable bushing, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed July 1, 2022. Remedy parts are expected to be available in 4th Quarter 2022. Owner notification letters were mailed October 27, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S43.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles. The bushing that attaches the shifter cable to the transmission may degrade or detach.
Consequence: A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, and cause the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.
Remedy: Dealers will replace the under hood shift bushing and add a protective cap over the shift cable bushing, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed July 1, 2022. Remedy parts are expected to be available in 4th Quarter 2022. Owner notification letters were mailed October 27, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S43.
20V331000 · Latches/locks/linkages:doors:latch
Jun 8, 2020
Ford Motor Company (Ford) is recalling certain 2011-2014 Fiesta, 2013-2014 Fusion, 2015 Mustang, 2013-2015 Escape and C-Max, 2012-2015 Focus, 2014-2016 Transit Connect, 2013-2014 Lincoln MKZ, and 2015 MKC vehicles. These vehicles were previously recalled and repaired under recalls 15V-246, 16V-643 or 17V-210, however the repair may not have been completed properly. A component within the door latches may break making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
Consequence & remedy
Consequence: A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
Remedy: Ford will notify owners, and dealers will inspect the latch date codes to confirm if the repair was done correctly, and replace the side door latches if necessary, free of charge. Owners will also have the option to inspect their own vehicle's door latches and enter the date codes into a website to determine if the latches are correct. Owner notification letters were mailed on July 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S30.
18V471000 · Power Train:automatic Transmission:lever And Linkage:floor Shift
Jul 16, 2018
Ford Motor Company (Ford) is recalling certain 2013-2014 Ford Escape, and 2013-2016 Ford Fusion vehicles, equipped with six-speed automatic transmissions. The bushing that attaches the transmission shifter cable to the transmission may degrade over time and cause the bushing to detach from the transmission. The condition could allow the driver to move the shift lever to Park and remove the ignition key, while the transmission may not be in Park, with no warning message or audible chime.
Consequence & remedy
Consequence: If the vehicle is exited without the transmission being in Park and without the parking brake being applied, the vehicle may unexpectedly move, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the shifter cable bushing, free of charge. The recall began September 20, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S20. Note: Owners are directed to use the parking brake until the recall remedy repairs can be made.
16V643000 · Latches/locks/linkages:doors:latch
Sep 6, 2016
Ford Motor Company (Ford) is recalling certain model year 2012-2015 Ford Focus, 2013-2015 Ford Escape and Ford C-MAX, 2015 Lincoln MKC and Ford Mustang, and 2014-2016 Ford Transit Connect vehicles. A component within the door latches may break, preventing the doors from latching and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
Consequence & remedy
Consequence: A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
Remedy: Ford will notify owners, and dealers will replace the door latches with an improved part, free of charge. The recall began on January 27, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S30.
15V813000 · Electrical System:wiring
Dec 2, 2015
Ford Motor Company (Ford) is recalling certain model year 2013 Escape vehicles manufactured January 11, 2012, to April 1, 2013, and 2013-2014 Focus ST vehicles manufactured May 03, 2012, to October 14, 2013. Insufficient compression in the engine wiring harness splices to the Manifold Absolute Pressure (MAP) sensor may provide incorrect signals to the powertrain control module (PCM).
Consequence & remedy
Consequence: The incorrect signals could cause the vehicle to hesitate or the engine to stall, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the current crimped splices with new splices, free of charge. The recall began on January 7, 2016. Owners may contact Ford customer service 1-866-436-7332. Ford's number for this recall is 14S17-S1.
14V597000 · Air Bags; Air Bags:side/window; Seat Belts
Sep 26, 2014
Ford Motor Company (Ford) is recalling certain model year 2013-2014 Ford C-Max vehicles manufactured January 19, 2012, to November 21, 2013; Ford Fusion vehicles manufactured February 3, 2012, to August 24, 2013; Ford Escape vehicles manufactured October 5, 2011, to November 1, 2013; and Lincoln MKZ vehicles manufactured April 25, 2012, to September 30, 2013. The coating on portions of the Restraint Control Module (RCM) may crack, and when exposed to humidity, circuits on the printed circuit board may short.
Consequence & remedy
Consequence: The short circuits could cause the frontal air bags, side curtain air bags and the seat belt pretensioners to not function as intended when needed, increasing the risk of occupant injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the RCM, free of charge. Parts are not currently available. The recall began on May 26,2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S21.
Additional source detail variants (3)
Seat Belts
Ford Motor Company (Ford) is recalling certain model year 2013-2014 Ford C-Max vehicles manufactured January 19, 2012, to November 21, 2013; Ford Fusion vehicles manufactured February 3, 2012, to August 24, 2013; Ford Escape vehicles manufactured October 5, 2011, to November 1, 2013; and Lincoln MKZ vehicles manufactured April 25, 2012, to September 30, 2013. The coating on portions of the Restraint Control Module (RCM) may crack, and when exposed to humidity, circuits on the printed circuit board may short.
Consequence: The short circuits could cause the frontal air bags, side curtain air bags and the seat belt pretensioners to not function as intended when needed, increasing the risk of occupant injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the RCM, free of charge. Parts are not currently available. The recall began on May 26,2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S21.
Air Bags:side/window
Ford Motor Company (Ford) is recalling certain model year 2013-2014 Ford C-Max vehicles manufactured January 19, 2012, to November 21, 2013; Ford Fusion vehicles manufactured February 3, 2012, to August 24, 2013; Ford Escape vehicles manufactured October 5, 2011, to November 1, 2013; and Lincoln MKZ vehicles manufactured April 25, 2012, to September 30, 2013. The coating on portions of the Restraint Control Module (RCM) may crack, and when exposed to humidity, circuits on the printed circuit board may short.
Consequence: The short circuits could cause the frontal air bags, side curtain air bags and the seat belt pretensioners to not function as intended when needed, increasing the risk of occupant injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the RCM, free of charge. Parts are not currently available. The recall began on May 26,2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S21.
Air Bags
Ford Motor Company (Ford) is recalling certain model year 2013-2014 Ford C-Max vehicles manufactured January 19, 2012, to November 21, 2013; Ford Fusion vehicles manufactured February 3, 2012, to August 24, 2013; Ford Escape vehicles manufactured October 5, 2011, to November 1, 2013; and Lincoln MKZ vehicles manufactured April 25, 2012, to September 30, 2013. The coating on portions of the Restraint Control Module (RCM) may crack, and when exposed to humidity, circuits on the printed circuit board may short.
Consequence: The short circuits could cause the frontal air bags, side curtain air bags and the seat belt pretensioners to not function as intended when needed, increasing the risk of occupant injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the RCM, free of charge. Parts are not currently available. The recall began on May 26,2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S21.
14V495000 · Electrical System:wiring
Aug 11, 2014
Ford Motor Company (Ford) is recalling certain model year 2013-2014 Escape vehicles manufactured October 5, 2011, to April 1, 2013, and equipped with 2.0 liter engines and Focus ST vehicles manufactured February 14, 2012, to October 14, 2013, and equipped with 2.0 liter engines. Insufficient compression in the engine wiring harness splices to the Manifold Absolute Pressure (MAP) sensor may provide incorrect signals to the powertrain control module (PCM).
Consequence & remedy
Consequence: The incorrect signals could cause the vehicle to hesitate or the engine to stall, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the current crimped splices with new splices, free of charge. The recall began in October 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S17.
14V237000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Air Bags:side/window
May 7, 2014
Ford Motor Company (Ford) is recalling certain model year 2013-2014 C-MAX, and Escape vehicles. In the affected vehicles, the restraint control module (RCM) may have errors in the programming software which may result in a delayed deployment of the side-curtain rollover air bag.
Consequence & remedy
Consequence: If the side-curtain rollover air bag is delayed in deploying in certain rollover circumstances, the risk of injury to the passengers is increased.
Remedy: Ford will notify owners, and dealers will reprogram the RCM, free of charge. The recall began on May 30, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S04.
Additional source detail variants (2)
Air Bags:side/window
Ford Motor Company (Ford) is recalling certain model year 2013-2014 C-MAX, and Escape vehicles. In the affected vehicles, the restraint control module (RCM) may have errors in the programming software which may result in a delayed deployment of the side-curtain rollover air bag.
Consequence: If the side-curtain rollover air bag is delayed in deploying in certain rollover circumstances, the risk of injury to the passengers is increased.
Remedy: Ford will notify owners, and dealers will reprogram the RCM, free of charge. The recall began on May 30, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S04.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Ford Motor Company (Ford) is recalling certain model year 2013-2014 C-MAX, and Escape vehicles. In the affected vehicles, the restraint control module (RCM) may have errors in the programming software which may result in a delayed deployment of the side-curtain rollover air bag.
Consequence: If the side-curtain rollover air bag is delayed in deploying in certain rollover circumstances, the risk of injury to the passengers is increased.
Remedy: Ford will notify owners, and dealers will reprogram the RCM, free of charge. The recall began on May 30, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S04.
14V239000 · Structure:body:door
May 7, 2014
Ford Motor Company (Ford) is recalling certain model year 2013-2014 Escape vehicles manufactured October 5, 2011, through April 10, 2014. Due to an assembly misalignment between the exterior door handle and the door outer panel, the affected vehicles have doors that may be difficult to close or may possibly open while driving.
Consequence & remedy
Consequence: A door that opens unexpectedly may result in an unrestrained occupant falling from the vehicle, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and correct the mounting of the door handles, as necessary, free of charge. The recall began on May 30, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S03.
14V164000 · Seats:front Assembly:recliner
Apr 2, 2014
Ford Motor Company (Ford) is recalling certain model year 2013-2014 Ford Fusion and Lincoln MKZ vehicles manufactured August 15, 2012, through September 10, 2013, 2013-2014 Ford Escape vehicles manufactured June 5, 2012, through August 12, 2013, and 2013-2014 Ford C-Max vehicles manufactured from July 23, 2012, through May 28, 2013. The driver and passenger seatback assemblies may have been produced with sub-standard weld joints used to attach the seat back recliner mechanism to the seat frame. The affected seat backs may have insufficient strength to meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems."
Consequence & remedy
Consequence: The back of the subject seats may become loose or lean while driving and potentially increase the risk of injury in certain crashes.
Remedy: Ford will notify owners, and dealers will replace the seatback, free of charge. The recall began on May 30, 2014. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 14C03.
13V583000 · Engine
Nov 25, 2013
Ford Motor Company (Ford) is recalling certain model year 2013 Escape vehicles manufactured October 5, 2011, through June 2, 2013 and equipped with 1.6L engines. The affected vehicles may experience localized overheating of the engine cylinder head which may cause cracks that could allow oil to leak.
Consequence & remedy
Consequence: Leaking engine oil may come into contact with a hot engine surface potentially resulting in an engine compartment fire.
Remedy: Ford will notify owners, and dealers will modify the engine shielding, cooling and control systems, free of charge. An interim notice will be mailed to owners during January 2014. The recall began on April 9, 2014. Owners may contact Ford at 1-866-436-7332. Ford's recall number is 13S12.
13V584000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Nov 25, 2013
Ford Motor Company (Ford) is recalling certain model year 2013 Escape vehicles manufactured from October 5, 2011, through July 11, 2012, and equipped with a 1.6L engine subject to prior safety recall NHTSA 12V-336. In some cases, the engine compartment fuel line may have been installed incorrectly when repaired under the prior recall. The misinstalled fuel line could chafe and eventually leak fuel.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Ford will notify owners and dealers will inspect the engine compartment fuel line, and if necessary, replace it, free of charge. An interim notice will be mailed to owners during January 2014. The recall began on April 9, 2014. Owners may contact Ford at 1-866-436-7332. Ford's recall number is 13S12.
13V085000 · Latches/locks/linkages
Mar 7, 2013
Ford is recalling certain model year 2013 Focus and C-Max vehicles built from November 16, 2012, through November 21, 2012; and model year 2013 Escape vehicles manufactured from November 14, 2012, through November 21, 2012. The left rear door child lock was built incorrectly. As a result, the child lock may not engage when the operator uses normal force to activate the child lock.
Consequence & remedy
Consequence: The operator may incorrectly believe the child lock is engaged. However, the door may be opened from the inside, increasing the risk of injury to an unrestrained child.
Remedy: Ford will notify owners, and dealers will inspect the affected rear door latches, and replace them as necessary, free of charge. The recall began on March 27, 2013. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332.
12V551000 · Engine And Engine Cooling
Dec 3, 2012
This is an update to a recently announced recall. Ford is recalling certain model year 2013 Escape vehicles manufactured from October 5, 2011, through November 26, 2012, equipped with 1.6L engines, as well as certain model year 2013 Fusion vehicles manufactured from February 3, 2012, through November 29, 2012, equipped with 1.6L engines. Coolant system leaks may cause the engines to overheat and leak flammable engine fluids.
Consequence & remedy
Consequence: If flammable engine fluids come in contact with the vehicles hot exhaust system, a vehicle fire could occur.
Remedy: Ford will notify owners, and dealers will inspect the engine for coolant system leaks and reprogram the vehicles powertrain control module and instrument cluster with an updated calibration and overheat strategy software. There will be no charge to owners for this service. Owners were recently notified to contact dealers to arrange for alternative transportation as Ford developed a remedy. Owners will be shortly receiving notifications to contact Ford dealers to schedule the free remedy repair. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332.
12V431000 · Engine And Engine Cooling
Sep 4, 2012
Ford is recalling certain model year 2013 Escape vehicles manufactured from October 5, 2011, through August 31, 2012, equipped with 1.6L engines. The cylinder head cup plug (freeze plug) may become dislodged resulting in significant loss of engine coolant.
Consequence & remedy
Consequence: As leaking engine coolant evaporates on the hot engine, the glycol may ignite causing an engine compartment fire.
Remedy: Ford will notify owners, and dealers will seal the existing plug and add a secondary plug cover, free of charge. The safety recall began on September 11, 2012. Owners may contact Ford at 1-866-436-7332.
12V336000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Jul 18, 2012
Ford is recalling certain model year 2013 Escape vehicles manufactured from October 5, 2011, through July 11, 2012, and equipped with a 1.6L engine. These vehicles have an engine compartment fuel line which may split, resulting in a leak.
Consequence & remedy
Consequence: If this leak occurs in the presence of an ignition source, there is an increased risk of a fire and/or personal injury.
Remedy: Ford will notify and instruct owners to stop driving their vehicles and contact a Ford or Lincoln dealer to arrange pick-up of their vehicle. Customers will be provided with a rental vehicle if needed. The dealer will replace the engine compartment fuel line, free charge. The recall began on August 10, 2012. Owners may contact Ford at 1-866-436-7332.
12V319000 · Service Brakes, Hydraulic:pedals And Linkages; Structure
Jul 6, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 2013 ESCAPE VEHICLES MANUFACTURED FROM MARCH 8, 2012 THROUGH JUNE 7, 2012. DUE TO MIS-POSITIONED CARPET PADDING THE CENTER CONSOLE TRIM PANEL MAY BE PUSHED OUTBOARD OF THE INTENDED POSITION, REDUCING CLEARANCE RELATIVE TO THE PEDAL PACKAGE.
Consequence & remedy
Consequence: THE REDUCED CLEARANCE MAY RESULT IN THE DRIVERS FOOT CONTACTING THE SIDE OF THE BRAKE PEDAL WHILE TRANSFERRING THE FOOT FROM THE ACCELERATOR PEDAL TO THE BRAKE PEDAL, INCREASING STOPPING DISTANCES AND THE RISK OF A CRASH.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL REMOVE THE CARPET PADDING AND LEFT-SIDE CONSOLE TRIM PANEL REPLACED WITH A NEW PANEL, FREE OF CHARGE. THE RECALL BEGAN ON JULY 20, 2012. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
Additional source detail variants (2)
Structure
FORD IS RECALLING CERTAIN MODEL YEAR 2013 ESCAPE VEHICLES MANUFACTURED FROM MARCH 8, 2012 THROUGH JUNE 7, 2012. DUE TO MIS-POSITIONED CARPET PADDING THE CENTER CONSOLE TRIM PANEL MAY BE PUSHED OUTBOARD OF THE INTENDED POSITION, REDUCING CLEARANCE RELATIVE TO THE PEDAL PACKAGE.
Consequence: THE REDUCED CLEARANCE MAY RESULT IN THE DRIVERS FOOT CONTACTING THE SIDE OF THE BRAKE PEDAL WHILE TRANSFERRING THE FOOT FROM THE ACCELERATOR PEDAL TO THE BRAKE PEDAL, INCREASING STOPPING DISTANCES AND THE RISK OF A CRASH.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL REMOVE THE CARPET PADDING AND LEFT-SIDE CONSOLE TRIM PANEL REPLACED WITH A NEW PANEL, FREE OF CHARGE. THE RECALL BEGAN ON JULY 20, 2012. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
Service Brakes, Hydraulic:pedals And Linkages
FORD IS RECALLING CERTAIN MODEL YEAR 2013 ESCAPE VEHICLES MANUFACTURED FROM MARCH 8, 2012 THROUGH JUNE 7, 2012. DUE TO MIS-POSITIONED CARPET PADDING THE CENTER CONSOLE TRIM PANEL MAY BE PUSHED OUTBOARD OF THE INTENDED POSITION, REDUCING CLEARANCE RELATIVE TO THE PEDAL PACKAGE.
Consequence: THE REDUCED CLEARANCE MAY RESULT IN THE DRIVERS FOOT CONTACTING THE SIDE OF THE BRAKE PEDAL WHILE TRANSFERRING THE FOOT FROM THE ACCELERATOR PEDAL TO THE BRAKE PEDAL, INCREASING STOPPING DISTANCES AND THE RISK OF A CRASH.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL REMOVE THE CARPET PADDING AND LEFT-SIDE CONSOLE TRIM PANEL REPLACED WITH A NEW PANEL, FREE OF CHARGE. THE RECALL BEGAN ON JULY 20, 2012. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ19005 · Door Latch Failures
Opened Dec 19, 2019 · Closed Feb 7, 2022
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:doors:latch; Structure:body; Structure:body:door
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Additional source detail variants (8)
Latches/locks/linkages:doors:latch
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Latches/locks/linkages:doors:latch
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Latches/locks/linkages
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Latches/locks/linkages
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Structure:body:door
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Structure:body:door
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Structure:body
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Structure:body
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
PE18007 · Loss Of Motive Power
Opened Jul 16, 2018 · Closed Dec 27, 2024
Status: closed (inferred from source dates) · Engine And Engine Cooling
On July 16, 2018, the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE) to investigate alleged instances of sudden stalling without warning on model year (MY) 2013 Ford Escape vehicles equipped with 1.6L GTDI turbocharged engines. Complaints alleged that vehicles stalled due to engine overheating, resulting in a delayed or no restart condition. When the investigation was opened, ODI had received 40 Vehicle Owner Questionnaires (VOQs). At this time, ODI has received 173 VOQs with five reported fires and no reported crashes. In investigating the incidents alleged in the VOQs, ODI revisited an apparently related recall that Ford had issued in November 2013 (Recall 13V-583). In Recall 13V-583, Ford recalled all MY 2013 Ford Escape vehicles equipped with the 1.6L engines, built from October 5, 2011, to June 2, 2013. This recall addressed potential engine compartment fires due to localized overheating of the engine cylinder head leading to cracks that can cause oil leaks onto a hot engine surface. The remedy was to provide several enhancements to the engine shielding, cooling and control systems, which involved recalibration of the powertrain calibration module and the instrument cluster system. The recalibration implemented a “Failure Mode Effects Management” (FMEM) strategy to alert the driver of a low coolant state and limit the power to the engine to prevent overheating to the point of cracking the cylinder head. The FMEM strategy includes a “Low Engine Coolant – Service Required” message in the instrument cluster when the coolant reaches a prescribed low level and the engine continues to perform normally, and a coolant level sensor that was incorporated such that if the coolant level is further reduced, the engine enters a reduced power mode (vehicle speed limited to about 40 mph). If the vehicle is driven farther and coolant is not added to the vehicle, the vehicle enters a further reduced power mode and audible and visual alerts will appear and sound, and the engine will be limited to operation at idle speeds. ODI sent Ford an information request letter in August 2018, and, in April 2021, additionally required that Ford provide an update of its field and warranty data. In response, Ford provided 4,047 customer complaints, field reports, and legal claims, consisting of 3,865 unique VINs, and 47,214 warranty claims, consisting of 33,684 unique VINs. Having had repeated discussions with ODI, Ford eventually binned all 4,047 post-recall reports and all 47,214 warranty claims to those that relate to loss of motive power due to coolant loss. Having so binned these reports and claims, Ford reported that the relevant number dropped to 227 reports with 222 unique VINs and 2,774 warranty claims with 1,875 unique VINs. In analyzing its own responsive data, Ford maintained that the remedy for Recall 13V-583 adequately addresses the risk of loss of motive power resulting from an engine overheat due to low coolant by providing clear warnings and progressive reduced power FMEM strategies. Ford further maintained that some complaints imply that the vehicles properly displayed the advanced and progressive warnings and reduced engine power modes, but that complainants ignored them. Ford, therefore, reported that it has not identified any further defect in the coolant system and that it believes the rate of complaints of reduced motive power (which some customers perceive reduced power as vehicle stalls) due to low coolant is low for the subject vehicles. Ford further states it believes that it has not identified any other related unreasonable risk to motor vehicle safety due to loss of motive power due to coolant loss or engine overheat. In addition to analyzing the vast amount of responsive data provided by Ford, ODI worked with NHTSA’s Vehicle Research and Test Center to review 1,462 VOQs with 1,347 unique VINs that were potentially related to this investigation. ODI found that 997 VOQs were relevant post-recall complaints. Of these, 161 VOQs included instances of stalling, sometimes preceded by warnings (low engine coolant message, audible/beeping sound, engine malfunction indicator lamp (MIL) illumination, etc.) and/or drivability issues (reduced power, vehicle jerking or shuddering, etc.). The other categories of complaints/failures were less severe or unrelated/undetermined: 73 related limp mode, nine related stall while vehicle stationary, 21 stalls unknown if related, 271 coolant failure without allegation of stalling, 64 engine MIL with no allegation of stalling, 267 not related to this investigation, 116 unknown if related, and 15 fires (including the initial 5 reports) that were ultimately determined to not be related to this investigation. ODI found that a relatively small percentage of the post-recall complaints involved loss of motive power (161 out of 997 VOQs; and 222 out of 3,865 Ford reports), while the remaining complaints involved vehicles in the early stages of FMEM mode, or were unrelated or undetermined if related to this investigation. ODI has further found that the number of complaints has declined significantly since mid-2021. Based on the analysis of the failure data indicating a declining trend of VOQs of loss of motive power, and in consideration of the remedy for Recall 13V-583 and NHTSA’s ongoing consent order with Ford, ODI is closing this Preliminary Evaluation. The agency will continue to monitor this issue under the heightened oversight pursuant to the consent order and the agency reserves the right to take additional action if warranted. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE16001 · Door Latch Failure
Opened Jan 16, 2016 · Closed Oct 29, 2016
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:doors:latch
In January, the Office of Defects Investigation (ODI) opened this Preliminary Evaluation based on consumers' allegations of doors failing to latch and/or inadvertently opening on model year (MY) 2012-2013 Ford Focus vehicles (subject vehicles).ODI has received 464 unique reports related to the alleged problem, with over 200 claiming that the door(s) opened inadvertently while the vehicle was in motion.One consumer alleged an injury that occurred while driving when a door inadvertently opened and then closed on a child's arm.Another alleged that a door that inadvertently opened struck a parked vehicle.In response to ODI's information request, Ford Motor Company (Ford) provided 500 unique reports related to the alleged problem on the subject vehicles.Ford reported no injury or accident claims.Ford also submitted 1,513 warranty claims related to door latch failures.Many customers indicated that the affected door could not be latched at all and some of them decided to restrain the door by other means in order to operate the vehicle.Some customers also reported door latch failures occurring on multiple doors and at different times.Additionally, Ford stated that MY 2014-2015 Ford Focus, 2013-2015 Ford Escape, 2013-2015 Ford C-Max, 2014-2016 Ford Transit Connect, 2015 Ford Mustang, and 2015 Lincoln MKC, all use the same door latch as the 2012-2013 Ford Focus.On September 6, 2016, Ford notified ODI that it would conduct a safety recall (16V-643) to remedy the door latches in the MY 2012-2015 Ford Focus and other Ford models mentioned above (total of approximately 2 million vehicles).According to Ford, a component within the door latch may break preventing the door from latching.Ford dealers will replace all four door latches in the recalled vehicles with a new more robust latch design that is currently in production.The recall action initiated by the manufacturer appears to address the safety risks.Accordingly, this investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
Additional source detail variants (2)
Latches/locks/linkages:doors:latch
In January, the Office of Defects Investigation (ODI) opened this Preliminary Evaluation based on consumers' allegations of doors failing to latch and/or inadvertently opening on model year (MY) 2012-2013 Ford Focus vehicles (subject vehicles).ODI has received 464 unique reports related to the alleged problem, with over 200 claiming that the door(s) opened inadvertently while the vehicle was in motion.One consumer alleged an injury that occurred while driving when a door inadvertently opened and then closed on a child's arm.Another alleged that a door that inadvertently opened struck a parked vehicle.In response to ODI's information request, Ford Motor Company (Ford) provided 500 unique reports related to the alleged problem on the subject vehicles.Ford reported no injury or accident claims.Ford also submitted 1,513 warranty claims related to door latch failures.Many customers indicated that the affected door could not be latched at all and some of them decided to restrain the door by other means in order to operate the vehicle.Some customers also reported door latch failures occurring on multiple doors and at different times.Additionally, Ford stated that MY 2014-2015 Ford Focus, 2013-2015 Ford Escape, 2013-2015 Ford C-Max, 2014-2016 Ford Transit Connect, 2015 Ford Mustang, and 2015 Lincoln MKC, all use the same door latch as the 2012-2013 Ford Focus.On September 6, 2016, Ford notified ODI that it would conduct a safety recall (16V-643) to remedy the door latches in the MY 2012-2015 Ford Focus and other Ford models mentioned above (total of approximately 2 million vehicles).According to Ford, a component within the door latch may break preventing the door from latching.Ford dealers will replace all four door latches in the recalled vehicles with a new more robust latch design that is currently in production.The recall action initiated by the manufacturer appears to address the safety risks.Accordingly, this investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
Latches/locks/linkages
In January, the Office of Defects Investigation (ODI) opened this Preliminary Evaluation based on consumers' allegations of doors failing to latch and/or inadvertently opening on model year (MY) 2012-2013 Ford Focus vehicles (subject vehicles).ODI has received 464 unique reports related to the alleged problem, with over 200 claiming that the door(s) opened inadvertently while the vehicle was in motion.One consumer alleged an injury that occurred while driving when a door inadvertently opened and then closed on a child's arm.Another alleged that a door that inadvertently opened struck a parked vehicle.In response to ODI's information request, Ford Motor Company (Ford) provided 500 unique reports related to the alleged problem on the subject vehicles.Ford reported no injury or accident claims.Ford also submitted 1,513 warranty claims related to door latch failures.Many customers indicated that the affected door could not be latched at all and some of them decided to restrain the door by other means in order to operate the vehicle.Some customers also reported door latch failures occurring on multiple doors and at different times.Additionally, Ford stated that MY 2014-2015 Ford Focus, 2013-2015 Ford Escape, 2013-2015 Ford C-Max, 2014-2016 Ford Transit Connect, 2015 Ford Mustang, and 2015 Lincoln MKC, all use the same door latch as the 2012-2013 Ford Focus.On September 6, 2016, Ford notified ODI that it would conduct a safety recall (16V-643) to remedy the door latches in the MY 2012-2015 Ford Focus and other Ford models mentioned above (total of approximately 2 million vehicles).According to Ford, a component within the door latch may break preventing the door from latching.Ford dealers will replace all four door latches in the recalled vehicles with a new more robust latch design that is currently in production.The recall action initiated by the manufacturer appears to address the safety risks.Accordingly, this investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.