NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
67 reportsClear category filter70,600 miles · Feb 9, 2017
Structure
TL* THE CONTACT OWNS A 2012 FORD ESCAPE. WHILE ATTEMPTING TO ACCELERATE, THE CONTACT'S FOOT BECAME STUCK ON A PLASTIC PIECE THAT PROTRUDED OUTWARDS NEAR THE PEDAL. THE CONTACT WAS FORCED TO APPLY MORE PRESSURE TO THE ACCELERATOR PEDAL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE…
Read full complaint
TL* THE CONTACT OWNS A 2012 FORD ESCAPE. WHILE ATTEMPTING TO ACCELERATE, THE CONTACT'S FOOT BECAME STUCK ON A PLASTIC PIECE THAT PROTRUDED OUTWARDS NEAR THE PEDAL. THE CONTACT WAS FORCED TO APPLY MORE PRESSURE TO THE ACCELERATOR PEDAL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 70,600.
NHTSA ODI #10953757
55,000 miles · Jan 24, 2017
Structure
I HAVE OWNED THIS ESCAPE FOR A LITTLE OVER 5 YRS (OUT OF WARRANTY). I JUST NOTICED THIS WINTER THAT THE PAINT WAS BUBBLING AND PEELING OFF THE REAR PASSENGER SIDE FENDER. THE INNER FENDER WELL (SAME SIDE) - THE METAL IS WARPED AND RUSTED. THE LIFT GATE ON THIS VEHICLE HAS STARTED TO RUST AT THE LOWER SEAM. RUST IS VISIBLE. …
Read full complaint
I HAVE OWNED THIS ESCAPE FOR A LITTLE OVER 5 YRS (OUT OF WARRANTY). I JUST NOTICED THIS WINTER THAT THE PAINT WAS BUBBLING AND PEELING OFF THE REAR PASSENGER SIDE FENDER. THE INNER FENDER WELL (SAME SIDE) - THE METAL IS WARPED AND RUSTED. THE LIFT GATE ON THIS VEHICLE HAS STARTED TO RUST AT THE LOWER SEAM. RUST IS VISIBLE. I THINK FORD MOTOR COMPANY SHOULD STEP UP TO THE PLATE AND FIX/REPAIR THIS FLAW. IT IS DEFINATELY A DEFECT OR POOR WORKMANSHIP.
NHTSA ODI #10947471
50,000 miles · Nov 30, 2016
StructureUnknown Or OtherVisibility
TWO DAYS AGO I WAS DRIVING DOWN THE HIGHWAY AT NIGHTTIME, ALONE. I WAS THE ONLY VEHICLE IN SIGHT, AND THEY WERE NO OVERPASSES ANYWHERE NEAR ME. AS I WAS DRIVING, OUT OF ABSOLUTELY NOWHERE MY REAR WINDSHIELD EXPLODED. GLASS WENT FLYING EVERYWHERE, EVEN TO THE POINT OF HITTING THE FRONT SEAT. I HAD NO IDEA WHAT HAPPENED, I THOUGHT…
Read full complaint
TWO DAYS AGO I WAS DRIVING DOWN THE HIGHWAY AT NIGHTTIME, ALONE. I WAS THE ONLY VEHICLE IN SIGHT, AND THEY WERE NO OVERPASSES ANYWHERE NEAR ME. AS I WAS DRIVING, OUT OF ABSOLUTELY NOWHERE MY REAR WINDSHIELD EXPLODED. GLASS WENT FLYING EVERYWHERE, EVEN TO THE POINT OF HITTING THE FRONT SEAT. I HAD NO IDEA WHAT HAPPENED, I THOUGHT SOMEONE MAY HAVE THROWN A BRICK THROUGH MY WINDOW. LUCKILY I HAD MY WITS ABOUT ME ENOUGH TO PULL OVER AND SEE WHAT IT HAPPENED. I EXAMINED MY VEHICLE AND NOTED THAT THERE WERE NO ROCKS AND STILL NO OTHER VEHICLES OR PEOPLE IN SIGHT. THERE WAS NO REASON FOR THIS WINDOW TO HAVE EXPLODED; IT HAPPENED COMPLETELY ON ITS OWN. IF I HAD A DOG OR CHILD IN THE BACKSEAT, THEY COULD HAVE BEEN KILLED. I WAS DRIVING AT 120KM/HR, THE SHEER NOISE AND SHOCK OF THE INCIDENT COULD HAVE EASILY CAUSED ME TO BE IN A FATAL ACCIDENT. I WAS LUCKY THAT I REACTED THE WAY THAT I DID, BUT MANY PEOPLE WOULDN'T HAVE. GLASS SHARDS WERE ALL OVER MY CAR. THEY FLEW TO THE FRONT SEAT. THEY CAME OUT AT SUCH A SPEED THEY EASILY COULD HAVE BLINDED OR CUT SOMEONE. THIS IS A COMMON PROBLEM WITH FORD SUVS! THERE ARE MULTIPLE NEWS REPORTS AND YET FORD HAS DONE NOTHING AS OF YET! *TR
NHTSA ODI #10928919
90,000 miles · Oct 4, 2016
Latches/locks/linkagesStructure
TL* THE CONTACT OWNS A 2012 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 35 MPH, THE FRONT DRIVER SIDE DOOR OPENED INDEPENDENTLY WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT STATED THAT THE DOOR LOCKED ONCE IT WAS AT THE RESIDENCE, BUT THE FAILURE RECURRED. THE CONTACT NOTIFIED THE LOCAL DEALER AND …
Read full complaint
TL* THE CONTACT OWNS A 2012 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 35 MPH, THE FRONT DRIVER SIDE DOOR OPENED INDEPENDENTLY WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT STATED THAT THE DOOR LOCKED ONCE IT WAS AT THE RESIDENCE, BUT THE FAILURE RECURRED. THE CONTACT NOTIFIED THE LOCAL DEALER AND AN INDEPENDENT MECHANIC WHO STATED THAT THE DOOR WAS FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000.
NHTSA ODI #10913716
42,000 miles · Aug 21, 2016
StructureUnknown Or Other
AC UNIT QUIT WORKING AT 42000 MILES. THE REAR WINDOW LEAKS, BAD LATCHES.
NHTSA ODI #10897412
38,000 miles · Aug 19, 2016
Structure
BODY PAINT PEELING AND RUST IN MULTIPLE AREAS INCLUDING WHEEL WELLS AND REAR CARGO DOOR SINCE 38K MILES. NOW AT 43K MILES MORE RUST IS VISIBLE. AT THIS POINT THE WARRANTY IS USELESS UNLESS RUST IS THROUGH BODY.
NHTSA ODI #10897097
105,000 miles · Aug 2, 2016
StructureUnknown Or Other
REAR LIFT GLASS HINGES CORRODE AND SNAP. MY HINGES BROKE WHILE STATIONARY THE VEHICLE WAS AT REST AND THE LIFT GATE WAS NOT IN USE.
NHTSA ODI #10892531
60,000 miles · Jul 29, 2016
Structure
TL* THE CONTACT OWNS A 2012 FORD ESCAPE. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER DOORS WERE EXTREMELY DIFFICULT TO OPEN. THE DEALER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS TO CHECK WITH THE MANUFACTURER TO DETERMINE A REPAIR SOLUTION FOR THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.
NHTSA ODI #10891633
94,000 miles · Jul 20, 2016
Structure
TL* THE CONTACT OWNS A 2012 FORD ESCAPE. WHILE WASHING THE VEHICLE, THE CONTACT DISCOVERED THAT THE LIFTGATE AND BOTH REAR WHEEL WELLS WERE CORRODED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 94,000.
NHTSA ODI #10886093
71,076 miles · Jul 8, 2016
Air BagsStructureCrash
MY WIFE AND ONE MONTH OLD CHILD WERE IN AN ACCIDENT THE OTHER DAY. SHE TURNED LEFT IN FRONT OF AN ONCOMING VEHICLE AND OUR 2012 FORD ESCAPE XLT WAS HIT IN THE FRONT PASSENGER CORNER. THE INSURANCE ADJUSTER JUST FINISHED DETERMINING THE DAMAGE ONLY TO CONCLUDE THAT THE VEHICLE IS A TOTAL LOSS. THERE WAS OVER $10,000 IN DAMAGE …
Read full complaint
MY WIFE AND ONE MONTH OLD CHILD WERE IN AN ACCIDENT THE OTHER DAY. SHE TURNED LEFT IN FRONT OF AN ONCOMING VEHICLE AND OUR 2012 FORD ESCAPE XLT WAS HIT IN THE FRONT PASSENGER CORNER. THE INSURANCE ADJUSTER JUST FINISHED DETERMINING THE DAMAGE ONLY TO CONCLUDE THAT THE VEHICLE IS A TOTAL LOSS. THERE WAS OVER $10,000 IN DAMAGE TO THE VEHICLE BEFORE HE TOOK IT APART TO DETERMINE HOW EXPENSIVE THE FRAME REPAIR WOULD BECOME. THE AIRBAGS DID NOT DEPLOY. I HAVE NOTIFIED FORD ABOUT THIS ISSUE AND THEY ARE "INVESTIGATING" WHICH I'M SURE WILL LEAD TO ABSOLUTELY NOTHING. HOW CAN A CAR RECEIVE A CATASTROPHIC IMPACT ON THE FRONT END LIKE THAT AND THE AIRBAGS NOT DEPLOY?
NHTSA ODI #10883483
NHTSA investigations
2PE13003 · Electronic Throttle Body Malfunction
Opened Feb 21, 2013 · Closed Feb 28, 2014
Status: closed (inferred from source dates) · Engine
On February 21, 2013, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE13-003 to investigate allegations of electronic throttle body (ETB) failures resulting in sudden reduction of engine power in model year (MY) 2009-2013 Ford Escape, Fusion, Mariner and Milan vehicles. During this investigation, Ford identified a condition in subject vehicles equipped with 2.5L and 3.0L engines that may result in a sudden reduction of engine power.According to Ford, the ETB internal motor contacts may develop a high resistance material buildup condition on the commutator, resulting in intermittent electrical connectivity and reduced engine power. When this condition occurs, the Malfunction Indicator Lamp (MIL) or Wrench light will illuminate and the vehicle may enter a limited limp home mode.Ford?s trade name for the feature is Failure Mode Effects Management (FMEM) mode.In this mode, engine power and vehicle speed are reduced, while full function of the power steering, power braking, lighting, and climate control systems are maintained.ODI?s complaint analysis indicate that the predominant failure mode involved reduced motive power associated with the limited limp home mode with engine speeds limited to approximately 900 RPM. Analysis of warranty claims provided by Ford identified 59,807 claims related to ETB replacements and approximately 50 percent of claims are associated with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed.Ford described several factors where the ETB motor may fail resulting in DTCs P2111 or P2112 but the failure is not an existing stuck open or closed ETB valve position.According to Ford, the ETB control strategy provides the driver with three FMEM modes that allow varying degrees of vehicle mobility depending on the severity of the fault detected.DTCs associated with stuck open or closed throttle valves are designated the highest failure severity resulting in engine speeds limited to high idle corresponding to the limited limp home mode.Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability.Other FMEM limp modes may result in reduced engine performance but will maintain vehicle speed above 20mph. During this investigation, Ford and its suppliers, Delphi and Igarashi, updated the powertrain control module (PCM) software to include a throttle body motor cleaning cycle during key-on and modified the ETB internal motor components design, surface finish and material composition to improve durability. Additionally, Ford developed a remedy procedure and issued a special Customer Satisfaction Program (CSP) 13N03 extending the ETB warranty coverage and instructing dealers to update the powertrain calibration to improve vehicle performance in the event that intermittent electrical connectivity of the throttle body motor contacts occurs. The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle, all vehicles are eligible for the program through January 31, 2015 regardless of mileage.Owners of the affected vehicles will be contacted by mail to take their vehicle to a Ford dealer who will reprogram the PCM to the latest calibration. The bulletin was sent to dealers on January 17, 2014 and the owner letter mailing began on January 27, 2014. See the investigative file for copies of Ford's bulletin and owner letter. This preliminary evaluation is closed. The closing of this investigation does not constitute a finding that
DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
Illustration