TL* THE CONTACT OWNS A 2009 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 45 MPH, THE STEERING ABILITY SEIZED. THE DEALER DIAGNOSED THAT THE POWER STEERING COLUMN NEEDED REPLACEMENT. THE CONTACT ALSO STATED THAT THE VEHICLE WAS REPAIRED UNDER A RECALL FOR THE POWER STEERING BACK IN AUGUST OF 2015. THE MANUFACTURER WAS NOTIFIED OF THE…
Read full complaint
TL* THE CONTACT OWNS A 2009 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 45 MPH, THE STEERING ABILITY SEIZED. THE DEALER DIAGNOSED THAT THE POWER STEERING COLUMN NEEDED REPLACEMENT. THE CONTACT ALSO STATED THAT THE VEHICLE WAS REPAIRED UNDER A RECALL FOR THE POWER STEERING BACK IN AUGUST OF 2015. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE NHTSA CAMPAIGN NUMBER WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
NHTSA ODI #10851459
133,414 miles · Mar 22, 2016
Steering
TL* THE CONTACT OWNS A 2009 FORD ESCAPE. WHILE DRIVING AT VARIOUS SPEEDS, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING INSTRUMENT CLUSTER MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT MENTIONED THAT THE FAI…
Read full complaint
TL* THE CONTACT OWNS A 2009 FORD ESCAPE. WHILE DRIVING AT VARIOUS SPEEDS, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING INSTRUMENT CLUSTER MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED AFTER THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 14V824000 (STEERING). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 133,414.
NHTSA ODI #10851012
125,000 miles · Mar 1, 2016
Steering
BEFORE 6/18/15 RANDOMLY WHILE DRIVING ANY SPEED MY VEHICLE HAD A WRENCH WARNING LIGHT ILLUMINATE AND LOSES COMPLETE POWER ALONG WITH STEERING, THE CAR SHUTS OFF COMPLETELY YOU HAVE TO TURN IGNITION OFF AND RESTART. IT WOULD RUN FINE FOR SEVERAL DAYS AND THEN RANDOMLY HAPPEN AGAIN OR POSSIBLY MULTIPLE TIMES IN A DAY. 6/17/15 -…
Read full complaint
BEFORE 6/18/15 RANDOMLY WHILE DRIVING ANY SPEED MY VEHICLE HAD A WRENCH WARNING LIGHT ILLUMINATE AND LOSES COMPLETE POWER ALONG WITH STEERING, THE CAR SHUTS OFF COMPLETELY YOU HAVE TO TURN IGNITION OFF AND RESTART. IT WOULD RUN FINE FOR SEVERAL DAYS AND THEN RANDOMLY HAPPEN AGAIN OR POSSIBLY MULTIPLE TIMES IN A DAY. 6/17/15 - I BROUGHT VEHICLE TO FORD DEALERSHIP TO FIX RECALL (13N03) ' TECH REPLACED THROTTLE BODY FOR THIS CORRECTION. AT THE SAME TIME THEY ALSO PERFORMED A RECALL (14S05) ' TECH REPROGRAMMED PSCM FOR CORRECTION. 11/24/15 ' WAS DRIVING MY VEHICLE WHEN THE WRENCH LIGHT CAME ON AGAIN AND THE WHOLE STEERING COLUMN FROZE UP. HAD TO STOP AND TURN VEHICLE OFF IN TRAFFIC AND BACK ON. NO CORRECTION TO PROBLEM THE VEHICLE WAS IMMEDIATELY BROUGHT BACK TO FORD DEALERSHIP. 11/25/15 ' I WAS TOLD THE TORQUE SENSOR NEEDS REPLACED. I ADVISED THEM THE RECALL WAS NOT PROPERLY FIXED THE FIRST TIME. I WAS INFORMED THAT PART IS NOT UNDER WARRANTY ACCORDING TO FORD SERVICE CITE. 11/27/15 ' THE TORQUE SENSOR AS INDICATED ON THEIR DIAGNOSTIC TESTING AND REPLACEMENT OF THIS PART FAILED TO FIX THE PROBLEM WITH THE STEERING BEING LOCKED UP. SERVICE TECH CONTACTED FORD HOTLINE TO TRY AND FIGURE OUT WHY THE PROBLEM WAS NOT ADDRESSED WITH REPLACEMENT OF THE PART THAT INDICATED AS THE ISSUE. 11/30/15 ' FORD SERVICE TECHNICIANS HAD TO WORK WITH FORD HOTLINE TO TROUBLESHOOT VEHICLE. THEY SAID NOW MY WHOLE STEERING COLUMN WOULD NEED REPLACEMENT. FORD SAID I NEEDED TO PAY FOR BOTH PARTS (WHICH DID NOT FIX ANY PROBLEM) AND LABOR. I REFUSE TO PAY FOR ANY PARTS. MY VEHICLE HAS BEEN AT DEALERSHIP WITH THIS ISSUE SO LONG MY TAGS ARE NOW DEAD. MY CAR NEEDS A SAFETY INSPECTION AND SERVICE MANAGER SAID THEY COULD PERFORM THE SAFETY INSPECTION AND JUST ELECTRONICALLY PUT THE 'PASSED' INFORMATION INTO THE SYSTEM. VEHICLE IS NOT SAFE AND IS STILL AT DEALERSHIP TO DATE.
NHTSA ODI #10839326
61,500 miles · Mar 1, 2016
Steering
TL* THE CONTACT OWNS A 2009 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 10 MPH, THE STEERING LOST POWER WITHOUT WARNING. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD. THE VEHICLE WAS ABLE TO BE RESTARTED. THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WERE NO RECALLS. THE FAIL…
Read full complaint
TL* THE CONTACT OWNS A 2009 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 10 MPH, THE STEERING LOST POWER WITHOUT WARNING. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD. THE VEHICLE WAS ABLE TO BE RESTARTED. THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WERE NO RECALLS. THE FAILURE MILEAGE WAS 61,500.... UPDATED 04/11/16 *BF THE DEALER REPLACED THE ENTIRE STEERING COLUMN. UPDATED 04/20/16.*JB
NHTSA ODI #10839295
70,000 miles · Feb 25, 2016
Steering
TL* THE CONTACT OWNS A 2009 FORD ESCAPE. THE CONTACT STATED THAT WHILE THE DRIVER WAS DRIVING AT AN UNKNOWN SPEED, THE STEERING WHEEL SEIZED WITHOUT WARNING. THE FAILURE RECURRED TWO TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER W…
Read full complaint
TL* THE CONTACT OWNS A 2009 FORD ESCAPE. THE CONTACT STATED THAT WHILE THE DRIVER WAS DRIVING AT AN UNKNOWN SPEED, THE STEERING WHEEL SEIZED WITHOUT WARNING. THE FAILURE RECURRED TWO TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V284000 (STEERING). THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.
NHTSA ODI #10838138
210,000 miles · Feb 24, 2016
Steering
I TOOK MY FORD ESCAPE INTO FORD TO GET THE STEERING RECALL DONE AND THEY REPROGRAMMED IT AND 2 WEEKS AFTER THE STEERING BECAME WORSE SO I TOOK IT BACK INTO FORD AND THEY ARE NOW TELL ME THAT THE STEERING COLUMN NEEDS TO BE REPLACED AND THAT WAS PART OF THE RECALL AND WILL NOT DO ANYTHING ABOUT IT RECALL NUMBER 14S05 THEY STEERIN…
Read full complaint
I TOOK MY FORD ESCAPE INTO FORD TO GET THE STEERING RECALL DONE AND THEY REPROGRAMMED IT AND 2 WEEKS AFTER THE STEERING BECAME WORSE SO I TOOK IT BACK INTO FORD AND THEY ARE NOW TELL ME THAT THE STEERING COLUMN NEEDS TO BE REPLACED AND THAT WAS PART OF THE RECALL AND WILL NOT DO ANYTHING ABOUT IT RECALL NUMBER 14S05 THEY STEERING WHEEL IS JERKING UNCONTROLLABLE AND ALL OVER THE ROAD THE WHEEL JERKS ALL THE TIME
NHTSA ODI #10838087
75,000 miles · Feb 24, 2016
Steering
TL* THE CONTACT OWNS A 2009 FORD ESCAPE. THE CONTACT RECEIVED A RECALL REPAIR FOR NHTSA CAMPAIGN NUMBER: 14V284000 (STEERING); HOWEVER, THE POWER STEERING FAILED. THE FAILURE OCCURRED AFTER THE REPAIR. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHO STATED THE FAILURE WAS NOT RELATED TO THE RECALL. THE MANUFACTURER WAS MADE AWARE…
Read full complaint
TL* THE CONTACT OWNS A 2009 FORD ESCAPE. THE CONTACT RECEIVED A RECALL REPAIR FOR NHTSA CAMPAIGN NUMBER: 14V284000 (STEERING); HOWEVER, THE POWER STEERING FAILED. THE FAILURE OCCURRED AFTER THE REPAIR. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHO STATED THE FAILURE WAS NOT RELATED TO THE RECALL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL FOR WHICH IT WAS PREVIOUSLY REPAIRED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.
NHTSA ODI #10838046
111,258 miles · Feb 18, 2016
Steering
WHILE DRIVING MY POWER STEERING LOCKED, MAKING IT EXTREMELY DIFFICULT TO STEER THE VEHICLE. I MANAGED TO PULL OVER STOP THE VEHICLE AND RESTART THE VEHICLE AT WHICH TIME THE SYMPTOMS WENT AWAY BUT HAPPENED AGAIN WHEN I STOPPED THE VEHICLE AND RESTARTED TO DRIVE HOME.
NHTSA ODI #10836962
86,000 miles · Feb 17, 2016
Steering
SIGNIFICANT VIBRATION IN THE STEERING WHEEL AND INTERMITTENT LOSS OF POWER STEERING. ALTHOUGH THE VEHICLE WAS COVERED BY RECALL 14S05, FORD IS UNWILLING TO REPLACE THE TORQUE SENSOR BECAUSE THEY "REPROGRAMMED" IT AND CLOSED OUT THE RECALL IN AUGUST 2014, WHICH THEY CLAIM FIXED THE PROBLEM. OBVIOUSLY, IT DID NOT FIX THE PROBLEM.
NHTSA ODI #10836696
Mileage unknown · Feb 10, 2016
Steering
I RECEIVED A RECALL NOTICE NUMBER 14S05 INVOLVING THE POWER STEERING, I TOOK THE CAR INTO BRIAN MOTORS IN EVERETT WASHINGTON ON DECEMBER 16, 2015. RECALL WAS TAKEN CARE. I HAD NO PROBLEM PRIOR TAKING IT INTO THE DEALER. APPROXIMATELY 2 WEEKS LATER I EXPERIENCED PROBLEMS WITH THE STEERING. I RETURNED THE VEHICLE TO BRIAN MOTORS I…
Read full complaint
I RECEIVED A RECALL NOTICE NUMBER 14S05 INVOLVING THE POWER STEERING, I TOOK THE CAR INTO BRIAN MOTORS IN EVERETT WASHINGTON ON DECEMBER 16, 2015. RECALL WAS TAKEN CARE. I HAD NO PROBLEM PRIOR TAKING IT INTO THE DEALER. APPROXIMATELY 2 WEEKS LATER I EXPERIENCED PROBLEMS WITH THE STEERING. I RETURNED THE VEHICLE TO BRIAN MOTORS IN EVERETT WASHINGTON AND WAS TOLD THAT THE POWER STEERING COLUMN ASSEMBLY NEEDED TO BE REPLACED. THIS WAS ONE OF THE REPAIR OPTIONS LISTED IN THE RECALL. I WAS THEN INFORMED THAT FORD HAD CLOSED THE RECALL AND THE PRICE OF THE REPAIR WOULD BE APPROXIMATELY 1500$ . AFTER CALLING FORD COSTUMER SERVICE IN DEARBORN AND BEING TOLD AGAIN THAT I WOULD BE RESPONSIBLE FOR THE REPAIR BECAUSE THE RECALL HAD BEEN CLOSED. I HAVE SINCE FOUND OUT THAT MANY OWNERS OF THIS YEAR AND MODEL ESCAPE HAVE EXPERIENCED IDENTICAL PROBLEMS AND RECEIVED THE SAME RESPONSE FROM FORD. I BELIEVE THAT THERE IS A DEFECT IN THE POWER STEERING COLUMN ON 2009 FORD ESCAPES AND IT IS FORDS RESPONSIBILITY TO CORRECT THE PROBLEM. I BELIEVE THAT THIS COULD POSE A RISK OF ACCIDENT TO ANYONE DRIVING THIS CAR AND THAT FORD NEEDS TO ADDRESS THIS IMMEDIATELY.
Ford Motor Company (Ford) is recalling certain model year 2008-2011 Ford Escape and Mercury Mariner vehicles manufactured August 18, 2006, through September 11, 2010. The affected vehicles have a steering torque sensor that may not be able to properly detect driver steering input. As a result, the system could remove the Electric Power Steering (EPS) assist.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will update the software for the power steering control module (PSCM) and the instrument cluster module, free of charge. If a vehicle shows a history of a loss of the torque sensor signal or fault codes relating to the PSCM when the vehicle is brought in for the recall remedy, the affected components will be replaced, free of charge. The recall began on July 18, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S05.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
DP15001 · Loss Of Power Steering While Driving
Opened Apr 1, 2015 · Closed Jun 14, 2018
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On May 27, 2014, amended June 2, 2014, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist while driving in approximately 746,067 model year (MY) 2008 through 2011 Ford Escape vehicles equipped with electric power assisted steering (NHTSA 14V-284, Ford 14S05). Ford's DIR described the defect condition as a poor signal to noise ratio [SNR] in the torque sensor within the Electric Power Assisted Steering (EPAS) system [which] does not allow the PSCM to determine the driver's steering input. When the system detects this fault condition, it transitions the EPAS system to the fail-safe/manual steering mode.Ford's DIR indicates that loss of power steering assist while driving would require higher steering effort at lower vehicle speeds, which may result in an increased risk of a crash.Ford's remedy instructs dealers to check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTCs) to determine the proper repair procedure. If no DTCs are present, dealers are to update the PSCM and instrument cluster module software. The updated PSCM software changes the torque sensor fault strategy so that the SNR condition does not result in a loss of power steering assist while driving.In addition, audible and visual warnings are provided for torque sensor faults.If DTCs indicating faults in the torque sensor, PSCM or Power Steering Motor (motor) are present in the initial recall inspection, the dealer performs the following repairs: 1) replaces the torque sensor for torque sensor faults (DTC B2278); or 2) replaces the steering column for faults related to the PSCM (DTC B1342) or motor (DTC B2277).Continued in attachment pages
PE13003 · Electronic Throttle Body Malfunction
Opened Feb 21, 2013 · Closed Feb 28, 2014
Status: closed (inferred from source dates) · Engine
On February 21, 2013, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE13-003 to investigate allegations of electronic throttle body (ETB) failures resulting in sudden reduction of engine power in model year (MY) 2009-2013 Ford Escape, Fusion, Mariner and Milan vehicles. During this investigation, Ford identified a condition in subject vehicles equipped with 2.5L and 3.0L engines that may result in a sudden reduction of engine power.According to Ford, the ETB internal motor contacts may develop a high resistance material buildup condition on the commutator, resulting in intermittent electrical connectivity and reduced engine power. When this condition occurs, the Malfunction Indicator Lamp (MIL) or Wrench light will illuminate and the vehicle may enter a limited limp home mode.Ford?s trade name for the feature is Failure Mode Effects Management (FMEM) mode.In this mode, engine power and vehicle speed are reduced, while full function of the power steering, power braking, lighting, and climate control systems are maintained.ODI?s complaint analysis indicate that the predominant failure mode involved reduced motive power associated with the limited limp home mode with engine speeds limited to approximately 900 RPM. Analysis of warranty claims provided by Ford identified 59,807 claims related to ETB replacements and approximately 50 percent of claims are associated with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed.Ford described several factors where the ETB motor may fail resulting in DTCs P2111 or P2112 but the failure is not an existing stuck open or closed ETB valve position.According to Ford, the ETB control strategy provides the driver with three FMEM modes that allow varying degrees of vehicle mobility depending on the severity of the fault detected.DTCs associated with stuck open or closed throttle valves are designated the highest failure severity resulting in engine speeds limited to high idle corresponding to the limited limp home mode.Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability.Other FMEM limp modes may result in reduced engine performance but will maintain vehicle speed above 20mph. During this investigation, Ford and its suppliers, Delphi and Igarashi, updated the powertrain control module (PCM) software to include a throttle body motor cleaning cycle during key-on and modified the ETB internal motor components design, surface finish and material composition to improve durability. Additionally, Ford developed a remedy procedure and issued a special Customer Satisfaction Program (CSP) 13N03 extending the ETB warranty coverage and instructing dealers to update the powertrain calibration to improve vehicle performance in the event that intermittent electrical connectivity of the throttle body motor contacts occurs. The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle, all vehicles are eligible for the program through January 31, 2015 regardless of mileage.Owners of the affected vehicles will be contacted by mail to take their vehicle to a Ford dealer who will reprogram the PCM to the latest calibration. The bulletin was sent to dealers on January 17, 2014 and the owner letter mailing began on January 27, 2014. See the investigative file for copies of Ford's bulletin and owner letter. This preliminary evaluation is closed. The closing of this investigation does not constitute a finding that
DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
Illustration