NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
175 reportsClear category filter100,000 miles · May 23, 2016
SteeringVehicle Speed Control
TL* THE CONTACT OWNS A 2008 FORD ESCAPE. WHILE DRIVING 5 MPH, THE CONTACT LOST CONTROL OF THE STEERING WHEEL AND THE STEERING WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS DIAGNOSED AS NEEDING A NEW STEERING COLUMN. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14V284000 (STEERING);…
Read full complaint
TL* THE CONTACT OWNS A 2008 FORD ESCAPE. WHILE DRIVING 5 MPH, THE CONTACT LOST CONTROL OF THE STEERING WHEEL AND THE STEERING WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS DIAGNOSED AS NEEDING A NEW STEERING COLUMN. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14V284000 (STEERING); HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000. UPDATED 08/02/16*LJ THE CONSUMER STATED AFTER THE STEERING COLUMN WAS REPLACED, SHE HAD TO PURCHASE A THROTTLE CONTROL AT A COST OF $800, BECAUSE THE VEHICLE WAS ACCELERATING ON ITS OWN.
NHTSA ODI #10870270
114,000 miles · Jan 22, 2016
Vehicle Speed Control
ACCELERATOR PEDAL STICKING, INTERMITTENTLY NOT WORKING
NHTSA ODI #10821747
116,000 miles · Dec 30, 2015
Vehicle Speed Control
PURCHASED A 2008 FORD ESCAPE NEW IN 2008 AND HAVE HAD IT WORKED ON 3 DIFFERENT TIMES FOR THE ACCELERATOR STICKING CAUSED BY THE THROTTLE BODY. IT WAS NEVER REPLACED. NOW BECAUSE I HAVE 116000 MILES ON IT I JUST GOT TAKEN ADVANTAGE OF. ONCE AGAIN THE ACCELERATOR STUCK AND LUCKILY I WAS ABLE TO PULL OVER AND HOLD THE BRAKE AND SHU…
Read full complaint
PURCHASED A 2008 FORD ESCAPE NEW IN 2008 AND HAVE HAD IT WORKED ON 3 DIFFERENT TIMES FOR THE ACCELERATOR STICKING CAUSED BY THE THROTTLE BODY. IT WAS NEVER REPLACED. NOW BECAUSE I HAVE 116000 MILES ON IT I JUST GOT TAKEN ADVANTAGE OF. ONCE AGAIN THE ACCELERATOR STUCK AND LUCKILY I WAS ABLE TO PULL OVER AND HOLD THE BRAKE AND SHUT IT OFF. I PAID $110 TO TOW IT TO A FORD DEALERSHIP. WELL NOW IT IS GOING TO COST ME $1000 TO REPLACE THE THROTTLE BODY. THIS SHOULD HAVE BEEN DONE PREVIOUSLY AND NOW IT SEEMS TO BE ON ME OR RISK BEING KILLED DUE TO THIS SAFETY ISSUE. EVEN IF IT WAS NEVER ISSUED AS A RECALL ITEM I HAVE HAD ISSUES WITH THIS SINCE PURCHASING IT NEW IN 2008. I WANT SOMETHING DONE. I DID CALL FORD MTR CO AND WAS TOLD THEY COULD NOT HELP ME BECAUSE THE VEHICLE HAS OVER 100000 MILES ON IT. WELL IF IT HAD BEEN HANDLED EVEN ONCE IN THE PAST 3 TIMES IT COULD HAVE GOTTEN ME KILLED THEN IT WOULD NOT BE AN ISSUE NOW. *JS
NHTSA ODI #10817015
162,000 miles · Oct 22, 2015
Power TrainVehicle Speed Control
ACCELERATION IS LABORED. THE VEHICLE SKIPS GEARS WHEN DRIVING AT A LOW SPEED RATE. THE VEHICLE WILL JERK AND MAKE NOISES AS IT SKIPPING THROUGH 2ND AND 4TH GEAR. UNFORTUNATELY, THIS HAPPENED IN TRAFFIC AT RUSH HOUR.
NHTSA ODI #10785480
3,000 miles · Sep 30, 2015
Electrical SystemElectronic Stability Control (esc)Vehicle Speed Control
ALL THESE ITEMS HAVE BEEN FIXED BY CAPITOL CITY FORD INDIANAPOLIS AND MACE FORD TERRE HAUTE, IN. I AM STILL HAVING PROBLEMS WITH THE THROTTLE THRUST AND ELECTRICAL PROBLEMS. CURRENTLY MY CAR WILL NOT START. OTHER MECHANICS SAID IT WAS THE STARTER, ITS NOT THE STARTER ITS ELECTRICAL SENSORS. THE VEHICLE SPEEDS UP SOMETIMES WHEN …
Read full complaint
ALL THESE ITEMS HAVE BEEN FIXED BY CAPITOL CITY FORD INDIANAPOLIS AND MACE FORD TERRE HAUTE, IN. I AM STILL HAVING PROBLEMS WITH THE THROTTLE THRUST AND ELECTRICAL PROBLEMS. CURRENTLY MY CAR WILL NOT START. OTHER MECHANICS SAID IT WAS THE STARTER, ITS NOT THE STARTER ITS ELECTRICAL SENSORS. THE VEHICLE SPEEDS UP SOMETIMES WHEN THE CAR IS NOT BEING EXCELERATED. SUSPENSION, HEATER SPEED CONTROL STOP WORKING WHEN THEY WORKED ON THE ELECTRICAL AND THEY REFUSE TO FIX IT. THERE IS MORE. I DON'T HAVE MY DOCUMENTATION, BUT I WILL SUBMIT IT LATER. THE CAR IS AT THE SHOP - BEING LOOKED AND WORKED ON - ITS STILL NOT STARTING - SO WE DON'T HAVE TRANSPORTATION!! I CANT AFFORD ANOTHER HIT FROM FORD WHEN THEY ARE NOT EVEN FIXING THE PROBLEM.
NHTSA ODI #10778672
117,700 miles · Sep 18, 2015
Traction Control SystemVehicle Speed Control
TL* THE CONTACT OWNS A 2008 FORD ESCAPE. THE CONTACT STATED THAT WHILE AT A STOP SIGN AND TURNING RIGHT TO MERGE WITH ONCOMING TRAFFIC, THE DASHBOARD DISPLAYED "THE TRACTION CONTROL KICKED IN" AND THERE WAS NO ACCELERATION AVAILABLE WHEN THE ACCELERATOR PEDAL WAS ENGAGED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TONE RING W…
Read full complaint
TL* THE CONTACT OWNS A 2008 FORD ESCAPE. THE CONTACT STATED THAT WHILE AT A STOP SIGN AND TURNING RIGHT TO MERGE WITH ONCOMING TRAFFIC, THE DASHBOARD DISPLAYED "THE TRACTION CONTROL KICKED IN" AND THERE WAS NO ACCELERATION AVAILABLE WHEN THE ACCELERATOR PEDAL WAS ENGAGED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TONE RING WAS REPLACED. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 117,700.
NHTSA ODI #10765200
87,000 miles · Sep 17, 2015
Service BrakesUnknown Or OtherVehicle Speed Control
WHEN I WOULD TRY TO ACCELERATE WHETHER FROM A STOPPED POSITION OR ALREADY IN MOTION MY GAS PEDAL STICKS. I'M UNABLE TO PRESS IT DOWN AND I LOSE SPEED. EACH TIME I PRESS THE GAS PEDAL OR BRAKE PEDAL I HEAR A POP. I WAS TRYING TO MERGE ONTO THE HIGHWAY AND IT SUDDENLY WOULDN'T LET ME ACCELERATE FOR A FEW MINUTES. THIS IS VERY DANG…
Read full complaint
WHEN I WOULD TRY TO ACCELERATE WHETHER FROM A STOPPED POSITION OR ALREADY IN MOTION MY GAS PEDAL STICKS. I'M UNABLE TO PRESS IT DOWN AND I LOSE SPEED. EACH TIME I PRESS THE GAS PEDAL OR BRAKE PEDAL I HEAR A POP. I WAS TRYING TO MERGE ONTO THE HIGHWAY AND IT SUDDENLY WOULDN'T LET ME ACCELERATE FOR A FEW MINUTES. THIS IS VERY DANGEROUS AND FRIGHTENING. IT ALSO DOES THIS IF I'M ALREADY IN MOTION OF IF I TRY TO ACCELERATE FROM A STOPPED POSITION. I FEAR FOR MY LIFE AND THE LIFE OF MY FAMILY. I TAKE MY HUSBAND TO WORK AN HOUR AWAY, THIS IS TERRIFYING AND UNACCEPTABLE. I ALSO TRANSPORT MY CHILDREN TO THEIR JOBS AND SCHOOLS. PLEASE HELP BEFORE SOMEONE GETS KILLED.
NHTSA ODI #10764453
83,500 miles · Sep 10, 2015
Vehicle Speed Control
I HAD TRAVELED ABOUT 8 MILES AND WAS TRAVELING AT 40MPH WHEN THE SPEED OF THE VEHICLE REMAINED AT 40MPH WITHOUT MY FOOT BEING ON GAS PEDAL (CRUISE WAS NOT ON). I SUCCESSFULLY STOP AT TRAFFIC LIGHT WITH ENGINE STILL EXCELARATING (RPMS WERE AT 2K)). WHILE SITTING AT LIGHT THE ENGINE REVED TO ABOUT 5K RPMS AS I HELD THE BRAKE. I PU…
Read full complaint
I HAD TRAVELED ABOUT 8 MILES AND WAS TRAVELING AT 40MPH WHEN THE SPEED OF THE VEHICLE REMAINED AT 40MPH WITHOUT MY FOOT BEING ON GAS PEDAL (CRUISE WAS NOT ON). I SUCCESSFULLY STOP AT TRAFFIC LIGHT WITH ENGINE STILL EXCELARATING (RPMS WERE AT 2K)). WHILE SITTING AT LIGHT THE ENGINE REVED TO ABOUT 5K RPMS AS I HELD THE BRAKE. I PULLED OVER TO VERIFY THAT NOTHING WAS UNDER THE GAS PEDAL. THIS HAPPENED TO MORE TIMES ON 9/9/15. MORNING OF 9/10 IT WORKED FINE UNTIL I HAD TRAVELED 8-10 MILES THEN THE SAME THING HAPPENED. I HAVE TAKEN IT TO A GARAGE AND THE CAN NOT FIND ANYTHING WRONG OR RECREATE THE PROBLEM. THANK GOD I WAS NOT TRAVELING AT 75MPH WHEN THIS HAPPENED BECAUSE I DOUBT THE BRAKES WOULD STOPPED ME. THE GARAGE HAS KEPT THE CAR TONIGHT TO TRY TO RECREATE THE PROBLEM. I AM AFRAID TO DRIVE THE VEHICLE IN FEAR OF HURTING SOMEONE OR MYSELF.
NHTSA ODI #10763003
115,000 miles · Aug 6, 2015
Vehicle Speed Control
I HAD MY CRUISE CONTROL ON AND HAD USED THE COAST BUTTON TO SLOW DOWN WHEN APPROACHING A CAR IN FRONT OF ME, I PROCEED TO ACCELERATE WHEN THE GAS PEDDLE CONTINUED TO GO DOWN AND SPEED INCREASE. I PRESSED THE OFF BUTTON ON CRUISE CONTROL AND IT WOULD NOT TURN OFF. WITH BOTH FEET ON THE BRAKE THE VEHICLE CONTINUED FORWARD. AS …
Read full complaint
I HAD MY CRUISE CONTROL ON AND HAD USED THE COAST BUTTON TO SLOW DOWN WHEN APPROACHING A CAR IN FRONT OF ME, I PROCEED TO ACCELERATE WHEN THE GAS PEDDLE CONTINUED TO GO DOWN AND SPEED INCREASE. I PRESSED THE OFF BUTTON ON CRUISE CONTROL AND IT WOULD NOT TURN OFF. WITH BOTH FEET ON THE BRAKE THE VEHICLE CONTINUED FORWARD. AS I LEFT THE ROAD WAY I TRIED TURNING VEHICLE OFF BUT IT KEPT RUNNING AT ABOUT 40 MILES PER HOUR I TRIED PUTTING IT IN NEUTRAL AND THE VEHICLE CONTINUED FORWARD AT WHICH TIME I PUT THE VEHICLE IN PARK. THE ENGINE STOPPED. AFTER 30 SECONDS I STARTED THE VEHICLE AND THE ENGINE ROARED, SO I SHUT IT OFF. IN THE PROCESS OF CALLING FOR ASSISTANT, LESS THAN A MINUTE, I HEARD A SOUND OF SOMETHING BEING RELEASE AND THE GAS PEDAL HIT MY FOOT. I STARTED THE VEHICLE AND THE ENGINE/SPEED WAS NORMAL. FRICK FORD DEALERSHIP SAYS ONLY AN ACCELERATION CODE SHOWING AND THERE IS NOTHING WRONG WITH THE VEHICLE. THEY SAID IT PROBABLY IS THE FLOOR MAT AND I SHOULD REMOVE THEM. THEY ONLY WORRIED ABOUT WARRANTY AND RECALL ISSUE AND DID NOT ADVISE ANY SERVICE WORK I WOULD PAY FOR OR DID THE EVEN RECOMMEND THIS.
NHTSA ODI #10746851
150,000 miles · Jul 7, 2015
Power TrainUnknown Or OtherVehicle Speed Control
ATTEMPTED TO PULL INTO UNCOMING TRAFFIC IN A 45MPH ZONE , BUT COULD NOT GET TO MORE THAN 10MPH. THE POWER TRAIN LIGHT APPEARED AS A WRENCH BOTTOM LEFT OF STEERING WHEEL. GLIDED/STEERED CAR IMMEDIATLY TO CLOSEST PARKING LOT AND CALLED CLOSEST FORD DEALERSHIP.
NHTSA ODI #10732510
Official recalls
3Sep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Sep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
May 29, 2014
Ford Motor Company (Ford) is recalling certain model year 2008-2011 Ford Escape and Mercury Mariner vehicles manufactured August 18, 2006, through September 11, 2010. The affected vehicles have a steering torque sensor that may not be able to properly detect driver steering input. As a result, the system could remove the Electric Power Steering (EPS) assist.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will update the software for the power steering control module (PSCM) and the instrument cluster module, free of charge. If a vehicle shows a history of a loss of the torque sensor signal or fault codes relating to the PSCM when the vehicle is brought in for the recall remedy, the affected components will be replaced, free of charge. The recall began on July 18, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S05.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP15001 · Loss Of Power Steering While Driving
Opened Apr 1, 2015 · Closed Jun 14, 2018
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On May 27, 2014, amended June 2, 2014, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist while driving in approximately 746,067 model year (MY) 2008 through 2011 Ford Escape vehicles equipped with electric power assisted steering (NHTSA 14V-284, Ford 14S05). Ford's DIR described the defect condition as a poor signal to noise ratio [SNR] in the torque sensor within the Electric Power Assisted Steering (EPAS) system [which] does not allow the PSCM to determine the driver's steering input. When the system detects this fault condition, it transitions the EPAS system to the fail-safe/manual steering mode.Ford's DIR indicates that loss of power steering assist while driving would require higher steering effort at lower vehicle speeds, which may result in an increased risk of a crash.Ford's remedy instructs dealers to check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTCs) to determine the proper repair procedure. If no DTCs are present, dealers are to update the PSCM and instrument cluster module software. The updated PSCM software changes the torque sensor fault strategy so that the SNR condition does not result in a loss of power steering assist while driving.In addition, audible and visual warnings are provided for torque sensor faults.If DTCs indicating faults in the torque sensor, PSCM or Power Steering Motor (motor) are present in the initial recall inspection, the dealer performs the following repairs: 1) replaces the torque sensor for torque sensor faults (DTC B2278); or 2) replaces the steering column for faults related to the PSCM (DTC B1342) or motor (DTC B2277).Continued in attachment pages
DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO
Illustration