NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
136 reportsClear category filter89,000 miles · Mar 7, 2013
Electrical SystemSteeringCrashInjury
AS I WAS BACKING UP, I LOST POWER STEERING. I WAS UNABLE TO TURN THE WHEEL WITHOUT GREAT FORCE, AND BACKED INTO THE PORCH. AFTER TURNING THE CAR OFF AND TURNING IT BACK ON, THIS RESOLVED. IT HAPPENED AGAIN THE NEXT DAY GOING FORWARD AT 40 MPH. I COULD HEAR SOMETHING IN THE STEERING COLUMN CLICK AND THEN LOST POWER STEERING. NOW …
Read full complaint
AS I WAS BACKING UP, I LOST POWER STEERING. I WAS UNABLE TO TURN THE WHEEL WITHOUT GREAT FORCE, AND BACKED INTO THE PORCH. AFTER TURNING THE CAR OFF AND TURNING IT BACK ON, THIS RESOLVED. IT HAPPENED AGAIN THE NEXT DAY GOING FORWARD AT 40 MPH. I COULD HEAR SOMETHING IN THE STEERING COLUMN CLICK AND THEN LOST POWER STEERING. NOW THE POWER STEERING HAS COMPLETELY GONE OUT. WHEN I START THE CAR, I CAN TURN THE STEERING WHEEL ALL THE WAY ONE DIRECTION AND "TRICK" IT INTO HAVING POWER STEERING FOR A MOMENT BEFORE IT CLICKS OFF AGAIN. I HAVE SUSTAINED A NECK AND SHOULDER INJURY FROM HAVING TO USE MY ENTIRE BODY TO TURN THE WHEEL, AND SLAMMING INTO THE PORCH WHEN THE WHEEL GOT "STUCK" IN A TURNED POSITION AND I WAS UNABLE TO TURN IT BACK. IT IS UNBELIEVABLE THAT NO ONE HAS DIED AS A RESULT OF FORD'S DEFECT. WILL THE NHTSA WAIT UNTIL THEN TO FORCE FORD INTO A RECALL? *TR
NHTSA ODI #10501966
68,000 miles · Mar 2, 2013
Electrical SystemSeatsFire
I TURNED ON MY SEAT WARMER ON DRIVER'S SEAT AND HEATER, WITHIN A MINUTE OR SO SMOKE STARTED COMING OUT BOTTOM PART OF CONTROL PANEL WHERE IT MEETS THE CONSOLE. THE SMOKE GOT WORSE. I WAS IN THE MIDDLE LANE OF HEAVY TRAFFIC AND HAD A DIFFICULT TIME GETTING OVER TO TURN OFF AND GET STOPPED. BY THIS TIME THE SMOKE WAS QUITE BAD (H…
Read full complaint
I TURNED ON MY SEAT WARMER ON DRIVER'S SEAT AND HEATER, WITHIN A MINUTE OR SO SMOKE STARTED COMING OUT BOTTOM PART OF CONTROL PANEL WHERE IT MEETS THE CONSOLE. THE SMOKE GOT WORSE. I WAS IN THE MIDDLE LANE OF HEAVY TRAFFIC AND HAD A DIFFICULT TIME GETTING OVER TO TURN OFF AND GET STOPPED. BY THIS TIME THE SMOKE WAS QUITE BAD (HAD ELECTRICAL SMELL) I HAD ALL WINDOWS DOWN & SUN ROOF OPEN. THE CAR ALARM WENT OFF, THE HEATER WOULD NOT TURN OFF. I FINALLY GOT STOPPED AND GOT OUT OF THE VEHICLE. A LADY PULLED IN TO THE CHURCH PARKING AREA WHERE I WAS AND CALLED 911 FOR ME. BY THIS TIME YOU COULD SEE ACTUAL FIRE (FLAMES) COMING FROM THE SAME SPOT AS SMOKE. IT WAS AMAZING HOW QUICKLY IT WAS IN FLAMES. THE VEHICLE BLEW UP. THE FIRE DEPARTMENT ARRIVED IN TIME TO PUT OUT THE FIRE. THE ONLY THING LEFT IS THE METAL SHELL AND THE TIRES. NOTHING IN THE INTERIOR. ALL WINDOWS AND SUNROOF BLEW OUT. BUMPERS, LIGHTS, TAIL LIGHTS MELTED. THANKS FORD. *TR
NHTSA ODI #10501034
110,000 miles · Feb 7, 2013
Electrical SystemSteering
I WAS DRIVING DOWN THE 5 FREEWAY. I HAD BEEN DRIVING FOR ABOUT 45 MINUETS. I CHANGED LANES TO THE RIGHT AND THE STEERING GOT EXTREMELY HARD TO MOVE. I PULLED OF THE FREEWAY AT THE NEXT OFF RAMP. THE ENTIRE TIME THE WHEEL WAS VERY HARD TO MANEUVER. I CAME TO A STOP TURNED OFF THE CAR, CHECKED ALL MY FLUIDS, AND GOOGLED THE ISSU…
Read full complaint
I WAS DRIVING DOWN THE 5 FREEWAY. I HAD BEEN DRIVING FOR ABOUT 45 MINUETS. I CHANGED LANES TO THE RIGHT AND THE STEERING GOT EXTREMELY HARD TO MOVE. I PULLED OF THE FREEWAY AT THE NEXT OFF RAMP. THE ENTIRE TIME THE WHEEL WAS VERY HARD TO MANEUVER. I CAME TO A STOP TURNED OFF THE CAR, CHECKED ALL MY FLUIDS, AND GOOGLED THE ISSUE ON MY PHONE. ALL RESULTS LEAD TO ELECTRICAL POWER STEERING. I TURNED THE CAR BACK ON AND ALL FUNCTION RETURNED. *TR
NHTSA ODI #10496722
110,000 miles · Jan 24, 2013
Electrical SystemSteering
WHILE BACKING OUT OF A PARKING SPACE THE STEERING LOCKED ON MY WIFE'S 2008 FORD ESCAPE. SHE CALLED ME TO COME HELP HER AS SHE WAS NOT ABLE TO MOVE HER ESCAPE. UPON ARRIVAL I INSPECTED THE VEHICLE FOR OBVIOUS SIGNS OF PROBLEMS, NONE WERE NOTED. I TRIED TO MOVE THE STEERING WHEEL; I WAS QUITE SHOCKED THAT THE STEERING WHEEL COULD …
Read full complaint
WHILE BACKING OUT OF A PARKING SPACE THE STEERING LOCKED ON MY WIFE'S 2008 FORD ESCAPE. SHE CALLED ME TO COME HELP HER AS SHE WAS NOT ABLE TO MOVE HER ESCAPE. UPON ARRIVAL I INSPECTED THE VEHICLE FOR OBVIOUS SIGNS OF PROBLEMS, NONE WERE NOTED. I TRIED TO MOVE THE STEERING WHEEL; I WAS QUITE SHOCKED THAT THE STEERING WHEEL COULD NOT BE MOVED. SINCE I AM 6'4" AND 300LBS MOST THINGS THAT I GRAB MOVE?THE STEERING WHEEL SHOULD HAVE MOVED, JUST WITHOUT THE ASSIST OF THE POWER ASSIST. THE VEHICLE WAS TOWED TO A FORD DEALERSHIP FOR THEM TO DIAGNOSE THE ISSUE. I WAS INFORMED THAT THE SENSORS IN THE STEERING COLUMN ARE BAD. THE DEALERSHIP STATED THAT THEY WERE ABLE TO RESET THE COMPUTER AND THAT THE STEERING NOW FUNCTIONS. THE DEALERSHIP INFORMED ME THAT I HAVE TWO CHOICES DRIVE THE VEHICLE AND SEE IF THE ISSUE REPEATS OR REPLACE THE ENTIRE STEERING COLUMN ($1,500.00). I EXPLAINED THAT THIS IS IN FACT A SAFETY ISSUE AS THE STEERING FAILED COMPLETELY AND LOCKED UP AS I WAS UNABLE TO MOVE THE STEERING WHEEL. FORD CUSTOMER CARE WAS CONTACTED AND THEY HAVE OFFERED NO ASSISTANCE IN THIS ISSUE AND CLAIM THAT THEY HAVE NO KNOWLEDGE OF ANY ISSUES PERTAINING TO THIS PROBLEM ON RECORD. THIS STATEMENT BY FORD CUSTOMER CARE SEEMS TO BE HIGHLY SUSPECT AS A QUICK INTERNET SEARCH FOUND MANY IDENTICAL ISSUES. THE COMPLETE FAILURE OF THE STEERING SYSTEM IS BEYOND UNACCEPTABLE! IF SOMEONE WITH MY STRENGTH CANNOT MOVE THE STEERING WHEEL THAN HOW IS SOMEONE THE SIZE OF MY WIFE SUPPOSED TO MOVE THE STEERING WHEEL IF AND IN THIS CASE WHEN THE STEERING SYSTEM FAILS. FORD NEEDS TO ACCEPT THAT THERE IS IN FACT A MAJOR SAFETY PROBLEM RELATED TO THE FAILURE OF THE ELECTRONIC STEERING SYSTEM OF THE FORD ESCAPE. COMPLETE FAILURE OF THE STEERING IS NOT ACCEPTABLE. AGAIN THIS WAS A COMPLETE FAILURE OF THE STEERING SYSTEM!!! *TR
NHTSA ODI #10494639
101,500 miles · Jan 21, 2013
Electrical SystemSteeringWheels
MY FORD ESCAPE IS MY FAMILY AND WORK VEHICLE. ONE MORNING I STARTED IT AFTER IT WAS PARKED IN COLD OVERNIGHT, ENGINE STARTED BUT THE STEERING WAS STUCK, THOUGHT BATTERY WAS BAD. RESTARTED SEVERAL TIMES UNTIL STEERING LOOSENED UP. DROVE CAR AND EVERY STOP LIGHT OR WHILE IDLING, THE STEERING WHEEL VIBRATED SO HARD AND HAVE TO HOLD…
Read full complaint
MY FORD ESCAPE IS MY FAMILY AND WORK VEHICLE. ONE MORNING I STARTED IT AFTER IT WAS PARKED IN COLD OVERNIGHT, ENGINE STARTED BUT THE STEERING WAS STUCK, THOUGHT BATTERY WAS BAD. RESTARTED SEVERAL TIMES UNTIL STEERING LOOSENED UP. DROVE CAR AND EVERY STOP LIGHT OR WHILE IDLING, THE STEERING WHEEL VIBRATED SO HARD AND HAVE TO HOLD IT STEADY, THOUGHT, TIME TO HAVE MY CONTROL ARM REPLACED AGAIN. TOOK IT TO A FRIEND'S CAR SHOP , SAID, THEY'VE BEEN HAVING COSTUMERS BRINGING THEIR FORD ESCAPES LATELY WITH THE SAME PROBLEM. THEY COULDN'T FIX IT. TOLD ME TO GO TO MY DEALERSHIP. DEALERSHIP DIAGNOSED IT , ELECTRONIC STEERING PROBLEM $90 FOR DIAGNOSIS, $1100 PARTS AND LABOR, ABOUT 3-DAYS TO ORDER FOR PARTS. TOO EXPENSIVE AND DANGEROUS, NEEDS TO HAVE A RECALL. *TR
NHTSA ODI #10493596
78,100 miles · Jan 16, 2013
Electrical SystemSteering
THE CAR INVOLVED WAS A 2008 FORD ESCAPE. I WAS DRIVING AT ABOUT 45 AND I LOST COMPLETE CONTROL OF MY POWER STEERING. I WAS UNABLE TO TURN STEERING WHEEL. I USED ALL MY FORCE TO GET TO THE SIDE OF THE ROAD. I THEN TURNED THE CAR OFF AND TURNED IT BACK ON MY STEERING WAS THEN FINE. I GOT BACK ON THE ROAD AND I LOST ALL OF MY POWE…
Read full complaint
THE CAR INVOLVED WAS A 2008 FORD ESCAPE. I WAS DRIVING AT ABOUT 45 AND I LOST COMPLETE CONTROL OF MY POWER STEERING. I WAS UNABLE TO TURN STEERING WHEEL. I USED ALL MY FORCE TO GET TO THE SIDE OF THE ROAD. I THEN TURNED THE CAR OFF AND TURNED IT BACK ON MY STEERING WAS THEN FINE. I GOT BACK ON THE ROAD AND I LOST ALL OF MY POWER STEERING AGAIN. THIS STEERING PROBLEM IS VERY DANGEROUS AND RECALL MUST BE ENFORCED!! *TR
NHTSA ODI #10493266
74,000 miles · Dec 7, 2012
Electrical SystemEnginePower Train
WHILE DRIVING AT 65 MPH ON I-10, TOWARD ARMSTRONG INTERNATIONAL AIRPORT, THE VEHICLE, WITH NO PRE-WARNING BEGAN TO DECELERATE (SLOW DOWN). THE VEHICLES SPEED DID NOT RESPOND TO DEPRESSING THROTTLE PEDAL; THE VEHICLE WOULD NOT MAINTAIN SPEED. FORTUNATELY, THERE WERE NO VEHICLE IN THE RIGHT LANE AND I WAS ABLE TO GET TO THE SHOULD…
Read full complaint
WHILE DRIVING AT 65 MPH ON I-10, TOWARD ARMSTRONG INTERNATIONAL AIRPORT, THE VEHICLE, WITH NO PRE-WARNING BEGAN TO DECELERATE (SLOW DOWN). THE VEHICLES SPEED DID NOT RESPOND TO DEPRESSING THROTTLE PEDAL; THE VEHICLE WOULD NOT MAINTAIN SPEED. FORTUNATELY, THERE WERE NO VEHICLE IN THE RIGHT LANE AND I WAS ABLE TO GET TO THE SHOULDER OF THE ROAD. THERE, BY TURNING OFF THE IGNITION AND RESTARTING THE VEHICLE I WAS ABLE TO CONTINUE THE TRIP UNTIL THE SECOND AND THIRD OCCURRENCE. THIS SITUATION OCCURRED THREE MORE TIME ON THE RETURN TRIP HOME. ALL ON THE INTERSTATE HIGHWAY. NEEDLESS TO SAY, AFTER THE FIRST OCCURRENCE I PROCEEDED IN THE FAR RIGHT LANE WHERE I COULD GET TO THE SHOULDER EASILY. AFTER DOING SOME INVESTIGATION, I HAVE FOUND THAT THIS HAS BEEN OCCURRING ON FORD ESCORTS SINCE 2004 AT LEAST. I FIND IT DIFFICULT TO BELIEVE THAT SUCH A POTENTIALLY DANGEROUS DESIGN FLAW IN AN AUTOMOBILE HAS PERSISTED SO LONG. IMAGINE WHAT WOULD BE THE CONSEQUENCES OF HAVING THIS OCCUR WHILE DRIVING IN THE MIDDLE OF A SIX LANE INTERSTATE WITH 18 WHEELERS ALL AROUND. AT BEST THERE WOULD BE AN ACCIDENT, THERE IS A VERY HIGH PROBABILITY OF FATALITIES. *TR
NHTSA ODI #10487730
53,000 miles · Nov 26, 2012
Electrical System
THE DASHBOARD CLUSTER (INSTRUMENT PANEL) FAILED WHILE DRIVING CAUSING THE SPEEDOMETER AND RPM GAUGES TO DROP TO ZERO. ALL THE INSTRUMENT LIGHTS TURNING, CAR NOT STARTING ON, AC BLOWING WARM AI, WERE ALL SIDE EFFECTS OF THE PROBLEM. SEARCHING FOR THE PROBLEM HAS AMOUNTED TO ALMOST $900 IN EXPENSES. SENT IN COMPLAINTS TO FORD, WH…
Read full complaint
THE DASHBOARD CLUSTER (INSTRUMENT PANEL) FAILED WHILE DRIVING CAUSING THE SPEEDOMETER AND RPM GAUGES TO DROP TO ZERO. ALL THE INSTRUMENT LIGHTS TURNING, CAR NOT STARTING ON, AC BLOWING WARM AI, WERE ALL SIDE EFFECTS OF THE PROBLEM. SEARCHING FOR THE PROBLEM HAS AMOUNTED TO ALMOST $900 IN EXPENSES. SENT IN COMPLAINTS TO FORD, WHO PROMISED TO ESCALATE THE ISSUE AND THEN NEVER CONTACTED ME. TOOK IT TO THE DEALER, WHO MENTIONED THAT THEY DIDN'T KNOW WHAT IT WAS AND THAT IT WAS SOMEWHERE IN THE VEHICLE. TOOK IT TO A RELIABLE MECHANIC WHO CALLED IN A SPECIALIST TO FIND BROKEN CONNECTIONS WITHIN THE PANEL CAUSING IT TO FAIL INTERMITTENTLY. I HAVE THE MECHANIC'S REPORT STATING THAT MANY SIMILAR MODELS HAVE THIS EXACT ISSUE AND IS SURPRISED FORD IN NOT GIVING ATTENTION TO THIS SAFETY ISSUE.
NHTSA ODI #10486901
Mileage unknown · Oct 11, 2012
Electrical SystemVisibility
OUT OF NOWHERE IN SEPT AND OCT OF 2011 MY SUN ROOF, RIGHT PASSENGER AND RIGHT BACK PASSENGER WINDOWS STOPPED WORKING. THEY FELL STRAIGHT DOWN.. THE MOTOR AND THE BAND QUIT AND NOW COME AUGUST AND OCTOBER OF .2012 THE SAME THING ON THE LEFT. I BOUGHT THIS BRAND NEW ON 2008 OUT OF THE DEALERSHIP AND NOW I HAVE TO SPEND MY TIME AND…
Read full complaint
OUT OF NOWHERE IN SEPT AND OCT OF 2011 MY SUN ROOF, RIGHT PASSENGER AND RIGHT BACK PASSENGER WINDOWS STOPPED WORKING. THEY FELL STRAIGHT DOWN.. THE MOTOR AND THE BAND QUIT AND NOW COME AUGUST AND OCTOBER OF .2012 THE SAME THING ON THE LEFT. I BOUGHT THIS BRAND NEW ON 2008 OUT OF THE DEALERSHIP AND NOW I HAVE TO SPEND MY TIME AND MONEY FOR A DEFECTIVE AUTO. *TR
NHTSA ODI #10479842
22,000 miles · Oct 8, 2012
Electrical SystemEnginePower Train
STARTING IN THE FALL OF 2009 WHEN THE WEATHER GOT COLDER, THE THROTTLE BECAME UNRESPONSIVE AND HARDER TO DEPRESS, REQUIRING A GREATER EFFORT TO PRESS DOWN THE PEDAL TO UN-STICK AND ONLY THEN WOULD THE THROTTLE PEDAL DEPRESS BEYOND THE IDLE POSITION. THEREFORE, THE VEHICLE CONTINUES TO LURCH FORWARD CREATING A SUDDEN, DANGEROUS …
Read full complaint
STARTING IN THE FALL OF 2009 WHEN THE WEATHER GOT COLDER, THE THROTTLE BECAME UNRESPONSIVE AND HARDER TO DEPRESS, REQUIRING A GREATER EFFORT TO PRESS DOWN THE PEDAL TO UN-STICK AND ONLY THEN WOULD THE THROTTLE PEDAL DEPRESS BEYOND THE IDLE POSITION. THEREFORE, THE VEHICLE CONTINUES TO LURCH FORWARD CREATING A SUDDEN, DANGEROUS CONDITION. THE PROBLEM HAS BEEN PERSISTENT AND CONTINUES TO GET WORSE. *TR
NHTSA ODI #10479297
Official recalls
3Sep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Sep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
May 29, 2014
Ford Motor Company (Ford) is recalling certain model year 2008-2011 Ford Escape and Mercury Mariner vehicles manufactured August 18, 2006, through September 11, 2010. The affected vehicles have a steering torque sensor that may not be able to properly detect driver steering input. As a result, the system could remove the Electric Power Steering (EPS) assist.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will update the software for the power steering control module (PSCM) and the instrument cluster module, free of charge. If a vehicle shows a history of a loss of the torque sensor signal or fault codes relating to the PSCM when the vehicle is brought in for the recall remedy, the affected components will be replaced, free of charge. The recall began on July 18, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S05.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP15001 · Loss Of Power Steering While Driving
Opened Apr 1, 2015 · Closed Jun 14, 2018
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On May 27, 2014, amended June 2, 2014, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist while driving in approximately 746,067 model year (MY) 2008 through 2011 Ford Escape vehicles equipped with electric power assisted steering (NHTSA 14V-284, Ford 14S05). Ford's DIR described the defect condition as a poor signal to noise ratio [SNR] in the torque sensor within the Electric Power Assisted Steering (EPAS) system [which] does not allow the PSCM to determine the driver's steering input. When the system detects this fault condition, it transitions the EPAS system to the fail-safe/manual steering mode.Ford's DIR indicates that loss of power steering assist while driving would require higher steering effort at lower vehicle speeds, which may result in an increased risk of a crash.Ford's remedy instructs dealers to check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTCs) to determine the proper repair procedure. If no DTCs are present, dealers are to update the PSCM and instrument cluster module software. The updated PSCM software changes the torque sensor fault strategy so that the SNR condition does not result in a loss of power steering assist while driving.In addition, audible and visual warnings are provided for torque sensor faults.If DTCs indicating faults in the torque sensor, PSCM or Power Steering Motor (motor) are present in the initial recall inspection, the dealer performs the following repairs: 1) replaces the torque sensor for torque sensor faults (DTC B2278); or 2) replaces the steering column for faults related to the PSCM (DTC B1342) or motor (DTC B2277).Continued in attachment pages
DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO
Illustration