NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
464 reports72,000 miles · Nov 3, 2021
StructureSuspension
The contact owns a 2006 Ford Escape. The contact stated that upon the depression of the accelerator pedal, the front passenger’s side subframe collapsed without warning. Due to the failure, the contact had the vehicle towed to an independent mechanic where it was discovered that severe corrosion on the passenger’s side subframe …
Read full complaint
The contact owns a 2006 Ford Escape. The contact stated that upon the depression of the accelerator pedal, the front passenger’s side subframe collapsed without warning. Due to the failure, the contact had the vehicle towed to an independent mechanic where it was discovered that severe corrosion on the passenger’s side subframe had caused the collapse. Neither the dealer nor the manufacturer had been notified of the failure. The vehicle was not repaired and remained in the possession of the independent mechanic. The failure mileage was approximately 72,000.
NHTSA ODI #11439162
Mileage unknown · Aug 13, 2021
Electrical SystemEngine And Engine Cooling
Code P0351, P0352, P0353, P0354, P0355, P0356. Vehicle shut down on the interstate on the way home for work, 2½ hours from home. And will not restart. Pcm most likely the problem.
NHTSA ODI #11429061
Mileage unknown · May 25, 2021
EnginePower Train
On Sunday May/23/2021 my car shut off suddenly with out warning after 3m of driving, the wrench orange lite came on, i was able to pull aside on the curb, turned off the car and waited a few minutes, i was able to turn the car back on, and the car restarted with out problem but the incident was there. when i got home i start loo…
Read full complaint
On Sunday May/23/2021 my car shut off suddenly with out warning after 3m of driving, the wrench orange lite came on, i was able to pull aside on the curb, turned off the car and waited a few minutes, i was able to turn the car back on, and the car restarted with out problem but the incident was there. when i got home i start looking on line for an explanation of what went wrong and i encounter that the 2006 Ford scape hybrid has been recall for stalling problems, somehow my car is not part of the recall according with the VIN number, but my car is a 2006 Ford Scape Hybrid, i don't understand why my car its not part of the recall and i hope that it did not fall under the cracks and i hope more that my car will not get stall in the freeway and cause an accident. please let me know if any additional information is need it
NHTSA ODI #11418514
226,230 miles · Apr 4, 2021
Electrical System
DASH LIGHTS GO OUT AT A FILL TANK OF GAS AND WHEN THE VEHICLE IS WARMED UP AND SOME TIMES. STAY OFF FOR A LONG TIME VEHICLE STAY RUNNING AND GOES DOWN THE ROAD .
NHTSA ODI #11406351
168,522 miles · Jan 9, 2021
Engine
KNOCKING, KNOCKING WHEN ACCELERATING, HESITATION.
NHTSA ODI #11387327
140,000 miles · Oct 30, 2020
Power TrainService BrakesVehicle Speed Control
ABS FAILURE. THE CAR BRAKES MAY AT TIMES LOCK-UP WITHOUT NOTICE. TRANSMISSION FAILURE: THE TRANSMISSION ACTS AS IF IT'S IN NEUTRAL WHEN IN BOTH FORWARD GEAR OR REVERSE. TRANSMISSION APPEARS TO BE IN GOOD REPAIR BUT THIS ISSUE PERSIST. THIS ISSUE APPEARS TO OCCUR FROM A BEGINNING ACCELERATION SUCH AS PUTTING CAR IN REVERSE …
Read full complaint
ABS FAILURE. THE CAR BRAKES MAY AT TIMES LOCK-UP WITHOUT NOTICE. TRANSMISSION FAILURE: THE TRANSMISSION ACTS AS IF IT'S IN NEUTRAL WHEN IN BOTH FORWARD GEAR OR REVERSE. TRANSMISSION APPEARS TO BE IN GOOD REPAIR BUT THIS ISSUE PERSIST. THIS ISSUE APPEARS TO OCCUR FROM A BEGINNING ACCELERATION SUCH AS PUTTING CAR IN REVERSE AND ACCELERATING OR PUTTING CAR IN DRIVE AND ACCELERATING. THIS ALSO HAPPENS WHEN YOU MAY BE STOPPED AT A TRAFFIC LIGHT AND ATTEMPT TO PROCEED ONLY TO HAVE THE CAR ACT AS IF IT'S IN NEUTRAL. THIS SLIPPING IN AND OUT OF GEAR ISSUE SEEMS TO ONLY HAPPEN FROM A TAKE OFF SPEED.
NHTSA ODI #11372406
246,000 miles · Oct 7, 2020
Service Brakes
WHILE DRIVING AT LOWER SPEEDS AND CITY SPEEDS, ABS LIGHT COME ON WITH SERVICE BRAKE SYSTEM MESSAGE APPEARS WHILE DRIVING AND TURNING. BRAKING IS TOUGH AND BARELY STOPS EVEN WITH HARD FOOT PRESSURE ON PEDAL. THIS IS AN ONGOING PROBLEM THAT INTERMITTENTLY HAPPENS. ONCE YOU LET THE CAR SIT FOR AWHILE (SINCE YOU ARE SCARED OF DRIV…
Read full complaint
WHILE DRIVING AT LOWER SPEEDS AND CITY SPEEDS, ABS LIGHT COME ON WITH SERVICE BRAKE SYSTEM MESSAGE APPEARS WHILE DRIVING AND TURNING. BRAKING IS TOUGH AND BARELY STOPS EVEN WITH HARD FOOT PRESSURE ON PEDAL. THIS IS AN ONGOING PROBLEM THAT INTERMITTENTLY HAPPENS. ONCE YOU LET THE CAR SIT FOR AWHILE (SINCE YOU ARE SCARED OF DRIVING IT), THE BRAKING SYSTEM RESETS AND PROBLEM IS NOT SEEN FOR MONTHS...UNTIL IT OCCURS AGAIN. INQUIRIES TO FORD ABOUT PROBLEM ESTIMATE THE COST OF REPLACING CYLINDER, HCU, AND BLEEDING BRAKES FAR EXCEEDS THE VALUE OF VEHICLE. ANNOYING AS THIS BRAKE PROBLEM WAS IDENTIFIED AS A WEAKNESS OF THIS CAR'S BRAKING SYSTEM AS FAR BACK AS 2005! WHY DOES FORD NOT RECALL AND FIX A KNOWN PROBLEM IN A TIMELY MANNER? MAY HAVE TO SCRAP AN OTHERWISE EXCELLENT WORKING VEHICLE BECAUSE IT IS UNSAFE TO DRIVE AND UNSAFE TO FELLOW DRIVERS SINCE IT MAY NOT RELIABLY STOP.
NHTSA ODI #11363179
128,585 miles · Sep 13, 2020
Steering
WHEN DRIVING,THE STEERING, WILL SWAY TO EITHER THE RIGHT OR LEFT.ONLY SLIGHTLY.I BOUGHT NEW TIRES ALIGNMENT. NEW TIE RODS.AND .STILL ISSUES
NHTSA ODI #11354735
180,000 miles · Aug 10, 2020
Engine
AFTER ABOUT 2 YEARS, 2008, CAR WAS DRAGGING TOOK IT TO FORD, WAS TOLD NOTHING WAS WRONG, IT WAS SOME TIME LATER, 2016 /2017 THAT THE TRANSMISSION WENT OUT, HAD IT REPLACED, LESS THAN 1 YEAR IT WENT OUT AGAIN, WHICH FORD REPLACED, WHEN THE SERVICE PERSON ASKED WHO DID IT, HE JUST ROLLED HIS EYES. 3 YEARS AND 2 MONTHS LATER, MORE …
Read full complaint
AFTER ABOUT 2 YEARS, 2008, CAR WAS DRAGGING TOOK IT TO FORD, WAS TOLD NOTHING WAS WRONG, IT WAS SOME TIME LATER, 2016 /2017 THAT THE TRANSMISSION WENT OUT, HAD IT REPLACED, LESS THAN 1 YEAR IT WENT OUT AGAIN, WHICH FORD REPLACED, WHEN THE SERVICE PERSON ASKED WHO DID IT, HE JUST ROLLED HIS EYES. 3 YEARS AND 2 MONTHS LATER, MORE TRANSMISSION PROBLEM, NOW THEYARE TELING IT THE PTU UNIT WHICH IS CAUSING OIL TO LEAK THROUGH THE ENGINE AND NOW THEY WANT 5,000.00 TO REPLACE IT. A TRANSMISSION SHOP WAS QUESTION AND THEY SAID THAT YEAR HAD LOTS OF ISSUE WITH THE TRANSMISSIONS AND WHEN FORD REPLACED THE TRANSMISSION THE PTRU UNIT WAS PUT IN WRONG, THAT THEY WERE CONSTANTLY FIXING IT, ALSO THAT THE HILLTOP FORD SERVICE DEPARTMENT IS THE WORSE ANYONE COULD GO TO, ALSO WHEN I TOOK MY CARE TO FORD, THE ENGINE LIGHT WAS NOT ON, AND WHEN I PICKED IT UP AND TOLD WHAT WAS WRONG, THEY HAD ON IT THE I WANTED TO FIND OUT WHY MY ENGINE WAS, I DID NOT, IT WAS NOT ON, I WAS TOLD THAT HE HAD TO PUT THAT OR THE CHARGES WOULD BE MORE, I WAS ALREADY BEING CHANGED OVER $200 WHEN I WAS NEVER TOLD ABOUT THE CHARGE IN THE FIRST PLACE.
NHTSA ODI #11348458
Mileage unknown · Aug 9, 2020
Steering
WHEN YOU FIRST START DRIVING THE VEHICLE THE STEERING IS VERY TIGHT WHEN TURNING LIKE IT'S IN 4WD BUT AFTER YOU DRIVE IT SOME IT LOOSENS UP AND DRIVES FINE. ONLY WHEN IT FIRST STARTS. THERE IS ISSUES WITH THE STEERING BEING TIGHT
NHTSA ODI #11344237
Official recalls
3Sep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Sep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Nov 9, 2005
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
Consequence & remedy
Consequence: AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
Illustration