MY CAR HAS ABOUT 140 000 MILES ON IT. I PUT A LOT OF MONEY INTO IT TO KEEP IT RUNNING SMOOTHLY. I JUST FOUND OUT THAT REAR RIGHT SHOCK COMPLETELY RUSTED AWAY FROM VEHICLES BODY AND IT WILL COST THOUSANDS OF DOLLARS TO FIX. I WOULD NEVER EXPECT FORD VEHICLE TO FALL APART LIKE THIS. NOW MY CAR IS JUNK WORTH 200 DOLLARS TO TOW AWAY…
Read full complaint
MY CAR HAS ABOUT 140 000 MILES ON IT. I PUT A LOT OF MONEY INTO IT TO KEEP IT RUNNING SMOOTHLY. I JUST FOUND OUT THAT REAR RIGHT SHOCK COMPLETELY RUSTED AWAY FROM VEHICLES BODY AND IT WILL COST THOUSANDS OF DOLLARS TO FIX. I WOULD NEVER EXPECT FORD VEHICLE TO FALL APART LIKE THIS. NOW MY CAR IS JUNK WORTH 200 DOLLARS TO TOW AWAY. I AM VERY DISSAPOINTED.I WILL NEVER BUY FORD AND I AM TELLING EVERYBODY WHAT HAPENNED. CAR STARTED MAKING LOUD BANGING NOISE IN REAR RIGHT WHEEL WELL UPON WHICH I TOOK IT TO MY MECHANIC RIGHT AWAY.HE TELLS ME CAR IS NOT WORTH FIXING.
NHTSA ODI #11340247
105,000 miles · Jun 30, 2020
StructureSuspension
RUST AND CORROSION ON THE WHEEL WELL CAUSED THE SHOCK MOUNT TO COME APART. NOW IT IS LOOSE AND VERY DANGEROUS. FORD MUST BE HELD RESPONSIBLE FOR TERRIBLE DESIGN.
NHTSA ODI #11331654
247,540 miles · Jan 14, 2020
SteeringSuspensionWheels
WAS DRIVING LESS THAN 15MPH WHEN SUDDENLY I LOST ALL CONTROL OF STEERING ON THE FRONT PASSENGER SIDE. WHEN I WAS ABLE TO GET HELP AFTER SITTING ON THE SIDE OF THE ROAD FOR 16 HOURS, I WAS INFORMED THAT ONE OF THE THREE WHEEL BEARINGS HAD SNAPPED. I DID A LITTLE RESEARCH AND FOUND THE RECALL FOR THE PASSENGER SIDE WHEEL ASSEMBLY …
Read full complaint
WAS DRIVING LESS THAN 15MPH WHEN SUDDENLY I LOST ALL CONTROL OF STEERING ON THE FRONT PASSENGER SIDE. WHEN I WAS ABLE TO GET HELP AFTER SITTING ON THE SIDE OF THE ROAD FOR 16 HOURS, I WAS INFORMED THAT ONE OF THE THREE WHEEL BEARINGS HAD SNAPPED. I DID A LITTLE RESEARCH AND FOUND THE RECALL FOR THE PASSENGER SIDE WHEEL ASSEMBLY AND BEARINGS. I ENTERED MY VIN NUMBER AND IT DIDN'T SAY WHETHER OR NOT IT WOULD BE FIXED. I TAKE PRIDE IN MY VEHICLES AND KEEP THE MAINTENANCE UP TO DATE, THEREFORE I CAN SAY THEY THIS HAPPENED DUE TO FAULTY PARTS AND FEEL LIKE I SHOULD BE ABLE TO HAVE IT FIXED.
NHTSA ODI #11299424
112,050 miles · Jan 12, 2020
SuspensionUnknown Or Other
PASSENGER SIDE FRAME FENDER WELL GAS TANK STRAP SHOCK MOUNT HAVE ALL RUSTED OUT . THE SHOCK MOUNT HAS ALMOST COME INSIDE THE CAR INSULATION IS HANGING OUT AND THE WIRE HARNESS IS STARTING TO HANG OUT NOT NORMAL FOR A CAR WITH ONLY 114023 MILES
NHTSA ODI #11298867
160,000 miles · Dec 13, 2019
SteeringSuspensionWheels
THE PASSENGER SIDE SUBFRAME RUSTED OUT AND CORRODED CAUSING THE SUBFRAME TO BREAK, RESULTING IN A VERY UNSAFE AND HAZARDOUS VEHICLE.
NHTSA ODI #11288947
178,998 miles · Oct 19, 2019
Suspension
I PURCHASED A 2005 FORD ESCAPE AND AFTER PURCHASING IT AND HAVING IT REGISTERED ON MY WAY HOME I GOT TO SOME ROADWAY WITH A LOT OF POT HOLES AND WHEN I HIT ONE I HEARD THIS GOD AWFUL NOISE COMING FROM THE RIGHT REAR ONLY TO DISCOVER THAT THE REAR SHOCK TOWER WAS COMPLETELY RUSTED OUT AND THE SHOCK JUST SWAYING AROUND UNATTACHED …
Read full complaint
I PURCHASED A 2005 FORD ESCAPE AND AFTER PURCHASING IT AND HAVING IT REGISTERED ON MY WAY HOME I GOT TO SOME ROADWAY WITH A LOT OF POT HOLES AND WHEN I HIT ONE I HEARD THIS GOD AWFUL NOISE COMING FROM THE RIGHT REAR ONLY TO DISCOVER THAT THE REAR SHOCK TOWER WAS COMPLETELY RUSTED OUT AND THE SHOCK JUST SWAYING AROUND UNATTACHED AT THE TOP. AFTER GETTING HOME AND RESEARCHING IT I FIND OUT THAT THIS IS A COMMON ISSUE WITH THE ESCAPE.
NHTSA ODI #11269575
140,000 miles · Oct 1, 2019
Exterior LightingService BrakesSuspension
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 35 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN ATTEMPTING TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE REAR PASSENGER SIDE SHOCK TOWER HOUSING WAS FRACTURED AND PUNCTURED THROUGH THE SUBFRAME. DURING THE …
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 35 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN ATTEMPTING TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE REAR PASSENGER SIDE SHOCK TOWER HOUSING WAS FRACTURED AND PUNCTURED THROUGH THE SUBFRAME. DURING THE FAILURE, THE BRAKE LINE AND REAR BRAKE LIGHT WIRE WERE SEVERED, WHICH CAUSED BRAKE FLUID TO LEAK AND THE REAR BRAKE LIGHT TO MALFUNCTION. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000. *JS
NHTSA ODI #11265404
Mileage unknown · Sep 23, 2019
StructureSuspension
AS I WAS DRIVING THERE WAS A REALLY LOUD CLUNKING ON THE REAR. I FIGURED IT WAS POTENTIALLY A BROKEN SHOCK. IN THE PASSENGER REAR WHEEL WELL WHERE THE SHOCK BOLTS TO THE FRAME WAS COPLETELY RUSTED OUT. WHEN I WAS HITTING BUMPS IT WASNT EVEN ATTACHED TO THE FRAME. THERE WAS NO WAY OF REPAIR. I AM SO GREATFUL I WAS SAFE. AND DIDN…
Read full complaint
AS I WAS DRIVING THERE WAS A REALLY LOUD CLUNKING ON THE REAR. I FIGURED IT WAS POTENTIALLY A BROKEN SHOCK. IN THE PASSENGER REAR WHEEL WELL WHERE THE SHOCK BOLTS TO THE FRAME WAS COPLETELY RUSTED OUT. WHEN I WAS HITTING BUMPS IT WASNT EVEN ATTACHED TO THE FRAME. THERE WAS NO WAY OF REPAIR. I AM SO GREATFUL I WAS SAFE. AND DIDNT GET INTO AN ACCIDENT. ONE WRONG BUMP. AND THE WHOLE SHOCK WOULDVE WENT THROUGH THE TRUNK AND COULD HAVE CAUSED A VERY SERIOUS ACCIDENT.
NHTSA ODI #11257262
60,000 miles · Sep 20, 2019
Suspension
THE BACK PASSENGER SIDE WHEEL WELL HAS COMPLETELY ROTTED AWAY, SO THE BODY OF THE CAR IS SLAMMED AGAINST THE SUSPENSION BARS, OBVIOUSLY CAUSING DAMAGE AS WELL AS AN UNBEARABLE CRASHING BANG ANY AND EVERY TIME YOU HIT A BUMP. I AM UNSURE IF MY WHEEL IS GOING TO COME OFF OR HOW LONG BEFORE MY FRAME WILL BE BENT. I HAVE SEEN SIMILA…
Read full complaint
THE BACK PASSENGER SIDE WHEEL WELL HAS COMPLETELY ROTTED AWAY, SO THE BODY OF THE CAR IS SLAMMED AGAINST THE SUSPENSION BARS, OBVIOUSLY CAUSING DAMAGE AS WELL AS AN UNBEARABLE CRASHING BANG ANY AND EVERY TIME YOU HIT A BUMP. I AM UNSURE IF MY WHEEL IS GOING TO COME OFF OR HOW LONG BEFORE MY FRAME WILL BE BENT. I HAVE SEEN SIMILAR COMPLAINT ABOUT THE SAME MAKE MODEL AND YEAR AND IT IS ALWAYS THE BACK WHEEL WELL.
NHTSA ODI #11256856
120,000 miles · Sep 18, 2019
SteeringSuspension
WHILE DRIVING HER 2005 FORD ECAPE AFTER COMING TO AN ABRUPT STOP AT A TRAFFIC LIGHT. MY DAUGHTER FOUND STEERING EXTREMELY DIFFICULT, WITH VEHICLE PULLING EXTREMELY TO THE RIGHT THEN SWERVING INTO THE OTHER LANE TO THE LEFT UPON TRYING TO CORRECT FOR THE PULL. SHE PULLED THE CAR OVER AND FOUND THAT WITH THE STEERING WHEEL STRA…
Read full complaint
WHILE DRIVING HER 2005 FORD ECAPE AFTER COMING TO AN ABRUPT STOP AT A TRAFFIC LIGHT. MY DAUGHTER FOUND STEERING EXTREMELY DIFFICULT, WITH VEHICLE PULLING EXTREMELY TO THE RIGHT THEN SWERVING INTO THE OTHER LANE TO THE LEFT UPON TRYING TO CORRECT FOR THE PULL. SHE PULLED THE CAR OVER AND FOUND THAT WITH THE STEERING WHEEL STRAIGHT AHEAD THE RIGHT FRONT WHEEL WAS POINTING OUTWARD TOWARD THE CURB WITH THE TOP OF THE WHEEL TILTED INWARD TOWARDS THE ENGINE. THE VEHICLE WAS UNDRIVABLE AND WAS TOWED HOME. VISUAL INSPECTION BY AN EXPERIENCED MECHANIC FOUND THAT EXTREME CORROSION OF THE SUBFRAME AT THE LOWER CONTROL ARM FRONT MOUNTING POINT HAD CAUSED THE SUBFRAME TO SEPERATE AND ALLOW THE LOWER CONTROL ARM TO BEND OUTWARDS AND CAUSE EXTREME MISALIGNMENT.
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
Consequence & remedy
Consequence: IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
Illustration