NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
153 reportsClear category filter90,150 miles · Jul 19, 2013
Electrical SystemEngineFuel System, Gasoline
WITHIN 1/4 MILE OF STARTING AND DRIVING FROM HOME, THE ENGINE BEGAN TO RUN VERY ROUGH, MISFIRING, IDLING ROUGH, ETC. PULLED OVER, OPENED HOOD, ENGINE WAS IDLING VERY ROUGH. NO CHECK ENGINE LIGHT. BROUGHT IT BACK HOME. TOTAL TRIP WAS LESS THAN 1 MILE. NEXT DAY, STARTED IT UP AGAIN, RAN SMOOTHER, BUT HAD NO POWER; VERY DIFFICULT T…
Read full complaint
WITHIN 1/4 MILE OF STARTING AND DRIVING FROM HOME, THE ENGINE BEGAN TO RUN VERY ROUGH, MISFIRING, IDLING ROUGH, ETC. PULLED OVER, OPENED HOOD, ENGINE WAS IDLING VERY ROUGH. NO CHECK ENGINE LIGHT. BROUGHT IT BACK HOME. TOTAL TRIP WAS LESS THAN 1 MILE. NEXT DAY, STARTED IT UP AGAIN, RAN SMOOTHER, BUT HAD NO POWER; VERY DIFFICULT TO GET ABOVE 20-30MPH. BROUGHT IT TO REPAIR SHOP. THEY DETERMINED THAT ALL THREE CATALYTIC CONVERTERS WERE CLOGGED UP FROM BROKEN/MELTED CATALYTIC CONVERTER INTERNAL PARTS. REPLACED ALL THREE CATALYTIC CONVERTERS, BUT REPAIR SHOP COULD NOT DETERMINE THE CAUSE OF THE INITIAL MISFIRING AND CATALYTIC CONVERTER DAMAGE. CHECK ENGINE LIGHT NEVER CAME ON AT ANY TIME. TOTAL REPAIR COST $2350.00. CAR HAD BEEN IN THE SAME SHOP EARLIER THAT WEEK FOR STATE INSPECTION AND LUBE-OIL-FILTER. NO ISSUES FOUND AT THAT TIME. BATTERY HAD FAILED TWO DAYS BEFORE THE PROBLEM, AND WAS REPLACED THE MORNING OF THE PROBLEM. THE ISSUE APPEARED UPON FIRST DRIVING THE CAR AFTER THE BATTERY WAS CHANGED. *TR
NHTSA ODI #10525712
100,000 miles · Jun 10, 2013
Electrical SystemEngine
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE ENGINE BEGAN TO OPERATE ROUGHLY. THE VEHICLE WAS TAKEN TO A CERTIFIED MECHANIC FOR INSPECTION WHERE THEY STATED THAT THE COMPUTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FA…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE ENGINE BEGAN TO OPERATE ROUGHLY. THE VEHICLE WAS TAKEN TO A CERTIFIED MECHANIC FOR INSPECTION WHERE THEY STATED THAT THE COMPUTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10516110
Mileage unknown · Apr 3, 2013
Electrical System
CPSC: I1330416A. 2005 FORD ESCAPE. CONSUMER STATED THE COMPUTER ON THE TRUCK HAS GONE BAD TWICE IN LESS THAN A MONTH. *LN
NHTSA ODI #10506122
130,000 miles · Mar 22, 2013
Electrical SystemEngineVehicle Speed Control
IT WAS TWO DAYS AFTER I GOT THE CAR, I WAS DRIVING HOME FROM MANASSAS TO FAIRFAX, ALL OF A SUDDEN THE ENGINE LIGHT CAME ON THE TRUCK STARTED TO SPUTTER AND I LOST ACCELERATION IN MY TRUCK. I WAS ON 495 AT NIGHT AND THE DASH BOARD STATED THAT THE CAR WOULD SHUT DOWN SO THAT THE ENGINE WOULD NOT OVER HEAT. I HAD TO CALL A TOW TR…
Read full complaint
IT WAS TWO DAYS AFTER I GOT THE CAR, I WAS DRIVING HOME FROM MANASSAS TO FAIRFAX, ALL OF A SUDDEN THE ENGINE LIGHT CAME ON THE TRUCK STARTED TO SPUTTER AND I LOST ACCELERATION IN MY TRUCK. I WAS ON 495 AT NIGHT AND THE DASH BOARD STATED THAT THE CAR WOULD SHUT DOWN SO THAT THE ENGINE WOULD NOT OVER HEAT. I HAD TO CALL A TOW TRUCK TO PEP BOYS IN ANNANDALE, VA AND THEY FIXED THE PROBLEM. BUT, I STILL HAVE ACCELERATION PROBLEMS AFTER IT WAS FIXED. I WILL TAKE IT BACK TO PEPBOYS TO FIND OUT IF IT IS THE SAME PROBLEM. *TR
NHTSA ODI #10504198
72,000 miles · Mar 19, 2013
Electrical System
TL- THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE STALLED WITH THE ILLUMINATION OF THE IGNITION INTERLOCK WARNING LIGHT. THE VEHICLE SUDDENLY RESTARTED INDEPENDENTLY. THE FAILURE RECURRED INTERMITTENTLY AS THE CONTACT WAS DRIVING AT VARIOUS SPEEDS. THE MANUFACTURER W…
Read full complaint
TL- THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE STALLED WITH THE ILLUMINATION OF THE IGNITION INTERLOCK WARNING LIGHT. THE VEHICLE SUDDENLY RESTARTED INDEPENDENTLY. THE FAILURE RECURRED INTERMITTENTLY AS THE CONTACT WAS DRIVING AT VARIOUS SPEEDS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 72,000. KMJ
NHTSA ODI #10503595
73,000 miles · Mar 4, 2013
Electrical SystemEnginePower Train
WHILE DRIVING THE CAR COMPLETELY WENT DEAD. EVERYTHING TURNED OFF. HAD TO DRIFT TO SIDE OF THE ROAD. TECHNICIAN TOLD ME IT WAS A PCM PROBLEM AND NEEDS TO REPLACE, COILS, PLUGS AND PCM. *TR
NHTSA ODI #10501233
155,000 miles · Feb 27, 2013
Electrical SystemEngine
THIS IS BEING RESUBMITTED, SINCE I BELIEVE THE REEVALUATION OF THE 09 AND NEWER FORD ESCAPES IS THE SAME PROBLEM THAT HAS BEEN OCCURRING WITH THE EARLIER YEAR FORD ESCAPES, BUT HAS NOT RECEIVED REVIEW. A DEFECTIVE PCM WHICH CAUSES COMPLETE AUTO SHUTDOWN, BURNING OUT THE COILS, ETC. HAS DOCUMENTED COMPLAINTS ALL OVER THE INTER…
Read full complaint
THIS IS BEING RESUBMITTED, SINCE I BELIEVE THE REEVALUATION OF THE 09 AND NEWER FORD ESCAPES IS THE SAME PROBLEM THAT HAS BEEN OCCURRING WITH THE EARLIER YEAR FORD ESCAPES, BUT HAS NOT RECEIVED REVIEW. A DEFECTIVE PCM WHICH CAUSES COMPLETE AUTO SHUTDOWN, BURNING OUT THE COILS, ETC. HAS DOCUMENTED COMPLAINTS ALL OVER THE INTERNET IN CAR COMPLAINT AND BUYING SITES FOR THIS VEHICLE. THE PCM IS DEFECTIVE ON THE ESCAPE AND WHEN IT STOPS FUNCTIONING ALL POWER IS LOST, AND THIS OCCURS WITHOUT WARNING LEAVING ONE WITHOUT BRAKES, POWER STEERING, ETC. THIS HAS BEEN A KNOWN PROBLEM WITH FORD AND YET FORD REFUSES TO CORRECT THE PROBLEM AND THE BILL IS IN THE NEIGHBORHOOD OF $2500-3000 TO BE SHOULDERED BY THE CUSTOMER. MALFUNCTION, HOWEVER, HAS MORE OMINOUS SEQUELAE THAN MONETARY COST, IN THAT IT MAY COST LIVES FROM CRASHES. FORD SHOULD RECALL THESE VEHICLES TO REPAIR THE CAUSATION, BUT OBVIOUSLY FORD NEEDS PRESSURE FROM THE PUBLIC AND IN PARTICULAR THE NHTSA ! *TR
NHTSA ODI #10500713
95,000 miles · Feb 27, 2013
Electrical System
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE ON THE SHOULDER OF THE ROAD. THE FAILURE CONTINUED INTERMITTENTLY. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTICS. THE VEHICLE WAS REPAIRED. THE CONTACT WAS NOT AWA…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE ON THE SHOULDER OF THE ROAD. THE FAILURE CONTINUED INTERMITTENTLY. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTICS. THE VEHICLE WAS REPAIRED. THE CONTACT WAS NOT AWARE OF THE REPAIRS PERFORMED. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.
NHTSA ODI #10500630
98,562 miles · Feb 17, 2013
Electrical System
I AM JUST GLAD THAT WHEN THE CAR DIED, I WAS JUST PULLING INTO A PARKING GARAGE. ALL I COULD THINK OF WAS WHAT COULD HAVE HAPPENED IF I WAS GOING THE 55 MPH SPEED LIMIT MINUTES EARLIER. VERY HEAVY BRAKING, MANUAL STEERING. I THINK FORD WANTS SOMEONE TO DIE IN A FEW CRASHES BEFORE THEY WILL COME OUT WITH A RECALL. I HAD TO WAIT…
Read full complaint
I AM JUST GLAD THAT WHEN THE CAR DIED, I WAS JUST PULLING INTO A PARKING GARAGE. ALL I COULD THINK OF WAS WHAT COULD HAVE HAPPENED IF I WAS GOING THE 55 MPH SPEED LIMIT MINUTES EARLIER. VERY HEAVY BRAKING, MANUAL STEERING. I THINK FORD WANTS SOMEONE TO DIE IN A FEW CRASHES BEFORE THEY WILL COME OUT WITH A RECALL. I HAD TO WAIT 2 WEEKS FOR A RE-MANUFACTURED COMPUTER AS THEY WERE HEAVILY BACK-ORDERED. THIS INDICATES THAT A LOT MORE PEOPLE THAN JUST 32 OR SO HAVE HAD THIS PROBLEM. I HAD TO PAY FOR 3 WEEKS OR CAR RENTALS AND ONLY GOT TO PAY WHAT I DID BECAUSE OF FAMILY TIES TO THE FORD DEALER. IT WOULD HAVE BEEN OVER $2800 DOLLARS IF PARTS AND LABOR WERE CHARGED RETAIL. FORD KNEW THERE WERE PROBLEMS BY ISSUING TWO TBS, YET THEY PREFERRED TO LET US PAY FOR THEIR ERROR. I FOUND OUT THAT FORD MAY REPAIR IT IF IT HAD LESS THAN 80,000 MILES AND LESS THAN 8 YEARS OLD. HOW MANY PEOPLE NEED TO BE IN ACCIDENTS BEFORE THIS VEHICLE IS RECALLED? *TR
NHTSA ODI #10498386
85,013 miles · Jan 22, 2013
Electrical SystemPower Train
WAS DRIVING MY CAR AT 45 MILES PER HOUR THE CAR BEGAN TO SPUTTER AND CAME TO VERY QUICK HALT IN THE MIDDLE OF TRAFFIC. I HAD THE CAR TOWED TO MY LOCAL GARAGE, IT WAS HOOKED UP TO A COMPUTER DIAGNOSTIC TOOL. THE TROUBLE CODES CAME UP P0351, P0352, P0353, P0354 WHICH I'M BEING TOLD IT WILL COST ME $ 750.00 TO REPLACE ALL 6 COILS…
Read full complaint
WAS DRIVING MY CAR AT 45 MILES PER HOUR THE CAR BEGAN TO SPUTTER AND CAME TO VERY QUICK HALT IN THE MIDDLE OF TRAFFIC. I HAD THE CAR TOWED TO MY LOCAL GARAGE, IT WAS HOOKED UP TO A COMPUTER DIAGNOSTIC TOOL. THE TROUBLE CODES CAME UP P0351, P0352, P0353, P0354 WHICH I'M BEING TOLD IT WILL COST ME $ 750.00 TO REPLACE ALL 6 COILS, $1100.00 TO REPLACE THE PCM MODULE AND I WILL NEED 6 NEW SPARK PLUGS. THESE PRICES DON'T INCLUDE LABOR OR DIAGNOSTIC COSTS EITHER. IN DOING SOME INVESTIGATION THIS IS A KNOWN ISSUE WITH FORD MOTOR COMPANY AND THE EMISSION WARRANTY ONLY COVERS YOU FOR 8 YEARS/80,000 MILES. NOT SURE WHAT A PCM MODULE IS OR WHAT COILS DO. THANK YOU FORD MOTOR COMPANY FOR INSTALLING FAULTY PARTS IN MY MOTOR WHEN THEY BUILT IT IN 2005. NOW THIS IS MY PROBLEM AND AT MY EXPENSE...... FORD SENT OUT A TBS REGARDING THE WRONG PLUGS WERE INSTALLED WHICH LEADS TO THIS ISSUE. TSB 09-2-6 AND TSB 10-18-10 IS EVIDENCE ENOUGH THEY NEW THERE WAS CLEARLY AN ISSUE WITH THE FACTORY INSTALLED SPARK PLUGS CAUSING RFI DAMAGE TO THE COP'S AND SUBSEQUENTLY THE ECM. IT APPEARS THEY WERE BETTING THAT MOST VEHICLES WOULD HAVE ISSUES OUTSIDE THE 80,000 MILE FEDERAL WARRANTY. *TR
NHTSA ODI #10494379
Official recalls
4Sep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Sep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Apr 7, 2006
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Dec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
Consequence & remedy
Consequence: IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
Illustration