THE ALERT FOR 'DRIVER DOOR AJAR' COMES ON AND WILL NOT TURN OFF, REGARDLESS OF HOW MANY TIMES AND/OR HOW HARD/SOFT THE DOOR IS CLOSED. THIS CAUSES THE INTERIOR LIGHTS TO STAY ON AFTER THE CAR IS TURNED OFF. I AM NOW DRIVING AROUND, IGNORING THE ALERT, WHICH IS DANGEROUS BECAUSE I COULD POTENTIALLY BE DRIVING WITH A DOOR THAT I…
Read full complaint
THE ALERT FOR 'DRIVER DOOR AJAR' COMES ON AND WILL NOT TURN OFF, REGARDLESS OF HOW MANY TIMES AND/OR HOW HARD/SOFT THE DOOR IS CLOSED. THIS CAUSES THE INTERIOR LIGHTS TO STAY ON AFTER THE CAR IS TURNED OFF. I AM NOW DRIVING AROUND, IGNORING THE ALERT, WHICH IS DANGEROUS BECAUSE I COULD POTENTIALLY BE DRIVING WITH A DOOR THAT IS NOT LATCHED PROPERLY, WHICH COULD RESULT IN A SERIOUS INJURY. THANK GOD IT IS NOT THE DOOR THAT MY SON USES. I AM HEARING FROM EVERY FORD OWNER I'VE SPOKEN TO AND ALL OVER THE INTERNET THAT THIS SEEMS TO BE A PROBLEM IN THE MAJORITY OF FORDS, SO I THINK SOMEONE NEEDS TO LOOK INTO A RECALL ON THIS. THANK YOU. *TR
NHTSA ODI #10610095
18,000 miles · Jul 10, 2014
Structure
THE DRIVER DOOR AJAR LIGHT STAYS ON EVEN THOUGH THE DOOR IS CLEARLY CLOSED. AS A RESULT, THE DOORS WILL NOT LOCK. *TR
NHTSA ODI #10609733
48,000 miles · Jun 22, 2014
Electrical SystemStructure
DRIVERS SIDE "DOOR AJAR WARNING" COMES ON VERY OFTEN AND WON'T GO OFF. DOESN'T ALWAYS COME ON IMMEDIATELY, BUT WHILE ON, WON'T ALLOW DOORS TO LOCK WHILE DRIVING. VERY DANGEROUS SITUATION. WHEN IT COMES ON, NOT ALWAYS IN A POSITION TO STOP IMMEDIATELY AND PUT IN PARK TO RESET . MUST STOP AND REPEAT CLOSING UNTIL IT TAKES. AG…
Read full complaint
DRIVERS SIDE "DOOR AJAR WARNING" COMES ON VERY OFTEN AND WON'T GO OFF. DOESN'T ALWAYS COME ON IMMEDIATELY, BUT WHILE ON, WON'T ALLOW DOORS TO LOCK WHILE DRIVING. VERY DANGEROUS SITUATION. WHEN IT COMES ON, NOT ALWAYS IN A POSITION TO STOP IMMEDIATELY AND PUT IN PARK TO RESET . MUST STOP AND REPEAT CLOSING UNTIL IT TAKES. AGAIN VERY DANGEROUS. LASTLY, WHEN EXITING THE AUTO IF THE SENSOR FAILS THEN THE LIGHTS STAY ON AN EXTENDED PERIOD, RUNNING THE BATTERY DOWN. NOT ALLOWING THE DOORS TO LOCK AND ALARM TO SET. *TR
NHTSA ODI #10605080
35,000 miles · Jun 18, 2014
Structure
DRIVER DOOR AJAR WARNING LIGHT STARTED COMING ON - AND STAYING ON - EVEN AFTER DOOR APPEARED TO BE SHUT PROPERLY AND SECURELY. THE DOOR LATCH HAD TO BE REPLACED AT A COST TO ME OF $613.93. *TR
NHTSA ODI #10604306
Mileage unknown · Jun 10, 2014
Structure
DOOR AJAR SENSOR IN DRIVE DOOR MALFUNCTIONING, SHOWS DOOR IS STILL AJAR AFTER MULTIPLE ATTEMPTS TO CLOSE. DOOR IS CLOSED BUT SENSOR WILL NOT GO OFF. KEEPS BEEPING WHILE DRIVING DOWN THE ROAD. *TR
NHTSA ODI #10597422
41,000 miles · May 22, 2014
Electrical SystemStructure
DOOR AJAR SENSOR IN DRIVER DOOR MALFUNCTIONING. SHOWS DOOR IS STILL AJAR AFTER MULTIPLE DOOR SLAMS. *TR
NHTSA ODI #10593453
37,000 miles · May 9, 2014
Structure
DOOR AJAR STAYS ON WITH LIGHTS AND DINGING NOISE EVEN THOUGH DOOR IS CLOSED! *TR
NHTSA ODI #10587419
40,000 miles · Apr 19, 2014
Electrical SystemStructure
THE DOOR AJAR LIGHT FOR MY DRIVERS DOOR WILL NOT GO OFF. MY DOORS DO NOT LOCK BECAUSE OF THIS .A BELL CHIMES WHEN I STOP MY CAR ALSO BECAUSE OF THIS. *TR
NHTSA ODI #10583699
72,000 miles · Apr 18, 2014
Electrical SystemStructure
THE DOOR AJAR LIGHT STAYS ON NO MATTER HOW HARD YOU CLOSE THE DOOR. *TR
NHTSA ODI #10583533
47,059 miles · Apr 8, 2014
Structure
FRONT DRIVERS SIDE DOOR, THE DOOR IS CLOSED AND THE SENSOR SAYS IT'S AJAR. I HAVE TO SLAM THE DOOR TO HAVE IT READ THAT IT'S SHUT. THE INTERIOR LIGHTS WILL STAY ON EVEN THOUGH THE DOOR IS SHUT. *TR
Ford Motor Company (Ford) is recalling certain model year 2012-2014 Ford Edge and Lincoln MKX vehicles manufactured September 2, 2010, to November 30, 2013; 2013-2014 Ford Taurus and Lincoln MKS vehicles manufactured August 25, 2011, to November 30, 2013; and 2013-2014 Ford Flex and Lincoln MKT vehicles manufactured September 12, 2011, to November 30, 2013. In the affected vehicles, the halfshaft retention circlip may not have been properly installed, and as a result, the halfshaft may move outward and disengage from the linkshaft while driving and without prior warning.
Consequence & remedy
Consequence: If the halfshaft and linkshaft become disengaged while driving, power will no longer be transmitted to the wheels, increasing the risk of a vehicle crash. Additionally, if the parking brake is not applied before exiting the vehicle, the vehicle may roll away despite the transmission being placed in 'Park', increasing the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the vehicles to make sure that the halfshaft is properly retained. If it is not, dealers will replace the linkshaft and also replace the halfshaft if it shows evidence of spline damage, free of charge. The recall began on August 4, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S10.
Ford Motor Company (Ford) is recalling certain model year 2012-2013 Edge vehicles manufactured from September 2, 2010, through April 25, 2013, and equipped with 2.0L engines. The fuel line pulse damper metal housing may crack as a result of an improper manufacturing process. A cracked fuel line pulse damper housing may result in a combination of fuel odor, weepage, or a continuous leak while the fuel system is pressurized.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Ford will notify owners, and dealers will replace the fuel line with one that does not have a damper, free of charge. The safety recall began on February 25, 2014. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 13S13. IMPORTANT: This recall supersedes recall 12V-438. All vehicles that have been remedied under the previous recall need to have the current remedy applied.
Ford is recalling certain 2012 Edge vehicles manufactured from September 2, 2010, through October 31, 2011, equipped with 2.0L engines. The fuel line pulse damper metal housing may crack as a result of an improper manufacturing process. A cracked fuel line pulse damper housing may result in a combination of fuel odor, weepage, or a continuous leak while the fuel system is pressurized.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Ford will notify owners, and dealers will repair the vehicles free of charge. The safety recall began on September 27, 2012. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
Additional source detail variants (3)
Interior Lighting
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
Latches/locks/linkages:doors:latch
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
Latches/locks/linkages
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
2012 Ford Edge Problems, Complaints & Recalls | Skip That Year
Illustration