NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
462 reportsClear category filter50,000 miles · Oct 17, 2016
Electrical SystemPower Train
ISSUE - 'SHIFT TO PARK' WARNING INDICATOR IS SHOWN WHEN THE VEHICLE IS PARKED AND THE SHIFTER IS IN THE 'P' POSITION. DOORS CANNOT BE LOCKED AND INTERNAL/EXTERNAL LIGHTS REMAIN ON WHILE IN THIS 'SHIFT TO PARK' POSITION DRAINING THE BATTERY. WHILE FOOT BRAKE PEDAL IS ENGAGED, SHIFTING AWAY FROM 'P' AND BACK TO 'P' SOMETIMES R…
Read full complaint
ISSUE - 'SHIFT TO PARK' WARNING INDICATOR IS SHOWN WHEN THE VEHICLE IS PARKED AND THE SHIFTER IS IN THE 'P' POSITION. DOORS CANNOT BE LOCKED AND INTERNAL/EXTERNAL LIGHTS REMAIN ON WHILE IN THIS 'SHIFT TO PARK' POSITION DRAINING THE BATTERY. WHILE FOOT BRAKE PEDAL IS ENGAGED, SHIFTING AWAY FROM 'P' AND BACK TO 'P' SOMETIMES REGISTERS THE VEHICLE AS IN THE CORRECT PARK POSITION. REPEAT UNTIL WARNING MESSAGE IS GONE. THE VEHICLE IS STATIONARY ON A FLAT SURFACE BUT I AM NOT SURE IF THE VEHICLE IS REALLY PARKED SINCE IT'S WARNING I'M NOT BUT THE SHIFTER IS IN THE 'P' POSITION. I DARE NOT TRY THIS ON A HILL--AND ALWAYS THE BRAKE PEDAL ENGAGED WHILE I'M FIDDLING WITH THE HAND SHIFTER. WHEN DID THIS HAPPEN? AT LEAST 4 TIMES A WEEK FOR A YEAR. *TR
NHTSA ODI #10916689
38,000 miles · Oct 17, 2016
Electrical System
AFTER CLOSING THE FRONT DRIVERS DOOR, THE DASH LIGHT INDICATES THAT THE DOOR IS NOT CLOSED AND LATCHED. I PUSH ON THE DOOR AND THE LATCH HAS CAUGHT. WHILE DRIVING, THE SYSTEM STILL SEES THE DOOR AS UNLATCHED. I HAVE PLAYED WITH THE LATCHING MECHANISM AND I CAN GET THE SENSOR TO SEE THE DOOR CLOSED IN ABOUT 1 OUT OF 50 ATTEMPT…
Read full complaint
AFTER CLOSING THE FRONT DRIVERS DOOR, THE DASH LIGHT INDICATES THAT THE DOOR IS NOT CLOSED AND LATCHED. I PUSH ON THE DOOR AND THE LATCH HAS CAUGHT. WHILE DRIVING, THE SYSTEM STILL SEES THE DOOR AS UNLATCHED. I HAVE PLAYED WITH THE LATCHING MECHANISM AND I CAN GET THE SENSOR TO SEE THE DOOR CLOSED IN ABOUT 1 OUT OF 50 ATTEMPTS. MOST OF THE TIME I DRIVE AROUND WITH THE SYSTEM SEEING THE DOOR AS OPEN. I HAVE NOT GOTTEN IT CHANGED BECAUSE I FEAR THE REPLACEMENT WILL FAIL TOO. *TR
NHTSA ODI #10916652
35,000 miles · Oct 15, 2016
Electrical SystemStructure
DRIVER SIDE DOOR AJAR WARNING LIGHT AND MESSAGE DISPLAYED AFTER ENTERING OR EXITING THE VEHICLE EVEN THOUGH THE DOOR IS SHUT. PROBLEM OCCURS INTERMITTENTLY, SEEMINGLY MORE OFTEN WHEN OUTSIDE TEMPERATURES REACH ABOVE 70 DEGREES. ATTEMPTS TO OPEN AND SHUT THE DOOR MULTIPLE TIMES OFTEN DOES NOT RESOLVE THE ISSUE. WHEN ISSUE OCCU…
Read full complaint
DRIVER SIDE DOOR AJAR WARNING LIGHT AND MESSAGE DISPLAYED AFTER ENTERING OR EXITING THE VEHICLE EVEN THOUGH THE DOOR IS SHUT. PROBLEM OCCURS INTERMITTENTLY, SEEMINGLY MORE OFTEN WHEN OUTSIDE TEMPERATURES REACH ABOVE 70 DEGREES. ATTEMPTS TO OPEN AND SHUT THE DOOR MULTIPLE TIMES OFTEN DOES NOT RESOLVE THE ISSUE. WHEN ISSUE OCCURS THE DOORS DO NOT LOCK AUTOMATICALLY WHEN THE VEHICLE BEGINS MOVING, INTERIOR LIGHTS REMAIN ON. OCCURS WHEN STARTING TO DRIVE THE VEHICLE OR WHEN PARKING. IF PARKING, WHEN THE KEY FOB "LOCK" BUTTON IS PUSHED THE HORN HONKS TWICE RATHER THAN THE NORMAL SINGLE HONK, INDICATING THAT THE SECURITY ALARM IS NOT ACTIVATED. PROBLEM OCCURRED WITHIN THE FIRST 10K MILES AND WAS FIXED BY FORD DEALERSHIP UNDER WARRANTY. PROBLEM STARTED TO OCCUR AGAIN AROUND 35K MILES (JAN 2016).
NHTSA ODI #10916284
42,681 miles · Oct 15, 2016
Electrical SystemStructure
"DOOR AJAR" SENSOR BEGAN APPEARING ON DASHBOARD SPORADICALLY FOR 1 MONTH. ALL DOORS WERE CLOSED PER NORMAL, DOOR LOCKS WERE NEGATIVE FUNCTION WHILE SENSOR ACTIVE AND VEHICLE WAS EITHER PARKED OR MOVING. AFTER 1 MONTH, SENSOR WAS ON PERMANENTLY. DOOR LATCH/S RR'D AT FORD DEALERSHIP WHERE THIS USED CPO EDGE WAS PURCHASED 13 MONTHS…
Read full complaint
"DOOR AJAR" SENSOR BEGAN APPEARING ON DASHBOARD SPORADICALLY FOR 1 MONTH. ALL DOORS WERE CLOSED PER NORMAL, DOOR LOCKS WERE NEGATIVE FUNCTION WHILE SENSOR ACTIVE AND VEHICLE WAS EITHER PARKED OR MOVING. AFTER 1 MONTH, SENSOR WAS ON PERMANENTLY. DOOR LATCH/S RR'D AT FORD DEALERSHIP WHERE THIS USED CPO EDGE WAS PURCHASED 13 MONTHS PRIOR. COST OF REPAIR: $540. SERVICE MANAGER HAS ADVISED ME THAT IN THE EVENT OF A RECALL FOR THIS ISSUE, I WILL BE REIMBURSED THE ENTIRE AMOUNT BY FORD. YEAH...RIGHT!
NHTSA ODI #10916268
40,000 miles · Oct 11, 2016
Electrical SystemUnknown Or Other
DRIVER SIDE DOOR DOES NOT CLOSE PROPERLY. DOOR AJAR LIGHT STAYS ON. HAPPENS MORE IN WARM WEATHER THAN COLD. HAS CAUSE DOME LIGHTS TO STAY ON OR COME ON INTERMITTENTLY . IF CAR NOT DRIVEN FOR A DAY OR TWO, HAS CAUSED BATTERY TO DRAIN COMPLETELY. ROADSIDE ASSISTANCE HAS HAD TO BE CALLED ON MULTIPLE OCCASIONS. HAS BEEN HAPPENI…
Read full complaint
DRIVER SIDE DOOR DOES NOT CLOSE PROPERLY. DOOR AJAR LIGHT STAYS ON. HAPPENS MORE IN WARM WEATHER THAN COLD. HAS CAUSE DOME LIGHTS TO STAY ON OR COME ON INTERMITTENTLY . IF CAR NOT DRIVEN FOR A DAY OR TWO, HAS CAUSED BATTERY TO DRAIN COMPLETELY. ROADSIDE ASSISTANCE HAS HAD TO BE CALLED ON MULTIPLE OCCASIONS. HAS BEEN HAPPENING FOR OVER A YEAR. WHEN CAR IS IN MOTION, CAR DOOR AJAR IS CONSTANTLY ON, AND ANYTIME YOU BREAK TO A NEAR STOP, THE ALARM BELL CHIMES.
NHTSA ODI #10915300
40,000 miles · Oct 5, 2016
Electrical SystemStructure
SOON AFTER PURCHASING A USED 2012 EDGE, THE OPEN DOOR LIGHT ON THE DASH CAME ON AND WOULD NOT GO OFF. ALL DOORS WERE CLOSED. ALSO THE DOORS WOULD NOT LOCK WHEN THE LIGHT CAME ON WHICH BECAME A SAFETY HAZARD PARTICULARLY WHEN TRANSPORTING CHILDREN. BROUGHT IT TO MY MECHANIC AND HE SAID THE DOOR LATCH AND LIGHT SWITCH WAS ONE MOD…
Read full complaint
SOON AFTER PURCHASING A USED 2012 EDGE, THE OPEN DOOR LIGHT ON THE DASH CAME ON AND WOULD NOT GO OFF. ALL DOORS WERE CLOSED. ALSO THE DOORS WOULD NOT LOCK WHEN THE LIGHT CAME ON WHICH BECAME A SAFETY HAZARD PARTICULARLY WHEN TRANSPORTING CHILDREN. BROUGHT IT TO MY MECHANIC AND HE SAID THE DOOR LATCH AND LIGHT SWITCH WAS ONE MODULE AND THAT IT HAD TO BE REPLACED TO THE TUNE OF ABOUT $500. ONCE REPLACED THE PROBLEM WAS SOLVED. LOOKING ONLINE, THIS IS A REALLY COMMON PROBLEM. I FEEL ITS A DEFECT THAT SHOULD BE RECALLED AND REPLACED!
NHTSA ODI #10914049
45,000 miles · Oct 4, 2016
Electrical System
MY FORD EDGE HAS ALL THE PROBLEMATIC SYMPTOMS DISPLAYED BY THE SHIFTER WARNING "SHIFT INTO PARK" AFTER THE CAR IS ALREADY IN PARK. THIS IS A WELL KNOWN SITUATION AND FORD SAYS IT'S NOT A SAFETY ISSUE. MY CAR HAS NOW PROGRESSED TO DISPLAYING THIS SAME MESSAGE NEARLY EVERY TIME WE SLOW DOWN TO STOP AT AN INTERSECTION THEN DISPLAYS…
Read full complaint
MY FORD EDGE HAS ALL THE PROBLEMATIC SYMPTOMS DISPLAYED BY THE SHIFTER WARNING "SHIFT INTO PARK" AFTER THE CAR IS ALREADY IN PARK. THIS IS A WELL KNOWN SITUATION AND FORD SAYS IT'S NOT A SAFETY ISSUE. MY CAR HAS NOW PROGRESSED TO DISPLAYING THIS SAME MESSAGE NEARLY EVERY TIME WE SLOW DOWN TO STOP AT AN INTERSECTION THEN DISPLAYS THE MESSAGE AGAIN AS WE ACCELERATE TO MOVE THROUGH THE INTERSECTION. WITH THIS INCREASING ALARM/WARNING DISPLAY THE CAR HAS ALSO QUIT MOVING INTO THE PRESET SEAT AND MIRROR ADJUSTMENT SETTINGS, DECREASING DRIVERS FIELD OF VISION WITHOUT CONSTANT ADJUSTMENTS. THE CONSISTENT ALARMS SOUNDING OF "SHIFT INTO PARK" AND "DOOR AJAR" (CURRENTLY BEING INVESTIGATED) IS VERY DISTRACTING, ESPECIALLY WHEN SLOWING OR ACCELERATING TO MAKE TRAFFIC CHANGE MANEUVERS. THESE ALARMS ARE MUCH MORE DISTRACTING THAN "HANDS FREE" PHONE CALLS YOU ARE CHECKING ALARMS WHILE CHANGING LANES, MERGING INTO TRAFFIC, OR NAVIGATING INTERSECTIONS ETC. I GIVE AN APPROXIMATE SPEED AND INCIDENT DATE AS THESE ARE ONGOING CONTINUING PROBLEMS. THANK YOU FOR YOUR ATTENTION TO THIS MATTER. *TR
NHTSA ODI #10913852
Mileage unknown · Oct 4, 2016
Electrical SystemUnknown Or Other
THE DRIVER DOOR IS FULLY CLOSED AND THE DASHBOARD LIGHT COMES ON STATING THE DOOR IS AJAR. INTERIOR LIGHT WILL NOT TURN OFF. THE DOOR WILL NOT LOCK AND BATT DRAINS.
NHTSA ODI #10913831
95,000 miles · Oct 4, 2016
Electrical SystemUnknown Or Other
DOOR AJAR LIGHT REMAINS ON, EVEN THOUGH THE DOOR IS PROPERLY CLOSED. DOORS WILL NOT LOCK WHILE THE DOOR AJAR LIGHT IS ACTIVE. INTERIOR LIGHTS WILL NOT GO OFF WHILE THE DOOR AJAR LIGHT IS ACTIVE.
NHTSA ODI #10913680
58,000 miles · Oct 4, 2016
Electrical System
DOOR AJAR WARNING LIGHT COMES ON WHEN DOOR IS CLOSED. WITH THAT PROBLEM IT LEAVES LIGHTS ON AND DRAINING BATTERY. I HAD VEHICLE REPAIRED AT FORD DEALER AT A COST OF $368.00. DEALER STATED THAT THIS PROBLEM IS SOMEWHAT COMMON BUT NO FORD RECALL ISSUED.
NHTSA ODI #10913599
Official recalls
3Jul 2, 2014
Ford Motor Company (Ford) is recalling certain model year 2012-2014 Ford Edge and Lincoln MKX vehicles manufactured September 2, 2010, to November 30, 2013; 2013-2014 Ford Taurus and Lincoln MKS vehicles manufactured August 25, 2011, to November 30, 2013; and 2013-2014 Ford Flex and Lincoln MKT vehicles manufactured September 12, 2011, to November 30, 2013. In the affected vehicles, the halfshaft retention circlip may not have been properly installed, and as a result, the halfshaft may move outward and disengage from the linkshaft while driving and without prior warning.
Consequence & remedy
Consequence: If the halfshaft and linkshaft become disengaged while driving, power will no longer be transmitted to the wheels, increasing the risk of a vehicle crash. Additionally, if the parking brake is not applied before exiting the vehicle, the vehicle may roll away despite the transmission being placed in 'Park', increasing the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the vehicles to make sure that the halfshaft is properly retained. If it is not, dealers will replace the linkshaft and also replace the halfshaft if it shows evidence of spline damage, free of charge. The recall began on August 4, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S10.
Jan 6, 2014
Ford Motor Company (Ford) is recalling certain model year 2012-2013 Edge vehicles manufactured from September 2, 2010, through April 25, 2013, and equipped with 2.0L engines. The fuel line pulse damper metal housing may crack as a result of an improper manufacturing process. A cracked fuel line pulse damper housing may result in a combination of fuel odor, weepage, or a continuous leak while the fuel system is pressurized.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Ford will notify owners, and dealers will replace the fuel line with one that does not have a damper, free of charge. The safety recall began on February 25, 2014. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 13S13. IMPORTANT: This recall supersedes recall 12V-438. All vehicles that have been remedied under the previous recall need to have the current remedy applied.
Sep 7, 2012
Ford is recalling certain 2012 Edge vehicles manufactured from September 2, 2010, through October 31, 2011, equipped with 2.0L engines. The fuel line pulse damper metal housing may crack as a result of an improper manufacturing process. A cracked fuel line pulse damper housing may result in a combination of fuel odor, weepage, or a continuous leak while the fuel system is pressurized.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Ford will notify owners, and dealers will repair the vehicles free of charge. The safety recall began on September 27, 2012. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE16012 · Door Ajar Warning Light Always On
Opened Sep 28, 2016 · Closed Mar 20, 2017
Status: closed (inferred from source dates) · Interior Lighting; Latches/locks/linkages; Latches/locks/linkages:doors:latch
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
Additional source detail variants (3)
Interior Lighting
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
Latches/locks/linkages:doors:latch
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
Latches/locks/linkages
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
Illustration