NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
277 reportsClear category filter100,000 miles · Nov 17, 2016
Power Train
MY CAR HAS MULTIPLE WARNING LIGHTS COME ON ALL AT THE SAME TIME. MY DASH SAYS ODO SYSTEM FAIL, THEN IS SAYS THE TIRE PRESSURE MONITOR FAILS, THE WRENCH FOR TRANSMISSION COMES ON, THEN THE TIRE PRESSURE SYMBOL COMES ON AND FLASHES, THE AIR BAG LIGHT COMES ON, AND THE CHECK ENGINE LIGHT COMES ON. THEN MY ODOMETER GOES TO ZERO. IF …
Read full complaint
MY CAR HAS MULTIPLE WARNING LIGHTS COME ON ALL AT THE SAME TIME. MY DASH SAYS ODO SYSTEM FAIL, THEN IS SAYS THE TIRE PRESSURE MONITOR FAILS, THE WRENCH FOR TRANSMISSION COMES ON, THEN THE TIRE PRESSURE SYMBOL COMES ON AND FLASHES, THE AIR BAG LIGHT COMES ON, AND THE CHECK ENGINE LIGHT COMES ON. THEN MY ODOMETER GOES TO ZERO. IF I SLOW DOWN TO A STOP SIGN OR SOMETHING, I PUSH THE GAS AND THE RPM'S ON MY CAR GO WAY UP BUT MY CAR HARDLY MOVES. ONCE I GET GOING TO A HIGHER SPEED, THE RPM'S GO DOWN...IT IS ALMOST LIKE IT IS STUCK IN A HIGH GEAR. THEN WHEN I PUT MY CAR INTO DRIVE AFTER IT WAS IN PARK, MY CAR JOLTS AND MAKES A HUGE CLANKING NOISE. IF I SHUT MY CAR OFF AND TURN IT BACK ON, IT MAKES A LOUD CLANKING NOISE BUT ALL MY WARNING LIGHTS TURN OFF EXCEPT THE CHECK ENGINE LIGHT. THEN WHEN I PUSH THE GAS AGAIN, IT IS STILL BARELY MOVING AND IN HIGH RPM'S BUT IT WILL RANDOMLY KICK INTO WHATEVER GEAR IT NEEDS TO BE IN AND MAKE ANOTHER LOUD CLANKING SOUND AND RUN FINE. THIS IS VERY DANGEROUS AND I AM NOT SURE WHY IT HAS NOT BEEN RECALLED YET. THIS HAPPENED TO ME FOR THE FIRST TIME IN THE MIDDLE OF A FOUR WAY STOP AND I BLOCKED THE INTERSECTION AND ALMOST GOT HIT BY ANOTHER CAR. THIS IS EVENTUALLY GOING TO CAUSE GREAT HARM OR EVEN DEATH TO SOMEONE.
NHTSA ODI #10926754
138,859 miles · Nov 11, 2016
Power Train
MY VEHICLE'S TRANSMISSION ACTS LIKES IT'S SLIPPING OR IN NEUTRAL WHEN IT'S NOT. JERKS WHEN IT SHIFTS GEARS. LOSES POWER WHEN I TRY TO ACCELERATE. I DID SOME RESEARCH THERE ARE HUNDREDS OF COMPLAINTS ABOUT THE TRANSMISSIONS IN THE FORD EDGE'S. I STARTED HAVING ISSUES SEVERAL WEEKS AGO BACK IN OCTOBER 2016. WHY SHOULD ALL THE OWNE…
Read full complaint
MY VEHICLE'S TRANSMISSION ACTS LIKES IT'S SLIPPING OR IN NEUTRAL WHEN IT'S NOT. JERKS WHEN IT SHIFTS GEARS. LOSES POWER WHEN I TRY TO ACCELERATE. I DID SOME RESEARCH THERE ARE HUNDREDS OF COMPLAINTS ABOUT THE TRANSMISSIONS IN THE FORD EDGE'S. I STARTED HAVING ISSUES SEVERAL WEEKS AGO BACK IN OCTOBER 2016. WHY SHOULD ALL THE OWNERS OF THESE DEFECTIVE TRANSMISSION HAVE TO PAY FOR THIS TO BE FIXED. THAT'S NOT RIGHT! WE GAVE FORD OUR HARD EARNED MONEY JUST TO GET A DEFECTIVE VEHICLE. TALKED TO FORD TODAY AND THEY DON'T CARE. NOT GOING TO DO ANYTHING THEY STATED. TODAY I WAS AT A 4 WAY STOP IN A SCHOOL ZONE AND WHEN I WANTED TO TAKE OFF IT ACTED LIKE IT WAS IN NEUTRAL. I GOT TO WHERE I COULD PULL OVER AND SAT THERE A FEW MINUTES AND WAS ABLE TO DRIVE IT THE OTHER MILE HOME. IT CLUNKS WHEN CHANGING GEARS AND JERKS. IT IS A INTERMITTENT PROBLEM AS IT DOESN'T HAPPEN EVERYDAY.
NHTSA ODI #10925548
140,000 miles · Nov 8, 2016
Power Train
STOPPED AT A LIGHT WOULD NOT PULL FORWARD AFTERWARDS LOUD CLUNKING NOISE, AIRBAG LIGHT CAME ON, SERVICE LIGHT CAME ON, ODOMETER WENT TO ZERO, CAR WOULD JERK WHILE IN GEAR BUT WOULDN'T MOVE FORWARD OR REVERSE. I'VE DONE SOME RESEARCH ON THIS PROBLEM, HUNDREDS OF PEOPLE ARE HAVING THE SAME PROBLEM WITH 2007 AND 2008 EDGE. WITH MOS…
Read full complaint
STOPPED AT A LIGHT WOULD NOT PULL FORWARD AFTERWARDS LOUD CLUNKING NOISE, AIRBAG LIGHT CAME ON, SERVICE LIGHT CAME ON, ODOMETER WENT TO ZERO, CAR WOULD JERK WHILE IN GEAR BUT WOULDN'T MOVE FORWARD OR REVERSE. I'VE DONE SOME RESEARCH ON THIS PROBLEM, HUNDREDS OF PEOPLE ARE HAVING THE SAME PROBLEM WITH 2007 AND 2008 EDGE. WITH MOST BEING TRANSMISSION SENSOR FAILURE. FORD KNOWS OF THIS PROBLEM WON'T DO ANYTHING ABOUT IT.
NHTSA ODI #10925089
158,751 miles · Oct 30, 2016
Power Train
THE VEHICLE WAS IN MOTION STOPPED AT A STOP LIGHT THEN PROCEEDED TO DRIVE OFF OR ACCELERATE UNABLE TO MOVE. GAVE MORE GAS NO ACCELERATION ABLE TO PULL OVER TO THE SIDE SHOULDER NOTICED THE TOOL BAR ON DASH. TURNED THE CAR OFF AND WAITED 5 MINUTES THEN STARTED THE CAR AND PUT INTO DRIVE A LOUD THUD WAS HEARD THEN THE TOOL BAR W…
Read full complaint
THE VEHICLE WAS IN MOTION STOPPED AT A STOP LIGHT THEN PROCEEDED TO DRIVE OFF OR ACCELERATE UNABLE TO MOVE. GAVE MORE GAS NO ACCELERATION ABLE TO PULL OVER TO THE SIDE SHOULDER NOTICED THE TOOL BAR ON DASH. TURNED THE CAR OFF AND WAITED 5 MINUTES THEN STARTED THE CAR AND PUT INTO DRIVE A LOUD THUD WAS HEARD THEN THE TOOL BAR WENT AWAY WAS ABLE TO ACCELERATE DRIVE THE VEHICLE TO DEALER. DURING THE DRIVE CAR DIDN'T RESPOND WELL TO ACCELERATION BUT RPMS INCREASED BUT CAR DIDN'T INCREASE IN SPEED. ALL OF THIS OCCURRED ON A CITY STREET WITHOUT TURNS
NHTSA ODI #10920123
Mileage unknown · Oct 26, 2016
Power Train
2008 FORD EDGE TRANSMISSION ISSUES. THE TRANSMISSION DOES NOT SHIFT PROPERLY AND STICKS IN GEAR AND SHIFTS VERY ERRATICALLY. IT HAPPENS AT LEAST ONCE A DAY OR MORE DEPENDING ON HOW OFTEN IT IS DRIVEN. THE CAR HAS BECOME UNRESPONSIVE AT DIFFERENT TIMES TO THE THE GAS PEDAL AND HAS ACTUALLY SHUT OFF IN THE MIDDLE OF THE ROAD, WE W…
Read full complaint
2008 FORD EDGE TRANSMISSION ISSUES. THE TRANSMISSION DOES NOT SHIFT PROPERLY AND STICKS IN GEAR AND SHIFTS VERY ERRATICALLY. IT HAPPENS AT LEAST ONCE A DAY OR MORE DEPENDING ON HOW OFTEN IT IS DRIVEN. THE CAR HAS BECOME UNRESPONSIVE AT DIFFERENT TIMES TO THE THE GAS PEDAL AND HAS ACTUALLY SHUT OFF IN THE MIDDLE OF THE ROAD, WE WERE ABLE TO COAST BARELY TO SAFETY. FROM READING FORD FORUMS IT IS A VERY COMMON PROBLEM, AND FORD KNOWS ABOUT IT BUT WILL DO NOTHING TO CORRECT THE PROBLEM. WE DO NOT FEEL SAFE MANY TIMES DRIVING THE CAR NOT KNOWING WHAT THE TRANSMISSION WILL OR WON'T DO NEXT,. *TR
NHTSA ODI #10919078
140,000 miles · Oct 17, 2016
Electrical SystemPower Train
TRANSMISSION DISENGAGES AT RANDOM WHILE MOVING IN TRAFFIC. ONCE IT OCCURS, VEHICLE CANNOT BE MOVED UNDER IT'S OWN POWER. ENGINE RUNS, BUT TRANSMISSIONS SLIPS. HIGH POTENTIAL FOR BEING STRANDED IN TRAFFIC AND STRUCK. HAS OCCURRED AT LEAST 4 TIMES. WAS ABLE TO COAST TO SIDE OF ROAD. ELECTRONICS IN DASH ACT UP, INCLUDING SERVICE WR…
Read full complaint
TRANSMISSION DISENGAGES AT RANDOM WHILE MOVING IN TRAFFIC. ONCE IT OCCURS, VEHICLE CANNOT BE MOVED UNDER IT'S OWN POWER. ENGINE RUNS, BUT TRANSMISSIONS SLIPS. HIGH POTENTIAL FOR BEING STRANDED IN TRAFFIC AND STRUCK. HAS OCCURRED AT LEAST 4 TIMES. WAS ABLE TO COAST TO SIDE OF ROAD. ELECTRONICS IN DASH ACT UP, INCLUDING SERVICE WRENCH AND NO SPEEDOMETER. APPARENTLY A KNOWN ISSUE BY FORD (TSB 07-21-11). LOTS OF COMMON COMPLAINTS ONLINE INVOLVING 2007-2008 MODEL EDGES. RELATED TO FAULTY SENSORS (AA5Z-7H103-B & AA5Z-7M101-B). *TR
NHTSA ODI #10916684
116,000 miles · Oct 2, 2016
EnginePower TrainVehicle Speed Control
DRIVING AT I275 TO ST PETERSBURG, AT 60MPH THE CAR MADE A LOUD NOISE FROM THE ENGINE AND REDUCED GEARS ABRUPTLY, IT FELT LIKE A HARD BRAKING FROM THE ENGINE, VERY HARD. THE RPM WENT SKYROCKET, THE CAR LOST POWER AND WOULDN'T GO OVER 45MPH OR IT WOULD DO THE SAME AGAIN. IT LOOKED LIKE IT WAS ON A VERY LOW GEAR, AS IT WAS AT 40MPH…
Read full complaint
DRIVING AT I275 TO ST PETERSBURG, AT 60MPH THE CAR MADE A LOUD NOISE FROM THE ENGINE AND REDUCED GEARS ABRUPTLY, IT FELT LIKE A HARD BRAKING FROM THE ENGINE, VERY HARD. THE RPM WENT SKYROCKET, THE CAR LOST POWER AND WOULDN'T GO OVER 45MPH OR IT WOULD DO THE SAME AGAIN. IT LOOKED LIKE IT WAS ON A VERY LOW GEAR, AS IT WAS AT 40MPH DOING ALMOST 4000RPM... I STOPPED AT A GAS STATION, TURNED IT OF AND LET IT SIT FOR ABOUT 20 MINUTES. WHEN I TRIED TO GO BACK ROME, AFTER 2 MILES IT DID THE SAME, IT LOST POWER. I DROVE BACK TO THE GAS STATION AND HAD IT TOWED HOME.
NHTSA ODI #10911070
75,000 miles · Sep 6, 2016
Air BagsElectrical SystemPower Train
MY VEHICLE FORD EDGE MODEL 2008, LOST CONTROL AS WELL AS SPEED WHEN THE WRENCH LIGHT CAME TO THE DASHBOARD, IMMEDIATELY AFTER THE AIRBAG LIGHT LIT UP, I HAD LITTLE OR NO ENGINE POWER TO ENGAGE GEAR TO KEEP UP WITH TRAFFIC SPEED. MY SPEED DROPPED TO 40 MILES OR LESS PER HOUR. VERY DANGEROUS SITUATION BECAUSE AT THAT MOMENT THE OD…
Read full complaint
MY VEHICLE FORD EDGE MODEL 2008, LOST CONTROL AS WELL AS SPEED WHEN THE WRENCH LIGHT CAME TO THE DASHBOARD, IMMEDIATELY AFTER THE AIRBAG LIGHT LIT UP, I HAD LITTLE OR NO ENGINE POWER TO ENGAGE GEAR TO KEEP UP WITH TRAFFIC SPEED. MY SPEED DROPPED TO 40 MILES OR LESS PER HOUR. VERY DANGEROUS SITUATION BECAUSE AT THAT MOMENT THE ODOMETER LIGHTING ALSO WENT OFF. DRIVING ON A HIGHWAY AT NIGHT NO ONE DRIVES BELOW 40 MILES PER HOUR, MADE THE SITUATION PRETTY GRAVE AND DANGEROUS. THE PROBLEM COMES FROM THE POWER TRAIN FAULTY SENSORS NEAR THE TRANSMISSION NEED TO BE REPLACED COSTING OVER $800,00, AS FOR THE AIRBAG I HAVEN'T RECEIVED A INVOICE YET.
NHTSA ODI #10904262
121,500 miles · Sep 3, 2016
Power TrainUnknown Or Other
FOR NO PARTICULAR REASON MY EDGE DECELERATES TO TEN MILES AN HOUR WHILE THE TACH READS 3RPMS IT HAS HAPPENED ON ALL TYPES OF ROADS AND IN TRAFFIC ALSO. THE TRANNY FLUID IS ALWAYS FINE. NO CODES ON DASH EITHER. I HAVE MY GAS PEDAL TO THE FLOOR AND IT WILL ONLY CREEP AT 10 MPH. WHEN IT REENGAGES IT IS A LARGE HARD JERK FORWARD. …
Read full complaint
FOR NO PARTICULAR REASON MY EDGE DECELERATES TO TEN MILES AN HOUR WHILE THE TACH READS 3RPMS IT HAS HAPPENED ON ALL TYPES OF ROADS AND IN TRAFFIC ALSO. THE TRANNY FLUID IS ALWAYS FINE. NO CODES ON DASH EITHER. I HAVE MY GAS PEDAL TO THE FLOOR AND IT WILL ONLY CREEP AT 10 MPH. WHEN IT REENGAGES IT IS A LARGE HARD JERK FORWARD. ONE EVENING AS I PULLED INTO MY OWN DRIVEWAY IT WOULDN'T MOVE FORWARD AT ALL I SHUT IT OFF WAITED RESTARTED IT AND IT WAS LIKE NOTHING HAPPENED. IT DOES STUDDER A BIT GOING UPHILL ALMOST LIKE IT DOESN'T WANT TO GO THEN IT DOES. FOR A WHILE I THOUGHT IT WAS THINGS LIKE BAD GAS DIRT IN A FUEL LINE LOW FLUIDS BUT IT ISN'T THIS 2008S NEED A RECALL AS MANY OTHER EDGE OWNERS HAVE THE SAME ISSUES. I HAVE MADE AN APPT FOR THE CAR AT THE DEALER AND I AM NOT CONVINCED THEY KNOW THE ANSWER EITHER. I RECEIVED THE RECALL FOR THE GAS TANK , BUT I WANT ONE FOR THIS AS I AND MANY OTHER FORD EDGE OWNERS HAVE THE SAME SCARY POWER TRAIN ISSUES REPORTED TO YOU NHTSA PLEASE HELP US . I WANT A RECALL FREE REPAIRS OR A TRADE IN WITH OUT BEING TAKEN ADVANTAGE OF BECAUSE OF THIS PROBLEM THANK YOU SAYLORSBURG PENNSYLVANIA.
NHTSA ODI #10903426
125,000 miles · Aug 26, 2016
Electrical SystemPower TrainService Brakes
FIRST I WAS DRIVING WHEN MY BREAKS STARTED TO FEEL LIKE THEY WERE LOCKING UP. COME TO FIND OUT IT WAS THE POWER BREAK BOOSTER WHICH COST ME $504.00. THEN 2 WEEKS LATER MY CAR STARTS TO DO A PUTTING FEELING AND COME TO FIND OUT 2 OF THE COILS BURNT UP THE POWER CONTROL MODULE COSTING ME $1058.00. A FEW MONTHS BEFORE THIS IT WAS I…
Read full complaint
FIRST I WAS DRIVING WHEN MY BREAKS STARTED TO FEEL LIKE THEY WERE LOCKING UP. COME TO FIND OUT IT WAS THE POWER BREAK BOOSTER WHICH COST ME $504.00. THEN 2 WEEKS LATER MY CAR STARTS TO DO A PUTTING FEELING AND COME TO FIND OUT 2 OF THE COILS BURNT UP THE POWER CONTROL MODULE COSTING ME $1058.00. A FEW MONTHS BEFORE THIS IT WAS IN THE FORD DEALERSHIP BECAUSE OF A LEAK ON THE FUEL PUMP. COSTING ME $216. I AM FURIOUS I HAVE HAD TO SPEND THIS IN THE LAST MONTH. I JUST SEEN ON THE NEWS THAT FORD HAS A RECALL ON THE POWER CONTROL MODULE BUT IT WAS NOT MY YEAR. I AM SIMPLY ASKING IF SOMEONE WOULD PLEASE LOOK INTO THIS SO MAYBE I CAN GET SOME OF THIS MONEY BACK TO PAY OFF THE DEBT IT CAUSED ME.
NHTSA ODI #10898892
Official recalls
6Mar 10, 2021
Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge. Owner notification letters were mailed on April 9, 2021 for the passenger side, and November 14, 2022 for the driver side. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S12.
Feb 16, 2021
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Additional source detail variants (3)
Air Bags:frontal:passenger Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal:driver Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Jan 10, 2017
Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain 2009 Ford Ranger, Edge, Fusion and Mustang, Lincoln MKX, MKZ and Zephyr and Mercury Milan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Ford is recalling certain 2007-2008 Ford Ranger, Edge and Lincoln MKX, 2006-2008 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ, 2005-2008 Ford Mustang and 2005-2006 Ford GT vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Interim letters informing owners of the recall and that parts are not yet available began mailing March 1, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
May 31, 2016
Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
Oct 29, 2014
Ford Motor Company (Ford) is recalling certain model year 2007-2008 Lincoln MKX, and Ford Edge vehicles, manufactured June 15, 2006, to September 22, 2008, and originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Due to corrosion from salt water exposure such as from road salt use, the affected vehicles may leak fuel from the fuel tank seam weld under the tank mounting reinforcement brackets.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Interim notices were mailed to owners on December 12, 2014. The recall began on October 6, 2015. Dealers will inspect the vehicles and either clean and treat the fuel tank with a corrosion preventative or replace the tank, free of charge. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S22.
Jul 3, 2008
FORD IS RECALLING 142 MY 2008 EDGE AND LINCOLN MKK ALL WHEEL DRIVE VEHICLES. THE FUEL TANK WELD FIXTURE MAY HAVE BEEN EXPOSED TO A CONTAMINANT DURING PRODUCTION WHICH COULD CAUSE A DIMPLE IN THE BOTTOM OF THE FUEL TANK AT A SPOT WELD.
Consequence & remedy
Consequence: THIS DIMPLE COULD RESULT IN A FUEL LEAK OR A FUEL DRIP FROM THE TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE FUEL TANK FREE OF CHARGE. THE RECALL BEGAN ON JULY 11, 2008. OWNERS MAY CONTACT FORD AT 1-866-437-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE09031 · Front Suspension Lower Ball Joint
Opened Jul 13, 2009 · Closed Nov 19, 2009
Status: closed (inferred from source dates) · Suspension:front:control Arm:lower Ball Joint
ON JULY 13, 2009, THE OFFICE OF DEFECTS INVESTIGATIONS (ODI) OPENED PRELIMINARY EVALUATION PE09-031 TO INVESTIGATE ALLEGATIONS OF FRONT LOWER BALL JOINT SEPARATION IN MODEL YEAR (MY) 2007 AND 2008 FORD EDGE AND LINCOLN MKX VEHICLES.THE INVESTIGATION WAS BASED ON THREE OWNER COMPLAINTS ALLEGING THAT THE FRONT LOWER BALL JOINT SEPARATED AND CAUSED THE FRONT SUSPENSION TO COLLAPSE WHILE DRIVING.ODI ALSO IDENTIFIED INFORMATION RELATED TO THE ALLEGED DEFECT IN EARLY WARNING DATA SUBMITTED BY FORD.PRELIMINARY ANALYSIS INDICATED THAT THE FAILURES WERE RELATED TO THE PINCH BOLT USED TO SECURE THE FRONT LOWER BALL JOINT STUD TO THE STEERING KNUCKLE.ONE COMPLAINT ALLEGED THAT A CRASH OCCURRED WHICH RESULTED IN A MINOR INJURY.HOWEVER, NO ADDITIONAL INFORMATION COULD BE OBTAINED TO SUPPORT THIS CLAIM.INFORMATION PROVIDED BY FORD IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER FOR PE09-031 INDICATE THAT IN EARLY MY 2007 PRODUCTION THERE WERE SOME ISSUES WITH THE FRONT LOWER CONTROL ARM BALL JOINT ASSEMBLY PROCESS.THE PINCH BOLTS USED WERE HAND STARTED AND HAD THE POTENTIAL TO CROSS THREAD AND NOT ACHIEVE PROPER CLAMP LOAD, POTENTIALLY RESULTING IN A LOOSE JOINT.IN NOVEMBER 2007, CHANGES WERE IMPLEMENTED TO CHASE AND CLEAN THE FIRST SIX THREADS OF THE BOLT TO PROVIDE EASIER HAND STARTING OF THE NUT AND ENSURE GOOD THREAD ENGAGEMENT BEFORE TIGHTENING. FORD ALSO IDENTIFIED ONGOING CONCERNS WITH THE POWER TRANSMISSION UNIT (PTU) SEALS AND FRONT SUSPENSION HYDRO-BUSHINGS ON THE SUBJECT VEHICLES, WHICH BOTH REQUIRE DISASSEMBLY OF THE FRONT LOWER BALL JOINT TO REPAIR.IF THE BALL JOINT IS NOT PROPERLY REASSEMBLED FOLLOWING SUCH SERVICE, THE JOINT MAY SEPARATE IN LATER SERVICE.FORD HAS PROVIDED ADDITIONAL INSTRUCTIONS AND NEW PINCH BOLTS TO THE PTU REPAIR KIT TO IMPROVE THE JOINT REASSEMBLY PROCESS. ODI'S ANALYSIS OF FAILURE DATA IDENTIFIED 31 INCIDENTS OF JOINT SEPARATION (WITH 12 SPECIFICALLY STATING THAT THEY OCCURRED WHILE DRIVING).REPAIR RECORDS FOR THESE 31 VEHICLES SHOWS THAT 28 INVOLVE SEPARATION OF THE JOINT ON THE PASSENGER (RIGHT) SIDE, WHICH IS THE SIDE THAT MUST BE DISASSEMBLED FOR PTU SERVICE.TWENTY-THREE OF THESE WERE FOUND TO HAVE BEEN PREVIOUSLY DISASSEMBLED FOR CONTROL ARM BUSHING SERVICE, PTU SERVICE OR OTHER TRANSMISSION REPAIR. THE EIGHT CLAIMS THAT DID NOT INVOLVE PRIOR SERVICE REPAIRS REQUIRING JOINT DISASSEMBLY ALL OCCURRED VERY EARLY IN VEHICLE LIFE, INDICATING THAT IT IS UNLIKELY THAT ANY JOINTS MANUFACTURED WITH LOOSE PINCH BOLTS ARE STILL IN SERVICE.ALL OF THESE JOINTS FAILED WITHIN 6 MONTHS IN SERVICE AND 10,000 MILES (THE MAXIMUM FAILURE MILEAGE IS 8,097 MILES).THERE HAVEN'T BEEN ANY SUCH FAILURES (I.E., NOT INVOLVING PRIOR SERVICE/DISASSEMBLY) SINCE DECEMBER 2008.THE RATE FOR INCIDENTS THAT DID NOT OCCUR FOLLOWING SERVICE AND, THUS, MAY BE RELATED TO THE MANUFACTURING PROCESS ISSUES IDENTIFIED BY FORD IS VERY LOW (2.5 PER 100,000 VEHICLES) AND THESE INCIDENTS OCCURRED VERY EARLY IN THE LIFE OF THE VEHICLES AND ARE NOT SHOWING A CONTINUING FAILURE TREND.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO
Illustration