NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
158 reportsClear category filter105,000 miles · Mar 8, 2016
Electrical SystemPower Train
TL* THE CONTACT OWNS A 2008 FORD EDGE. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED INDEPENDENTLY. THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO OPERATE. THE CONTACT HAD TO JIGGLE THE GEAR FOR THE VEHICLE TO OPERATE NORMALLY. THE FAILURE RECURRED FOUR TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MEC…
Read full complaint
TL* THE CONTACT OWNS A 2008 FORD EDGE. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED INDEPENDENTLY. THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO OPERATE. THE CONTACT HAD TO JIGGLE THE GEAR FOR THE VEHICLE TO OPERATE NORMALLY. THE FAILURE RECURRED FOUR TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CAUSE OF THE FAILURE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 105,000. THE VIN WAS NOT PROVIDED.
NHTSA ODI #10845615
88,000 miles · Feb 11, 2016
Electrical SystemStructure
TL* THE CONTACT OWNS A 2008 FORD EDGE. THE CONTACT STATED THAT A WARNING LIGHT KEPT RANDOMLY FLASHING FOR THE DOOR SENSOR, WHICH INDICATED THAT THE DOOR WAS NOT SHUT WHEN THE DOOR WAS CLOSED AND VISE VERSA FOR ALL FOUR DOORS. THE CONTACT WAS UNABLE TO ENTER THE VEHICLE UNLESS THE CONTACT MANUALLY UNLOCKED THE DOORS FROM THE OUTS…
Read full complaint
TL* THE CONTACT OWNS A 2008 FORD EDGE. THE CONTACT STATED THAT A WARNING LIGHT KEPT RANDOMLY FLASHING FOR THE DOOR SENSOR, WHICH INDICATED THAT THE DOOR WAS NOT SHUT WHEN THE DOOR WAS CLOSED AND VISE VERSA FOR ALL FOUR DOORS. THE CONTACT WAS UNABLE TO ENTER THE VEHICLE UNLESS THE CONTACT MANUALLY UNLOCKED THE DOORS FROM THE OUTSIDE. THE INTERNAL DOME LIGHT REMAINED ILLUMINATED AS THE FAILURE PROGRESSED. THE VEHICLE WAS NOT INSPECTED AND DIAGNOSED. THE VEHICLE WAS TO BE TAKEN TO A DEALER. THE APPROXIMATE FAILURE MILEAGE WAS 88,000.
NHTSA ODI #10825538
Mileage unknown · Jan 30, 2016
Electrical System
DRIVER DOOR AJAR LIGHT REMAINS ON AFTER CLOSING THE DOOR SEVERAL TIMES. ONCE LIGHTS FINALLY GO OUT, IT WILL POP RIGHT ON AGAIN, EVEN AS I WAS DRIVING. THIS IS EXTREMELY DANGEROUS, BECAUSE WE'LL NEVER KNOW WHEN THE DOORS ARE AJAR. EVEN BIGGER ISSUE IS THE DOORS NOT BEING UNLOCKED IN THE PROCESS. JUST ANNOYED WITH THIS ALLTOGETHER…
Read full complaint
DRIVER DOOR AJAR LIGHT REMAINS ON AFTER CLOSING THE DOOR SEVERAL TIMES. ONCE LIGHTS FINALLY GO OUT, IT WILL POP RIGHT ON AGAIN, EVEN AS I WAS DRIVING. THIS IS EXTREMELY DANGEROUS, BECAUSE WE'LL NEVER KNOW WHEN THE DOORS ARE AJAR. EVEN BIGGER ISSUE IS THE DOORS NOT BEING UNLOCKED IN THE PROCESS. JUST ANNOYED WITH THIS ALLTOGETHER. HOPEFULLY SOMETHING WILL BE DONE ABOUT IT. IT'S DRAINING THE BATTERY IN THE PROCESS. THANK YOU.
NHTSA ODI #10823252
98,000 miles · Jan 12, 2016
Electrical System
OUR VEHICLE BEGAN TO STUTTER WHILE DRIVING DOWN A 4 LANE HIGHWAY AND THEN SUDDENLY TURNED OFF WHILE CAR WAS STILL IN DRIVE AND IN MOTION. ONCE THE ENGINE TURNED OFF ON ITS OWN THE POWER STEERING DID NOT WORK MAKING IT DIFFICULT TO STEER TO THE SIDE OF ROAD. CAR WAS TOWED TO DEALERSHIP PROBLEM WAS NOTED AS A FAULTY PCM WHICH CAU…
Read full complaint
OUR VEHICLE BEGAN TO STUTTER WHILE DRIVING DOWN A 4 LANE HIGHWAY AND THEN SUDDENLY TURNED OFF WHILE CAR WAS STILL IN DRIVE AND IN MOTION. ONCE THE ENGINE TURNED OFF ON ITS OWN THE POWER STEERING DID NOT WORK MAKING IT DIFFICULT TO STEER TO THE SIDE OF ROAD. CAR WAS TOWED TO DEALERSHIP PROBLEM WAS NOTED AS A FAULTY PCM WHICH CAUSED THE COILS TO OVERHEAT AND CAUSE BOTH THE PCM AND COIL TO FAIL. COILS WAS SEVERELY MELTED FROM OVERHEATING AND MAY HAVE EVENTUALLY CAUGHT ON FIRE. FORD WAS NOTIFIED OF THE PROBLEM AND STATES THAT THE MANUFACTURE DATE WAS ACKNOWLEDGED IN A TSB 14-0059 BUT THAT THERE IS NO RESPONSIBILITY OF FORD MOTOR COMPANY END. COST TO REPAIR WAS $3000 DUE TO TSB STATING THAT CUSTOMER NEEDS TO REPLACE ALL COILS AND PCM WITH A UNIT THAT DOES NOT CAUSE OVERHEATING AND LOSS OF POWER TO CAR
NHTSA ODI #10819776
80,100 miles · Dec 23, 2015
Electrical System
TL* THE CONTACT OWNS A 2008 FORD EDGE. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE VEHICLE WENT INTO LIMP MODE AND SHE WAS UNABLE TO CONTROL THE VEHICLE. THE CONTACT MANEUVERED THE VEHICLE TO THE SIDE OF THE ROAD TO A COMPLETE STOP AS ALL WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHER…
Read full complaint
TL* THE CONTACT OWNS A 2008 FORD EDGE. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE VEHICLE WENT INTO LIMP MODE AND SHE WAS UNABLE TO CONTROL THE VEHICLE. THE CONTACT MANEUVERED THE VEHICLE TO THE SIDE OF THE ROAD TO A COMPLETE STOP AS ALL WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE IGNITION COIL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 80,100.
NHTSA ODI #10811962
135,000 miles · Nov 24, 2015
Air BagsElectrical SystemPower Train
AUTO TRANSMISSION WILL NOT SHIFT, ENGINE REVS AND NO POWER, WRENCH LIGHT AIRBAG WARNING LIGHTS,DEAD SPEEDO, ODOMETER SHOWS DASHES. HAD TRANS FLUID CHANGED. NO HELP. I HAVE SEEN SEVERAL PROBLEMS NOTED ON THE INTERNET. DEALERS ARE NOT FIXING THE PROBLEM BY REBUILDING THE TRANS FOR SEVERAL THOUSAND DOLLARS. THE TRANS FAILING SHOU…
Read full complaint
AUTO TRANSMISSION WILL NOT SHIFT, ENGINE REVS AND NO POWER, WRENCH LIGHT AIRBAG WARNING LIGHTS,DEAD SPEEDO, ODOMETER SHOWS DASHES. HAD TRANS FLUID CHANGED. NO HELP. I HAVE SEEN SEVERAL PROBLEMS NOTED ON THE INTERNET. DEALERS ARE NOT FIXING THE PROBLEM BY REBUILDING THE TRANS FOR SEVERAL THOUSAND DOLLARS. THE TRANS FAILING SHOULD NOT AFFECT THE VARIOUS ELECTRICAL PROBLEMS ASSOCIATED WITH THIS INCIDENT. THE SYSTEM WILL RESET IF THE ENGINE IS TURNED OFF AND THEN RESTARTED WITH NOTHING INDICATING A PROBLEM. THERE DOESNT APPEAR TO BE ANY CODES SET. I URGE FORD TO EMBRACE THESE PROBLEMS BEFORE SOMEONE IS HURT BECAUSE THE TRANS "JUMPS" OUT OF GEAR AND CAUSES AN ACCIDENT. THIS REPORTED PROBLEM SHOULD NOT BE "NEWS" TO YOUR COMPLAINTS DEPARTMENT. I HAVE CHOSEN TO ALWAYS PREFER A FORD PRODUCTS DURING MY 50 YEARS OF DRIVING AND EXPECT AN HONEST, THOROUGH AND CONCISE INVESTIGATION BE GIVEN TO THIS PROBLEM.
NHTSA ODI #10806612
84,000 miles · Nov 11, 2015
Air BagsElectrical SystemEngine
BENEATH THE DRIVERS SEAT, THERE IS A LOUD SOUND THAT RESIGNATES THROUGHOUT THE VEHICLE. ALSO THE ELECTRICAL PANEL HAD TO BE REPLACED AND SENSORS GO OFF PERIODICALLY.
NHTSA ODI #10789806
60,000 miles · Oct 1, 2015
Electrical SystemExterior LightingWheels
ABOUT 3 MONTHS AGO THE DRIVERS SIDE FRONT DOOR AJAR LIGHT WAS STAYING ON AND WOULD NOT GO AWAY EVEN THE DOOR WAS CLOSED. WE HAVE BEEN ALL KINDS OF OTHER PROBLEMS RELATED TO THIS PROBLEM SUCH AS DOOR CHIMES GOING OFF RANDOMLY ALL THE TIME THE DOME LIGHTS WILL NOT TURN OFF WHEN CAR IS PARKED AND SHUT OFF. THE NOISE AND LIGHTS ARE…
Read full complaint
ABOUT 3 MONTHS AGO THE DRIVERS SIDE FRONT DOOR AJAR LIGHT WAS STAYING ON AND WOULD NOT GO AWAY EVEN THE DOOR WAS CLOSED. WE HAVE BEEN ALL KINDS OF OTHER PROBLEMS RELATED TO THIS PROBLEM SUCH AS DOOR CHIMES GOING OFF RANDOMLY ALL THE TIME THE DOME LIGHTS WILL NOT TURN OFF WHEN CAR IS PARKED AND SHUT OFF. THE NOISE AND LIGHTS ARE A MAJOR DISTRACTION. THE OTHER PROBLEM WE HAVE EXPERIENCED WITH THE VEHICLE BUT HAVE HAD FIXED IS THE TWO REAR WHEEL BEARINGS HAVE BEEN REPLACED. THE FIRST WHEN THE VEHICLE HAD ONLY 36,000 PLUS OR MINUS A THOUSAND OR TWO AND THE OTHER WHEN WE ONLY HAD 60,000 MILES ON VEHICLE. THIS IS EXPENSIVE AND SHOULD NOT GO BAD IN THAT SHORT OF TIME. WE DO NOT PULL ANYTHING WITH THE VEHICLE OR DRIVE IT ROUGH.
NHTSA ODI #10779044
72,000 miles · Jul 17, 2015
Electrical SystemStructure
TL* THE CONTACT OWNS A 2008 FORD EDGE. THE CONTACT STATED THAT THE DRIVER SIDE DOOR AJAR WARNING INDICATOR ILLUMINATED. THE CONTACT MENTIONED THAT THE AUTOMATIC DOOR LOCKS HAD NOT ENGAGED AND THE INTERIOR DOME LIGHTS REMAINED ILLUMINATED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 7…
Read full complaint
TL* THE CONTACT OWNS A 2008 FORD EDGE. THE CONTACT STATED THAT THE DRIVER SIDE DOOR AJAR WARNING INDICATOR ILLUMINATED. THE CONTACT MENTIONED THAT THE AUTOMATIC DOOR LOCKS HAD NOT ENGAGED AND THE INTERIOR DOME LIGHTS REMAINED ILLUMINATED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 72,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10734852
143,000 miles · Jun 29, 2015
Electrical SystemPower TrainVehicle Speed Control
AS I WAS DRIVING, DASH FLASHED "ODO DATA ERROR", THEN WRENCH LIGHT CAME ON FOLLOWED BY AIRBAG, TPM, ENGINE LIGHT, BASICALLY ALL WARNING LIGHTS, ODOMETER WENT TO ZERO, LOSS OF ACCELARATION, PULLED OVER AND PLACED IN PARK, CAR WAS REVVING HIGH, TURNED CAR OFF AND RESTARTED, SAME, PUT ON DRIVE, STEPPED ON GAS, CAR REVVED BUT NO MOV…
Read full complaint
AS I WAS DRIVING, DASH FLASHED "ODO DATA ERROR", THEN WRENCH LIGHT CAME ON FOLLOWED BY AIRBAG, TPM, ENGINE LIGHT, BASICALLY ALL WARNING LIGHTS, ODOMETER WENT TO ZERO, LOSS OF ACCELARATION, PULLED OVER AND PLACED IN PARK, CAR WAS REVVING HIGH, TURNED CAR OFF AND RESTARTED, SAME, PUT ON DRIVE, STEPPED ON GAS, CAR REVVED BUT NO MOVEMENT. TURNED CAR OFF AND WAITED COUPLE MINUTES, RESTATED, WARNING LIGHTS DISAPPEARED, ODOMETER BACK TO ACTUAL MILEAGE. PUT ON DRIVE, STEP ON GAS, HESITATION THEN LOUD TRANSMISSION THUMP AND CAR STARTED MOVING AGAIN.
NHTSA ODI #10730968
Official recalls
6Mar 10, 2021
Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge. Owner notification letters were mailed on April 9, 2021 for the passenger side, and November 14, 2022 for the driver side. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S12.
Feb 16, 2021
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Additional source detail variants (3)
Air Bags:frontal:passenger Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal:driver Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Jan 10, 2017
Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain 2009 Ford Ranger, Edge, Fusion and Mustang, Lincoln MKX, MKZ and Zephyr and Mercury Milan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Ford is recalling certain 2007-2008 Ford Ranger, Edge and Lincoln MKX, 2006-2008 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ, 2005-2008 Ford Mustang and 2005-2006 Ford GT vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Interim letters informing owners of the recall and that parts are not yet available began mailing March 1, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
May 31, 2016
Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
Oct 29, 2014
Ford Motor Company (Ford) is recalling certain model year 2007-2008 Lincoln MKX, and Ford Edge vehicles, manufactured June 15, 2006, to September 22, 2008, and originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Due to corrosion from salt water exposure such as from road salt use, the affected vehicles may leak fuel from the fuel tank seam weld under the tank mounting reinforcement brackets.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Interim notices were mailed to owners on December 12, 2014. The recall began on October 6, 2015. Dealers will inspect the vehicles and either clean and treat the fuel tank with a corrosion preventative or replace the tank, free of charge. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S22.
Jul 3, 2008
FORD IS RECALLING 142 MY 2008 EDGE AND LINCOLN MKK ALL WHEEL DRIVE VEHICLES. THE FUEL TANK WELD FIXTURE MAY HAVE BEEN EXPOSED TO A CONTAMINANT DURING PRODUCTION WHICH COULD CAUSE A DIMPLE IN THE BOTTOM OF THE FUEL TANK AT A SPOT WELD.
Consequence & remedy
Consequence: THIS DIMPLE COULD RESULT IN A FUEL LEAK OR A FUEL DRIP FROM THE TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE FUEL TANK FREE OF CHARGE. THE RECALL BEGAN ON JULY 11, 2008. OWNERS MAY CONTACT FORD AT 1-866-437-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE09031 · Front Suspension Lower Ball Joint
Opened Jul 13, 2009 · Closed Nov 19, 2009
Status: closed (inferred from source dates) · Suspension:front:control Arm:lower Ball Joint
ON JULY 13, 2009, THE OFFICE OF DEFECTS INVESTIGATIONS (ODI) OPENED PRELIMINARY EVALUATION PE09-031 TO INVESTIGATE ALLEGATIONS OF FRONT LOWER BALL JOINT SEPARATION IN MODEL YEAR (MY) 2007 AND 2008 FORD EDGE AND LINCOLN MKX VEHICLES.THE INVESTIGATION WAS BASED ON THREE OWNER COMPLAINTS ALLEGING THAT THE FRONT LOWER BALL JOINT SEPARATED AND CAUSED THE FRONT SUSPENSION TO COLLAPSE WHILE DRIVING.ODI ALSO IDENTIFIED INFORMATION RELATED TO THE ALLEGED DEFECT IN EARLY WARNING DATA SUBMITTED BY FORD.PRELIMINARY ANALYSIS INDICATED THAT THE FAILURES WERE RELATED TO THE PINCH BOLT USED TO SECURE THE FRONT LOWER BALL JOINT STUD TO THE STEERING KNUCKLE.ONE COMPLAINT ALLEGED THAT A CRASH OCCURRED WHICH RESULTED IN A MINOR INJURY.HOWEVER, NO ADDITIONAL INFORMATION COULD BE OBTAINED TO SUPPORT THIS CLAIM.INFORMATION PROVIDED BY FORD IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER FOR PE09-031 INDICATE THAT IN EARLY MY 2007 PRODUCTION THERE WERE SOME ISSUES WITH THE FRONT LOWER CONTROL ARM BALL JOINT ASSEMBLY PROCESS.THE PINCH BOLTS USED WERE HAND STARTED AND HAD THE POTENTIAL TO CROSS THREAD AND NOT ACHIEVE PROPER CLAMP LOAD, POTENTIALLY RESULTING IN A LOOSE JOINT.IN NOVEMBER 2007, CHANGES WERE IMPLEMENTED TO CHASE AND CLEAN THE FIRST SIX THREADS OF THE BOLT TO PROVIDE EASIER HAND STARTING OF THE NUT AND ENSURE GOOD THREAD ENGAGEMENT BEFORE TIGHTENING. FORD ALSO IDENTIFIED ONGOING CONCERNS WITH THE POWER TRANSMISSION UNIT (PTU) SEALS AND FRONT SUSPENSION HYDRO-BUSHINGS ON THE SUBJECT VEHICLES, WHICH BOTH REQUIRE DISASSEMBLY OF THE FRONT LOWER BALL JOINT TO REPAIR.IF THE BALL JOINT IS NOT PROPERLY REASSEMBLED FOLLOWING SUCH SERVICE, THE JOINT MAY SEPARATE IN LATER SERVICE.FORD HAS PROVIDED ADDITIONAL INSTRUCTIONS AND NEW PINCH BOLTS TO THE PTU REPAIR KIT TO IMPROVE THE JOINT REASSEMBLY PROCESS. ODI'S ANALYSIS OF FAILURE DATA IDENTIFIED 31 INCIDENTS OF JOINT SEPARATION (WITH 12 SPECIFICALLY STATING THAT THEY OCCURRED WHILE DRIVING).REPAIR RECORDS FOR THESE 31 VEHICLES SHOWS THAT 28 INVOLVE SEPARATION OF THE JOINT ON THE PASSENGER (RIGHT) SIDE, WHICH IS THE SIDE THAT MUST BE DISASSEMBLED FOR PTU SERVICE.TWENTY-THREE OF THESE WERE FOUND TO HAVE BEEN PREVIOUSLY DISASSEMBLED FOR CONTROL ARM BUSHING SERVICE, PTU SERVICE OR OTHER TRANSMISSION REPAIR. THE EIGHT CLAIMS THAT DID NOT INVOLVE PRIOR SERVICE REPAIRS REQUIRING JOINT DISASSEMBLY ALL OCCURRED VERY EARLY IN VEHICLE LIFE, INDICATING THAT IT IS UNLIKELY THAT ANY JOINTS MANUFACTURED WITH LOOSE PINCH BOLTS ARE STILL IN SERVICE.ALL OF THESE JOINTS FAILED WITHIN 6 MONTHS IN SERVICE AND 10,000 MILES (THE MAXIMUM FAILURE MILEAGE IS 8,097 MILES).THERE HAVEN'T BEEN ANY SUCH FAILURES (I.E., NOT INVOLVING PRIOR SERVICE/DISASSEMBLY) SINCE DECEMBER 2008.THE RATE FOR INCIDENTS THAT DID NOT OCCUR FOLLOWING SERVICE AND, THUS, MAY BE RELATED TO THE MANUFACTURING PROCESS ISSUES IDENTIFIED BY FORD IS VERY LOW (2.5 PER 100,000 VEHICLES) AND THESE INCIDENTS OCCURRED VERY EARLY IN THE LIFE OF THE VEHICLES AND ARE NOT SHOWING A CONTINUING FAILURE TREND.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO
Illustration