NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
13 reportsClear category filter185,000 miles · May 29, 2008
Engine And Engine CoolingService Brakes, HydraulicSteering
TL*THE CONTACT OWNS A 1992 FORD ECONOLINE. AFTER STARTING THE VEHICLE, THE WATER PUMP BEGAN LEAKING FLUID. THE LABOR COST FOR THE REPAIR WAS $100. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL. THE PEDAL EXTENDED TO THE FLOOR AND MADE IT VERY DIFFICULT TO STOP THE VEHICLE. WHILE THE MECHANIC WAS …
Read full complaint
TL*THE CONTACT OWNS A 1992 FORD ECONOLINE. AFTER STARTING THE VEHICLE, THE WATER PUMP BEGAN LEAKING FLUID. THE LABOR COST FOR THE REPAIR WAS $100. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL. THE PEDAL EXTENDED TO THE FLOOR AND MADE IT VERY DIFFICULT TO STOP THE VEHICLE. WHILE THE MECHANIC WAS INSPECTING THE VEHICLE, HE OBSERVED AN INCOMPLETE STICKER INSIDE THE DOOR BY THE MANUFACTURER IN 1992. THE CONTACT WAS CONCERNED THAT THE STICKER INDICATED THAT THERE WERE SOME PARTS ON THE VEHICLE THAT WERE NOT COMPLETELY INSTALLED. THE CONTACT STATED THAT THE FRONT END ALSO NEEDED TO BE ALIGNED. THE VEHICLE WAS PURCHASED 1 YEAR AGO. THE CURRENT AND FAILURE MILEAGES WERE 187,000. UPDATED 06/16/08 *BF
NHTSA ODI #10229223
Mileage unknown · Aug 28, 2007
Engine And Engine CoolingFire
1992 FORD ECONOLINE CAUGHT FIRE IN THE ENGINE COMPARTMENT CAUSING THE VAN TO BE COMPLETELY ENGULFED IN FLAMES. *KB OHIO TRAFFIC CRASH REPORT. *JB
NHTSA ODI #10201493
Mileage unknown · Nov 5, 2003
Engine And Engine CoolingFire
1992 FORD ECONOLINE SUFFERED TIRE TREAD SEPARATION AS WELL AS ENGINE FIRE.*MR TIRE TREAD SEPARATED CAUSING CONSUMER TO PULL OVER. ONCE ON THE SIDE OF THE ROAD, HIS WIFE NOTICED FLAMES COMING FROM THE ENGINE COMPARTMENT. CONSUMER OPENED HOOD AND EXTINGUISHED WHAT HE COULD SEE. WHEN MORE FLAMES LIT UP AND THE …
Read full complaint
1992 FORD ECONOLINE SUFFERED TIRE TREAD SEPARATION AS WELL AS ENGINE FIRE.*MR TIRE TREAD SEPARATED CAUSING CONSUMER TO PULL OVER. ONCE ON THE SIDE OF THE ROAD, HIS WIFE NOTICED FLAMES COMING FROM THE ENGINE COMPARTMENT. CONSUMER OPENED HOOD AND EXTINGUISHED WHAT HE COULD SEE. WHEN MORE FLAMES LIT UP AND THE EXTINGUISHER WAS GONE, THEY GOT THEIR TWO DOGS OUT AND WALKED AWAY FROM THE VEHICLE. NOTHING WAS SALVAGEABLE. *PH
NHTSA ODI #10048308
Mileage unknown · Jul 25, 2002
Engine And Engine Cooling
CONSUMER STATES THAT THE RUBBER FUEL LINE IS BEING OVERHEATED/BURNED BY THE EXHAUST SYSTEM AND MAY CAUSE A FIRE. MANUFACTURER WAS NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*JB
NHTSA ODI #8014720
Mileage unknown · Apr 15, 2002
Engine And Engine CoolingFuel System, Gasoline
VEHICLE STALLS IN WARM WEATHER, AT ANY SPEED AND ANY TIME.*AK. CONSUMER STATED THE DEALER DISCOVERED THE PROBLEM AS BEING THE COOLANT SENSOR, ALSO THE FUEL FILTER AND DRIVEBELT WERE REPLACED.*JB
NHTSA ODI #8007631
Mileage unknown · Feb 25, 2002
Engine And Engine Cooling
CONSUMER STATED WHEN THE WEATHER IS COLD, THE ENGINE IDLES FASTER THAN IT SHOULD, CONSUMER STATED THE ENGINE SHOULD IDLE LESS AS THE ENGINE BECOMES WARM BUT IT DOES NOT, THE VEHICLE DRIVES FASTER THAN IT SHOULD AND OCCASIONALLY SLOW ENGINE SPEED TO NORMAL, HOWEVER WHEN THE THROTTLE IS PUSHED AGAIN THE PROBLEM RETURNS.*JB
NHTSA ODI #8004490
Mileage unknown · Apr 26, 2001
Engine And Engine CoolingEquipmentSuspension
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #744619
Mileage unknown · Aug 26, 2000
Engine And Engine Cooling
I REPORTED A DEFECT WITH MY VEHICLE IN OCT OF 1999 AND RECIEVED A RESPONCE FROM DOT THAT IT IS BEING INVESTIGATED AND I WILL GET A RESPONSE. THAT RESPONSE HAS NOT COME YET AND 1 YEAR IS NOT ACCEPTABLE TO WAIT FOR A REPLY ON A SAFTEY ISSUE. THE PROBLEM IS THAT THE OIL PAN ON MY VEHICLE RUSTED THROUGH. I HAVE BEEN INFORMED BY T…
Read full complaint
I REPORTED A DEFECT WITH MY VEHICLE IN OCT OF 1999 AND RECIEVED A RESPONCE FROM DOT THAT IT IS BEING INVESTIGATED AND I WILL GET A RESPONSE. THAT RESPONSE HAS NOT COME YET AND 1 YEAR IS NOT ACCEPTABLE TO WAIT FOR A REPLY ON A SAFTEY ISSUE. THE PROBLEM IS THAT THE OIL PAN ON MY VEHICLE RUSTED THROUGH. I HAVE BEEN INFORMED BY THE DEALER, SERVICE STATIONS, AND THE MANUFACTURE THAT THIS IS NOT AN UNUSSUAL PROBLE FOR MY TYPE ENGINE. IF THAT BE THE CASE, THIS SHOULD BE A RECALL BY FORD DO TO FAULTY METAL AND/OR PAINT PROCESS. WHAT HAPOPENS IS THE PAINT BUBBLKES AWAY FROM THE METAL ALLOWING WATER TO GET BETWEEN THE PAINT AND THE METAL. IT TOOK ONLY 6 YEARS AND/OR 70K MILES TO ROT A HOLE THROUGH MY OIL PAN. THE EXPENSE OF REPLACEMENT IS $600 BECAUSE THEY HAVE TO LIFT THE ENGINE TO CLEAR THE OIL PAN FROM THE CROSS MEMBERS. AS I COULD NOT WAIT ANY LONGER TO HERE THE RESULTS OF YOUR INVESTIGATION, I HAD TO PAY TO HAVE MINE REPLACED. I HAVE HEARD FROM THE DEALER SERVICE TECHNICIANS THAT THEY THOUGHT THERE USED TO BE A SERVICE BULLETIN ON THIS DEFECT BUT THEY COULDN'T FIND IT. I HAVE CHECKED YOUR DATABASE AND CANNOT FIND ONE EITHER. THIS COUDL POTENTIALLY BE A SERIOUS PROBLEM IF THE HOLE WOULD OCCUR WHILE DRIVING... SUDDUN LOSS OF OIL, BURN UP ENGINE... POTETIAL LOCKUP OF DRIVE LINE ... ETC ..... BTW.. WHEN I INITIALLY INVESTIGATED THIS IN 1999, I FOUND THE PROBLEM TO BE BIG ENOUGH THAT THE SERVICE CENTERS IN THE AREA COULD NOT KEEP OILPANS IN STOCK BECAUSE OF THE HIGH RATE OF REPLACEMENT....
NHTSA ODI #729152
Mileage unknown · Jul 19, 2000
Engine And Engine CoolingFire
ENGINE FAILURE CAUSED FIRE. YH
NHTSA ODI #553115
Mileage unknown · Jun 6, 2000
Engine And Engine CoolingFuel System, Gasoline
FUEL LEAKED FROM WELD OF THE FUEL TANK. ALSO, FUEL VAPORS/FUMES CAME INTO VEHICLE. DEALER NOTIFIED, BUT REPAIRS WERE MADE AT AN INDEPENDENT REPAIR SHOP. *ML
NHTSA ODI #863128
Official recalls
3Feb 4, 2008
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Jun 8, 1993
THE FUEL FILLER HOSE OR FUEL FILLER VENT HOSE WAS DAMAGED BY A DRILL BIT USED TO INSTALL THE DSO PACKAGE ATTACHING HARDWARE ONTO THE FLOOR PAN.
Consequence & remedy
Consequence: IF EITHER OF THE HOSES WAS PENETRATED BY THE DRILL BIT,FUEL LEAKAGE COULD RESULT, PARTICULARLY DURING FUELING OF THE VEHICLE. IN THEPRESENCE OF AN IGNITION SOURCE, THIS COULD RESULT IN FIRE.
Remedy: REPLACE THE FUEL FILLER AND VENT HOSES AND RELOCATE THE MOUNTING HARDWARE IN THE FLOOR PAN.
Aug 24, 1992
THE TIRE CERTIFICATION LABELS INCORRECTLY IDENTIFY THE VEHICLE TIRE REQUIREMENTS AS P235/75R15 SL (STANDARD LOAD), RATHER THAN AS P235/75R15 XL (EXTRA LOAD).
Consequence & remedy
Consequence: THE CERTIFICATION LABELS ON THE AFFECTED VEHICLES DO NOTCOMPLY WITH FMVSS 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THANPASSENGER CARS." INCORRECT TIRE SELECTION COULD RESULT IN SUDDEN FAILURE OFA TIRE WHILE THE VEHICLE IS IN MOTION, AND RESULT IN A VEHICLE ACCIDENT.
Remedy: CORRECT TIRE INFORMATION LABELS AND INSTALLATION INSTRUCTIONS WILL BE MAILED TO THE OWNERS OF THESE VEHICLES. OWNERS WILL BE INSTRUCTED THAT DEALERS CAN INSTALL THE LABEL PROVIDED IF THEY PREFER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration