IllustrationTRANSMISSION HAS BEEN REPLACED THREE TIMES WITHIN LESS THEN 60,000 MILES. DEALER NOTIFIED AND REPAIRED TRANSMISSION ON TWO OCCASIONS, BUT REFUSED TO REPAIR ON THE THIRD UNLESS COST IS PICKED UP BY THE CONSUMER. *AK
1991 Ford Econoline
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Econoline years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 24 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports1 fire reports1 injury reports
Power Train complaints
2 reportsBRAKES OVERHEAT/FAIL. *DH
Official recalls
393V073000 · Suspension:rear:shock Absorber
Apr 27, 1993
THE REAR SHOCK CROSSMEMBER OF THE FRAME CAN CRACK AND SEPARATE FROM THE FRAME.
Consequence & remedy
Consequence: SEPARATION OF THE REAR SHOCK CROSSMEMBER FROM THE FRAMECAN RESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Remedy: REPLACE THE REAR CHOCK CROSSMEMBER WITH A SHOCK CROSSMEMBER MADE OF HIGH STRENGTH STEEL.
91V172000 · Seat Belts:front:anchorage
May 4, 1992
THE SAFETY BELT ANCHORAGE FOR THE REAR BENCH SEAT FAILED TO COMPLY WITH THE STANDARDS OF FMVSS 210.
Consequence & remedy
Consequence: FAILURE TO MEET THE LOAD REQUIREMENTS OF FMVSS 210 PLACETHE SEAT OCCUPANTS IN INCREASED RISK OF INJURY IN THE EVENT OF A SUDDEN STOPOR ACCIDENT.
Remedy: THE MANUFACTURE WILL REPLACE THE NON-COMPLYING SAFETY BELT ANCHORAGE WITH A NEW ANCHORAGE THAT MEETS THE REQUIREMENTS OF FMVSS 210.
91V146000 · Fuel System, Gasoline:storage:auxillary Tank:selector Devices
Sep 4, 1991
THE DUAL FUEL TANK SELECTOR VALVE MAY MALFUNCTION AND CAUSE AN OVERFILL CONDITION IN ONE OF THE FUEL TANKS, RESULTING IN AN OVERFLOW OF FUEL PAST THE FILLER CAP.
Consequence & remedy
Consequence: THE OVERFLOW OF FUEL PAST THE FILLER CAP CAUSES A FUELLEAKAGE, WHICH CAN RESULT IN A FIRE WHEN EXPOSED TO A SOURCE OF IGNITION.
Remedy: REPLACE THE DUAL FUEL TANK SELECTOR VALVE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA93022 · Idle Air Spd Ctrl Vlv Malf
Opened Jul 30, 1993 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
PE93010 · Idle Air Spd Ctrl Vlv Malf
Opened Mar 2, 1993 · Closed Jul 30, 1993
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available